Cygolite Metro 500 User manual

CYGOLITE
1307-A EAST SAINT GERTRUDE PL., SANTA ANA, CA 92705 USA
PHONE: [phone] EMAIL: [email protected]
www.cygolite.com
• Ultra bright 500 & 360 lumen outputs
• Custom TIR optic for cycling
• 6 Lighting modes
(Med > Hi > Low > 2-in-1 SteadypulseTM > DayLightning > Walking)
• Internal USB rechargeable Li-Ion battery
• Side illumination ports for added visibility
• Water resistant design
• Feather-light 110 grams
• LocktiteTM tool-free handlebar mount
OPERATION MANUALOPERATION MANUAL
OPERATION MANUALOPERATION MANUAL
OPERATION MANUAL
CONTENTS
•MetroHeadlight
• USB cable
•Handlebarbracket
In the USA, the Metro comes with a one year limited warranty against any
defective part or craftsmanship. The battery is warranted up to 180 days
after the original date of purchase. If the unit is under warranty, Cygolite
will repair or replace defective components at no charge provided the
product has not been subject to misuse, abuse, or non-Cygolite authorized
alteration, modification or repair. Warranted products requiring service
must receive a Return Merchandise Authorization number (RMA#) from
customer service. The original receipt (INCLUDING DATE) is required on
all warranty repairs. Shipping costs inccurred from shipping warranty or
repair items from the customer to Cygolite are covered by the customer.
For warranty issues outside the USA, contact the retailer where the
purchase was made.
The headlight will not turn on.
· Make sure the power button was firmly pressed.
· Make sure the light is fully charged.
All Cygolite products are backed by Cygolite’s warranty, providing
quality, craftsmanship, and the assistance of our knowledgeable staff.
If any support is needed, we will assist with 48 hour turnarounds on parts
and service. For questions, problems, and/or authorized Cygolite parts
contact us.
Congratulations on your purchase of the Metro LED headlight system.
Please refer to this guide to operate your Metro safely and properly.
The Metro series is designed to be used on bikes in some of the most
extreme outdoor conditions. Over time, dust and dirt may hinder the
connections on your headlight. To prevent this from happening, ensure that
the headlight is clean after every ride.
Wipe the headlight with a damp cloth. Do not submerge the battery or
headlight in water. Remove all dirt around or on the plugs or jacks on the
headlight.
The High-Brightness LED has extensive life so bulb replacement is not
required.
Q: When should I replace the bulb?
· The LED bulb has extensive life so bulb replacement is not neeeded.
Q: When should I charge my battery?
·
If the light dims dramatically during use, the battery is low. At this
time we recommend to turn the light off and charge immediately.
Cygolite recommends to monitor your run times and charge your
light according to its use. The battery can be charged any time, but
we recommend fully charging the battery every time you charge it.
Q: Can I use non-Cygolite parts for this unit?
· No, Cygolite parts are manufactured to specific quality
specifications. To ensure the quality of your lighting system,
only use Cygolite parts. Use of non-Cygolite parts will void the
warranty and may cause damage to the light.
Q: Can I leave my light charging for extended periods of time?
· Yes, the light is smart charging & will prevent from overcharging but
like all electrical appliances we recommend disconnecting the
headlight and charger when the light is fully charged.
Q: Will my Non-Cygolite USB charger recharge the Metro?
· Cygolite recommends to use the provided Cygolite USB cable
(or optional wall charger) to properly charge the Metro. Non-
Cygolite USB chargers can charge the Metro but make sure the
charger plug matches the USB port of the light and the power
button indicates the light is taking a charge. If the power button
does not illuminate when charging, charge the light with the
supplied USB cable.
Q: Can I use this light for activities other than cycling?
· No, this light is specifically intended for bicycle use only.
Q: What happens if water gets into the side illumination ports?
· Nothing will happen if water enters the side illumination ports since
the internals are water sealed.
Q: What if the battery needs replacement?
· If the battery ever needs replacement, contact Cygolite customer
service to arrange the battery relacement.
Bicycle Headlight System
with 24/7 Safety Technology
If you have more questions that are not listed here,
visit the support page at: www.cygolite.com
CAUTION:
· Headlight may get hot during use. Use caution when handling.
· Unplug the headlight from charger when not in use.
· Unplug connectors by the plug, never by the cable.
· Do not modify or substitute any parts with non-Cygolite parts.
· Do not open headlight case.
· Provide adequate airflow to the headlight to cool during use.
· If the light is on & stationary longer than 10 minutes, turn it off.
· Do not look directly at light.
· Do not operate or submerge under water.
· Do not operate the light unattended.
· Keep headlight away from combustible materials.
· Do not package headunit when hot or immediately after use.
· Carrying a flash light is recommended.
· This light is for bicycle use only.
· State laws regarding flashing bicycle lights may vary among states. Use the flashing
modes in accordance to your local state laws as well as federal law.
Metro 500 / 360
TM
FEATURESFEATURES
FEATURESFEATURES
FEATURES
CONTENTSCONTENTS
CONTENTSCONTENTS
CONTENTS
WARRANTYWARRANTY
WARRANTYWARRANTY
WARRANTY
COMMITMENTCOMMITMENT
COMMITMENTCOMMITMENT
COMMITMENT
CARECARE
CARECARE
CARE
TROUBLESHOOTINGTROUBLESHOOTING
TROUBLESHOOTINGTROUBLESHOOTING
TROUBLESHOOTING
F.A.Q.sF.A.Q.s
F.A.Q.sF.A.Q.s
F.A.Q.s

Charging Port
Rubber Cover
WARNING: Fully charge the battery before first time use. We
recommend to charge the battery with the supplied USB cable. If using
another USB cable or charger, check the power button to verify the light
is taking a proper charge. The button will iluminate to show its charging
status. The charger is for indoor use only.
3
1. Pull the top of the rubber cover to reveal the charging port.
(Do not remove rubber cover from light)
2. Connect the USB charging cable to a USB power source.
3. Insert charging cable into the USB charging port on back of light.
4. The power button on top of the light will flash green when charging
then have a steady green when fully charged.
5. Allow approximately 5 continuous hours to fully charge.
6. Disconnect the cables when charging is complete and cover charging
port with rubber cover.
The Metro features 6 light modes controlled by the power button. During
use, the power button will illuminate to show the power is on. The diagram
and instructions below indicate where the light features are located on the
headlight.
CAUTION: The light may get hot during use. Handle with care and turn
light off if stationary for more than 10 minutes.
OPERATION
1. Press power button to operate the light. The light will turn on and the
power button will illuminate.
2. Press power button to scroll through the different settings.
3. Hold the power button for 2 second to turn the light off.
4. Walking mode: (when the light is OFF, hold the power button for 2
second to turn the light ON in the Walking mode.
LIGHT MODE MEMORY
For convenience, the Metro memorizes the last mode used before it is
turned off. When it is turned back on, it will turn on in that mode.
LIGHT MODES
Med > High > Low > SteadypulseTM > DayLightningTM > Walking
24/7 Safety TechnologyTM are modes made specifically for night and
day use for added visibility whenever you ride.
SteadyPulseTM mode alerts motorists with triple pulses while constantly
lighting your path at night. It is made especially for riding at night in high
traffic areas.
DayLightningTM mode boosts flash brightness to lightning-like flashes
that are brighter than the high mode to demand motorist’s attention in
peak daylight.
CAUTION: For daytime use only.
SIDE ILLUMINATION PORTS
During use, the side ports will illuminate to provide added side visibility to
adjacent motorists and traffic.
3. Wrap bracket around handlebar, return thumbnut in slotted space, twist
thumbnut clockwise to tighten.
4. Slide headlight back into the bracket until headlight clicks into place.
5. To remove headlight, press the release tab on the bracket and slide the
headunit forward.
HEADLIGHT OPERATIONHEADLIGHT OPERATION
HEADLIGHT OPERATIONHEADLIGHT OPERATION
HEADLIGHT OPERATION
34
BATTERY CHARGINGBATTERY CHARGING
BATTERY CHARGINGBATTERY CHARGING
BATTERY CHARGING
1
RUN TIMESRUN TIMES
RUN TIMESRUN TIMES
RUN TIMES
Thumbnut
Release Tab
Power Button
(During use)
Solid = Light On
USB port
The LocktiteTM handlebar bracket has a tool-free design to let you mount
the bracket on the handlebar with ease while firmly staying in place
through all riding conditions.
1. Attach handlebar spacers to inside of handlebar bracket for standard
sized handlebars. Remove spacers for oversized handlebars.
2. Attach rubber pad to handlebar spacer (or handlebar bracket) for grip.
MOUNTING ON HANDLEBARSMOUNTING ON HANDLEBARS
MOUNTING ON HANDLEBARSMOUNTING ON HANDLEBARS
MOUNTING ON HANDLEBARS
Rubber pad
Attach Handlebar spacers
(for standard sized bars)
Power Button
(During charging)
Flash
Solid
= Charging
= Full
2
Side Illumination ports
4
ADJUST THE SIDE-TO-SIDE BEAM DIRECTION
Swivel the headlight left to right to adjust the side-
to-side direction. If side swivel becomes loose,
tighten the swivel screw on the top of the bracket
with a philips screwdriver.
ADJUSTING THE VERTICAL BEAM DIRECTION
Twist bracket thumbnut counterclockwise to loosen
bracket. Rotate bracket around handlbar for
preferred vertical beam angle then tighten
thumbnut.
OPTIONAL WALL CHARGING
If you prefer to charge directly through a wall outlet, an optional wall
charger (Part No. ND-0501000U) is available. To order, call Cygolite
customer service or order online at: shop.cygolite.com
1
2
OPTIONAL MOUNTING
An optional helmet mount kit (Part No. HLMT-DCV6) is available for this
light. To order, call Cygolite customer service or order online at:
shop.cygolite.com
Thumbnut
LOW BATTERY
If the light dims dramatically during use, the battery is near empty. At this time
we recommend stop using the light and recharge it immediately.
High
1:30
1:45
Med
2:15
2:30
Low
10
12
DayLightning
6
6
Light Modes (hr:min)
Model
METRO 500
METRO 360
Walking
30
30
SteadyPulse
3
3