Curtis G3 D1000 Series User manual

G3 D1000 Series
Twin Airpot Coffee Brewing System
USER GUIDE
READ AND SAVE THESE INSTRUCTIONS
NOTICE TO INSTALLER: Please leave this booklet with the machine.
øøøøø #
'$%'30/5$07&3 'SFW"
“Tall” version shown

CONTENTS CL29
.H\)HDWXUHV6SHFLÀFDWLRQV6\VWHP5HTXLUHPHQWV..............................................................................................FS29
,PSRUWDQW6DIHJXDUGV............................................................................................................................................... IS2
,QVWDOODWLRQ,QVWUXFWLRQV*HQHUDO...............................................................................................................................II2
,QVWDOODWLRQ,QVWUXFWLRQV/HYHOLQJ:DWHU6XSSO\(OHFWULFDO....................................................................................II35
2SHUDWLQJ,QVWUXFWLRQV ............................................................................................................................................OI23
&OHDQLQJ,QVWUXFWLRQV................................................................................................................................................CI1
&OHDQLQJ,QVWUXFWLRQV................................................................................................................................................CI9
3URJUDPPLQJ*XLGH ............................................................................................................................................... 3*
5RXJK,Q'UDZLQJ................................................................................................................................................. 5'
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV.................................................................................................................... IP51
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\9ROW......................................................................... IP52
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\'XDO9ROWDJH ................................................................. IP53
(OHFWULFDO6FKHPDWLF9ROW..............................................................................................................................ES53
(OHFWULFDO6FKHPDWLF'XDO9ROWDJH ......................................................................................................................ES54
7URXEOHVKRRWLQJ*XLGH ............................................................................................................................................7*
7URXEOHVKRRWLQJ*XLGH ..........................................................................................................................................7*
(UURU&RGHV .............................................................................................................................................................EC5
3URGXFW:DUUDQW\....................................................................................................................................................3:
Contact Information
Wilbur Curtis Co., Inc.
6913 Acco Street | Montebello, CA 90640 US
Phone: [phone] | Toll Free: 800-421-6150
Email: [email protected] | Web: www.wilburcurtis.com
'PSUIFMBUFTUTQFDJmDBUJPOTBOEJOGPSNBUJPOHPUPXXXXJMCVSDVSUJTDPN
5PMM'SFF].POEBZ'SJEBZA.M.- 4:00 P.M.PT
Email: [email protected]
%VFUPDPOUJOVFEQSPEVDUJNQSPWFNFOUUIFQSPEVDUTJMMVTUSBUFEQIPUPHSBQIFEJOUIJTHVJEFNBZWBSZTMJHIUMZGSPNUIFBDUVBMQSPEVDU
%$0/5&/54-*45øø  "

KEY FEATURES/SPECIFICATIONS/SYSTEM REQUIREMENTS FS29
Key Features
• Precise Gourmet Control Over All Critical Functions — The G3 Digital Control Module provides you the
expertise to brew premium gourmet coffee with ease.
• #VJMU*O'JOF5VOJOH#SFXJOH.PEFT1SFJOGVTJPOPSQVMTFCSFXFOIBODFTFYUSBDUJPOPGHPVSNFUDPGGFFnBWPS
Cold water brew lockout prevents brewing when water temperature is below set level.
• The Digital Control Module is encapsulated in high-tech polymer and is impervious to heat, steam and
moisture.
• Intuitive Scroll-Through Precision Programming — Large, brightly lighted display communicates functions at a
glance. Easily adjust time, volume, temperature, brew functions and more.
• Two heads are easily programmed independently of each other.
• Industry’s most effective mineral tolerant design.
6SHFLÀFDWLRQV6HOHFWHG0RGHOV
(OHFWULFDO6XSSO\5HTXLUHPHQWV
02'(/ '(6&5,37,21 3+$6( 92/76 $036 +($7,1*&21),* :,5( :$776 +(57= &$3$&,7<
'*7$ Twin brewer 1 PH 220 V 23.2 A 2 x 2500 W 3W + G 5100 W 50/60 Hz 14.0 gal/hr
[53.0 l/hr]
'*+$ Twin brewer, tall 1 PH 220 V 23.2 A 2 x 2500 W 3W + G 5100 W 50/60 Hz 14.0 gal/hr
[53.0 l/hr]
'*7$ Twin brewer, dual voltage 1 PH 120/220 V 15/12.7 A 2 x 1600 W 2W/3W + G 1800/2800 W 50/60 Hz 5.0/8.0 gal/hr
[18.9/30.3 l/hr]
'*+$ Twin brewer, dual voltage, tall 1 PH 120/220 V 15/12.7 A 2 x 1600 W 2W/3W + G 1800/2800 W 50/60 Hz 5.0/8.0 gal/hr
[18.9/30.3 l/hr]
'LPHQVLRQV :DWHU6XSSO\5HTXLUHPHQWV
02'(/ +(,*+7 :,'7+ '(37+ 6+,3:(,*+7 6+,3&8%( :$7(5&211(&725 :$7(535(6685( 0,1)/2:5$7(
'*7$ 26.00”
[66.0 cm]
18.13”
[46.0 cm]
20.00”
[50.8 cm]
53.0 lbs
[24.0 kg]
8.78 cu. ft.
[0.25 m3]µÁDUH
20 - 90 psi
[138 - 620 kPa]
1.0 gpm
[3.8 lpm]
'*+$ 29.25”
[74.3 cm]
18.13”
[46.0 cm]
20.00”
[50.8 cm]
59.0 lbs
[26.8 kg]
8.78 cu. ft.
[0.25 m3]µÁDUH
20 - 90 psi
[138 - 620 kPa]
1.0 gpm
[3.8 lpm]
'*7$ 26.00”
[66.0 cm]
18.13”
[46.0 cm]
20.00”
[50.8 cm]
53.0 lbs
[24.0 kg]
8.78 cu. ft.
[0.25 m3]µÁDUH
20 - 90 psi
[138 - 620 kPa]
1.0 gpm
[3.8 lpm]
'*+$ 29.25”
[74.3 cm]
18.13”
[46.0 cm]
20.00”
[50.8 cm]
60.0 lbs
[27.2 kg]
8.78 cu. ft.
[0.25 m3]µÁDUH
20 - 90 psi
[138 - 620 kPa]
1.0 gpm
[3.8 lpm]
D1000 KEY FEATURES/SPECS/SYSTEM REQUIREMENTS 092419A
Following are the factory default settings for the D1000 brewer:
• Energy Save Mode = Off• Brew Temperature = 200°F (92°C)
• Brew Volume = 74 oz. (2.2 l)

IMPORTANT SAFEGUARDS IS2
Symbols
This is the safety alert symbol. It is used to alert you to potential physical injury hazards. Obey all safety
messages that follow this symbol to avoid possible injury or death.
DANGER - Indicates a hazardous situation which, if not avoided, will result in death or serious injury.
WARNING - Indicates a hazardous situation which, if not avoided, could result in death or serious injury.
CAUTION - Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
NOTICE - Indicates a situation which, if not avoided, could result in property damage.
IMPORTANT - Provides information and tips for proper operation.
SANITATION REQUIREMENTS
Important Safeguards/Conventions
WARNING:
• Make sure that this appliance is installed and grounded according to the INSTALLATION
*/4536$5*0/4CZRVBMJmFEQFSTPOOFMCFGPSFBUUFNQUJOHUPVTFJU'BJMVSFUPGPMMPXUIF*/45"--"5*0/
INSTRUCTIONS could result in personal injury or void the warranty.
• This appliance is designed for commercial use. Any service other than cleaning and preventive
maintenance should be performed by an authorized Wilbur Curtis service technician.
• 5PSFEVDFUIFSJTLPGmSFPSFMFDUSJDTIPDL%0/05PQFOUIFTFSWJDFQBOFMT5IFSFBSFOPVTFS
serviceable parts inside.
• Keep hands, arms and other items away from hot surfaces of the unit during operation.
• Clean the appliance and any dispensers completelyCFGPSFVTJOHUIFNGPSUIFmSTUUJNFBDDPSEJOHUP
the CLEANING INSTRUCTIONS. Clean them regularly as instructed in the CLEANING INSTRUCTIONS.
• Use this appliance only for its intended use, brewing/dispensing hot and/or cold beverages/water.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory
or mental capabilities or lack of experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person responsible for their safety. Children should
be supervised to ensure that they do not play with the appliance.
• Avoid spillage onto the power (mains) connector.
$0''&&5&"#3&8&34*.1035"/54"'&(6"3%44:.#0-4 )
WARNING - 5IJTQSPEVDUDBOFYQPTFZPVUPDIFNJDBMTJODMVEJOH"DSZMBNJEFBOE#JTQIFOPM"#1"
which are known to the State of California to cause cancer and birth defects or other reproductive harm.
'PSNPSFJOGPSNBUJPOWJTJUXXX18BSOJOHTDBHPW

IMPORTANT SAFEGUARDS IS2
$0''&&5&"#3&8&34*.1035"/54"'&(6"3%44:.#0-4 )
CE Requirements
• This appliance must be installed in locations where it can be overseen by trained personnel.
• 'PSQSPQFSPQFSBUJPOUIJTBQQMJBODFNVTUCFJOTUBMMFEXIFSFUIFUFNQFSBUVSFJTCFUXFFO¡$UP¡$
• This appliance is not suitable for outdoor use.
• 5IJTBQQMJBODFTIBMMOPUCFUJMUFENPSFUIBO¡GPSTBGFPQFSBUJPO
• "OFMFDUSJDJBONVTUQSPWJEFFMFDUSJDBMTFSWJDFBTTQFDJmFEJODPOGPSNBODFXJUIBMMMPDBMBOEOBUJPOBMDPEFT
'PSTBGFVTFBOBMMQPMFEJTDPOOFDUJPONVTUCFJODPSQPSBUFEJOUPUIFmYFEXJSJOHJOBDDPSEBODFXJUIUIF
XJSJOHSVMFTPVUMJOFEJODMBVTFPG*&$GPSNFFUJOHUIFNJOJNVNFMFDUSJDBMTBGFUZPGUIJTTUBOEBSE
• This appliance must not be cleaned by water jet.
• 5IJTBQQMJBODFDBOCFVTFECZQFSTPOTBHFEGSPNZFBSTBOEBCPWFJGUIFZIBWFCFFOHJWFOTVQFSWJTJPOPS
instruction concerning use of the appliance in a safe way and if they understand the hazards involved.
• ,FFQUIFBQQMJBODFBOEJUTDPSEPVUPGSFBDIPGDIJMESFOBHFEMFTTUIBOZFBST
• "QQMJBODFTDBOCFVTFECZQFSTPOTZFBSTBOEBCPWFXJUISFEVDFEQIZTJDBMTFOTPSZPSNFOUBMDBQBCJMJUJFT
or lack of experience and knowledge if they have been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards involved.
• $IJMESFOVOEFSUIFBHFPGZFBSTTIPVMECFTVQFSWJTFEUPFOTVSFUIFZEPOPUQMBZXJUIUIFBQQMJBODF
• If the power cord is ever damaged, it must be replaced by the manufacturer or authorized service personnel
with a special cord available from the manufacturer or its authorized service personnel in order to avoid a
hazard.
• Machine must not be immersed for cleaning.
• $MFBOJOHBOEVTFSNBJOUFOBODFTIBMMOPUCFNBEFCZDIJMESFOVOMFTTUIFZBSFPMEFSUIBOZFBSTBOE
supervised.
• This appliance is intended to be used in household and similar applications such as:
 oTUBGGLJUDIFOBSFBTJOTIPQTPGmDFTBOEPUIFSXPSLJOHFOWJSPONFOUT
 oCZDMJFOUTJOIPUFMTNPUFMTBOEPUIFSSFTJEFOUJBMUZQFFOWJSPONFOUT
– bed and breakfast type environments.
• This appliance not intended to be used in applications such as:
– farm houses
• Access to the service areas permitted by Authorized Service personnel only.
• 5IF"8FJHIUFETPVOEQSFTTVSFMFWFMJTCFMPXE#"

INSTALLATION INSTRUCTIONS II2
Installation Instructions
Installation Requirements
• A secure surface capable of supporting the weight of the appliance.
• For units without an attached cord set attached or dual voltage units set up for use with 220 - 240 Volts:
"QQSPQSJBUFMZTJ[FE6-MJTUFEHSPVOEJOHUZQFQPXFSDBCMFUPNFFUUIFFMFDUSJDBMTQFDJmDBUJPOTGPSUIF
BQQMJBODF*GZPVIBWFRVFTUJPOTBCPVUUIFDPSSFDUDBCMFTJ[FBOEMFOHUIDPOTVMUBRVBMJmFEJOTUBMMFS*GUIF
appliance will be hard wired to a junction box, the power cable must be long enough so that the unit can be
moved for cleaning underneath.
• "HSPVOEFEFMFDUSJDBMDPOOFDUJPOUPBOFMFDUSJDBMDJSDVJUUIBUNFFUTUIFFMFDUSJDBMTQFDJmDBUJPOTPGUIF
appliance (see SPECIFICATIONS). The circuit must be protected by the appropriate sized circuit breaker. If
you are not certain that the existing circuit meets the requirements for your unit, consult a licensed electrician.
• "XBUFSmMUSBUJPOTZTUFNJTSFRVJSFEUPNBJOUBJOUSPVCMFGSFFPQFSBUJPO8JMCVS$VSUJT$P*ODSFDPNNFOETB
8JMCVS$VSUJTBQQSPWFEXBUFSmMUFS4FFUIF$VSUJT&RVJQNFOU$BUBMPHGPSBGVMMMJOFPG8JMCVS$VSUJTBQQSPWFE
XBUFSmMUFST
• 1PUBCMFXBUFSTVQQMZMJOFDPOOFDUJPOGSPNUIFXBUFSmMUFSDBQBCMFPGTVQQMZJOHUIFNJOJNVNnPXSBUFSFRVJSFE
CZUIFTQFDJmDBUJPOT5IFXBUFSTVQQMZMJOFNVTUCFBCMFUPDPOOFDUUPUIFnBSFmUUJOHPOUIFCBDLPGUIF
VOJU4FFUIFSPECIFICATIONS section for the correct size. The water line should also be capable of being
controlled by a shut off valve. Do not connect the water line to a saddle valve or needle valve.
/4'*OUFSOBUJPOBMSFRVJSFTUIFGPMMPXJOHXBUFSDPOOFDUJPO
1A quick disconnect or additional coiled tubing (at least two times the depth of the appliance) is required
so that it can be moved for cleaning underneath.
2 5IJTFRVJQNFOUJTUPCFJOTUBMMFEXJUIBEFRVBUFCBDLnPXQSPUFDUJPOUPDPNQMZXJUIBQQMJDBCMF
federal, state and local codes.
 8BUFSQJQFDPOOFDUJPOTBOEmYUVSFTEJSFDUMZDPOOFDUFEUPBQPUBCMFXBUFSTVQQMZTIBMMCFTJ[FE
installed and maintained in accordance with federal, state and local codes.
WARNING:*OTUBMMBUJPOJTUPCFQFSGPSNFEPOMZCZBRVBMJmFEJOTUBMMFS
WARNING: Improper electrical connection may result in an electric shock hazard or damage the unit. This
brewer must be properly grounded.
NOTICE: DO NOT connect this brewer to a hot water supply. The water inlet valve is not rated for hot water.
Do not exceed the maximum water pressure stated in the SPECIFICATIONS section.
IMPORTANT: Observe all governing codes and ordinances.
#3&8&34(&/&3*$*/45"--"5*0/*/4536$5*0/4 &
5IF*OUFSOBUJPOBM1MVNCJOH$PEFPGUIF*OUFSOBUJPOBM$PEF$PVODJMBOEUIF'PPEBOE%SVH"ENJOJTUSBUJPO
'%"'PPE$PEFNBOVBMEJSFDUUIBUUIJTFRVJQNFOUNVTUCFJOTUBMMFEXJUIBEFRVBUFCBDLnPXQSFWFOUJPO
JODPNQMJBODFXJUIGFEFSBMTUBUFBOEMPDBMDPEFT'PSVOJUTJOTUBMMFEPVUTJEFPGUIF64"NBLFTVSFUIBU
the installation is in compliance with the applicable plumbing/sanitation code for your area.

Installation
Leveling
1 Position the brewer on the counter top. Level it left to
right and front to back by turning the bottom of the
MFHTDPOmHVSBUJPOWBSJFT
Connecting the Water Supply
2 Flush the water supply line prior to installation to
QVSHFBJSBOEEFCSJTGSPNUIFXBUFSmMUFSBOEUVCJOH
3 $POOFDUUIFXBUFSTVQQMZMJOFUPUIFnBSFmUUJOHPO
UIFCBDLPGUIFCSFXFSDPOmHVSBUJPOWBSJFT-FBWF
the water supply valve closed until the power is
connected.
Setting Up Dual Voltage Units for 220-240 Volt
Operation (CBHS, D500GT[H]63, D1000GH62 and
D1000GT63 Series Models)
4 Remove the front cover by removing the screws that
hold it in place.
5 Loosen the strain relief on the back of the brewer.
6 Disconnect the existing power cable from the terminal
block and remove it.
7 Disconnect and cap the jumper wire between the “C”
and “N” terminals on the terminal block.
8 Feed the 220-240 Volt power cable through the strain
relief, into the brewer. The brewer may be wired for
connection directly to a junction box or for use with
a power plug that connects to an electrical outlet
meeting the brewer SPECIFICATIONS.
9 Connect the wires on the power cable to the
terminal block inside the brewer according to the
ELECTRICAL SCHEMATIC.
10 Tighten the strain relief.
11 Replace the front cover.
INSTALLATION INSTRUCTIONS II35
DECANTER/DISPENSER BREWERS, INSTALLATION INSTRUCTIONS - 200F 080519A
WARNING: Use the leveling legs to level the
brewer only. Do not use them to adjust brewer
height. Do not extend them higher than necessary.
Front
panel
Terminal
block
WARNING: Do not connect the power cord to the
power supply until instructed to do so.
or

15 Feed the power cable into the brewer. The brewer may
be wired for connection directly to a junction box or for
use with a power plug that connects to an electrical
outlet meeting the brewer SPECIFICATIONS.
16 Connect the wires on the power cable to the terminal
CMPDLJOTJEFUIFCSFXFSBTTQFDJmFE4FFUIF
ELECTRICAL SCHEMATIC.
17 Tighten the strain relief and replace the front cover.
continued...
Brewers With Strain Relief Mounted to the Back
13 Remove the front cover by removing the screws that
hold it in place.
14 Loosen the strain relief on the back of the brewer.
Connecting the Brewer Wiring (Units That Come from
the Factory Without a Power Cord Attached)
Brewers With Power Connector Mounted to the Back
12 $POOFDUB$*&$QPXFSDPSEOPUTVQQMJFE
compatible with the electrical outlet installed in the
GBDJMJUZBOEUIBUNFFUTTQFDJmDBUJPOT
INSTALLATION INSTRUCTIONS II35
DECANTER/DISPENSER BREWERS, INSTALLATION INSTRUCTIONS - 200F 080519A
WARNING: Do not connect the power cord to the
power supply until instructed to do so.
Style
varies
Front
panel
Terminal
block
or

20 Connect the power plug to the appropriate electrical
outlet.
Powering Up the Brewer
21 Turn on the water supply valve.
22 Make sure that the circuit breaker supplying power to
the unit is on.
23 Turn the toggle switch on the back of the brewer to the
0/QPTJUJPO5IFXBUFSUBOLXJMMTUBSUUPmMM8IJMFUIF
UBOLJTmMMJOHJOTQFDUUIFXBUFSTVQQMZMJOFGPSMFBLT
continued...
INSTALLATION INSTRUCTIONS II35
DECANTER/DISPENSER BREWERS, INSTALLATION INSTRUCTIONS - 200F 080519A
WARNING: Connect the power cord only to the
appropriate type and size electrical outlet. If it is
not compatible, either have the cord replaced or
have the electrical outlet upgraded by a licensed
electrician. Do not use an extension cord. Do not
use a power cord/plug that is damaged.
Electrical Connection
Connection to a Junction Box
18 Connect the power cable wires to the terminals in
the junction box and replace the cover. See the
ELECTRICAL SCHEMATIC for the power supply
requirements.
Connection to an Electrical Outlet
19 If not already installed, install the appropriate type of
power plug for your locality. Consult local electrical
codes to determine the approved type of power plug
for your region.
WARNING: Turn off power to the junction box at the
circuit breaker panel and lock out and tag the circuit
breaker before connecting the power cable to the
junction box.
Style
varies
Power cable from brewer

INSTALLATION INSTRUCTIONS II35
DECANTER/DISPENSER BREWERS, INSTALLATION INSTRUCTIONS - 200F 080519A
Powering Up the Brewer (cont.)
24 When the water in the tank rises to the correct level, the
heating elements will turn on automatically. Depending
on the incoming water temperature and the electrical
TQFDJmDBUJPOTUIFXBUFSUBOLUZQJDBMMZSFRVJSFTUP
minutes to reach the factory set operating temperature.
When the water has heated, Ready to brew will be
displayed on the LCD screen.
25 Perform a brew cycle of a least 12 oz./350 ml to purge
any remaining air from the system. See OPERATING
INSTRUCTIONS. During the initial brew cycle and
XIFOFWFSUIFmMUFSJTSFQMBDFEZPVNBZIFBSUIF
TPVOETPGBJSCFJOHQVSHFEGSPNUIFmMUFSUVCJOHBOE
water tank.
26 *GUIFVOJUJTFRVJQQFEXJUIBIPUXBUFSGBVDFUmMMB
coffee cup with hot water to purge air from the hot
water line.
IMPORTANT: When operating the brewer at
higher elevations, reduce the factory set operating
UFNQFSBUVSF¡'¡$CZ¡'¡$GPSFBDI
1000 ft./300 m of elevation above 4000 ft./1200 m.
See the PROGRAMMING GUIDE section.

OPERATING INSTRUCTIONS OI23
("*3105#3&8&301&3"5*/(*/4536$5*0/4øø #
Brewing Instructions
2 Center an empty airpot under
the brew basket.
3 *OTFSUBDMFBOQBQFSmMUFSJOUP
the brew basket.
 Fill with the proper amount
of ground coffee. Level the
DPGGFFJOUIFmMUFS
5 4MJEFUIFmMMFECSFXCBTLFU
into the brew rails under the
control panel. Slide it all the
way back until it stops.
The brewer will brew coffee based on the settings programmed into the universal control module (UCM). To
change the settings, see the PROGRAMMING GUIDE section.
 The brewer should be ON.
$POmSNUIJTBUUIFSFBSUPHHMF
switch. “Ready to brew”
should be on the display. If
the brewer is connected to an
inter-lock grinder, the grinder
should be on. When inter-lock
connection is made, grind
coffee at this time.
6 Press the brew button. Brewing
will begin immediately.
WARNING - TO AVOID SCALDING, AVOID SPLASHING. Keep body parts clear of the brewer during
brewing. Do not remove the brew basket while “Brewing” appears on the display.
The G3 brewer is factory preset for optimal performance.

NOTICE - Do not use cleaning liquids, compounds or powders containing chlorine (bleach) or corrosives.
5IFTFQSPEVDUTQSPNPUFDPSSPTJPOBOEXJMMEBNBHFUIFmOJTIFT USE OF THESE PRODUCTS WILL VOID
THE WARRANTY.
CLEANING INSTRUCTIONS CI1
Cleaning The Brewer - Daily
BREWERS - GENERIC, CLEANING INSTRUCTIONS 080416B
WARNING: HOT SURFACES - To avoid injury, allow the brewer and dispenser(s) to cool before cleaning.
The brewer should be OFF.5VSOUIFCSFXFSPGGCZnJQQJOHUIFSFBSUPHHMFTXJUDIUPUIF0''QPTJUJPO
1 Remove the dispenser(s). Wipe exterior brewer surfaces with a damp cloth to remove spills and debris.
2 Remove the brew basket(s) and clean them in a mild detergent solution. Use a soft bristled brush for hard to
clean areas. Rinse with clean water, then dry.
3 Wipe the spray head area with a cloth soaked in a mild detergent solution. Rinse with a cloth soaked with
clean water removing any residual detergent. Use a clean, soft cloth to dry.
4 Dump out the drip tray(s) (if applicable). Rinse with clean water, then dry with a soft, clean cloth.
Cleaning The Brewer - Weekly
The brewer should be OFF.5VSOUIFCSFXFSPGGCZnJQQJOHUIFSFBSUPHHMFTXJUDIUPUIF0''QPTJUJPO
1 Remove the spray head(s), unscrewing counterclockwise from the dome plate.
2 Thoroughly clean and rinse the dome plate area.
3 Clean the brew basket rails with a brush soaked with a mild detergent solution. Rinse the area with a cloth
soaked with clean water, removing any residual detergent.
4 Dry the area with a soft, clean cloth.
5 Reattach the spray head(s).
WARNING: DO NOT immerse the brewer in water or any other liquid.

Cleaning the Airpot/Pour Pot (Daily)
CLEANING INSTRUCTIONS CI9
10631054"*31054$-&"/*/(*/4536$5*0/4ø #
WARNING: DO NOT immerse the airpot/pour pot or lid assembly in water or any other liquid. Do not place the
airpot/pour pot or lid in a dishwasher. Placing a airpot or pour pot in a dishwasher will void the warranty.
Cleaning Airpots
 Wash - Wipe the exterior surfaces of the airpot and
lid with a sponge soaked with the detergent solution
to remove spills and debris. Fill the liner with the
detergent solution. Use a sponge cleaning brush to
clean inside. Clean the spout/siphon tube with the
detergent solution.
 Rinse - Rinse the airpot and the spout/siphon tube
with clean, warm water.
3 Sanitize - Sanitize the interior of the airpot, the
spout/siphon tube and the lid, using a commercial
sanitizer suitable for food grade applications. Swab,
brush or pressure spray the sanitizing solution
according to the directions on the package.
 Air Dry - Turn the airpot and lid upside down.
Allow all parts to air dry.
Cleaning Pour Pots
 Wash - Wipe the exterior surfaces of the pour pot
and lid with a sponge soaked with the detergent
solution to remove spills and debris. Fill the liner with
the detergent solution. Use a sponge cleaning brush
to clean inside.
 Rinse - Rinse the pour pot and the lid with clean,
warm water.
3 Sanitize - Sanitize the interior of the pour pot and
the lid, using a commercial sanitizer suitable for
food grade applications. Swab, brush or pressure
spray the sanitizing solution according to the
directions on the package.
 Air Dry - Turn the pour pot and lid upside down
and allow to air dry.
Start by preparing a mild solution of detergent and warm water. Remove the airpot/pour pot from the brewer and
remove/open the lid. On airpots, remove the nozzle assembly. Rinse.
Nozzle
assembly
TLXA2201G000 shown. Appearance and size varies
with model number.
CLXP6401S100 shown. Appearance and size varies
with model number.
NOTE: The stem on the bottom of TFT series pour pot lids have a built-in sensor used for the FreshTrac®
feature. Keep this stem free from coffee oil build-up for proper operation. After cleaning, inverting the lid
GPSTFDPOETSFTFUTUIF'SFTI5SBDUJNFS

PROGRAMMING GUIDE PG8
With unit OFF, press and hold
bottom right BREW button (4).
Then press and release
ON/OFF button. Continue to
hold down BREW button until
Enter Code appears.
Enter 4 digit code.
(factory default = 1-2-3-4)
Curtis
Entering
Programming mode
Enter Code
- - - -
To enter programming mode:
<Program Menus>
ÅSelect Æ
Brew by Volume
ÅSelect Æ
Brew by Time
ÅSelect Æ
Pre-Infusion
ÅSelect Æ
PulseBrew On/Off
ÅSelect Æ
Drip-Out Mode
ÅSelect Æ
Temperature
ÅSelect Æ
Energy Save Mode
ÅSelect Æ
Brew Count Odom.
ÅSelect Æ
Brew Count Total
ÅSelect Æ
Cold Brew Lock
ÅSelect Æ
Master Reset
ÅSelect Æ
Service Call
ÅSelect Æ
Access Code
ÅSelect Æ
Banner Name
ÅSelect Æ
P-Maintenance
ÅSelect Æ
Beeper On/Off
ÅSelect Æ
Displ. Brew Time
ÅSelect Æ
Display Messages
ÅSelect Æ
Model Select
ÅSelect Æ
Exit
ÅSelect Æ
8$8$130(3"..*/((6*%&ø "
IMPORTANT: All programming functions are performed with the
three center buttons.
The symbols below the buttons are:
 Ż 4DSPMM61
~4&-&$5PS&/5&3UPTBWFOFXQBSBNFUFS
Ź4DSPMM%08/
Once you enter programming mode, press Żor Źto scroll UP or DOWN
through the various functions/features. Press ~4FMFDUUPNBLFDIBOHFT
to the function/feature displayed. Then press Żor Źto scroll through
the various available settings. See Programming Options for detailed
descriptions.

Programming Options
4FFUIFmSTUQBHFPGUIFQSPHSBNNJOHHVJEFGPSJOTUSVDUJPOTPOBDDFTTJOHFBDIJOEJWJEVBMNFOVJUFN
Some menus save and exit automatically when a parameter is updated. Other menus exit to the previous menu
when a parameter is saved. To exit, press Źuntil EXIT appears on the display, then press ~.
Brew by Volume - BEKVTUTUIFWPMVNFCSFXFEUIFGBDUPSZEFGBVMUJTP[-8JUIBOFNQUZBJSQPUJO
place, press the appropriate BREW button. When the desired volume is reached, press the same BREW
button again to stop the brew cycle and set the volume.
Brew by Time - adjusts the amount of coffee brewed by time rather than by volume (the factory default is
NJOTFD0ODFBDDFTTFEQSFTTŻor ŹVOUJMUIFOVNCFSPGNJOVUFTJTnBTIJOH5IFOQSFTT~repeatedly
to change the number value. Press Żor ŹVOUJMUIFOVNCFSPGTFDPOETJTnBTIJOH5IFOQSFTT~repeatedly
to change the number value. Press Żor ŹVOUJMiFYwJTnBTIJOHUIFOQSFTT~to exit.
Temperature - TFUTUIFCSFXJOHUFNQFSBUVSFPGUIFXBUFSIFMEJOUIFXBUFSUBOLUIFGBDUPSZEFGBVMUJT'
5IFSBOHFJT'UP'0ODFBDDFTTFEQSFTTŻor Źto choose the desired temperature. Then press ~
to set and exit.
Energy Save Mode - saves energy during periods when the brewer is not in use (the factory default is
0''8IFOTFUUP0/UIFCSFXFSBVUPNBUJDBMMZTIVUTPGGUXPIPVSTBGUFSUIFMBTUCSFXDZDMF1SFTTUIF0/
0''CVUUPOUPSFUVSOUPOPSNBMPQFSBUJPO8IFOTFUUP0/'UIFCSFXFSTIVUTPGGUXPIPVSTBGUFSUIFMBTU
CSFXDZDMFCVUUIFXBUFSUBOLUFNQFSBUVSFSFNBJOTBU'6TFUIF0/'TFUUJOHUPSFBDICSFXJOH
temperature faster after periods of non-use. Once accessed, press Żor Źto choose the desired setting.
Then press ~to set and exit.
Brew Count Odom - When accessed, this feature displays the total brew cycles since the odometer was last
reset. Press Żto exit or ~reset and exit.
Pre-Infusion - sets the brewer Pre-Infusion time (Pulse Brew must be off to access, the factory default is
%JTBCMFE1SF*OGVTJPOJODSFBTFTDPOUSPMPGDPGGFFDMBSJUZBOEFYUSBDUJPO8IFOUVSOFEPOUIFSBOHFJTUP
seconds. Once accessed, press Żor Źto choose the desired setting, then, press ~to exit. To turn off pulse
CSFXNPEFDIPPTFGPSUIFUJNF
When Pre-infusion is ON, Pulse Brew disappears from the list of menu items.
Brew Count Total - when accessed, displays the total brew cycles on the brewer. It cannot be reset. The
display returns to the previous screen automatically after a few seconds.
Cold Brew Lock - adjusts the temperature at which the brewer will brew coffee when the BREW button is
pressed (Ready to BrewBQQFBSTPOUIFEJTQMBZUIFGBDUPSZEFGBVMUJT'5IJTGFBUVSFBMTPBEKVTUTUIF
UFNQFSBUVSFBUXIJDIUIFIFBUJOHFMFNFOUUVSOTPOUPSFIFBUUIFXBUFSJOUIFUBOL5IFBWBJMBCMFTFUUJOHT
BSF¡'¡'BOE0''0''JTXJUIJO¡'CFMPXUIFUFNQFSBUVSFTFUUJOH0ODFBDDFTTFEQSFTTŻor Źto
choose the desired setting. Then press ~to set and exit.
Master Reset - SFTFUTUIFCSFXFSVOJWFSTBMDPOUSPMNPEVMF6$.UPUIFGBDUPSZEFGBVMUTFUUJOHT0ODF
accessed, “Are You Sure?” will appear on the display. Press Żfor Yes or Źfor No.
Service Call - sets the service phone number that appears on the display when the UCM detects a SENSOR
ERROR or WATER ERROR . Once accessed, press Żor Źto choose the number to be changed. Then press
~repeatedly to change the number value. Press Żor Źto choose the next number to change or choose exit
and press ~.
PROGRAMMING GUIDE PG8
8$8$130(3"..*/((6*%&ø "

PROGRAMMING GUIDE PG8
Programming Options (cont.)
Access Code - TFUTUIFBDDFTTDPEFFOUFSFEUPBDDFTTQSPHSBNNJOHNPEFUIFGBDUPSZEFGBVMUJT
Once accessed, press Żor Źto choose the number to change. Then press ~repeatedly to change the
OVNCFSWBMVFSBOHFJTUP1SFTTŻor Źto choose the next number to change or choose exit and
press ~.
Banner Name - changes the banner name that appears on the display (the factory default is Curtis/P
CBOOFSOBNFBQQFBSTXIFOBMMCMBOLTBSFFOUFSFE0ODFBDDFTTFEQSFTTŻor Źto choose the letter to
change. Then press ~repeatedly to change the number value. Press Żor Źto choose the next number to
change or choose ex and press ~to exit.
P-Maintenance - UVSOTPOPGGBOEBEKVTUTUIF1.BJOUFOBODFQSFWFOUJWFNBJOUFOBODFCSFXNPOJUPS
UIFGBDUPSZEFGBVMUJT0''8IFO0/UIF6$.NFBTVSFTUIFOVNCFSPGHBMMPOTCSFXFECFGPSFUIF
1.BJOUFOBODFSFNJOEFSBQQFBSTPOUIFEJTQMBZ5IFSBOHFJT0''UPHBMMPOT0ODFBDDFTTFEQSFTTŻ
or Źto choose the desired setting, then, press ~to exit.
Beeper On/Off - turns the beeper that is heard each time a button is pressed on or off (the factory default is
0/0ODFBDDFTTFEQSFTTŻor Źto choose the desired setting. Then, press ~to exit.
Pulse Brew - TFMFDUTUIFQVMTFCSFXQBUUFSO1SF*OGVTJPONVTUCFPGGUPBDDFTTUIFGBDUPSZEFGBVMUJT$5IF
QVMTFCSFXQBUUFSOTFMFDUFEiUVOFTwPSDIBOHFTUIFnBWPSPGUIFDPGGFF0ODFBDDFTTFEQSFTTŻor Źto
choose the desired setting. Then, press ~to exit.
8IFO1VMTF#SFXJTPO$PME#SFX-PDLJTTFUXJUIJO'BOE$PME#SFX-PDLBOE1SF*OGVTPO
disappear from the list of program selections.
Pulse Brew Guidelines
• 'JMUFSQBDLUZQFDPGGFFTUZQJDBMMZFYUSBDUCFUUFSXJUIUIF"BOE#QVMTFTFUUJOH
• Decaffeinated coffees typically extract better with the B pulse setting.
• High-yield coffees typically extract better with the C pulse setting. Of course, any of the A, B or C
TFUUJOHTNBZCFVTFEUPTVJUZPVSUBTUFQSPmMF
• Settings D and E are manual pulse counts.
Display Brew Time - UVSOTUIFEJTQMBZPGUIFCSFXUJNFEVSJOHCSFXJOHPOPSPGGUIFGBDUPSZEFGBVMUJT0/
Once accessed, press Żor Źto choose the desired setting, then press ~to exit.
Drip-out Mode - TFUTUIFESJQPVUNPEFUJNFS"GUFSXBUFSTUPQTnPXJOHJUBMMPXTBEEJUJPOBMUJNFGPSUIFXBUFS
UPESBJOGSPNUIFCSFXCBTLFUCFGPSFUIFCSFXCBTLFUMPDLSFMFBTFTUIFGBDUPSZEFGBVMUJTNJO5IJTGFBUVSF
SFEVDFTUIFDIBODFUIBUUIFCSFXCBTLFUXJMMCFSFNPWFEUPPFBSMZ5IFSBOHFJT0''UPNJOVUFT0ODF
accessed, press Żor Źto choose desired setting, then, press ~to exit.
8$8$130(3"..*/((6*%&ø "
Setting Description
A Starts at beginning of brew cycle. 4 cycles of 10 seconds on and 5 seconds off, then on until end of brew cycle.
BStarts towards end of brew cycle (without drip mode). 4 cycles of 5 seconds off and 4 cycles of 10 seconds on.
Ends when brew cycle ends.
C Starts at beginning of brew cycle. 5 cycles of 25 seconds on and 10 seconds off, then on until end of brew cycle.
DManually set. Starts at 30 seconds after the beginning of brew cycle. Number of pulses is adjustable from 1 to 10.
Pulse on time and off time are both adjustable from 5 to 60 seconds.
EManually set. Starts at beginning of brew cycle. Number of pulses is adjustable from 1 to 24. Pulse on time and off
time are both adjustable from 1 to 150 seconds.

PROGRAMMING GUIDE PG8
8$8$130(3"..*/((6*%&ø "
Programming Options (cont.)
Display Messages - UVSOTEJTQMBZPGUIFNFTTBHFi3JOTF4FSWFS#FGPSF#SFXJOHw0/PS0''UIFGBDUPSZ
EFGBVMUJT0/0ODFBDDFTTFEQSFTTŻor Źto choose the desired setting, then press ~to exit.
Model Select - changes the model number and number of batches (to match the label on the universal control
NPEVMFUIFGBDUPSZEFGBVMUJT%(50ODFBDDFTTFEQSFTTŻor Źuntil the model number matching the
model number label on the brewer appears, then press ~. Press Żor Źuntil the number of batches matches
the number of batch sizes on the UCM label, then press ~to exit.

ROUGH-IN DRAWINGS RD35
D1000 Airpot Coffee Brewers
D1000, ROUGH-IN DRAWING 120717A
D1000GH
29.25 in
[74.3 cm]
D1000GT
19.63 in
[49.8 cm]
D1000GH
26.38 in
[67.0 cm]
D1000GT
14.88 in
[37.8 cm]
D1000GT
13.88 in
[35.2 cm]
D1000GT
26.00 in
[66.0 cm]
D1000GH
22.88 in
[58.1 cm] D1000GT
23.13 in
[58.7 cm]
D1000GH
18.13 in
[46.0 cm]
D1000GH
17.13 in
[43.5 cm]
2.50 in
[6.4 cm]
20.00 in
[50.8 cm]
18.13 in
[46.0 cm]
16.88 in
[42.9 cm]
Water
Supply
16.50 in
[41.9 cm]
with WC-3316 brew basket with WC-3338 brew basket

ILLUSTRATED PARTS LIST IP51
D1000, ILLUSTRATED PARTS/RECOMMENDED PARTS 040319C
11A
11B
8
23
9
26
9
29
5
27
20
21
31
13
19
15
14
3
24
10
28
25
2
28
12A
12B
16A
16B
7A
7B
4
4
30
30
18
18
1
28
17
22
28
17
D1000GT/ D1000GH - Main Chassis - Exploded View
Water tank assemblies:
- 220 Volt, see section IP52
- Dual Voltage, see section IP53
6
A

ILLUSTRATED PARTS LIST IP51
D1000, ILLUSTRATED PARTS/RECOMMENDED PARTS 040319C
ITEM # PART # DESCRIPTION
1 WC-817 VALVE, DUMP RIGHT 120V 12W W/RECTIFIER
AP/GEM
2 WC-889 VALVE, DUMP LEFT 120V 12W ALPHA’S/D1000/
GEM-12/TLP
3 WC-3518 LEG, GLIDE 3/8”-16 STUD SCREW
4 WC-2962K aKIT, FITTING SPRAYHEAD SS
5 WC-314 POWER BLOCK, 5 STATION
6 WC-37132-101 KIT, VALVE REPAIR FOR DELTROL
WC-820WDR,WC-821WDR, WC-844WDR
7A WC-785 CONTROL MODULE, UCM 120V D1000 GT/
D500GT 2 BATCH
7B WC-37177 KIT, UCM & LABEL OVERLAY D1000GT
(INCLUDES ITEM 8)
8 WC-39430 LABEL, UCM OVERLAY INNER D1000GT
9 WC-29025 SPRAYHEAD, PURPLE ADVANCE FLOW
10 WC-8560 HEATSINK, ASSY 1PH GEM612ILD GEM-12D/
TL9002-10/D1000AP/T
11A WC-3316 BREW CONE, W/HANDLE ASSY 7.1”D.W/WC-
3317 & WC-3323 ALP/AP
11B WC-3338 BREW CONE, W/HANDLE ASSY 6.7”D DLX WC-
3314 & WC-3313
12A WC-5847 1COVER, FRONT D1000AP
12B WC-5848 2COVER, FRONT D1000GH TALL
13 WC-2401-P KIT, ELBOW 3/8 NPT X 1/4 FLARE
14 WC-1412-P CORD GRIP, 3/4” FOR METAL CORD TO .81”OD
15 WC-1200 2CORD, 14/3 SJTO 6’ BLK W/PLUG
16A WC-13273 1HARNESS, ASSY D1000GT 220V
16B WC-13285 2HARNESS, ASSY D1000GT DV 120/220
ITEM # PART # DESCRIPTION
17 WC-29044-101 SLEEVE, OVERFLOW
18 WC-4213-P NUT, 5/8 LOCK PLATED
19 WC-847 VALVE, INLET 2 GPM 120V 10W GEN USE
BROWN BODY
20 WC-5310 TUBE, 5/16 ID x 1/8W SILICONE GEN USE
21 WC-5231 COMPOUND, HEAT SINK 5OZ
22 WC-103 SWITCH, TOGGLE NON-LIT DPST 25A
125/250VAC RESISTIVE
23 WC-5421 COVER, TOP SS GEM-12D GEM-
612ILD,TL9002,312IL
24 WC-3503 LEG, 3/8”-16 STUD SCREW BUMPER
25 WC-1809-P FAUCET, PS/HPS SERIES HOT WTR 1/2-20 UNF
AP/ALP
26 WC-6221
GRID, DRIP TRAY SS C250/500/ 1000/
TL9001/9002/SCTL9002
(OPTIONAL, OLDER UNITS WITH SUMP IN BASE)
27 WC-39396
LABEL, UCM OVERLAY DUAL D1000GT/H
CURTIS LOGO (INCLUDES INNER AND OUTER
LABEL)
28 WC-4426 SCREW, 8-32x3/8 PH HEAD TRUSS
29 WC-1806 SEAT CUP, SILICONE USE ON WC-1809 FAUCET
30 WC-4320 O’RING, 0.487I.D.x 0.693OD x0.103CS BUNA-N
#112
31 WC-4616 SCREW, 1/4-20 x 1/2 PHILLIPS PAN HEAD
STAINLESS STEEL
D1000GT/ D1000GH - Main Chassis - Parts List
ITEM # PART # DESCRIPTION
1 WC-817 VALVE, DUMP RIGHT 120V 12W W/RECTIFIER
AP/GEM
2 WC-889 VALVE, DUMP LEFT 120V 12W ALPHA’S/D1000/
GEM-12/TLP
6 WC-37132-101 KIT, VALVE REPAIR FOR DELTROL
WC-820WDR,WC-821WDR, WC-844WDR
7B WC-37177 KIT, UCM & LABEL OVERLAY D1000GT
(INCLUDES ITEM 8)
ITEM # PART # DESCRIPTION
9 WC-29025 SPRAYHEAD, PURPLE ADVANCE FLOW
19 WC-847 VALVE, INLET 2 GPM 120V 10W GEN USE
BROWN BODY
20 WC-5310 TUBE, 5/16 ID x 1/8W SILICONE GEN USE
21 WC-5231 COMPOUND, HEAT SINK 5OZ
22 WC-103 SWITCH, TOGGLE NON-LIT DPST 25A
125/250VAC RESISTIVE
D1000GT/ D1000GH - Recommended Parts to Stock
1D1000GT, 2D1000GH
a6WDLQOHVVVWHHOÀWWLQJNLWLVFRPSDWLEOHZLWKROGHUXQLWV