Curtis G4 Omega Series User manual

G4 Omega Series 3.0/6.0 Gallon
Coffee Brewing System
USER GUIDE
READ AND SAVE THESE INSTRUCTIONS
NOTICE TO INSTALLER: Please leave this booklet with the machine.
øøøøø "
'$0.&("'30/5$07&3 'SFW/$

CONTENTS CL37
.H\)HDWXUHV6SHFLÀFDWLRQV6\VWHP5HTXLUHPHQWV..............................................................................................FS37
,PSRUWDQW6DIHJXDUGV............................................................................................................................................... IS2
,QVWDOODWLRQ,QVWUXFWLRQV*HQHUDO...............................................................................................................................II2
,QVWDOODWLRQ,QVWUXFWLRQV/HYHOLQJ:DWHU6XSSO\(OHFWULFDO......................................................................................II6
2SHUDWLQJ,QVWUXFWLRQV ............................................................................................................................................OI30
&OHDQLQJ,QVWUXFWLRQV%UHZHU ...............................................................................................................................CI13
&OHDQLQJ,QVWUXFWLRQV%UHZ%DVNHW ......................................................................................................................CI14
&OHDQLQJ,QVWUXFWLRQV7KHUPDO'LVSHQVHUV ..........................................................................................................CI15
3URJUDPPLQJ*XLGH ............................................................................................................................................... 3*
5RXJK,Q'UDZLQJ................................................................................................................................................. 5'
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV0DLQ&KDVVLV........................................................................................... IP68
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\6LQJOH............................................................................ IP70
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\7ZLQ9ROW............................................................... IP71
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\7ZLQ9ROW............................................................... IP72
(OHFWULFDO6FKHPDWLF20*6................................................................................................................................ES70
(OHFWULFDO6FKHPDWLF20*6*......................................................................................................................ES71
(OHFWULFDO6FKHPDWLF20*7*....................................................................................................................ES72
(OHFWULFDO6FKHPDWLF20*7* ...........................................................................................................................ES73
(OHFWULFDO6FKHPDWLF20*7*......................................................................................................................ES74
(OHFWULFDO6FKHPDWLF20*7*......................................................................................................................ES75
7URXEOHVKRRWLQJ*XLGH*HQHUDO............................................................................................................................7*
7URXEOHVKRRWLQJ*XLGH665&LUFXLW ......................................................................................................................7*
7URXEOHVKRRWLQJ*XLGH'LDJQRVWLFV ....................................................................................................................7*
(UURU&RGHV .............................................................................................................................................................EC1
3URGXFW:DUUDQW\....................................................................................................................................................3:
Contact Information
Wilbur Curtis Co., Inc.
6913 Acco Street | Montebello, CA 90640 US
Phone: [phone] | Toll Free: 800-421-6150
Email: [email protected] | Web: www.wilburcurtis.com
'PSUIFMBUFTUTQFDJmDBUJPOTBOEJOGPSNBUJPOHPUPXXXXJMCVSDVSUJTDPN
5PMM'SFF].POEBZ'SJEBZA.M.- 4:00 P.M.PT
Email: [email protected]
%VFUPDPOUJOVFEQSPEVDUJNQSPWFNFOUUIFQSPEVDUTJMMVTUSBUFEQIPUPHSBQIFEJOUIJTHVJEFNBZWBSZTMJHIUMZGSPNUIFBDUVBMQSPEVDU
0.&("$0/5&/54-*45øø  "

KEY FEATURES/SPECIFICATIONS/SYSTEM REQUIREMENTS FS37
Key Features
• High Volume Brewing – OMGT/OMGT10 brews 36 gallons of coffee per hour. OMGS brews 25 gallons of
coffee per hour
• High Volume Tank Capacity – 6.5 gallons (Single), 14.5 gallons (Twin)
• High Volume Brew Basket – Can accommodate up to 28 oz. of ground coffee
• G4 Digital Control Board – Password protected, precise control over all aspects of brewing, including
pre-infusion, pulse-brew and volume control
• Electrical Conversion – All Omega units ship standard from the factory as three phase. All units easily convert
GSPNUISFFQIBTFUPTJOHMFQIBTFJOUIFmFME
6SHFLÀFDWLRQV6HOHFWHG0RGHOV
(OHFWULFDO6XSSO\5HTXLUHPHQWV
02'(/ '(6&5,37,21 3+$6( 92/76 $036 +($7,1*&21),* :,5( :$776 +(57= *$/+5
20*6 Single (3.0 gallon) 3 PH
1 PH
220 V
220 V
19.9 A
23.2 A
3 x 2500 W
2 x 2500 W
4W + G
3W + G
7600 W
5100 W
50/60 Hz
50/60 Hz
23.3
15.5
20*6 Single (3.0 gallon) with transformer 3 PH
1 PH
220 V
220 V
19.9 A
23.2 A
3 x 2500 W
2 x 2500 W
3W + G
2W + G
7600 W
5100 W
50/60 Hz
50/60 Hz
23.3
15.5
20*7 Twin (6.0 gallon), 208 Volt 3 PH
1 PH
208 V
208 V
34.0 A
39.4 A
3 x 4000 W
2 x 4000 W
4W + G
3W + G
12200 W
8200 W
50/60 Hz
50/60 Hz
36.0
24.8
20*7 Twin (6.0 gallon), 240 Volt 3 PH
1 PH
240 V
240 V
29.4 A
34.2 A
3 x 4000 W
2 x 4000 W
4W + G
3W + G
12200 W
8200 W
50/60 Hz
50/60 Hz
36.0
24.8
20*7 Twin (6.0 gallon), 208 Volt with
transformer
3 PH
1 PH
208 V
208 V
34.0 A
39.4 A
3 x 4000 W
2 x 4000 W
3W + G
2W + G
12200 W
8200 W
50/60 Hz
50/60 Hz
36.0
24.8
([SRUW
20*7 Twin (6.0 gallon), export 3 PH
1 PH
415 V
415 V
21.0 A
20.0 A
3 x 4000 W
2 x 4000 W
3W + G
2W + G
15000 W
8200 W
50/60 Hz
50/60 Hz
36.0
24.8
$OOXQLWVVKLSFRQÀJXUHGIRUSKDVHRSHUDWLRQDQGDUHÀHOGFRQYHUWLEOHWRVLQJOHSKDVH
'LPHQVLRQV :DWHU6XSSO\5HTXLUHPHQWV
02'(/ +(,*+7 :,'7+ '(37+ 6+,3:(,*+7 6+,3&8%( :$7(5&211(&725 :$7(535(6685( 0,1)/2:5$7(
20*6 40.13” 21.38” 23.25” OEV 16.0 cu ft µÁDUH
20 - 90 psi 4.0 gpm
20*6 40.13” 21.38” 23.25” OEV 16.0 cu ft µÁDUH
20 - 90 psi 4.0 gpm
20*7 40.13” 36.50” 23.25” OEV 30.7 cu ft µÁDUH 20 - 90 psi 4.0 gpm
20*7 40.13” 36.50” 23.25” OEV 30.7 cu ft µÁDUH 20 - 90 psi 4.0 gpm
20*7 40.13” 36.50” 23.25” OEV 30.7 cu ft µÁDUH 20 - 90 psi 4.0 gpm
([SRUW
20*7 40.13” 36.50” 23.25” OEV 30.7 cu ft µÁDUH
20 - 90 psi 4.0 gpm
OMEGA, KEY FEATURES/SPECS/SYSTEM REQUIREMENTS 102417NC
Following are the factory default settings for the Omega brewer:
• Brew Volume = Large-Medium-Small
• Energy Save Mode = Off
• Brew Temperature = 200°F
• Water Bypass = LARGE: 20%
MEDIUM: 20%
SMALL: 10%

IMPORTANT SAFEGUARDS IS2
Symbols
This is the safety alert symbol. It is used to alert you to potential physical injury hazards. Obey all safety
messages that follow this symbol to avoid possible injury or death.
DANGER - Indicates a hazardous situation which, if not avoided, will result in death or serious injury.
WARNING - Indicates a hazardous situation which, if not avoided, could result in death or serious injury.
CAUTION - Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
NOTICE - Indicates a situation which, if not avoided, could result in property damage.
IMPORTANT - Provides information and tips for proper operation.
SANITATION REQUIREMENTS
Important Safeguards/Conventions
WARNING:
• Make sure that this appliance is installed and grounded according to the INSTALLATION
*/4536$5*0/4CZRVBMJmFEQFSTPOOFMCFGPSFBUUFNQUJOHUPVTFJU'BJMVSFUPGPMMPXUIF*/45"--"5*0/
INSTRUCTIONS could result in personal injury or void the warranty.
• This appliance is designed for commercial use. Any service other than cleaning and preventive
maintenance should be performed by an authorized Wilbur Curtis service technician.
• 5PSFEVDFUIFSJTLPGmSFPSFMFDUSJDTIPDL%0/05PQFOUIFTFSWJDFQBOFMT5IFSFBSFOPVTFS
serviceable parts inside.
• Keep hands, arms and other items away from hot surfaces of the unit during operation.
• Clean the appliance and any dispensers completelyCFGPSFVTJOHUIFNGPSUIFmSTUUJNFBTBDDPSEJOHUP
the CLEANING INSTRUCTIONS. Clean them regularly as instructed in the CLEANING INSTRUCTIONS.
• Use this appliance only for its intended use, brewing/dispensing hot and/or cold beverages/water.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory
or mental capabilities or lack of experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person responsible for their safety. Children should
be supervised to ensure that they do not play with the appliance.
• Avoid spillage onto the power (mains) connector.
$0''&&5&"#3&8&34*.1035"/54"'&(6"3%44:.#0-4 &
WARNING - 5IJTQSPEVDUDBOFYQPTFZPVUPDIFNJDBMTJODMVEJOH"DSZMBNJEFBOE#JTQIFOPM"#1"
which are known to the State of California to cause cancer and birth defects or other reproductive harm.
'PSNPSFJOGPSNBUJPOWJTJUXXX18BSOJOHTDBHPW

IMPORTANT SAFEGUARDS IS2
$0''&&5&"#3&8&34*.1035"/54"'&(6"3%44:.#0-4 &
CE Requirements
• This appliance must be installed in locations where it can be overseen by trained personnel.
• 'PSQSPQFSPQFSBUJPOUIJTBQQMJBODFNVTUCFJOTUBMMFEXIFSFUIFUFNQFSBUVSFJTCFUXFFO¡$UP¡$
• "QQMJBODFTIBMMOPUCFUJMUFENPSFUIBO¡GPSTBGFPQFSBUJPO
• "OFMFDUSJDJBONVTUQSPWJEFFMFDUSJDBMTFSWJDFBTTQFDJmFEJODPOGPSNBODFXJUIBMMMPDBMBOEOBUJPOBMDPEFT
'PSTBGFVTFBOBMMQPMFEJTDPOOFDUJPONVTUCFJODPSQPSBUFEJOUPUIFmYFEXJSJOHJOBDDPSEBODFXJUIUIF
XJSJOHSVMFTPVUMJOFEJODMBVTFPG*&$GPSNFFUJOHUIFNJOJNVNFMFDUSJDBMTBGFUZPGUIJTTUBOEBSE
• This appliance must not be cleaned by water jet.
• 5IJTBQQMJBODFDBOCFVTFECZQFSTPOTBHFEGSPNZFBSTBOEBCPWFJGUIFZIBWFCFFOHJWFOTVQFSWJTJPOPS
instruction concerning use of the appliance in a safe way and if they understand the hazards involved.
• ,FFQUIFBQQMJBODFBOEJUTDPSEPVUPGSFBDIPGDIJMESFOBHFEMFTTUIBOZFBST
• "QQMJBODFTDBOCFVTFECZQFSTPOTZFBSTBOEBCPWFXJUISFEVDFEQIZTJDBMTFOTPSZPSNFOUBMDBQBCJMJUJFT
or lack of experience and knowledge if they have been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards involved.
• $IJMESFOVOEFSUIFBHFPGZFBSTTIPVMECFTVQFSWJTFEUPFOTVSFUIFZEPOPUQMBZXJUIUIFBQQMJBODF
• If the power cord is ever damaged, it must be replaced by the manufacturer or authorized service personnel
with a special cord available from the manufacturer or its authorized service personnel in order to avoid a
hazard.
• Machine must not be immersed for cleaning.
• $MFBOJOHBOEVTFSNBJOUFOBODFTIBMMOPUCFNBEFCZDIJMESFOVOMFTTUIFZBSFPMEFSUIBOZFBSTBOE
supervised.
• This appliance is intended to be used in household and similar applications such as:
 oTUBGGLJUDIFOBSFBTJOTIPQTPGmDFTBOEPUIFSXPSLJOHFOWJSPONFOUT
 oCZDMJFOUTJOIPUFMTNPUFMTBOEPUIFSSFTJEFOUJBMUZQFFOWJSPONFOUT
– bed and breakfast type environments.
• This appliance not intended to be used in applications such as:
– farm houses
• Access to the service areas permitted by Authorized Service personnel only.
• 5IF"8FJHIUFETPVOEQSFTTVSFMFWFMJTCFMPXE#"

INSTALLATION INSTRUCTIONS II2
Installation Instructions
Installation Requirements
• A secure surface capable of supporting the weight of the appliance.
• For units without an attached cord set: Appropriately sized, UL listed, grounding type power cable to meet
UIFFMFDUSJDBMTQFDJmDBUJPOTGPSUIFBQQMJBODF*GZPVIBWFRVFTUJPOTBCPVUUIFDPSSFDUDBCMFTJ[FBOEMFOHUI
DPOTVMUBRVBMJmFEJOTUBMMFS*GUIFBQQMJBODFXJMMCFIBSEXJSFEUPBKVODUJPOCPYUIFQPXFSDBCMFNVTUCFMPOH
enoughTPUIBUUIFVOJUDBOCFNPWFEGPSDMFBOJOHVOEFSOFBUI
• "HSPVOEFEFMFDUSJDBMDPOOFDUJPOUPBOFMFDUSJDBMDJSDVJUUIBUNFFUTUIFFMFDUSJDBMTQFDJmDBUJPOTPGUIF
appliance (see SPECIFICATIONS5IFDJSDVJUNVTUCFQSPUFDUFECZUIFBQQSPQSJBUFTJ[FEDJSDVJUCSFBLFS*G
ZPVBSFOPUDFSUBJOUIBUUIFFYJTUJOHDJSDVJUNFFUTUIFSFRVJSFNFOUTGPSZPVSVOJUDPOTVMUBMJDFOTFEFMFDUSJDJBO
• "XBUFSmMUSBUJPOTZTUFNJTSFRVJSFEUPNBJOUBJOUSPVCMFGSFFPQFSBUJPO8JMCVS$VSUJT$P*ODSFDPNNFOETB
8JMCVS$VSUJTBQQSPWFEXBUFSmMUFS7JTJUwww.wilburcurtis.comUPTFFUIFGVMMMJOFPG8JMCVS$VSUJTBQQSPWFE
XBUFSmMUFST
• 1PUBCMFXBUFSTVQQMZMJOFDPOOFDUJPOGSPNUIFXBUFSmMUFSDBQBCMFPGTVQQMZJOHUIFNJOJNVNnPXSBUFSFRVJSFE
CZUIFTQFDJmDBUJPOT5IFXBUFSTVQQMZMJOFNVTUCFBCMFUPDPOOFDUUPUIFnBSFmUUJOHPOUIFCBDLPGUIF
unit. See the SPECIFICATIONS section for the correct size. The water line should also be capable of being
DPOUSPMMFECZBTIVUPGGWBMWF%POPUDPOOFDUUIFXBUFSMJOFUPBTBEEMFWBMWFPSOFFEMFWBMWF
/4'*OUFSOBUJPOBMSFRVJSFTUIFGPMMPXJOHXBUFSDPOOFDUJPO
1 "RVJDLEJTDPOOFDUPSBEEJUJPOBMDPJMFEUVCJOHBUMFBTUUXPUJNFTUIFEFQUIPGUIFapplianceJTSFRVJSFE
 TPUIBUJUDBOCFNPWFEGPSDMFBOJOHVOEFSOFBUI
2 5IJTFRVJQNFOUJTUPCFJOTUBMMFEXJUIBEFRVBUFCBDLnPXQSPUFDUJPOUPDPNQMZXJUIBQQMJDBCMF
federal, state and local codes.
 8BUFSQJQFDPOOFDUJPOTBOEmYUVSFTEJSFDUMZDPOOFDUFEUPBQPUBCMFXBUFSTVQQMZTIBMMCFTJ[FE
installed and maintained in accordance with federal, state and local codes.
WARNING:*OTUBMMBUJPOJTUPCFQFSGPSNFEPOMZCZBRVBMJmFEJOTUBMMFS
WARNING: *NQSPQFS FMFDUSJDBM DPOOFDUJPO NBZ SFTVMU JO BO FMFDUSJD TIPDL IB[BSE 5IJT CSFXFS NVTU CF
properly grounded.
NOTICE:%0/05DPOOFDUUIJTCSFXFSUPBIPUXBUFSTVQQMZ5IFXBUFSJOMFUWBMWFJTOPUSBUFEGPSIPUXBUFS
%POPUFYDFFEUIFNBYJNVNXBUFSQSFTTVSFTUBUFEJOUIFSPECIFICATIONS section.
IMPORTANT:0CTFSWFBMMHPWFSOJOHDPEFTBOEPSEJOBODFT
#3&8&34(&/&3*$*/45"--"5*0/*/4536$5*0/4 $
5IF*OUFSOBUJPOBM1MVNCJOH$PEFPGUIF*OUFSOBUJPOBM$PEF$PVODJMBOEUIF'PPEBOE%SVH"ENJOJTUSBUJPO
'%"'PPE$PEFNBOVBMEJSFDUUIBUUIJTFRVJQNFOUNVTUCFJOTUBMMFEXJUIBEFRVBUFCBDLnPXQSFWFOUJPO
in compliance with federal, state and local codes. For units installed outside of the U.S.A., make sure that
the installation is in compliance with the applicable plumbing/sanitation code for your area.

INSTALLATION INSTRUCTIONS II6
Installation
Leveling
1 Position the brewer on the countertop. Level it left to
right and front to back by turning the bottom of the legs.
Connect the Water Supply
2 Flush the water supply line prior to installation to purge
BJSBOEEFCSJTGSPNUIFXBUFSmMUFSBOEUVCJOH
3 $POOFDUUIFXBUFSTVQQMZMJOFUPUIFnBSFmUUJOHPO
the back of the brewer. Leave the water supply valve
closed until the power is connected.
Installation Requirements (cont.)
• The brewer must maintain a minimum distance of 4 inches from the chassis to the walls on the left, right and
back sides (see below).
• The brewer must not have anything mounted above it or on top of it.
WARNING: Use the leveling legs to level the
brewer only. Do not use them to adjust brewer
height. Do not extend them higher than necessary.
0.&("*/45"--"5*0/*/4536$5*0/4ø 122717A
Top ViewFront View
Nothing on top of or above the brewer
4” (10.2 cm)
Brewer
4” (10.2 cm)
4” (10.2 cm)

INSTALLATION INSTRUCTIONS II6
Installation (cont.)
Connect the Brewer Wiring
4 Remove the screws that hold the top panel in place
and remove.
5 If the brewer will be operated using a single phase
power supply:
DOMESTIC UNITS: Remove the cap from the jumper
wire attached to the L3 terminal on the terminal block,
then attach the exposed end of the jumper wire to the
L2 terminal (L2 and L3 jumpered).
EXPORT UNITS: The L3 terminal is not used. Connect
the power cable to terminals L1, L2 and GND (2W + G).
6 Loosen the strain relief on the back of the brewer.
7 Feed the end of the power cable into the brewer.
8 Connect the wires on the power cable to the terminal
block inside.
9 Tighten the strain relief and replace the top panel.
10 Connect the power cable wires to the terminals in the
junction box. See the ELECTRICAL SCHEMATIC for
the power supply requirements.
Power Up the Brewer
11 Turn on the water supply valve.
12 Turn on the circuit breaker supplying power to the
brewer.
13 Turn the power switch on the right side of the brewer
UPUIF0/QPTJUJPO5IFXBUFSUBOLXJMMTUBSUUPmMM8IJMF
UIFUBOLJTmMMJOHJOTQFDUUIFXBUFSTVQQMZMJOFGPSMFBLT
continued...
Power switch
WARNING: Turn off power to the junction box at the
circuit breaker panel before connecting the power
cable to the brewer.
Rear
panel
Power
cord
Top
View
Terminal
block
Strain
relief
&RQ¿JXUDWLRQYDULHV
with model

14 Go to the PROGRAMMING GUIDE section and
program the brewer for the correct model and batch
number.
15 When the water level in the tank rises to the correct
volume, the heating elements will turn on automatically.
Depending on the brewer capacity, the incoming water
UFNQFSBUVSFBOEUIFFMFDUSJDBMTQFDJmDBUJPOTUIFXBUFS
tank typically requires about 25 to 45 minutes to reach
the factory set operating temperature. When the water
has heated, “Ready to Brew” should be on the display.
16 #FGPSFCSFXJOHGPSUIFmSTUUJNFEJTQFOTFPVODFTPG
hot water through the hot water faucet to help purge air
from the tubing inside the brewer.
17 Brew a cycle of at least 192 ounces, to purge any
remaining air from the tubing. See OPERATING
INSTRUCTIONS. During the initial brew cycle and
XIFOFWFSUIFmMUFSJTSFQMBDFEZPVNBZIFBSUIF
TPVOETPGBJSCFJOHQVSHFEGSPNUIFmMUFSUVCJOHBOE
water tank.
0.&("*/45"--"5*0/*/4536$5*0/4ø 122717A
INSTALLATION INSTRUCTIONS II6
IMPORTANT: When operating the brewer at
higher elevations, reduce the factory set operating
temperature (200°F) by 2°F for each 1000 feet of
elevation above 4000 feet. See PROGRAMMING
GUIDE.

OPERATING INSTRUCTIONS OI30
Brewing Instructions
The G4 Omega Brewer is factory preset for optimal performance.
0.&("01&3"5*/(*/4536$5*0/4ø /$
2 Center an empty dispenser
under the brew basket.
3 *OTFSUBDMFBOQBQFSmMUFS
into the brew basket. Fill with
the proper amount of ground
coffee. Level the coffee in the
mMUFS
4 4MJEFUIFmMMFECSFXCBTLFU
into the brew rails under the
control panel. Slide it all the
way back until it stops.
5 )PMEZPVSmOHFSPOUIF
appropriate brew icon. As
soon as you hear the click
of the brew valve, lift your
mOHFS#SFXJOHXJMMCFHJO
The brewer will brew coffee based on the settings programmed into the universal control module (UCM). To
change the settings, see the PROGRAMMING GUIDE section.
 The brewer should be ON.
$POmSNUIJTBUUIFQPXFS
switch on the side. “Ready
to brew” should be on the
display. If the brewer is
connected to an inter-lock
grinder, the grinder should
be on. When inter-lock
connection is made, grind
coffee at this time.
WARNING - TO AVOID SCALDING, AVOID SPLASHING. Keep body parts clear of the brewer during
CSFXJOH%POPUSFNPWFUIFCSFXCBTLFUXIJMFi#SFXJOHwBQQFBSTPOUIFEJTQMBZ
6 If a keypad appears on
the display, the brew code
feature is enabled (default
is off). Brewing will start
immediately after you enter
the brew code. See the
PROGRAMMING GUIDE to
set up/disable the brew code.
Power switch

NOTICE -Do not use cleaning liquids, compounds or powders containing chlorine (bleach) or corrosives.
5IFTFQSPEVDUTQSPNPUFDPSSPTJPOBOEXJMMEBNBHFUIFmOJTIFT USE OF THESE PRODUCTS WILL VOID
THE WARRANTY.
CLEANING INSTRUCTIONS CI13
Cleaning The Brewer - Daily
BREWERS WITH SIDE POWER SWITCH, CLEANING INSTRUCTIONS 101717NC
WARNING: HOT SURFACES -To avoid injury, allow the brewer and dispenser(s) to cool before cleaning.
The brewer should be OFF.5VSOUIFCSFXFSPGGCZnJQQJOHUIFNBJOQPXFSTXJUDIPOUIFTJEFUPUIF0''QPTJUJPO
1 Remove the dispenser(s). Wipe exterior brewer surfaces with a damp cloth to remove spills and debris.
2 Remove the brew basket(s) and clean them in a mild detergent solution. Use a soft bristled brush for hard to
clean areas. Rinse with clean water, then dry.
3 Wipe the spray head area with a cloth soaked in a mild detergent solution. Rinse with a cloth soaked with
clean water removing any residual detergent. Use a clean, soft cloth to dry.
4 Dump out the drip tray(s) (if applicable). Rinse with clean water, then dry with a soft, clean cloth.
Cleaning The Brewer - Weekly
The brewer should be OFF.5VSOUIFCSFXFSPGGCZnJQQJOHUIFNBJOQPXFSTXJUDIPOUIFTJEFUPUIF0''QPTJUJPO
1 Remove the spray head(s), unscrewing counterclockwise from the dome plate.
2 Thoroughly clean and rinse the dome plate area.
3 Clean the brew basket rails with a brush soaked with a mild detergent solution. Rinse the area with a cloth
soaked with clean water, removing any residual detergent.
4 Dry the area with a soft, clean cloth.
5 Reattach the spray head(s).
WARNING: DO NOT immerse the brewer in water or any other liquid.

Cleaning the Brew Basket Handles (Weekly)
CLEANING INSTRUCTIONS CI14
-"3(&$"1"$*5:#3&8#"4,&5$-&"/*/(*/4536$5*0/4ø /$
Once a week clean the brew basket handles.
 Prepare a mild solution of dishwashing detergent
and warm water.
2 Remove the two handles from the brew basket.
Use a slotted screwdriver to remove the four slotted
screws that attach them.
3 Clean the brew basket with the mild detergent
solution. Use a soft bristled brush for hard to clean
areas. Rinse with clean water, then dry.
4 Use the soft bristled brush soaked in detergent to
brush out the hard to reach recessed areas of the
handle. Pay special attention to the attachment
channels of the handle.
5 Rinse the handles to remove all detergent residue
and air dry.
6 Reattach the handles onto the brew basket.

Cleaning the 3.0 Gallon Thermal Dispensers (Daily)
CLEANING INSTRUCTIONS CI15
("--0/5)&3."-%*41&/4&3$-&"/*/(*/4536$5*0/4ø /$
Gauge glass
shield
Faucet
Assembly
Silicone
cup
Lid
assembly
Glass
tube
WARNING: DO NOT immerse thermal dispensers in water or any other liquid. Do not place the thermal
dispensers in a dishwasher. Placing a thermal dispenser in a dishwasher will void the warranty. To avoid
damage, DO NOT use a brush to clean the faucet or the inside of the dispenser shank (outlet).
Cleaning the Container
 Prepare a mild solution of detergent and warm
water. Remove the dispenser from the brewer and
remove the lid. Rinse.
 Wash - Wipe the exterior surfaces of the container
with a sponge soaked with the detergent solution
to remove spills and debris. Fill the liner with the
detergent solution. Take a sponge brush and scrub
out the stainless steel liner.
3 Rinse - Rinse with clean, warm water.
 Sanitize - Sanitize the interior of the dispenser
using a commercial sanitizer suitable for food grade
applications. Swab, brush or pressure spray the
sanitizing solution according to the directions on the
package.
5 Air Dry - Turn the container upside down and allow
to air dry.
Cleaning the Faucet Parts, Lid and Gauge Glass
 Disassemble the faucet - Unscrew the handle/
bonnet assembly from the top of the faucet
and remove it. Inspect the seat cup for wear.
Replace the seat cup if it is damaged.
Unscrew the two screws from the base of the
gauge glass shield and remove the shield.
Carefully lift the gauge glass tube from the
silicone cup. Inspect the glass tube for cracks
or chips. If broken, replace the glass with a new
one.
 Wash - Wash the faucet parts, the lid, the
gauge glass and silicone parts in the detergent
solution. Using the supplied brush, clean inside
UIFmMMUVCFPOUIFMJE$MFBOUIFJOTJEFPGUIF
gauge glass with a gauge brush soaked with
detergent solution.
3 Rinse - Thoroughly rinse all parts with clean,
warm water.
 Sanitize - After rinsing, place the lid, the
faucet parts and the gauge parts in a sink to
be sanitized. Immerse them in a commercial
sanitizer suitable for food grade applications.
Sanitize according to the directions on the
package.
5 Air Dry - Allow all parts to thoroughly air dry.
6 Reassemble - When dry, reassemble the
handle/bonnet. Hand tighten the handle/bonnet
onto the top of the faucet assembly, reinstall
the site gauge and cover. If replacing a broken
gauge glass, carefully remove any traces of
glass from the silicone parts before inserting
the new gauge glass tube. Reinstall the lid.
Seat
cup
Handle
Bonnet
Top
cap

PROGRAMMING GUIDE PG1
Touchscreen Control Module
The touchscreen turns on whenever power is provided to the brewer and the rear toggle switch is on. The symbol
buttons on the screen control operation and programming. Pressing the on-screen symbols and buttons with
ZPVSmOHFSUJQBDUJWBUFTUIFWBSJPVTGVODUJPOT5IFEFGBVMUTDSFFOBTXFMMBTBEEJUJPOBMDPOUSPMCVUUPOTBSFTIPXO
CFMPX5IFDPOmHVSBUJPOPGUIFEFGBVMUTDSFFOWBSJFTEFQFOEJOHPOUIFCSFXFSNPEFM
2 The ACCESS CODE screen will appear. The
EFGBVMUQBTTDPEFJT0ODFUIFDPEFJT
FOUFSFEQSFTT0,5IF."*/.&/6TDSFFOXJMM
appear. The access code can be reset in the
$POUSPM4FUUJOHTTVCNFOVVOEFS1BTTXPSET
Status lights
Brew Buttons
Curtis logoHome Undo Scroll
left/right
Return to
previous
Control symbols - all
symbols may not be
present at the same
time
Entering Programming Mode
 5BQUIFXIJUF$VSUJTMPHPPOUIFUPVDITDSFFOmWFUJNFTUPFOUFSQSPHSBNNJOHNPEFTFFEJBHSBNBCPWF
 5IF."*/.&/6TDSFFODPOUBJOTBTFSJFTPGTVC
menu icons. The icons vary based on the model
TFMFDUFEVOEFSUIF.PEFM4FMFDUTVCNFOV'PS
UIFCSFXFSUPPQFSBUFQSPQFSMZUIFNPEFMTFMFDUFE
must match the model series on the brewer model
OVNCFSMBCFMBGmYFEUPUIFPVUTJEFPGUIFNBDIJOF
(130(3"..*/((6*%&ø %

PROGRAMMING GUIDE PG1
SELECTIONS FOR
COFFEE BREWER MODELS
SELECTIONS FOR
TEA BREWER MODELS
SELECTIONS FOR
COMBO BREWER
MODELS
Coffee
Gemini
Gemini IF
GEMX
TP/TPX
Milano
Omega
Gourmet Std
Light Roast
Dark Roast
High Yield
Filter Pack
Decaf
Custom Recipe
Model Select Control Settings Brew Settings
Recipes
Tea
Model Select Control Settings Brew Settings Settings Summary
Recipes
Combo
Model Select Control Settings Coffee
Brew Settings
Tea
Brew Settings Settings Summary Exit
Exit
Settings Summary Exit
Tea Recipes Coffee Recipes
Temperature Settings
Warmer Settings*
Quality Timer
Energy Savings
Sounds
Diagnostics
Display Settings
Preventative Maintenance
Brew Counter
Passwords
Master Reset
Regional Settings
Filter Pre-Wet*
Satellite LED Color*
Rinse Volume*
Custom Recipes
Chemex
V60
Kalita
Brew Basket
Custom Recipes
TP1G/TP1GX Single
Twin
Single
Twin
One Batch
Two Batch
Three Batch
One Batch
Two Batch
Three Batch
See Brew
Settings
One Batch
One Batch
Two Batch
Seraphim Twin Paper Cup
Gold Cup
By Volume/Time
Pre/Pulse
Bypass
Drip Out
Tea/IC-1Batch
Tea/IC-2Batch
Tea/IC-3Batch
Tea/IC-4Batch
Tea-Sweet
Dual-Dilution
Dual-Sweet
Standard-Purple
Standard-Gray
Standard-Amber
Tropical-Purple
Tropical-Gray
76/308-Purple
76/308-Gray
Temperature Settings
Quality Timer
Energy Savings
Sounds
Diagnostics
Display Settings
Preventative Maintenance
Brew Counter
Passwords
Master Reset
Regional Settings
Full Only
Full & Half
By Volume/Time
Dilution by Volume/Time
Dilution Delay/Stir/Fast-Brew
Pulses
Drip-Out
Sweetener*
Combo
Combo/IC
Combo-Sweet
Standard-Purple
Standard-Gray
Standard-Amber
Tropical-Purple
Tropical-Gray
76/308-Purple
76/308-Gray
Standard-Amber
Tropical-Amber
76/308-Amber
Standard-Purple
Standard-Amber
Gourmet Std
Light Roast
Dark Roast
High Yield
Filter Pack
Decaf
Temperature
Quality Timer
Energy Savings
Sounds
Diagnostics
Display Settings
Preventative Maintenance
Brew Counter
Passwords
Master Reset
Regional Settings
Full Only
Full & Half
Combo HV
Combo HV/IC
Single
Twin
By Volume/Time
Dilution by Volume/Time
Dilution Delay
Pulses
Drip-Out
By Volume/Time
Pre/Pulse
Bypass
Drip-Out
Pulses
Sprayhead Types
Batch Size
Sprayhead Types
Single
Twin
Ceramic Cup
Paper Cup
Filter pack
One Batch
Two Batch
Three Batch
®
™
™
®
®
Programming
4IPXOCFMPXBSFUIFWBSJPVTQSPHSBNNJOHPQUJPOTBWBJMBCMFJOUIFQSPHSBNNJOH."*/.&/65IFJDPOTUIBU
BQQFBSWBSZCBTFEPOUIFCSFXFSNPEFMTFMFDUFEVOEFS.PEFM4FMFDU
'FBUVSFOPUBWBJMBCMFPOTPNFNPEFMT
(130(3"..*/((6*%&ø %

PROGRAMMING GUIDE PG1
USB - Easy Programming
5IFSFBSFUXPNFUIPETGPSDIBOHJOHUIFEFGBVMUTFUUJOHTPO(CSFXFST5IFTFUUJOHTDBO
CFQSPHSBNNFENBOVBMMZVTJOHUIFCSFXFSUPVDITDSFFOPSBVUPNBUJDBMMZVTJOHUIF64#
6OJWFSTBM4FSJBM#VTEBUBQPSUPOUIFTJEFPGUIFCSFXFS6TJOHUIF64#DPOOFDUJPOBOE
BnBTIESJWFFBTJMZSFQSPHSBNTUIFTFUUJOHTCZTJNQMZDPQZJOHEBUB
"nBTIESJWFDBODPQZBMMPGUIFTFUUJOHTGSPNPOFJEFOUJDBM(CSFXFSUPBOPUIFS%PJOHTPFMJNJOBUFTUIFOFFEUP
program each step individually using the touchscreen. This process also makes it easy to quickly standardize the
QSPHSBNTFUUJOHTPONVMUJQMF(CSFXFST
6TFBnBTIESJWFUIBUTVQQPSUT64#PSBCPWFBOEIBTBUZQF"64#DPOOFDUJPO5IFTUPSBHFDBQBDJUZNVTU
CF(#NJOJNVN
IMPORTANT:5IFnBTIESJWFNVTUCFcompletelyCMBOL&SBTFBOZFYJTUJOHmMFTPOUIFESJWFCFGPSF
TUBSUJOHUIFGPMMPXJOHQSPDFTT
Uploading the Software to the Flash Drive
 .BLFTVSFUIFCSFXFSJTPO$IFDLUPNBLFTVSFUIBUUIFCSFXFSZPVBSFDPQZJOHTFUUJOHTGSPNJTQSPHSBNNFE
as desired.
2 0QFOUIFDPWFSPOUIF64#QPSUBOEJOTFSUUIFDPOOFDUPSPOUIFFNQUZnBTIESJWF5IFQPSUJTMPDBUFEPOUIF
SJHIUTJEFQBOFMPGUIFCSFXFSOFBSUIFUPQ5IFVOJWFSTBMDPOUSPMNPEVMF6$.XJMMVQMPBEBMMPGUIFTFUVQ
EBUBPOUPUIFnBTIESJWF5IFZFMMPX-&%JDPOPOUIFUPQMFGUPGUIFUPVDITDSFFOXJMMMJHIUJOEJDBUJOHUIBUEBUBJT
USBOTGFSSJOH5IJTQSPDFTTXJMMPOMZUBLFBTFDPOEUPDPNQMFUF
Downloading the Software to the Brewer from the Flash Drive
 Select the (identical) brewer you wish to make program changes to. The brewer must be on.
2 1MVHUIFMPBEFEnBTIESJWFJOUPUIF64#QPSUPOUIFCSFXFS5IFEBUBDPQJFEGSPNUIFmSTUCSFXFSXJMM
BVUPNBUJDBMMZEPXOMPBEPWFSXSJUJOHBMMUIFTFUUJOHTUIBUXFSFPOUIFTFDPOECSFXFS
 5IFSFE-&%POUIFUPQMFGUPGUIFUPVDITDSFFOXJMMJOEJDBUFUIBUUIFEPXOMPBEJTJOQSPDFTT5IJTXJMMPOMZUBLF
a second.
 0ODFUIFEPXOMPBEJTDPNQMFUFUIF6$.XJMMSFCPPUTPUIBUUIFDIBOHFTUBLFFGGFDU
 3FNPWFUIFnBTIESJWF5IFEPXOMPBEJTDPNQMFUF5IFEBUBPOUIFnBTIESJWFDBODPOUJOVFUPCFEPXOMPBEFE
into as many identical brewers as needed.
USB File Transfer
5IJTTDSFFOXJMMCFQSFTFOUXIFOFWFSUIF64#nBTIESJWFJTJOTFSUFE
provided the brewer is not currently brewing.
5IFEFGBVMUBDUJPOJTi/P"DUJPOw5IF6$.XJMMBMXBZTDSFBUFBCBDLVQ
POUIFnBTIESJWFCFGPSFEPXOMPBEJOHTFUUJOHTSFDJQFTPSBTDSFFOTBWFS
*GBmSNXBSFVQEBUFJTQSFTFOUPOUIFnBTIESJWFUIFmSNXBSFVQEBUF
QSPDFEVSFXJMMCFTUBSUFECFGPSFUIFTDSFFOJTTIPXO
FILE TRANSFER
Settings/recipes
Present on USB
Screensaver
Not present on USB
Start
Upload
to USB
Download
from USB No Action
(130(3"..*/((6*%&ø %

ROUGH-IN DRAWINGS RD43
Omega - Single Coffee Brewer
OMEGA, ROUGH-IN DRAWING 120116NC
21.38 in
[54.3 cm]
40.13 in
[101.9 cm]
9.00 in
[22.9 cm]
24.42 in
[62.0 cm]
25.23 in
64.1 cm]
23.56 in
59.8 cm]
22.31 in
[56.7 cm]
2.00 in
[5.1 cm]
14.69 in
[37.3 cm]
23.94 in
[60.8 cm]
8.13 in
[20.6 cm]

ROUGH-IN DRAWINGS RD43
Omega - Twin Coffee Brewer
OMEGA, ROUGH-IN DRAWING 102417NC
23.25 in
[59.1 cm]
23.38 in
[59.4 cm]
24.67 in
[62.6 cm]
22.00 in
[55.9 cm]
36.50 in
[92.7 cm]
14.13 in
[35.9 cm]
2.00 in
[5.1 cm]
40.13 in
[101.9 cm]
9.00 in
[22.9 cm]
24.25 in
[61.6 cm]

ILLUSTRATED PARTS LIST IP68
OMEGA, ILLUSTRATED PARTS/RECOMMENDED PARTS 111617NC
Supplies and Accessories - All Models
CAB-1 - Cleaning Brush
2
35
40
31
36
38B
38A
321
4
7
6
9
8
12
11
19
27
18
28
26
32
37A
37B
39
30A
30B
13A
13B
16
20
17
OMGS[16] - Main Chassis - Exploded View
Water tank assembly: See section IP70
5A
5B
41
1
14
34
42
33
15
10
43
24
29
25
22
23

ILLUSTRATED PARTS LIST IP68
OMEGA, ILLUSTRATED PARTS/RECOMMENDED PARTS 111617NC
ITEM # PART # DESCRIPTION
1 WC-5350 TUBE, 1/2 ID x 1/8W SILICONE GEN USE
3 WC-12012 VALVE, DUMP .50 DIA. 120VAC 50/60HZ OMGT/
OMGS
6 WC-442 SOLENOID, LOCK BREW CONE RIGHT/LEFT
120V TP2T/TP2S/GEMSS/GEM
9 WC-10001 CONTROL MODULE, UPM 120/220V G4
OMGS[16] - Recommended Parts to Stock
ITEM # PART # DESCRIPTION
14 WC-5310 TUBE, 5/16 ID x 1/8W SILICONE
19 WC-14045-101 CURRENT SENSOR ASSY G4
21 WC-12019 VALVE, INLET 4GPM 120V 9W BB/BH
22 WC-29086 SPRAYHEAD, PLASTIC 8 INCH DIAMETER
OMGT/OMGS
OMGS[16] - Main Chassis - Parts List
1OMGS 2OMGS16
ITEM # PART # DESCRIPTION
1 WC-5350 TUBE, 1/2 ID x 1/8W SILICONE GEN USE
2 WC-62068 LID, TOP OMGS
3 WC-12012 VALVE, DUMP .50 DIA. 120VAC 50/60HZ OMGT/
OMGS
4 WC-2977-02 FITTING, SPRAYHEAD PLASTIC
5A WC-33004 BREW CONE ASSY NON-METAL OMGT/S
5B WC-37593 KIT, BREW CONE ASSEMBLY W/WIRE BASKET
OMGT/S (INCLUDES ITEM 41)
6 WC-442 SOLENOID, LOCK BREW CONE RIGHT/LEFT
120V TP2T/TP2S/GEMSS/GEM
7 WC-43089 GASKET, 1.00OD X .625 I.D. X .030 THK WHITE
EPDM 70 SHORE
8 WC-10000 CONTROL MODULE, TOUCH SCREEN G4
9 WC-10001 CONTROL MODULE, UPM 120/220V G4
10 WC-8559-101 RELAY, SOLID STATE 480V/60A W/HEATSINK
AND SCREW TERMINALS
11 WC-300 POWER BLOCK, 3 STA 175A 600Vk RU’S
12 WC-305 POWER BLOCK, 3 STA 85A 600V
13A WC-1825 FAUCET, ASSY HOT WATER TP2S
13B WC-3705HW KIT, FAUCET S SERIES HOT WATER USE ON
WC-1800HW
14 WC-5310 TUBE, 5/16 ID x 1/8W SILICONE
15 WC-3528 LEG, 4" ADJUSTABLE 3/8-16 THRD ITALIAN
STYLE
16 WC-589-101 TRANSFORMER,120VAC-24V 4.8A W/ LEADS &
MOLEX CONNECTOR
17 WC-2402P ELBOW, 3/8”FL x 3/8” NPT PLATE
18 WC-588 NOISE, EMI FILTER 250VAC/20A
19 WC-14045-101 CURRENT SENSOR ASSY G4
20 WC-172 SWITCH, 50 AMP ROCKER STYLE OMGT/ OMGS
21 WC-12019 VALVE, INLET 4GPM 120V 9W BB/BH
22 WC-29086 SPRAYHEAD, PLASTIC 8 INCH DIAMETER
OMGT/OMGS
ITEM # PART # DESCRIPTION
23 WC-4549 SCREW, 3/8-16 X .787 KNURLED THUMB, SST.
OMEGA
24 WC-5231 COMPOUND, SILICONE 5OZ
25 WC-43141 O-RING, 7.484” ID X .139” CS OMGT/ OMGS
26 WC-10008 UNIVERSAL HOST ADAPTER USB
27 WC-1515 CORD GRIP, 1” OMGT/ OMGS
28 WC-1516 1,2,3 BREAKER, CIRCUIT 2-POLE 20A/ 250VAC
29 WC-43140 O-RING, 1” I.D. X 1/8” THICK OMGT/ OMGS
30A WC-13991 1HARNESS, ASSY OMGS
30B WC-13991-101 2HARNESS, ASSY OMGS16
31 WC-39982 LABEL, FRONT WRAP OMEGA
32 WC-4212-02 NUT, 5/8-18 JAM PLASTIC
33 WC-594-101 2TRANSFORMER, 250VA, 208-575VAC TO 24/115,
230VAC
34 WC-39805 LABEL, GOLD CUP NAMEPLATE
35 WC-53115 TRIM, EDGE VINYL 7/16”-1/32” X33/64 WITH
METAL CORE TCO/TC (ORDER 4 FEET)
36 WC-14017 PLUG, DOME 0.75”DIA HOLE BLACK PLASTIC
NYLON 6/6 FOR OMGT
37A WC-62069-102 COVER ASSY, FRONT NON- METAL BREW
CONE OMGS
37B WC-62069-101 COVER ASSY, FRONT NON-ROTATE OPTION
ONLY (NON-ROTATE OPTION ONLY)
38A WC-61819 BRACKET, SERVER STOP OMGT
38B WC-61819-101 BRACKET, BREWCONE NOT ROTATE
39 WC-2471 ELBOW, SILICONE OMEGA
40 WC-390092 LABEL, FRONT OMEGA CURTIS LOGO
41 WC-3394 BREW BASKET, WIRE ASSEMBLY OMGT/OMGS
42 WC-43059 CLAMP, HOSE SNAP NYLON .616/.707
43 WC-43058 PLUG, TANK DRAIN PLASTIC