Elkay Harmony LKHA2031CR Operating instructions

SAVE FOR CONSUMER
INSTALLATION / OWNER’S MANUAL
Harmony - Pull-Down Kitchen Faucet
LKHA2031CR
LKHA2031NK
LKLFHA2031CR
LKLFHA2031NK
Includes:
Tools:
A
B
E
F
D
1/2”
[13 mm]
13/16”
[20 mm]
5/8”
[16 mm]
D1
D1
D2B1
B2
B3
B4
C1
C2
C
NOTE: only 1 D1 washer is
used with this faucet model
NOTE: these washers are not
used on this faucet model

321
Before inserting the single lever group in the hole of
the sink, make sure that the base gasket is properly
positioned in its seat and that the exible hoses are
well tightened to the body of the tap.
Place the single lever group in the hole of the sink,
orienting the spout toward the sink tank.
For countertop thicknesses less than 1/16” thick
use the rubber gasket (B1) and mounting ange
(B2), for all other installations use the rubber gasket
(B1) and metal washer (B3).
Secure mounting hardware in place by tightening
mounting nut (B4) with wrench (F).
Install the check valve (C2) to the outlet hose with a
rubber washer (C1).
Secure with wrench.
Attach the pull-down hose to the bottom of the
check valve with a rubber washer (D1).
Secure with wrench.
13/16”
[20 mm]
WARNING: please carefully read and properly follow the instructions for installation found in this manual.
STEPS:
1/2”
[13 mm]
54
Attach the counterweight (D2) to the exible hose
approximately 15-3/4” [400mm] from the connection
to the outlet pipe.
Connect the exible hoses to the supply connections
with rubber gaskets.
Secure with wrench.
Turn on the water and check for leaks.
321
Before dissassembling the faucet be sure that the water supply is turned off.
Remove the nish cap (A), paying attention not to damage it. Remove the setscrew (B) with a 1/8” [2,5mm] hex wrench. Remove the handle (C). Lift the nishing ring nut
(D) using the reference notch. Remove the indicator ring (E). Unscrew the cartridge nut (F) then pull out the cartridge (G). Put the new cartridge into the body of the faucet,
checking that the two centering pins enter into the respective seats (X) and that the gaskets on the cartridge are well positioned.
Reassmble the handle following the instructions in reverse order.
5/8”
[16 mm]
Hot
Cold
Red
Blue
CARTRIDGE REPLACEMENT
B
A
C
X
1/8”
[2,5 mm]
GF
1-1/8”
[28 mm]
E
D
B1
B3
B4
B2
F
A
C2
D1
D2
C1

1
321
Remove the hand shower from its seat. Unscrew it from its cover paying attention not to
lose the rubber gasket (A).
Separate the hand shower cover from the hose.
54
Unscrew the bushing connected to the end of the
hose (B) paying attention not to loose the rubber
gasket (C).
You can now totally remove the hose from the faucet
body and replace it with a new hose.
Reassemble the hand shower assembly by following
the instructions in reverse order.
REPLACEMENT OF THE HAND SHOWER
2
Before removing the aerator make sure that the faucet is turned off.
Unscrew the aerator using the aerator installtion key (E) included with the faucet.
If the aerator is clogged just rinse it with running water. Do not use detergents.
Reassemble the aerator by following the instructions in reverse order.
AERATOR CLEANING / REPLACING
1/2”
[13 mm]
5/16”
[8 mm]
E
A
B
C

CARE AND CLEANING INSTRUCTIONS
Congratulations on your purchase of an Elkay product.
Although your product is extremely durable, attention
should be given to the care, cleaning and maintenan-
ce of this product. Cleaning agents and abrasives may
cause damage, which may result in oxidation and di-
scoloration.
By following these simple guidelines for proper care
and cleaning, it will give you years of enjoyment:
TO CLEAN: Simply wipe gently with a damp cloth and
blot dry with a soft towel. A common rule of thumb is:
when you dry off, dry off your product.
Avoid build-up of soap, toothpaste or mineral de-•
posits, as these tend to have an adverse effect on
the appearance of the product.
NEVER use cleaning products of any kind on this•
product - especially those containing ammonia,
bleach or alcohol - or those with any form of abra-
sive.
FOR CARE AND MAINTENANCE:
The water in certain areas of the world can be•
very caustic - standing water around the product
can cause damage. Be sure to remove standing
water with a dry, soft cloth as soon as possible.
For polished brass nishes, as often as once •
a week, you can apply a paste wax or special,
non-abrasive, brass coating (DO NOT APPLY
POLISH).
Before applying a protective coating, gently brush•
the entire xture using a soft tooth brush. This will
remove any dirt or deposit build-up.
These simple steps will add temporary protective•
coating to your faucet and extend the life of the
nish.
Failure to follow care and cleaning will void your war-
ranty.
For additional information, please visit elkayusa.com.
WARRANTY
Elkay warrants that all parts and nishes of the Elkay
Residential brand faucets are free from defects in ma-
terials and workmanship for the life of the product, if
purchased after 1996. This warranty extends to the ori-
ginal consumer purchaser of the product only.
If the product should leak or drip during normal use,
Elkay will provide, free of charge, a replacement car-
tridge. For other defects in material or workmanship,
Elkay will, at its option, supply replacement parts (or if
no longer available a comparable product). Elkay re-
serves the right to examine product in question and its
installation prior to replacement.
What is not covered:
1. Damage caused by accident, negligence, misuse,
abuse, improper installation or operation or failure to
follow care or installation instructions enclosed with
your product.
2. Damage occurring during shipment of the product
(claims must be presented to the carrier).
3. Normal wear and tear.
4. Labor charges, costs of removal and reinstallation,
and any damages to other property.
5. All industrial, commercial and business use whose
purchasers are hereby extended a limited lifetime on
mechanical parts and 5 years on nish.
What you must do to obtain warranty service:
Either write to Elkay, attention Customer Care, 2222
Camden Court, Oak Brook, IL 60523 or call 1-800-223-
5529. Please provide date of purchase and installation,
description of nature of the defect, and model number
or description of model and/or component part.
THIS LIMITED WARRANTY IS EXPRESSLY IN LIEU
OF ANY OTHER WARRANTIES, EXPRESSED IM-
PLIED, ARISING BY LAW OR OTHERWISE, INCLU-
DING WITHOUT LIMITATION, ANY IMPLIED WAR-
RANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE. THIS LIMITED WAR-
RANTY MAY NOT BE ALTERED, VARIED, OR EX-
TENDED, EXCEPT BY A WRITTEN INSTRUMENT
EXECUTED BY ELKAY. THE REMEDY OF REPAIR
OR REPLACEMENT AS PROVIDED UNDER THIS
LIMITED WARRANTY IS EXCLUSIVE. IN NO EVENT
SHALL THE MANUFACTURER BE LIABLE FOR ANY
CONSEQUENTIAL OR INCIDENTAL DAMAGES TO
ANY PERSON, WHETHER OR NOT OCCASIONED
BY NEGLIGENCE OF ELKAY, INCLUDING WITHOUT
LIMITATION DAMAGES FOR LOSS OF USE, COSTS
PROPERTY DAMAGE OR OTHER MONETARY
LOSS.
Some states do not allow the exclusion or limitation of
incidental or consequential damages or limitations on
how long an implied warranty lasts, so the above limi-
tations or exclusions may not apply. This warranty from
state to state.
This warranty covers product installed in the United
States and Canada.
ELKAY LIMITED LIFETIME WARRANTY

Elkay
elkayusa.com
REPLACEMENT PARTS
LKHA2031CR
LKHA2031NK

Elkay
elkayusa.com
REPLACEMENT PARTS
LKLFHA2031CR
LKLFHA2031NK

ET40966 - R2