Costway EP24830 User manual

www.costway.com
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE.
Visit us: www.costway.com
Follow Costway
Please give us a chance to make it right and do better！
Contact our friendly customer service department for help first.
Replacements for missing or damaged parts will be shipped ASAP!
USER’S MANUAL
16” DOUBLE BLADE PEDESTAL FAN
EP24830

Contact Us!
Do NOT return this item.
Contact our friendly customer service department for help first.
E-mail
US: [e-mail]
UK: [e-mail]
Before You StartBefore You Start
Please read all instructions carefully.
Retain instructions for future reference.
Separate and count all parts and hardware.
Read through each step carefully and follow the proper order.
We recommend that, where possible, all items are assembled near to the
area in which they will be placed in use, to avoid moving the product
unnecessarily once assembled.
Always place the product on a flat, steady and stable surface.
Keep all small parts and packaging materials for this product away from
babies and children as they potentially pose a serious choking hazard.
www.costway.com
02

www.costway.com
PACKAGE CONTENTS
03

www.costway.com
USING INSTRUCTION
Signal Word Definitions
NOTE: These are general definitions only; all may not pertain to the specific product purchased.
DANGER – Indicates an imminently hazardous situation, which, if not avoided, will result in
death or serious injury. Usage of this signal word is limited to the most extreme situations.
WARNING – Indicates a potentially hazardous situation, which, if not avoided, could result in
death or serious injury.
CAUTION – Indicates a potentially hazardous situation, which, if not avoided, may result in
minor/moderate injury or product/property damage. It also alerts against unsafe practices.
● Always unplug unit when not in use, moving to a new location and when cleaning.
● Extreme caution is necessary when fan is used by or near children or invalids.
● Do not operate any fan with a damaged cord or plug, after the fan malfunctions, has been
dropped or damaged in any manner.
● Do not use outdoors.
● Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may
cause electric shock, and/or a fire hazard.
● Do not use fan in areas where gasoline, paint, or flammable materials are used or stored. A fan
has sparking parts inside.
● Do not place fan on an uneven surface or a surface smaller than the fan that might allow it to
tip or fall causing damage to property or injury to people.
● Do not use the fan with the fan guards removed.
Do not route cord under carpeting or cover cord with throw rugs, runner, or the like. Arrange
cord away from traffic area where cord will not be tripped over. To disconnect fan, turn controls
to off, then remove plug from outlet.
CAUTION: TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT USE THIS
FAN WITH ANY SOLID STATE SPEED CONTROL DEVICE.
Use this fan only as described in this manual. Any other use not recommended by the
manufacturer may cause fire, electric shock, or injury to persons.
CAUTION: This fan is equipped with an automatic reset limit control. If fan overheats for any
reason this limit control will open and stop the fan.
04

www.costway.com
USING INSTRUCTION
USING INSTRUCTION
BLADE AND GRILLS ASSEMBLY
Before beginning assembly of product, make sure
all parts are present. Compare parts with package
contents list and diagram above. If any part is
missing or damaged, do not attempt to assemble the
product. Contact customer service for replacement
parts.
Estimated Assembly Time: 30 minutes
Tools Required for Assembly: Phillips Screwdriver
(not included).
Assembling the Base, Pillar, Adjustable Pole and Manual Control Panel
Step 1. Align the pillar over the base, making sure that the holes in the pillar align with the holes in
the base. Screw the Pillar Tightening Nut onto the Pillar clockwise to tighten into the base until
secure.
Step 2. Hold the Adjustable Pole & loosen the Height Adjustment Knob by twisting it
counter-clockwise, adjust the pole to the desired height and tighten the Height Adjustment Knob .
Step 3. Place the Manual Control Panel onto the Adjustable Pole and tighten the Screw of Control
Panel
1, Remove the spinner and the plastic nut from the front side
of the motor .Fix the rear grill and plastic nut to the motor
shaft then tighten the plastic nut. Take the plastic ring out
of packing carton, slip the ring of the rear grill into the
deep slot of the plastic ring.(Figure 1)
2.Discard PVC sleeve on shaft. Insert the blade into shaft,
make sure the stopper pin is clipped into the groove of the
blade. Screw the spinner counter-clockwise to tighten
the blade (Figure2)
3. After putting the centre piece of the front grill upright ,
slip the ring of the front grill into the other slot of the plastic
ring, tighten the bolt in the joint of the ring by a screwdriver.
(Figure 3)
Caution: To avoid the risk, make sure the Plastic Ring tie the
Front Grill and Rear Grill up before operating.
05

www.costway.com
OPERATION
Remote Control:
06

Fig. 4 Fig. 5
www.costway.com
Attention: The remote control must face to the receiver
1.The using range of the remote control must be within 7 meters away from receiver. If the
remote control isn’t faced to the receiver, its using range will be narrowed.
2.If this fan is used in the room with operating high-power machines, the remote control may be
out of order.
3.Don’t put any obstructions between the receiver and remote control
4.If you don’t use the remote control, please take the cell out and keep it well
5.Please take good care of the remote control and avoid knocking and breaking it
Manual Control:
1.On/ Speed /Off : Press this button one time ,it will switch on/off, indicator light ring will be on,
Press the button twice it will be in wind speed state, the relative indicator light will be on. Press this
key again , the following diagram shows the order of the wind flow.
ON 1(Low) 2(MED.)3(HIGH) OFF
2.Timer/ Osc / Mode functions are used in the same way as the remote control.
Note: The remote control requires AAA batteries ( Batteries are not included)
07

Fig.7Fig.6
www.costway.com
MAINTENANCE
WARNING: ALWAYS UNPLUG THE UNIT BEFORE ATTEMPTING TO PERFORM ANY
SERVICE FUNCTION.
Cleaning: Remove front guard by removing screws and nuts from opposing guards with a
screwdriver. To clean the fan blade, use a soft cloth moistened with a mild soap solution. Use a soft
brush and soap solution to clean the guards (grills). DO NOT use gasoline, benzene or thinner, or
other hazardous liquids or abrasives.
Lubrication: The motor is pre-lubricated at the factory and requires no addition oil.
USER SERVICING INSTRUCTIONS
NOTE:
This product employs overload protection (fuse). A blown fuse indicates an overload or
short-circuit situation. If the fuse blows, unplug the product from the outlet. Replace the
fuse as per the user servicing instructions (follow product marking for proper fuse rating) and check
the product. If the replacement fuse blows, a short-circuit may be present and the product should be
discarded or returned to an authorized service facility for examination and/or repair.
HOW TO REPLACE THE FUSE
• Grasp plug and remove from the receptacle or other outlet device. Do not unplug by pulling on
cord. Open fuse cover by sliding it towards blades (see Fig. 6). Then remove the fuse, pry it out
carefully (see Fig. 7). Replace the new fuse and push the cover back.
• WARNING: Risk of fire. Replace fuse only with 5 Amp, 125 Volt fuse. Do not replace
attachment plug. Discard product if the attachment plug is damaged.
08

www.costway.com
09

Welcome to visit our website and purchase our quality products!
We would like to extend our hearelt thanks to
all of our customers for taking me to assemble
this product and giving us valuable feedbacks.
With your inspiring rating, COSTWAY will be more consistent to offer you
EASY SHOPPING EXPERIENCE, GOOD PRODUCTS and EFFICIENT SERVICE!
US office: Fontana, California
UK office: Ipswich
www.costway.com
Reward Points
Exclusive Customer Service
Personalized Recommendaons
Permanent Shopping Cart
Order History
www.costway.com
10