Handicare Puma 20 User manual

PUMA 20
USER MANUAL
9006395D
EN

© 2011 Handicare
All rights reserved.
The information provided herein may not be reproduced and/or published in any form, by print,
photoprint, microfilm or any other means whatsoever (electronically or mechanically) without the prior
written authorization of Handicare.
The information provided is based on general data concerning the construction known at the time of
the publication of this manual. Handicare executes a policy of continuous improvement and reserves
the right to changes and modifications.
The information provided is valid for the product in its standard version. Handicare can therefore not
be held liable for any damage resulting from specifications of the product deviating from the standard
configuration. Illustrations contained in the manual may deviate from the configuration of your product.
The information made available has been prepared with all possible diligence, but Handicare cannot
be held liable for any errors contained in the information or the consequences thereof.
Handicare accepts no liability for loss resulting from work executed by third parties.
Names, trade names, trademarks etc. used by Handicare may not, as per the legislation concerning
the protection of trade names, be considered as being available.
2011-01
English

4 |
1 Introduction 6
1.1 This user manual 6
1.2 Symbols used in this manual 6
2 Safety 7
2.1 Temperature 7
2.2 Electromagnetic radiation 7
2.3 Moving parts 8
2.4 Markings on the wheelchair 9
3 General description 10
3.1 Main components 10
3.2 Configurations 10
3.3 The user 11
3.4 User environment 11
3.5 Adjustment options 12
4 Wheelchair settings 13
4.1 Seating system 13
4.2 Seat height 13
4.3 Centre of gravity setting 13
4.4 Controller height and depth 14
4.5 Control system programme 14
5 Use of the wheelchair 15
5.1 Checking the wheelchair before use 15
5.2 Getting in and out of the wheelchair (transfer) 15
5.3 Driving the wheelchair 16
5.4 Obstacles 18
5.5 Adjustment options 18
5.6 Pushing the wheelchair 19
5.7 Transport of the wheelchair (without occupant) 19
5.8 The wheelchair as a passenger seat in a car 20
5.9 Fastening the seat belt 22
5.10 Storage after use 22
6 Maintenance of the wheelchair 23
6.1 Maintenance plan 23
6.2 Batteries 23
6.3 Tyres 24
6.4 Cleaning the wheelchair 24
6.5 Decommissioning the wheelchair 25
7 Troubleshooting 26
8 Technical specifications 27
8.1 CE declaration and requirements 27
8.2 Technical information 27
8.3 Electric wiring diagram 29

| 5
9 Warranty 30
9.1 Provisions of warranty 30
9.2 Liability provisions 31

6 | Introduction
1 Introduction
Congratulations on choosing a Handicare
wheelchair. Handicare’s high-quality
mobility products are designed to enhance
independence and make your everyday life
easier.
1.1 This user manual
This user manual will help you to use and
maintain your wheelchair safely. This entire
user manual for this wheelchair consists of
three booklets:
• The general wheelchair user manual (this
booklet)
• The user manual for the seating system
• The user manual for the controller
When necessary this general user manual
refers to other manuals as shown below:
Seating system: Refers to the user manual
for the seating system.
Controller: Refers to the user manual
for the controller.
Battery charger: Refers to the user manual
for the battery charger.
Read this entire user manual (all of the
booklets) carefully before using the product.
If one of the user manuals was not included
with your wheelchair, please contact your
dealer immediately.
In addition to this user manual, there is also a
service manual for qualified specialists.
CONTACT HANDICARE IF YOU HAVE A
VISUAL IMPAIRMENT.
1.2 Symbols used in this manual
Note!
Pointing out possible problems to the user.
Caution!
Advice for the user to prevent damage to the
product.
Warning!
Warnings for the user to prevent personal in
jury.
Not following these instructions may result
in physical injury, damage to the product or
damage to the environment!

Safety | 7
2 Safety
Warning!
Always follow the instructions given next to
the warning symbols! Not following these
instructions may result in physical injury,
damage to the wheelchair or damage to the
environment. Where possible, the warnings
have been placed in the applicable paragraphs.
2.1 Temperature
Warning!
Avoid physical contact with the wheelchair’s
motors. The motors are continuously in motion
during use and can reach high temperatures.
After use, the motors will cool down slowly.
Physical contact may cause burns.
Ensure that the wheelchair is not exposed to
direct sunlight for extended periods of time.
Certain parts of the wheelchair, such as the
seat, the backrest and the armrests, can
become hot if exposed to the sun for too long.
This may cause burns or skin irritation.
2.2 Electromagnetic radiation
The standard version of your electric
wheelchair has been tested for compliance
with the applicable requirements regarding
electromagnetic radiation (EMC requirements).
Note!
It cannot be excluded that electromagnetic
radiation emanating from mobile telephones,
medical apparatus and other sources, may
have an influence on the wheelchair.
It cannot be excluded that the wheelchair will
interfere with the electromagnetic fields of, for
example, shop doors, burglar alarm systems
and/or garage door openers.
In the unlikely event that such problems do
occur, you are requested to notify your dealer
immediately.

8 | Safety
2.3 Moving parts
Warning!
Contact with the moving parts of the wheelchair should
be avoided. A wheelchair has moving and rotating
parts. Contact with moving parts may result in serious
physical injury or damage to the wheelchair.
Moving/rotating parts (figure 1)
1. Wheels (turning and pivoting)
2. Electrical tilt adjustment
Figure 1

Safety | 9
101248-05_14
1
2
3
4
5
6
7
2.4 Markings on the wheelchair
Note!
Never remove or cover up the markings, symbols and
instructions affixed to the wheelchair. These safety
features must remain present and clearly legible
throughout the entire lifespan of the wheelchair.
Replace or repair any markings, symbols or instructions
that have become illegible or damaged immediately.
Please contact your dealer for assistance.
Markings used on the wheelchair (figure 2):
1. Check manual before using
2. Freewheel switch in ‘Drive’ mode. Freewheel switch
in ‘Push’ mode. Never set the freewheel switch to
‘Push’ mode while the wheelchair is on a slope.
3. Battery charging connection
4. Attachment point for the tie-down system for
transportation in a vehicle.
5. Risk of breakage! Use caution when swinging the
controller aside in order to avoid anything becoming
trapped.
6. Risk of pinching. Keep hands and fingers clear of the
moving parts when adjusting the height and/or when
adjusting the tilt of the wheelchair.
7. Identification plate
A. Model
B. Year of manufacture
C. Identification number
D. Indoor or outdoor use
E. Maximum load in kg
Figure 2

10 | General description
101248-05_25
9
6
4
7
8
5
1
2
3
101248-05_24
9
6
4
7
8
5
2
1
3
3 General description
Comfort is of paramount importance to many people
who make use of a wheelchair. And this is exactly what
this electrical driven wheelchair offers: an unknown
degree of driving comfort. A distinctive feature is the
unique independent suspension system, which absorbs
not only shocks, but also vibrations.
3.1 Main components
(figure 3 and 4)
1. Drive wheels
2. Castor wheels
3. Freewheel switch
4. Controller
5. Seat cushion
6. Backrest
7. Armrest
8. Legrest with foot support
9. Headrest
3.2 Configurations
Generally speaking, the wheelchair comprises a chassis
with a seating system on top. This special chassis
makes it possible for the wheelchair to be configured
as front wheel drive (FWD, figure 3) or rear wheel-drive
(RWD, figure 4). The wheelchair is available in different
speeds (6 km/h & 10 km/h).
In addition, the Puma 20 can be supplied with two
different types of tyres (for indoor and outdoor use).
This will have an effect on certain specifications.
Warning!
It is not allowed to change the technical specifications.
Do not make any changes to the electrical circuit.
Modifications to the wheelchair or to any parts thereof
are not permitted.
Figure 3
Figure 4