HAMPTON BAY FP20306 User manual

WARNING
Do not store or use gasoline or other
flammable vapors and liquids, in the
vicinity of this or any other appliance.
An LP-cylinder not connected for use
shall not be stored in the vicinity of
this or any other appliance.
WARNING
USE PROPANE GAS ONLY.
For use with tanks marked propane only.
DO NOT connect to a remote gas supply.
Propane Tanks sold separately.
DANGER
CARBON MONOXIDE HAZARD
7KLVDSSOLDQFHFDQSURGXFHFDUERQPRQR[LGHZKLFKKDVQRRGRU
8VLQJLWLQDQHQFORVHGVSDFHFDQNLOO\RX
1HYHUXVHWKLVDSSOLDQFHLQDQHQFORVHGVSDFHVXFKDVFDPSHU
WHQWFDU RUKRPH
INSTALLER:
Leave this manual with the appliance.
CONSUMER:
Retain this manual for future reference.
This Fire Pit must be attended at all times!
WARNING
When Fire Pit is not in use—disconnect
Propane Tank.
If Fire Pit is stored indoors—remove
Propane Tank.
FOR OUTDOOR USE ONLY!
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
FIRE OR EXPLOSION HAZARD
If you smell gas:
1.Shut off gas to the appliance.
2.Extinguish any open flame.
3.If odor continues, leave the area
immediately.
4.After leaving the area, call your gas
supplier or fire departent. WARNING
If the information in this manual is not
followed exactly, a fire or explosion
may result causing property damage,
personal injury, or loss of life.
DANGER
Failure to follow these instructions
could result in fire or explosion, which
could cause property damage,
personal injury, or death.
WARNING
WARNING
USE AND CARE GUIDE
26" Round Concrete Propane Gas Fire Column
Item#
Model# FP20306

Read and follow all instructions and warnings in this Owner’s Manual
thoroughly before installing, operating, or servicing this fire column.
Improper installation, use, maintenance, adjustment or storage can cause
fire or explosion, resulting in serious injury or property damage.
WARNING
prepare for use:
.HHSDZD\IURP&RPEXVWLEOH)ODPPDEOH,WHPV
t o not put any other fireplace cover or anything flammable on or beneath fire column.
t Combustible materials should never be within . m ft of the top, .22 m ft of back or sides of fire column.
t or use on noncombustible floor material only.
t Keep fire column area clear and free from combustible materials, gasoline, and other flammable vapors and liuids.
,QVSHFWIRUOHDNVZHDUDQGGDPDJH
t Check for gas leaks before use - ee page , tep 8 for instructions on how to check for gas leaks.
t Inspect burner and hose before use - Replace if there is evidence of ecessive abrasion, wear, or damage.
t
Inspect hose before each use. ose assembly must be replaced prior to use if there is evidence of ecessive abrasion or
wear or if hose is damaged. Use a manufacturer-specified replacement hose only.
3UHSDUHDUHDHQVXUHSURSHUXVHRI)LUHColumn&RYHU
t Make sure ventilation openings on sides of fire column (B) are open and clear of debris.
t o not lay nylon cover over fire column for at least  hours after it is turned  and has completely cooled down.
to not use fire column if any part has been under water. Immediately call a ualified service technician to inspect fire column
and to replace any part of the control system and any gas control that has been under water.
t Remove nylon cover from fire column before operating.
when in use:
Do's
 Use propane cylinders with the following reuired measurements only . cm2 in (diameter)  . cm in (tall)
with capacity  kg. lbs.)
 If flame goes out while operating, turn gas valve . ait five minutes before attempting to relight.
Due to high surface temperatures always keep a safe distance to avoid burning or clothes catching fire.
●Keep fuel supply hose away from any heated surfaces.
Don't's
ever lean over the open fire column or place hands or fingers on the upper portion while in use.
 o not use fire column for cooking.
t o not burn any other materials other than what is supplied with and intended for use in fire column .
t olid fuels shall not be burned in this fire column.
t o not pour water into fire column .
t o not move fire column while in operation.
t ire pit should never be operated by children. Children must be supervised when they are anywhere near fire column .
 o not rest feet on fire column
t o not use fire column on vehicles or boats. lways operate fire column on flat ground outdoors.
When not in use:
t The cylinder must be disconnected when the fire column is not in use.
t Remove Battery from ignitor when not using fire column for an etended length of time.
t Clean battery contacts and also those of the device prior to battery installation.

%"/(&34"/%8"3/*/(45)*4130%6$564&41301"/&0/-:t6TFQSPQBOFDZMJOEFSTXJUIUIFGPMMPXJOHSFRVJSFENFBTVSFNFOUTPOMZDNJOEJBNFUFSYDNJOUBMMXJUIDBQBDJUZLHMCTt.BYHBTTVQQMZDNJOXDLQBt0OMZDZMJOEFSNBSLFEQSPQBOFwNBZCFVTFEtMGZPVTFFTNFMMPSIFBSUIFIJTTPGFTDBQJOHHBTGSPNUIFQSPQBOFDZMJOEFS.Turn off gas supply and get away from gas cylinder and fire column at once.
2.%POPUBUUFNQUUPDPSSFDUUIFQSPCMFNZPVSTFMG ϮŝŶĐŚĞƐƚŽ
ϭϬŝŶĐŚĞƐ
Observe flame color and flame height when the fire column after being lit :
1.) Flame color should be yellow.
2.) Flame height burns at 2 - 10 inches high.
.Call your gas supplier and  or the fire department for help.
t  dented or rusty propane cylinder may be haardous and should be cleared by your gas supplier prior to use.
t o not attempt to disconnect gas regulator or any gas fitting while fire column is in operation.
t The gas pressure regulator provided with fire column must be used.
t o not use a propane cylinder with a damaged valve and any other worn out parts.
t Transport and store empty propanecylinders carefully and properly.
Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns
or clothes catching fire.
t oung children should be carefully supervised when they are in the area of fire column.
t Clothing or other flammable materials should not be hung from fire column or placed on or near fire column.
1SPQBOFHBTTVQQMZDZMJOEFSUPCFVTFENVTUCFt DPOTUSVDUFEBOENBSLFEJOBDDPSEBODFXJUIUIF64%FQBSUNFOUPGT ransportation (T) pecifications for LP-as Cylinders PSUIF4UBOEBSE GPS$ZMJOEFST4QIFSFTBOE5VCFTGPS5SBOTQPSUBUJPOPG%BOHFSPVT(PPETBOE$PNNJTTJPO$"/$4"#BTBQQMJDBCMFt provided with a listed overfilling prevention device.
t provided with a cylinder connection device compatible with
the connection for the appliance.
ZKHQVWRULQJfLUHcolumn
torage of fire column indoors is permissible only if the cylinder is disconnected and removed from fire column. Cylinders must be
stored outdoors in a well-ventilated area out of reach of children. isconnected cylinders must have threaded valve plugs tightly
installed and must not be stored in a building, garage or any other enclosed area.
Turn  control knob and close propane cylinder valve. Turn coupling nut counterclockwise by hand onlydo not use tools to
disconnect. Loosen cylinder screw beneath bottom shelf, then lift propane cylinder up and out of shelf. Place dust cap
on cylinder valve outlet whenever the cylinder is not in use.
WARNING! ,PSURSHULQVWDOODWLRQDGMXVWPHQWDOWHUDWLRQVHUYLFHRUPDLQWHQDQFHFDQFDXVHLQMXU\RUSURSHUW\GDPDJH5HIHUWR
WKHRZQHUVLQIRUPDWLRQPDQXDOSURYLGHGZLWKWKLVDSSOLDQFH)RUDVVLVWDQFHRUDGGLWLRQDOLQIRUPDWLRQFRQVXOWDTXDOLILHGLQVWDOOHU
VHUYLFHDJHQF\RUWKHJDVVXSSOLHU
The Propane-gas supply cylinder must be disconnected when this appliance is not in use.
Repairs should be done by a ualified service person. ire column should be inspected before use and at least annually be a ualified service
person.
More freuent cleaning may be reuired as necessary. It is imperative that the control compartment, burners, and circulating air
passageways of the appliance are kept clean.
ny guard or other protective device removed for servicing the appliance shall be replaced prior to operating the appliance.
Installation and repair should be done by a ualified service person. The appliance should be inspected before use and at least annually
by a ualified service person. More freuent cleaning may be reuired as necessary. It is imperative that the control compartment,
burners, and circulating air passageways of the appliance are kept clean.
Any guard or other protective device removed for servicing the appliance shall be replaced prior to operating the appliance
FOR YOUR SAFETY: Surfaces of fire pit can remain extremely hot for a period after use. Allow 45 minutes to cool down before
touching or moving the fire pit
3
3

PREPARATION FOR ASSEMBLY
PACKAGE CONTENTS AND COMPONENTS
Before beginning assembly of fire column, make sure all parts are present.
Compare parts with package contents list. If any part is missing or damaged, do not attempt to assemble fire column.
Estimated Assembly Time: 25 minutes
127(<RXPXVWIROORZDOOVWHSVWRSURSHUO\DVVHPEOHfLUHcolumn0DNHVXUHWKHJDVYDOYHLVWXUQHG2))EHIRUHDVVHPEOLQJ
'RQRWDWWHPSWWRDVVHPEOHZLWKRXWSURSHUWRROV
WARNING
Failure to position the parts in accordance with
these diagrams or failure to use only parts
specifically approved with this appliance may
result in
property damage or personal injury.
F
H
G
A
C
L
B
I
E
M
J
K
N
PARTQTY
"#$%&' 5.5 lbsG*'JSFPlateFire Pit #PEZ%PPS #VSOFSQSFBTTFNCMFE (VBSEQSFBTTFNCMFE Lava Rock  """#BUUFSZPVC Cover+"EKVTUBCMFGFFUQSFBTTFNCMFE$POUSPM,OPCQSFBTTFNCMFE,-.
DESCRIPTION
N*HOJUFSQSFBTTFNCMFE3FHVMBUPSQSFBTTFNCMFETouch-Up Kit
Door Knob D
H

ASSEMBLY INSTRUCTIONS 
Make sure the gas supply system is turned to .
18"3/*/(This fire column requires air flow under
the unit. Do not place on uneven
surface or on grass, turf or carpet.

2

3Place propane tank (not included) in the metal stand inside Body (B) and make sure the gas tank sits on the metal
stand completely. Turn the wing screw on the outer part of metal stand clockwise to secure the gas tank tightly.
2Turn door knob (N), Remove door (C) 
c

6
"44&.#-:*/4536$5*0/44a) Turn cylinder valve on the top of propane tank clockwise to close off gas supply. 6HH)LJXUH4D
b) crew regulator coupling clockwise by hand only. Make sure it is fastened. 6HH)LJXUH4E
To install battery (G), unscrew rubber cap of electric igniter (K) and place battery (G) into the battery
case. Make sure the positive pole () faces out towards cap. crew cap back to battery case tightly.
JODMVEFE+
+DUGZDUH8VHG
AAA%DWWHU\ x 1
6
K
G
4a4b
5 5HSODFH'RRU&RQWR%RG\% and turn door knob to secure 



8
7"44&.#-:*/4536$5*0/48"3/*/(keep lava rock and other objects
off of screen (shown at left)
Holes in the screen must be
exposed in order to allow gas to
escape
Blocked screen can cause gas
to build inside fire column and
ultimately cause an explosion
and risk of serious injury. #VSOFS3JOH$033&$5#VSOFSSJOHJTDPNQMFUFMZDPWFSFEFYDFQUGPSTDSFFO*/$033&$5/PUFUIBUUIFCVSOFSSJOHJTWJTJCMF7E
4DSFFO7a
7F
a 3ODFH Lava Rock(F)HYHQO\LQILUHERZO
8VHFDXWLRQZKHQKDQGOLQJlava rock DVLWLVVKDUS6HH)LJXUH7D
b) 'RQRWSODFHDQ\lava rock RYHUWKHVFUHHQ6HHILJXUH7E
c &RPSOHWHO\FRYHUWKHHQWLUHEXUQHUULQJZLWKlava rock6HHILJXUH7F
)DLOXUHWRFRPSOHWHO\FRYHUWKHEXUQHUULQJZLWKWKHODYDURFN ZLOOFDXVHIODPHWRH[WLQJXLVKRFFDVLRQDOO\
8Before using fire column, check for gas leaks.
Perform leak test in a well-ventilated area outside and where no source of spark can occur.
a) fter opening door for access, open tank valve fully (counter-
clockwise).
b) Turn control knob to the  position.
c) pply soapy water solution ( drops dish detergent plus  o.
water) to check all connections for leaks before attempting to
light fire column.
d) Coat soapy water onto all connections (shown in figure at right,
, 2 ,, , ). 6HH)LJXUH8.
e) 7XUQFRQWURONQREWRWKH21SRVLWLRQ,IWKHUHDUHDQ\OHDNV
VRDS\ZDWHUZLOOEXEEOHZKHUHOHDNLVRFFXUULQJ
If a leak is found, turn tank valve off and do not use fire column
until repairs are made.

4DSFFO

01&3"5*/(*/4536$5*0/4%HIRUHHDFKXVHEnsureWRLQVSHFWKRVH5HSODFHKRVHLIWKHUHDUHDQ\VLJQVRIFXWWLQJZHDURUDEUDVLRQ
WARNING! 'XULQJLQLWLDOlightingRIWKHfLUHcolumnVWD\DZD\IURPILUHcolumnIRUPLQXWHVDVlava
rockPD\SRSDQGFDXVH LQMXU\WRWKHIDFHRUH\HV
1.7XUQc\OLQGHUvDOYHRQWRSRIpURSDQHtDQNFRXQWHUFORFNZLVHWRRSHQJDVVXSSO\
2.7RLJQLWH%XUQHU5LQJSee Figure 9
a) SUHVVDQGKROG(OHFWULF,JQLWHUEXWWRQD.
b) DWWKHVDPHWLPHSXVKLQDQGWXUQ&RQWURO.QREEFRXQWHUFORFNZLVH WR/2:SRVLWLRQ
c) .HHSWKH&RQWURO.QREESXVKHGLQWROLJKWWKH%XUQHU5LQJ
WARNING! If ignition does NOT immediately occur
t UHOHDVH(OHFWULF,JQLWHU%XWWRQDDQGWXUQ&RQWURO.QREWR2))FORFNZLVH
t :$,70,187(6WRFOHDURXWWKHJDV
t UHSHDWOLJKWLQJLQVWUXWLRQVLQ6WHS2 asDERYH
3 $IWHULJQLWLRQUHOHDVH(OHFWULF,JQLWHU%XWWRQD
&RQWLQXHWRSXVKDQGKROGWKH&RQWURO.QREIRUVHFRQGV
CARE AND MAINTENANCE
1RWH)ODPHVKRXOGEH\HOORZEOXHFRORU
To Extinguish 6HH)LJXUH10
 3XVKDQGWXUQ&RQWURO.QREFORFNZLVHWR2))SRVLWLRQ
 7XUQF\OLQGHUYDOYHRQJDVWDQNWRFORVHJDVVXSSO\LIQRWLQXVHIRUDORQJWLPH
WARNING! Do not place lid or nylon cover on top of fire column for at least 4 hours
after use and until fire pit has cooled.
9
10
D
E
E
D
Caution: Only use pressure regulator and hose assembly supplied with fire column. Replacement
pressure regulator and hose assemblies must be specified or supplied by manufacturer.
To Light
t Store the fire column in a cool dry place away from direct sunlight.
t The propane tank must be disconnected and removed from the fire column before the fire column can be stored indoors.
t Make sure both the gas and the fire column are turned off before changing battery. Please refer to the process of installing the
battery (tep 6).
t Use manufacturer approved or supplied replacement parts and accessories only. Use of unauthoried replacement parts
may void the warranty.
t Keep fire column free and clear from combustible materials.
t isually inspect burner ring for blockages (spider webs, dirt, etc.). Keep fire column free and clear from debris.
t fter burner ring and lava rock are completely cooled down, use a soft brush to get rid of mild stains, loose dirt and soil. ipe
with a soft cloth.
The manufacturers warranty will be voided by, and manufacturer disclaims any responsibility for following actions
t Modification of the fire bowl andor components including the gas valve assembly.
tUse of any component part not manufactured or approved by manufacturer.
t Use and installation other than as instructed in this manual.
88"33"33"/5"/5::WARNING: FUELS USED IN LIQUEFIED PROPANE GAS APPLIANCES ,AND THE PRODUCTS OF
COMBUSTION OF SUCH FUELS,CAN EXPOSE YOU TO CHEMICALS INCLUDING BENZENE,WHICH IS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM For more information go to :www.P65Warnings.ca.gov
ADVERTENCIA:LOS COMBUSTIBLES USADOS EN EQUIPOS PARA LICUAR GAS PROPANO,ASi COMO
LOS PRODUCTOS DE SU COMBUSTION,PUEDEN EXPONERTE A SUSTANCIAS QUiMICAS,ENTRE ELLAS
EL BENCENO,QUE EL ESTADO DE CALIFORNIA RECONOCE COMO CAUSA DE CANCER Y DE
MALFORMACIONES CONGENITAS Y OTROS DANOS AL SISTEMA REPRODUCTOR
Para mas informacion,visite www.P65Warnings.ca.gov
8

5306#-&4)005*/(No Igniter battery or igniter battery short of
power Replace with new igniter battery
Igniter battery is incorrectly inserted Reinsert the battery proporly
Igniter broken or cracked Call the customer service for replacement part
Ignition wire is loose or disconnected to
igniter Reinsert the ignition wire
Electricity leakage in ignition wire or the
needle of ignition wire can not aim at the
hole of burner while lighting
Call the customer service for replacement part
The switch of gas cylinder was
not switch on Not switch on the valve of gas cylinder Switch on the valve of gas cylinder
Inproperly connect between
regulator and gas cylinder
Regulator is loose or disconnected to gas
cylinder Check and reconnect the regulator to gas cylinder
No gas in gas cylinder No or short of gas Check if the gas cylinder is empty ,if yes, replace it
Switch on the gas cylinder when the
balance gas still existed in hose cause
excess flow safety valve activated
Turn the control knob to "OFF",Swich off the valve
of gas cylinder and disconnect the regulator from the
valve of gas cylinder.Turn the control knob to
"LOW", Wait 30 seconds, Turn the control to
"OFF",Reconnect the regulator to the gas
cylinder.Light the appliance as indicated in the "To
Light"section of manual
Obvious gas leakage in gas system cause
excess flow safety valve activated
Check the gas system to see if gas leakage, if yes,
Call the customer service for help.
Bends or kinks in regulator Regulator was bends or kinks cause the
poor fluent gas inside of hose Straighten hose of all bends or kinks
No or short of gas See"No or Short of gas" above See"No or Short of gas" above
High or gusting winds Flame was blow out by high or gusting
winds
Remove the appliance to the place without high or
gusting winds
Loose connected in
thermocouple
Loose connected between thermocouple
and valve Call the customer service for help
Media fall into inside guard cause block
the entrance of oxygen
Media fall into inside guard and cover the
flame in burner hole which also cause the
low temperature while conduction
Guard covered by media Guard covery by media cause the
inproprely burning inside hole of guard
Remove the media from the guard as indicated in
manual
Too much carbon deposition
inside guard
The carbon deposition will occur since the
gas can not sufficient burning when using
the appliance
Open the top of guard by using pincer and clean the
carbon deposited in guard,thermocouple,ignition
wire,burner.lastly recover the top of guard .
Excess flow safety valve has
been activated
No or Short of
gas
No spark
between
ignition wire
and burner's
hole while
pushing the
igniter button.
Inside guard blocked by media Open and clean the guard
Flame blow out
No power in igniter
The ignition wire didn't conduct
electricity Problem Cause Solution