Eaton NZM2-XHB-DA Manual

Electric current! Danger to life!
Only skilled or instructed persons may carry out the
following operations.
Lebensgefahr durch elektrischen Strom!
Nur Elektrofachkräfte und elektrotechnisch
unterwiesene Personen dürfen die im Folgenden
beschriebenen Arbeiten ausführen.
Tension électrique dangereuse !
Seules les personnes qualifiées et averties doivent
exécuter les travaux ci-après.
¡Corriente eléctrica! ¡Peligro de muerte!
El trabajo a continuación descrito debe ser realizado
por personas cualificadas y advertidas.
Tensione elettrica: Pericolo di morte!
Solo persone abilitate e qualificate possono eseguire
le operazioni di seguito riportate.
触电危险！
只允许专业人员和受过专业训练的人员进行
下列工作。
Электрический ток! Опасно для жизни!
Только специалисты или проинструктированные
лица могут выполнять следующие операции.
en
de
fr
es
it
zh
ru
Emergency On Call Service: Local representative (www.eaton.eu/aftersales) or [phone] (de, en) 1/3
Instruction Leaflet
Montageanweisung
Notice d’installation
Instrucciones de montaje
Istruzioni per il montaggio
安装说明
Инструкция по монтажу
01/17 IL01206008Z
(AWA1230-2398)
NZM2-XHB-DA(R)(-OAG)(-NA)
Door Mounted Rotary Handle kit for Supply Circuit
Disconnecting Means, complete with internal
Supplementary Handle (shown at left) for compliance
with the provisions of NFPA 79, Electrical Standard for
Industrial Machinery, and UL 508A, Safety Standard
for Industrial Control Panels.
For use with NZM2, NS2 (-NA) E31593, E148671
Molded Case Circuit Breakers and Switches
UL File No. E140305 (DIHS) UL/CSA Type 4X, 12
CSA File No. LR 22086
T
R
I
P
O
F
F
O
N
1
OFF
Z 2
5
Z 2 2
1
3
4
2
45º
1
2
3
4 x
4
5
Z 2
4 x
1 Nm
(9 lb-in)
6
45º
3
3
OFF
T
R
I
P
O
F
F
O
N
7
T
R
I
P
O
F
F
O
N
2 x
Z 2
1 Nm
(9 lb-in)

2/3 Emergency On Call Service: Local representative (www.eaton.eu/aftersales) or [phone] (de, en)
01/17 IL01206008Z
Cutting shaft to desired length Re-installing handle and shaft
Cut to desired length
Smooth out cut end
Handle and shaft are factory assembled as one unit.
To facilitate cutting of shaft to desired length,
use a 3 mm (0.12“) hex wrench or driver to loosen
inner screw at base of handle and remove handle
and shaft unit from housing.
Re-install handle and shaft unit after cutting,
and re-tighten inner hex screw as shown.
Fasten door-mounted handle coupling piece
(supplied as part of the kit) to other end of shaft as shown.
1
f130 mm
(f5.12”)
40 mm
(1.57”)
2 - 5 mm
(0.08 - 0.20”)
2
o8.0 mm
(o0.31”)
3
4 x
4
36 mm g0.5 mm
(1.42” g0.02” )
5
6
7
T
R
I
P
O
F
F
O
N
3
2
1
3 mm
1
2
T
R
I
P
O
F
F
O
N
1
3
3 mm
2
2.5 Nm
(22 lb-in)
8
3 mm
2 Nm
(17.7 lb-in)
9
23 mm g1
(0.91” g0.04”)
10

Emergency On Call Service: Local representative (www.eaton.eu/aftersales) or [phone] (de, en) 3/3
01/17 IL01206008Z
Eaton Industries GmbH, Hein-Moeller-Straße 7-11, 53115 Bonn, Germany
© 2008 by Eaton Industries GmbH, www.eaton.eu/documentation All Rights Reserved
01/17 IL01206008Z DE05 Doku
Printed in Germany (01/17)
NZM2-XHB-DA-OAG
Per the intent of NFPA 79, Electrical Standard for Industrial
Machinery, the Supplementary Handle enables the Supply
Circuit Disconnecting Means to remain operable at all times
by qualified persons, independent of the door position and
without the use of accessory tools or devices.
In addition, use of the handle to close the disconnecting means
is prevented when the door is open, unless an interlock is
operated by deliberate action.
Deliberate Action to close Disconnecting Means:
Turn handle clockwise appr. 20° as shown.
From this position, push the handle in to engage shaft,
then turn clockwise to ON to close switch.
To open Disconnecting Means:
Turn handle counter-clockwise from ON to OFF.
(No deliberate action necessary when going from ON to OFF).
11
1
2
TRIP
Z 2
1 Nm
(8.9 lb-in)
3
OFF
TRIP
RESET
1
T
R
I
P
O
F
F
O
N
2
4 - 8 mm
(0.16 - 0.32”)
OFF
T
R
I
P
O
N
O
F
F
3
1
2
Q20°
T
R
I
P
O
F
F
O
N
Q20°
1
Warning! Danger to Life!
Operation of the Supplementary Handle may cause
circuits inside panel to become energized and create
a potentially hazardous condition. Operation to be
carried out by Qualified Persons only!