Generac Power Systems 4000XL 9777-2 Administrator Guide

Generator(Operation(Instructions(
(
!(
(
(
(
Warning((
•Position!Generator!Exhaust!to!point!away!from!products!being!used!or!where!people!
will!be!located.!
•Position!Generator!about!15!feet!away!from!where!products!are!being!used.!
!
Turning(Generator(ON(
1. Turn!the!Motor(Switch!to!Run!(turns!it!on)!
2. Turn!the!Gas(Switch!on!by!rotating!counter‐clockwise!to!6!o’clock!(pointed!down)!
3. Push!the!Choke(Lever!to!the!left!(half!way!should!be!enough,!if!it!doesn’t!start!then!
you!can!turn!it!¾!or!all!the!way)!
4. Pull!the!Starter(Rope!to!turn!to!Generator!on!
!
Page!1!of!2!!!!!!!!!!!!!!!!!!!!!!!!!!!Provided!by!Magic!Jump!Rentals!Inc.!!

!
5. IMPORTANT:!Once!the!Generator!is!on,!turn!the!Choke(Lever!back!to!the!right!(to!
off!position).!NOTE:&If&you&leave&the&Choke&Lever&to&the&left,&the&Generator&will&likely&
turn&off&by&itself&or&the&gas&will&be&used&up&too&quickly.!
!
!
Turning(Generator(OFF((
1. Turn!the!Motor(Switch!to!Stop!(turns!it!off)!
2. Turn!the!Gas(Switch!off!by!rotating!it!clockwise!to!9!o’clock!(pointed!left)!!
oIMPORTANT:!Make!sure!Gas!Switch!is!turned!off,!otherwise!gas!will!continue!
to!go!into!motor!and!eventually!choke!the!motor.!This!will!create!problems!if!
you!need!to!turn!it!on!again.!!
!
Refueling(Generator(
•Make!sure!to!turn!the!Generator!OFF!(refer!to!instruction!above!on!Turning(
Generator(OFF)!
oIMPORTANT:!Make!sure!any!products!plugged!into!Generator!are!not!being!
used!before!you!turn!the!Generator!off.!
•Un‐tighten!Gas!Cap!to!open!it!for!refueling!
•Fill!Gas!Tank!until!Gas!has!almost!reached!the!top!
•IMPORTANT:!Fill(Gas(Tank(with(Unleaded(Gas(ONLY!
•!
Troubleshooting(
•Generator!Not!Turning!On!
oProblem(1:!Motor!Switch!is!not!set!to!Run!!
Solution:!Refer!to!Turning!Generator!ON,!step!1!
oProblem(2:!No!Gas!in!the!Gas!Tank!
Solution:!Refer!to!Refueling!Generator!on!first!page!
oProblem(3:!Choke!Lever!not!set!to!the!left!
Solution:!Refer!to!Turning!Generator!On,!Step!3!
oProblem(4:!Gas!Switch!was!left!on!when!the!Generator!was!not!in!use!and!
motor!has!been!filled!with!Gas!
Solution:!Call!Magic!Jump!Rentals!at!800‐873‐8989!for!assistance.!
Caution!(
•Make!sure!Idle(Control!(located!on!the!bottom!right!where!the!electrical!outlets!are!
located)!is!turned!OFF!
oPotential(Problem:!If!Idle!Control!is!set!to!ON,!Generator!might!throw!the!
circuit!while!Electrical!Cord!is!plugged!in!and!product!is!in!operation.!This!will!
cause!the!product!to!turn!off!while!it!is!being!used!and!potential!cause!harm.!!
!
!
!
!
!
!
!
Page!2!of!2!!!!!!!!!!!!!!!!!!!!!!!!!!!Provided!by!Magic!Jump!Rentals!Inc.!!