Ewbank EW5015 User manual

INSTRUCTION MANUAL
WDV15 15L Wet And Dry Vacuum Cleaner
EW5015
Ewbank has a British heritage to be proud of. It’s a household favourite and much loved brand that has been providing innovative cleaning solutions for over 135 years.

2
CONTENTS
Safety Instructions...........................................................................................3 - 5
Appliance Overview ...........................................................................................6
Using Your Vacuum Cleaner ............................................................................7 - 9
Cleaning & Maintenance ............................................................................10 - 12
Troubleshooting ................................................................................................13
Mains Plug Fuse Replacement.............................................................................14
Disposal of the Appliance ..................................................................................14
Warranty Terms & Conditions .............................................................................15

3
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
SAFETY INSTRUCTIONS
PLEASE READ ALL THE INSTRUCTIONS BEFORE
USE AND WHEN USING THE APPLIANCE, THE
FOLLOWING PRECAUTIONS MUST BE TAKEN:
WARNING! TO REDUCE THE RISK OF FIRE,
ELECTRIC SHOCK, OR INJURY:
1. Do not leave the vacuum cleaner plugged in when not in
use. Unplug from the socket before servicing.
2. Only use as described in this manual, including
attachments. Attachments used should only be that of the
manufacturers.
3. Do not use when the cord or plug are damaged. If
the vacuum cleaner is not working as it should be or
has been dropped, damaged, left outdoors, or fallen
into water, the vacuum cleaner must be serviced by an
engineer.
4. Do not pull or carry by the cord, use the cord as a
handle, trap the cord, or pull the cord around sharp
edges and corners. Do not run the vacuum cleaner over
the cord and keep the cord away from heated surfaces.
5. Do not unplug the vacuum cleaner by pulling on the
cord. To unplug, grasp the plug.
6. Do not handle the plug or the vacuum cleaner with wet
hands.
7. Do not actively put any objects into any of the vacuum
cleaners openings. Do not use with any of the opening
blocked. Keep free of dust, lint, hair and anything that
may reduce airflow.
8. Keep hair, loose clothing, fingers and all parts of the
body away from any openings and/or moving parts.
9. Turn all controls off before unplugging.
10. Take extra care when cleaning on stairs.
11. Do not use to pick up flammable or combustible liquids

4
such as gasoline. Do not use in areas where this may be
present.
12. Unplug before connecting the hose.
13. Do not pick anything up that is burning or smoking such
as cigarettes, matches or hot ashes.
14. Do not use without correct filter in place.
15. If the cord is damaged, it must be replaced by the
manufacturer, or a service engineer.
16. This appliance is not intended for use by persons
(including children) with reduced physical, sensory
or mental capabilities, or lack of experience and
knowledge. Only when they have been given supervision
or instruction to use the appliance by a person
responsible for their safety, can they then use it.
17. Children should be supervised to ensure that they do not
play with the appliance.
18. The mains power supply should comply with the
information on the appliance’s rating plate.
19. Do not use or store the vacuum cleaner in humid
environments.
20. Do not use with an extension cable.
21. Never dismantle any part of the appliance.
22. When cleaning on stairs, ensure the vacuum cleaner is
located below the user. Keep on the floor when possible.
23. When retaining the packaging, store out of the reach of
children.
24. Do not store outdoors. Store out of the way with the
power cord neatly wrapped up, to prevent accidents.
25. When vacuum cleaning static electricity may be created.
To prevent shocks, do not access any parts with your
hand until the area is clear.
26. Check the recommended cleaning instructions of your
flooring before vacuum cleaning.
27. Do not use the vacuum cleaner to vacuum powders such
SAFETY INSTRUCTIONS

5
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
SAFETY INSTRUCTIONS
as flour and cement. It can damage, block or break the
motor.
28. Do not use or store the vacuum cleaner in excessively
high or low temperatures, outside of 0-40°c. Avoid
the vacuum cleaner being in direct sunshine for a long
period.
29. If the vacuum cleaner is broken do not disassemble it.
This must be done by a qualified technician.
30. This appliance is for household, hotel and similar place
only.
31. Do not use around explosive dust, liquids, vapors or any
electrical devices that can produce sparks, which can
cause fire, or explosion.
32. Do not use at filling stations or anywhere gasoline is
stored or dispensed.
33. Do not vacuum toxic or carcinogenic dust or materials
or other health endangering materials such as asbestos
lead and pesticides.
34. Keep the appliance away from oven stoves or other heat
sources.
35. Check before operation that the local power supply is
the same as the specification on the rating label.
36. Do not stand on or flatten the hose. Do not use if the
hose is broken
37. If there is foam or liquid coming out of machine
when picking up water, please turn off the appliance
immediately.
38. This model is NOT designed to be used for vacuuming
large amounts of water. If used to vacuum large amounts
of water, it can lead to damage being caused to the
product and/or property.

6
APPLIANCE OVERVIEW
ACCESSORIES
Handle
Sliding Air Block
Tube
Floor Head
Hose
Switch Button/ Power Regulator
Carry Handle
Cord Storage
Wheel
Hose Connector
Fastening Clip
Vacuum Cleaner
Wheels Screws
Bristle Brush
(Crevice Nozzle)
Tubes
Hose
For Dry
For Water

7
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
USING THE VACUUM CLEANER
Locking clips
Release the fastening clips to open
the housing, then take out wheels
and accessories.
Take lid off and turn upside down. Install
castor wheels into the corresponding hole on
the base.
When replacing lid ensure the lid and drum
align correctly and fasten clips.
1
2
3
Insert the hose connector into the hose socket
at the front of the vacuum container.
Align connecting knots top and bottom.
Once inserted turn clockwise to lock.
Hose connector
USING THE VACUUM CLEANER

8
USING THE VACUUM CLEANER
Connect the hose handle, metal tubes and
floor head as shown.
4
5
6
Hold the plug and insert into the
wall socket
1. Press the switch button/power regulator
to turn on/off the cleaner.
2. Turning the power/regulation button
will increase and decrease the power
of suction. Anti clockwise will decrease
power and clockwise increase power.
On/off switch

9
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
USING THE VACUUM CLEANER
7You can adjust the airflow by pushing the sliding block on
the tube handle up and down.
Minimal suction power (switch fully open): curtains and fine
materials.
Medium suction power: cushions and mattresses. Maximum
suction power (switch closed): tiled, wooden and robust floor
that has been heavily soiled.
IMPORTANT NOTE: When picking up water more
than a spill/splash, keep the sliding air block
closed. This will prevent airated water getting
inside the lter which then does not support and
lift the oat for auto shut o.

10
CLEANING AND MAINTENANCE
EMPTYING THE DUST BARREL
Note: If the vacuum container is full, empty it as soon as possible
Fastening clips
Release the fastening clips to open the
housing.
1
Empty the dry or solid content of the vacuum
container into a waste bin. Empty liquid
content down a drain.
Note: wherever possible always empty the
vacuum container into a waste disposal bin
outside to avoid any re-emission of dust,
debris and allergens inside.
2
Replace the upper housing and fasten the
clips.
3
IMPORTANT NOTE: In the event of a major blockage or that the
dust container is too full, the vacuum cleaner will automatically stop
working to avoid over-heating. This will prolong the life of motor.

11
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
CLEANING AND MAINTENANCE
Warning: When the lter is obviously covered with dust or the suction
decreases considerably, please clean promptly, as this will improve
the working eciency and extend the life of the cleaner. NEVER use
the machine without lters.
CLEANING THE HEPA FILTER
Turn off at main plug/switch.
Remove the top and rest upside down.
1
Remove the filter by turning anti
clock wise as pictured on the lock.
2
Once the HEPA filter and dust barrel have been carefully
cleaned, ensure each part is left to dry fully (usually in
direct sunlight for 24hours) before reinstalling.
3
Carefully rinse the HEPA filter with cold water. Then use a
damp cloth to remove any stubborn dirt on the inside of the
dust barrel
4
IMPORTANT: This model is NOT designed to be used for vacuuming
large amounts of water. If used to vacuum large amounts of water, it
can lead to damage being caused to the product and/or property.
Please note use sponge lter for something larger than a spill/splash.
Ensure lter is fully dry before use. NEVER use appliance without the
lters.

12
SWITCHING FROM HEPA TO SPONGE FILTER
CLEANING AND MAINTENANCE

13
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
If you experience difficulties with the appliance, please check the suggestions below
before contacting customer services on 01473 271272:
PROBLEM POSSIBLE CAUSES SOLUTIONS/TIPS
The suction is poor. The airflow adjustment
switch is open.
Close the airflow
adjustment switch.
An object is blocked. Check the hose, the handle
and the floor head or
attachment for blockages.
Filters are not fitted
properly or are blocked.
Clean or replace the filter.
Device does not work. The appliance is not
properly plugged into
the socket.
Check that the plug has
been inserted properly.
Danger!
Never try to repair a defective appliance yourself. You can
put yourself and/or future users in danger. Repairs must only
be done by a service engineer.
TROUBLESHOOTING

14
MAINS PLUG FUSE REPLACEMENT & DISPOSAL INFORMATION
Disposal Information
The European Directive 2012/19/EU on Waste Electrical and Electronic
Equipment (WEEE), requires that old household electrical appliances must
not be disposed of in normal unsorted municipal waste.
Old appliances must be collected separately in order to optimise the
recovery and recycling of the materials they contain and reduce the impact on human
health and the environment.
The crossed out “wheeled bin” symbol on the product reminds you of your obligation,
that when you dispose of the appliance it must be separately collected. Consumers
should contact their local authority or retailer for information concerning the correct
disposal of their old appliance.
Fuse Cover
Fuse Replacement (Class II)
Remove the fuse cover with a small flat head screw driver. Take
out the fuse and replace with a new fuse of the same Amp.
Replace the fuse cover and push back into place.

15
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR Tel. [phone]
WARRANTY TERMS & CONDITIONS
Ewbank Warranty Terms & Conditions
This product is guaranteed for a period of 24 months as standard from the date of
purchase against mechanical and electrical defects.
To qualify for the warranty, the product must be used for domestic household use
only and in accordance with the instructions in the user manual. Any misuse of the
product will result in the warranty being void.
The warranty does not cover accidental damage, misuse, neglect, tampering or
incorrect adjustment or installation.
The warranty will be rendered invalid if the product is resold, has had its serial
number removed (or has an invalid serial number), or if an unauthorised person
has carried out any repairs or alterations.
The warranty does not cover accessories or consumable parts that require
replacement under normal use. This includes shelving, dials, filters, belts and trays
etc.
In the unlikely event of a breakdown please refer to the Troubleshooting guide in
your user manual and check all plugs, fuses and the electricity supply.
If you still require assistance please contact our Customer Service department on
01473 271 272 or write to us at the following address:
Customer Service Department
Ewbank, 38 Bluestem Road,
Ipswich, Suolk, IP3 9RR
Please quote the Product Code and the PO Number on the front of the instruction
manual and give details of the exact fault. We will then decide whether to repair
or replace the item.
Before we arrange the repair or replacement you will be required to return a copy
of your proof of purchase. Please retain your original.
If an item is replaced within the agreed warranty period, the warranty for the
replacement item will be calculated from the purchase date of the original.
In the event that the product is inspected and no fault is found or the product is not
within the warranty period you will be charged for the repair and any carriage
costs.

Disclaimer: Ewbank operate a policy of continual improvement and development.
We therefore reserve the right to change/alter the specification and appearance of our appliances without prior notice.
All diagrams and images shown in this manual are for illustration purposes only.
Your Guarantee
This product is covered by a 2 year guarantee.
This does not cover normal wear and tear or abuse.
For guarantee purposes, please retain your original receipt as proof of purchase.
This guarantee does not affect your statuatory rights.
For spares, service and further information please contact;
Ewbank, 38 Bluestem Road, Ipswich, Suffolk, IP3 9RR
EU: Castle Electrical Factors Ltd., Dundalk, A91 KA9R, IR
Tel: [phone]