Empire Comfort Systems DVD32FP34N-1 Quick start guide
INSTALLATION INSTRUCTIONS
AND
OWNER’S MANUAL
WARNING: If not installed, operated and maintained
in accordance with the manufacturer’s instructions,
this product could expose you to substances in fuel
or from fuel combustion which can cause death or
serious illness.
Direct Vent Zero Clearance Gas
Fireplace Heater
This appliance may be installed as an OEM installation
in a manufactured home (USA only) or mobile
home and must be installed in accordance with the
manufacturer's instructions and the manufactured
home construction and safety standard, Title 24 CFR,
Part 3280 or Standard for Installation in Mobile Homes,
CAN/CSA Z240 MH.
This appliance is only for use with the type(s) of
gas indicated on the rating plate. A conversion kit is
supplied with the appliance.
Installer: Leave this manual with the appliance.
Consumer: Retain this manual for future reference.
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
any phone in your building.
neighbor’s phone. Follow the gas supplier’s
instructions.
— Installation and service must be performed by a
-
plier.
WARNING: If the information in these instructions
result causing property damage, personal injury
or loss of life.
EMPIRE
EMPIRE
Comfort Systems
DIRECT VENT
GAS FIREPLACE HEATER
FOR OEM INSTALLATION IN
MANUFACTURED HOMES
MODELS
DVD32FP34N-1 DVD36FP34N-1
GAS-FIRED
UL FILE NO. MH30033
Page 1
26988-3-1012Page 2
Important Safety Information ............................................................................................................ 3
Safety Information for Users of LP Gas ............................................................................................ 4
.................................................................................... 5
.................................................................................................................................... 6
....................................................................................................................... 6
........................................................................................................................................ 7
............................................................................................................................ 7
....................................................................................................................................... 8
Rear Vent Conversion/Vent Systems................................................................................................ 9
................................................................................................................................. 10-13
........................................................................................................ 14-17
...................................................................................................... 18-19
.................................................................................................................. 20
............................................................................................................................. 21
.............................................................................................................. 22
Framing and Finishing ............................................................................................................... 23-24
.................................................................................................................... 24
.................................................................................................................. 25-26
.................................................................................................................... 26-27
............................................................................................................................... 28
Operating Instructions................................................................................................................ 29-30
........................................................................................................ 31
................................................................................................ 32
....................................................................................................... 33
Maintenance and Service ............................................................................................................... 34
Parts List......................................................................................................................................... 35
Parts View....................................................................................................................................... 36
Gas Conversion Instructions...................................................................................................... 37-38
.......................................................................................................... 39
.................................................................................. 40
................................................................................... 40
.................................................................................................................................... 41
........................................................................................................... 42
............................................................................................................. 42
............................................................................................................... 43
Section Page
TABLE OF CONTENTS
26988-3-1012 Page 3
tile or other combustible material other than wood
or wood panel extending the full width and depth of
the appliance.
base as used on wood stoves. The protection is for
rugs that are extremely thick and light colored tile.
of high surface temperatures and should stay away
to avoid burns or clothing ignition.
they are in the same room as the appliance.
placed on or near the appliance.
proper operation.
appliance.
vapor and liquids.
(wood, coal, paper or cardboard etc.) be used in this
appliance.
be obstructed in any way.
person.
damaged parts.
40 for
ordering.
water.
IMPORTANT SAFETY INFORMATION
26988-3-1012Page 4
and explosions. In its natural state, propane is odorless and
colorless. You may not know all the following safety precautions
which can protect both you and your family from an accident.
Read them carefully now, then review them point by point
with the members of your household. Someday when there
may not be a minute to lose, everyone’s safety will depend
on knowing exactly what to do. If, after reading the following
information, you feel you still need more information, please
contact your gas supplier.
where the conditions are such that you may not detect the odor
o set too
LP periodic sniff test of
the LP-Gas is a good safety measure under any condition.
you do detect the odorized LP-Gas.
-
Finally,
SOME POINTS TO REMEMBER
NO ODOR DETECTED - ODOR FADE
LP-GAS WARNING ODOR
If a gas leak happens, you should be able to smell the gas because of the odorant put in the LP-Gas.
That’s your signal to go into immediate action!
26988-3-1012 Page 5
Instructions to Installer
This appliance must be installed in accordance with local
ANSI Z223.1
This appliance must be installed in accordance with the
MANUFACTURED HOME CONSTRUCTION and SAFETY
STANDARD, Title 24 CFR, Part 3280, or when such a standard
is not applicable, and SAFETY STANDARD, Title 24 CFR, Part
3280, or when such a standard is not applicable, ANSI/NCSBCS
A225.1/NFPA, Manufactured Home Installations Standard.
State of Massachusetts:
Massachusetts.
Warning:
in these instructions or use with a type of gas not shown on the
the change.
Important
High Altitude
Canadian High Altitude
Preparation
component.
Inc.
Bedroom Applications
INTRODUCTION
26988-3-1012Page 6 Figure 1
Dim ADVD32 ADVD36
34"
863 mm
37"
939 mm
31"
787 mm
34"
863 mm
C23 1/16"
585 mm
23 1/16"
585 mm
35 5/8"
905 mm
35 5/8"
905 mm
32 3/4"
832 mm
32 3/4"
832 mm
F16 3/8"
416 mm
16 3/8"
416 mm
G24 1/2"
622 mm
24 1/2"
622 mm
H7 1/8"
181 mm
7 1/8"
181 mm
I21 1/2"
546 mm
24 1/2"
622 mm
J10 3/4"
273 mm
12 1/4"
311 mm
9 1/4"
235 mm
9 1/4"
235 mm
RIGHT SIDE VIEW
J
H
K
ADVD32 ADVD36
5.3 5.9
4.1 4.1
P-254
2.10 mm
P-288
LP
P-287
P-182
Height without standoff
Width
Venting
Options
Description
Remote Control
Options & Accessories
Description
FWS-1
SPECIFICATIONS
FIREPLACE DIMENSIONS
26988-3-1012 Page 7
15”
(381mm)
TOP EDGE OF FIREPLACE
12”(305mm)
10”(254mm)
MANTEL
COMBUSTIBLE TRIM AND MANTELS
ALLOWED IN SHADED AREA
4”
5”
6”
7”
8”
9”
11”
13 3/4”
3/4”
1½”
21/4”
3”
33/4”
4½”
6”
8”
3”
Figure 3
Figure 4
Figure 5
Note:
Section.
Figure 2
Combustible Material
Side
SEE MANTLE CHART FOR
MAXIMUM MANTLE DEPTH
NON-COMBUSTIBLE
FIRST 3(SEE MAGNIFIED
VIEW)
NAILING
FLANGES
GLASS FRONT
TOP FRAMING
LEDGE
FINISHED WALL
(COMBUSTIBLE)
SEE MANTLE CHART
FOR MINIMUM HEIGHT
OF MANTLE ABOVE UNIT
2"x4" HEADER
STAND OFF
3" (76 mm) HEIGHT
ABOVE TOPOF
FIREPLACE
3"
”
CLEARANCES
LOCATING FIREPLACE
CABINET
INSTALLATION
FLUSH WALL
INSTALLATION
ROOM DIVIDER
INSTALLATION
CORNER
INSTALLATION
ANGLED CORNER
INSTALLATION
ISLAND
INSTALLATION
26988-3-1012Page 8
Figure 6
Installing a New Main Gas Cock
NOTE:
in a hazardous condition.
Checking Manifold Pressures
Figure 7
Minimum
4.5" 7.0" 14.0"
10.8" 11.0" 14.0"
3.5"
10.0"
Note:
Note:
and Fittings.
Recommended Gas Pipe Diameter
Pipe Length
L.P. L.P.
0-10ft
0-3m
1/2"
12.7 mm
3/8"
9.5 mm
1/2"
12.7 mm
3/8"
9.5 mm
11-40ft
4-12m
1/2"
12.7 mm
1/2"
12.7 mm
5/8"
15.9 mm
1/2"
12.7 mm
41-100ft
13-30m
1/2"
12.7 mm
1/2"
12.7 mm
3/4"
19 mm
1/2"
12.7 mm
101-150ft
31-46m
3/4"
19 mm
1/2"
12.7 mm
7/8"
22.2 mm
3/4"
1.9 mm
GAS SUPPLY
26988-3-1012 Page 9
with 4 screws.
screws.
®
®
Security Secure Vent®
Note: Discard insulation
& retainer when using
vertical venting off
back of fireplace.
VERTICAL VENTING
HORIZONTAL VENTING
FLUE INSULATION
INSULATION
RETAINER
INLET VENT COLLAR
INLET VENT COLLAR
FLUE OUTLET
COLLAR
FLUE COVER PLATE
(See note above)
INLET VENT
COVER PLATE
FLUE COVER PLATE
INLET VENT
COVER PLATE
Note:Itis recommended that the
flue cover plate tab be pulled
outward prior to removal.
This will ensure that the plate
is not accidentally dropped
inside the rear air chamber.
Note: Discard insulation
& retainer when venting off
top of fireplace.
26988-3-1012Page 10
Framing and Finishing
Figure 8
Vent Pipe Clearance
Figure 9A
VENT PIPE
1" MINIMUM CLEARANCE AROUND VENT PIPE
TopofVent
Combustibles NOT
allowed in shaded
area
1"
1"
3"
(25 mm)
7” Diameter
intake vent
4” Diameter flue
(25 mm)
(76 mm)
Figure 9B
INSTALLATION
26988-3-1012 Page 11
35 3/4" 35 3/4"
34 3/8" 37 3/8"
"C" 16 3/8" 16 3/8"
Figure 11
Attention
Attention:
Finishing (Figures 12 and 13)
Warning:
Caution:
Flush Mount Mantel Installation (Figure 10)
NAILOR OTHER SUITABLEFASTENER
Figure 10
framing dimensions.
CAUTION:
INSTALLATION (continued)
26988-3-1012Page 12
Flush Wall Installation
3! OF NON-COMBUSTIBLE MATERIAL
FINISHED WALL
FRONT TRIMOR NON-
COMBUSTIBLE MA TERIAL
(INSTALLA TION IS OPTIONAL)
JOINT BETWEEN FINISHED
WALL AND UNIT SEALED
WITH 300° F, 149°CSEALANT
MATERIAL (SEALANT IS OPTIONAL)
Figure 12
Combustible Surround Installation
3! OF NON-COMBUSTIBLE MATERIAL
FINISHED WALL
FRONT TRIM OR NON-COMBUSTIBLE
MATERIAL (INSTALLATIONIS OPTIONAL)
JOINT BETWEEN FINISHED WALL AND
UNIT SEALED WITH 300°F149
MATERIAL (SEALANT IS OPTIONAL)
°C
SEALANT
COMBUSTIBLE SURROUND
MANTELSHELF
2X4
HEADER
STAND OFF
Figure 13
Attention:
Vent Runs (Figures 14, 15, 16, 17 and 18)
VERTICAL, 90° ELBOW WITH HORIZONTAL TERMINATION
DVD32, 36
47 ½
(121 cm)
T
O BOTTOM
OF UNIT
VENTCAP/
THIMBLE
”
WALL FIRESTOP/
THIMBLE
Figure 14
INSTALLATION (continued)
26988-3-1012 Page 13
VENT CAP
A
"
PIPE LENGTH
WALL FIRESTOP/
THIMBLE
"
6" 5 1/8" to 6 1/2"
9" 8 1/8" to 9 1/2"
12" 11 1/8" to 12 1/2"
Figure 15
VERTICAL, 90° ELBOW TO
HORIZONTAL OUT THE WALL
WALL FIRESTOP/
THIMBLE
"C"
6" 11 1/4" to 12 3/4" 4 3/4" to 6 1/4"
9" 14 1/4" to 15 3/4" 7 3/4" to 9 1/4"
12" 17 1/4" to 18 3/4" 10 3/4" to 12 1/4"
Figure 16
CORNER INSTALLATION VERTICAL, 90° ELBOW TO
HORIZONTAL OUT THE WALL
VENT
CAP
WALL FIRESTOP/
THIMBLE
36 1/8"
918 mm
38 3/8"
975 mm
25 1/2"
648 mm
27 1/8"
689 mm
C11 1/2"
292 mm
12 5/8"
321 mm
51 1/8"
1.299 m
54 1/4"
1.378 m
Figure 17
CORNER INSTALLATION HORIZONTAL, 45° ELBOW TO
HORIZONTAL OUT THE WALL
WALL FIRESTOP/
THIMBLE
6" 4" to 5 1/2" 4" to 5"
9" 6" to 7 1/2" 6" to 7 1/2"
12" 9" to 10 1/2" 9" to 10 1/2"
Figure 18
INSTALLATION (continued)
26988-3-1012Page 14
To Use the Vent Graph (Figure 19)
accordance with same.
6.5 feet.
14.5 feet.
counted.
Figure 19
VERTICAL DIMENSION FROM THE BOTTOM OF THE UNIT
TO THE CENTER OF THE FLUE OUTLET
WITH VERTICAL OR HORIZONTAL TERMINATION CAPS
VENTING FIREPLACE - TOP
26988-3-1012 Page 15
Figure 21
22 is 20 feet.
Firestop at
Firestop at
VENTING FIREPLACE - TOP (continued)
Figure 22
26988-3-1012Page 16
MAXIMUM HORIZONTAL
RUN WITH NO VERTICAL
RISE AND 90° ELBOW
MAXIMUM HORIZONTAL
RUN WITH MINIMUM
VERTICAL RISE AND
90° ELBOW
minimum
Positioning the Fireplace
Cutting the Hole (Figures 23)
FIREPLACE
SERIES
HARD ELBOW DIMENSIONS
"A" "B" "C" "D"
ADVD32FP 41-1/2"
4-1/2"
6-1/2"
9 1/8"
ADVD36FP 41-1/2"
4-1/2"
6-1/2"
9 1/8"
FIREPLACE
SERIES
FLEX PIPE 90 DEGREE BEND
"A" "B" "C" "D"
ADVD32FP 43"
4-1/2"
6-1/2"
9 1/8"
ADVD36FP 43"
4-1/2"
6-1/2"
9 1/8"
Figure 23
Figure 24
VENTING FIREPLACE - TOP (continued)
Figure 25
B
C
A
CENTER OF ELBOW
STRAIGHT OUT
(MINIMUM)
D
C
B
V
H
MINIMUM HOLE LOCATION DIMENSIONS FOR THROUGH
THE WALL HORIZONTAL INSTALLATIONS WITH 90 DEGREE
ELBOW OFF TOP OF FIREPLACE
SEE FIGURE 19 ON PAGE 14 FOR PERMISSIBLE "H" AND "V"
DIMENSIONS.
26988-3-1012 Page 17
Figure 26
Figure 27
Figure 28
24”
24” MINIMUM
CLEARANCE TO
COMBUSTIBLES
EXAMPLES - TOP VENT RUN
26988-3-1012Page 18
To Use the Vent Graph (Figure 29)
unit in accordance with same.
EXAMPLE A:
EXAMPLE B:
SPECIAL NOTE:
Example:
Figure 29
VERTICAL DIMENSION FROM THE BOTTOM OF THE UNIT
TO THE CENTER OF THE FLUE OUTLET
WITH VERTICAL OR HORIZONTAL TERMINATION CAPS
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
HORIZONTAL RUN
REAR EXIT-VERTICAL AND HORIZONTAL TERMINATION
(DIMENSIONS IN FEET)
REAR HORIZONTAL
VENT CONNECTION
B
A
VENTING FIREPLACE - REAR
5/16" and 3/8" for LP gas.
26988-3-1012 Page 19
Figure 30
Figure 31
Figure 32
Figure 33
Pipe Length H1
24"
24"
Pipe Length H1
24"
24"
EXAMPLES - REAR VENT RUN
26988-3-1012Page 20
""
and sides.
Information on Various Venting Routes and Components
Figure 34
TERMINATION CLEARANCES
This manual suits for next models
1
Table of contents
Other Empire Comfort Systems Indoor Fireplace manuals
Empire Comfort Systems
Empire Comfort Systems VFLB36FP30N User manual
Empire Comfort Systems
Empire Comfort Systems DVCP36(PP Quick start guide
Empire Comfort Systems
Empire Comfort Systems DVP36FP3 series User manual
Empire Comfort Systems
Empire Comfort Systems MILLIVOLT STANDING PILOT Series Quick start guide
Empire Comfort Systems
Empire Comfort Systems VFS32FB0F-4 Installation instructions
Empire Comfort Systems
Empire Comfort Systems BFM18MTN Quick start guide
Empire Comfort Systems
Empire Comfort Systems DVD32 Quick start guide
Empire Comfort Systems
Empire Comfort Systems CIVF-25-2 Quick start guide
Empire Comfort Systems
Empire Comfort Systems LS38DF-1 Quick start guide
Empire Comfort Systems
Empire Comfort Systems DV25IN33LN-3 Quick start guide
Empire Comfort Systems
Empire Comfort Systems DVP42FP3(0 Quick start guide
Empire Comfort Systems
Empire Comfort Systems White Mountain Hearth Tahoe DVCX42FP30P Quick start guide
Empire Comfort Systems
Empire Comfort Systems MILLIVOLT DVCD32FP30N-4 Planning guide
Empire Comfort Systems
Empire Comfort Systems Mantis PV-28SV50-BN-1 User manual
Empire Comfort Systems
Empire Comfort Systems VFLL38FP30L-1 Quick start guide
Empire Comfort Systems
Empire Comfort Systems MANTIS BF28(B User manual
Empire Comfort Systems
Empire Comfort Systems DVCT40CSP95KN-1 Series User manual
Empire Comfort Systems
Empire Comfort Systems DVCT50CBP95-1 Planning guide
Empire Comfort Systems
Empire Comfort Systems CIDV-30 User manual
Empire Comfort Systems
Empire Comfort Systems SELECT VFS32FB0F-6 Quick start guide
Empire Comfort Systems
Empire Comfort Systems VFD32FB0L-2 Quick start guide
Empire Comfort Systems
Empire Comfort Systems VFP36SP32E Quick start guide
Empire Comfort Systems
Empire Comfort Systems White Mountain Hearth DVCX42FP91K-3 Quick start guide
Empire Comfort Systems
Empire Comfort Systems VFLC10IN32N-1 Quick start guide
Popular Indoor Fireplace manuals by other brands
Napoleon
Napoleon NEFL42CHD-1 manual
Masport
Masport WOOD FIRE installation guide
JAYLINE
JAYLINE SS280 Installation & operation instructions
Heat-N-Glo
Heat-N-Glo SL-32S Installation
kozy heat
kozy heat Bellingham 52 quick start guide
Paragon Fires
Paragon Fires ROOM SEALED INSET LIVE FUEL EFFECT GAS FIRE owner's manual
Monessen Hearth
Monessen Hearth LCUF32CR-B Installation & owner's manual
PuraFlame
PuraFlame Galena owner's manual
Dimplex
Dimplex Toluca Deluxe instruction manual
SEI
SEI TENNYSON FA8544AO Assembly instructions
Dru
Dru G25 installation manual
Capital fireplaces
Capital fireplaces Designline DL700 Installation and user instructions
IronStrike
IronStrike VINTAGE VINT-DVS-U Installation and operation
ACR Heat
ACR Heat HERITAGE N25 Installation and operating instruction manual
European Home
European Home HVF-42 Installation, operation and owner's manual
Quadra-Fire
Quadra-Fire MTVERNINSAE-MBK Owner's manual operation & care
Harman Home Heating
Harman Home Heating Accentra Insert Installation & operating manual
Trimline Fires
Trimline Fires Zircon 1024 installation instructions