Elkay EFY8*1B Installation manual

PAGE 1 97345C (6/98)
EFY8*1B
Installation/Care/Use Manual
USES HFC-134A REFRIGERANT
FIG. 1
1, 2, 3
SEE FIG. 4
31
15, 18
36
27
32
21
33
35
23
34
30
28
6, 178
20
12
19
13, 14
16
25, 26
4, 7

PAGE 2
97345C (6/98)
EFY8*1B
FIG. 2
E = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.
ASEGURE UNA VENTILACIÓN ADECUADA MANTENIENDO UN ESPACIO E 4" (102mm) (MÍN.) DE HOLGURA ENTRE LA REJILLA DE VENTILACIÓN DEL MUEBLE Y LA PARED ASSUREZ-VOUS UNE BONNE VENTILATION EN GARDANT 4" (102mm) (MIN.) ENTRE LES ÉVENTS DE LENCEINTE ET LE MUR.
F=WALL SCREW HOLES AGUJEROS DE TORNILLOS DE PARED TROUS DE VIS DU MUR G = 2 X 4 BLOCKING
BLOQUEO DE 2 X 4 BLOC 2 X 4
FINISHED FLOOR
PISO ACABADO
PLANCHER FINI
LEGEND/LEYENDA/LÉGENDE A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB 1-1/2 IN. (38mm) OUT
FROM WALL SHUT OFF BY OTHERS
SE RECOMIENDA UBICAR ELTUBO CORTO DE CONEXIÓN AL TUBO DE COBRE SIN CHAPAR DE 3/8" DE DIÁM. EXT.A 1-1/2"
(38mm) FUERA DE LA LLAVE DE PASO EN LAPARED COLOCADA POR TERCEROS.
EMPLACEMENT RECOMMANDÉ D'ALIMENTATION EN EAU PAR TUBE EN CUIVRE NON PLAQUÉ DE 3/8 PO. (9,5 mm) D.E.
CONNECTANT UNE TUYAUTERIE DE 1-1/2 PO. (38mm) DEPUIS LE ROBINET D'ARRÊT FOURNI PAR D'AUTRES.
B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN
UBICACIÓN RECOMENDADA PARA EL DRENAJE DE SALIDA DE AGUA, DE 1¼ DE DIÁMETRO. EMPLACEMENT RECOMMANDÉ POUR LE DRAIN DE D.E. 1-1/4" DE SORTIE DEAU.
C = 1-1/4 TRAP NOT FURNISHED**
PURGADOR DE 1¼ NO PROPORCIONADO** SIPHON 1-1/4 NON FOURNI**
D = ELECTRICAL OUTLET LOCATION
UBICACIÓN DE LA TOMA DE ELECTRICIDAD EMPLACEMENT DE LA PRISE DE COURANT

PAGE 3 97345C (6/98)
EFY8*1B
FIG. 3
FIG. 4
CONDENSER WATER VALVE ADJUSTMENT
The condenser water valve is factory preset for a condenser water outlet temperature of 95° to 105° F.
If actual temperature varies greatly from this, readjust water flow rate at the valve using the following procedures.
1. START UP COMPRESSOR
This can be accomplished by depressing the cooler push button (See Fig. 1 - Item 3). Keep water running
during the entire re-adjustment procedure.
2. ADJUSTMENT CONDENSER WATER VALVE
Adjust valve by rotating adjustment stem. Rotating stem clockwise will decrease water flow. Counterclockwise
rotation will increase water flow. Increasing water flow will result in a lower condenser outlet temperature, while
decreasing water flow will result in a higher outlet temperature. Proper adjustment is attained when condenser
outlet temperature is 95° to 105° F.
24
11
5, 22, 29
10 9
STREAM HEIGHT
ADJUSTMENT SCREW ADJUST THIS SCREW TO ELIMINATE
VALVE LEVER "FREE PLAY" OR
CONTINUOUS FLOW FROM BUBBLER
CORRECT STREAM HEIGHT
PUSH BUTTON
VALVE ADJUSTMENT

PAGE 4
97345C (6/98)
EFY8*1B
ELKAY MANUFACTURING COMPANY  2222 CAMDEN COURT  OAK BROOK, IL
PRINTED IN U.S.A.
PARTS LIST 115V
DESCRIPTION
1
2
3
4
5
6
7
8
9
10
11
12*
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
NS
Stem Bushing
Push Button Stem
Cap Push Button
Drain Plug
Nut-Regulator Retaining
Bubbler Nipple
Strainer Plate
Basin
Regulator Lever
Pivot Bracket
Regulator Retaining Bracket
Compressor
Overload
Relay
Cold Control
Valve - Wtr Temp
Bubbler
Electrical Box-Cold Control
Vacuum Break
Electrical Box-Power Connection
Tailpipe Assy
Regulator Holder
Snap Bushing
Regulator Mounting Bracket
Nut 1-1/4 Slip Joint
Adaptor-Drain W/O Holes
Strainer
Condenser Assy
Regulator
Drier
Evaporator
Tee - 1/4 x 1/4 x 1/4
Check Valve
Elbow - 3/8
Right Panel
Left Panel
Front Panel
101452331870
101507531550
101453431640
102639931640
15005C
15008C
160270508640
171403742590
26860C
26861C
26862C
35790C
35797C
35803C
35892C
40136C
45314C
45340C
45346C
45347C
45689C
50986C
51454C
55880C
55885C
55913C
55996C
601418151550
61314C
66202C
66505C
70682C
75494C
75561C
401536242830
401536342830
401507442830
*REPLACE WITH SAME COMPRESSOR USED IN ORIGINALASSEMBLY.
NOTE: All correspondence pertaining to ELKAY water coolers or orders
for repair parts MUST include Model No. and Serial No. of cooler, name
and part number of replacement part.
PART NO.ITEM
www.DrinkingFountainDoctor.com 800-518-5388