Dialight Vigilant User manual

9100HZC280501 REV B
Dialight, 1501 Route 34 South, Farmingdale, NJ, USA 07727
Tel: [phone] Fax: [phone] www.dialight.com
Page 1
Area Light with Battery Backup UL1598/A / UL844 / UL924
Important Information
These instructions contain safety information, read and follow them carefully. Dialight will not accept any
responsibility for injury, damage or loss, which may occur due to incorrect installation, operation or maintenance.
Operation/Installation Instructions
Note:Save these instructions for future use
use.
Note:These instructions are for Battery Backup specific case only. For
general Area Light information, see supplemental instruction sheet

9100HZC280501 REV B
Dialight, 1501 Route 34 South, Farmingdale, NJ, USA 07727
Tel: [phone] Fax: [phone] www.dialight.com
Page 2
Area Light with Battery Backup UL1598/A / UL844 / UL924
WARNING:To avoid fire and electrical shock, turn off power at circuit breaker or
fuse and test that the power is off before wiring.
1. Install luminaire as intended using supplemental installation manual(s).
2. Connect the mains supply wires to the luminaire as shown below.
120-277 VAC BATTERY BACKUP SWITCH LIVE –
NORTH AMERICA
SYMBOL
COLOR
CONNECTION
GREEN
EARTH
L
BLACK
PERMANENT LIVE
L’
ORANGE
SWITCH LIVE
N
WHITE
NEUTRAL
Replacing the Battery Pack
1. Open battery cover by unscrewing six 10-32 captive screws as shown to access battery pack connection.
NOTE: For maintained battery backup, connect
the black wire to the supply permanent live and
the orange wire to the supply switch live. For
sustained battery backup, connect both the
orange and black wires to the supply live.

9100HZC280501 REV B
Dialight, 1501 Route 34 South, Farmingdale, NJ, USA 07727
Tel: [phone] Fax: [phone] www.dialight.com
Page 3
Area Light with Battery Backup UL1598/A / UL844 / UL924
2. Disconnect battery pack from battery driver as shown.
3. Unscrew two 10-32 screws and slide battery pack out of housing. Discard old battery pack according to
respective national regulations on waste disposal.

9100HZC280501 REV B
Dialight, 1501 Route 34 South, Farmingdale, NJ, USA 07727
Tel: [phone] Fax: [phone] www.dialight.com
Page 4
Area Light with Battery Backup UL1598/A / UL844 / UL924
4. Collect the replacement battery pack and slide into the battery enclosure as shown. Align the two 10-32
captive screws already in the pack with the two corresponding holes in the enclosure.
Torque to 28-30 in-lbs
5. Connect battery pack to battery driver as shown.
Figure A
Figure B

9100HZC280501 REV B
Dialight, 1501 Route 34 South, Farmingdale, NJ, USA 07727
Tel: [phone] Fax: [phone] www.dialight.com
Page 5
Area Light with Battery Backup UL1598/A / UL844 / UL924
6. Close battery cover by tightening six 10-32 captive screws as shown to 28-30 in-lbs.
NOTE: When closing, be sure no wires interfere with closure to avoid risk of pinching.
Battery Backup Function
Battery Backup Indicator Light Functions
LED Indicator Status
Status/Mode
Green ON and blinks every 10s
System OK/AC OK
Red ON and blinks every 5s
Battery not detected/Faulty, Check connections/Replace Battery
Red LED Blinks every 2s
Light Output Fault. Check wiring connections
RED LED Blinks every 1s
Multiple faults
Green LED Blinks every 2s
Performing Function Test*
Green LED blinks every 1s
Performing Duration Test/Commissioning Test*
*Function Test –Tests for the basic functionality of battery and light output connections
*Duration/Commissioning Test –Tests for full duration of light output in battery backup mode.
Technical Data
Area Light Battery Backup
Nominal AC Supply Voltage
120-277V AC, 50-60Hz, Single Phase
Power Consumption
[Lumens] [W]
9000 71
7000 (Wide Optic) 69
7000 57
6000 45
4000 35
3000 29
Power Factor(AC only) >0.95
ATHD(AC only) <10% @120VAC
<10% @230/240VAC
<12% @277VAC
Temperature
-4°F to +131°F [-20°C to +55°C]
Technical Data
Area Light Battery Backup (cont.)
Housing Material
A360 Die Cast Aluminum
Finish
Powder Coat
Gray, RAL 7040
Lens
Polycarbonate or glass
Dimensions
Conduit Mount option
10.7 x 12.2 x 8.1 in.
[271 x 311 x 205 mm]
All other mounting options
Size varies by mount type

9100HZC280501 REV B
Dialight, 1501 Route 34 South, Farmingdale, NJ, USA 07727
Tel: [phone] Fax: [phone] www.dialight.com
Page 6
Area Light with Battery Backup UL1598/A / UL844 / UL924
Technical Diagrams
Dimensions: in [mm]
NOTE: Below is for conduit mount luminaire only. Other available mounting options will effect overall dimensions.
Official Statement
All statements, technical information, and recommendations contained herein are based on information and tests that
Dialight believes to be reliable. The accuracy or completeness thereof is not guaranteed. In accordance with Dialight “Terms
and Conditions of Sale” and since conditions of use are outside our control, the purchaser should determine the suitability of
the product for his or her intended use and assumes all risk and liability whatsoever in connection therewith.