Harman XXV-TC User manual
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1713-90-00680i
Model(s):
XXV-TC Freestanding Pellet Stove
Installation Manual
Installation and Appliance Setup
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE: SAVE THESE INSTRUCTIONS
Please read this entire manual before
installation and use of this pellet fuel-
burning room heater.
Failure to follow these instructions could
result in property damage, bodily injury
or even death.
Hot glass will cause burns.
High temperatures may ignite clothing or other
HOT SURFACES!
NOTE
WARNING
WARNING
CAUTION
!
CAUTION
!
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1723-90-00680i
TABLE OF CONTENTS
3
4
4
4
4
4
2 Getting Started
5
6
6
3 Framing and Clearances
7
8
8
8
9
9
4 Termination Location and Vent Information
15
18
19
19
19
20
21
21
5 Appliance Setup
22
22
6 Reference Materials
23
24
Safety Alert Key:
• DANGER!
• WARNING!
• CAUTION!
• NOTICE:
!
= Contains updated information
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1733-90-00680i
Installation Standard Work Checklist
ATTENTION INSTALLER:
Follow this Standard Work Checklist
Customer: ________________________________ Date Installed: __________________________
Lot/Address: ________________________________ Location of Stove: __________________________
________________________________ Installer: __________________________
Model: ________________________________ Dealer/Distributer Ph # __________________________
Serial Number: __________________________
!
WARNING! Risk of Fire or Explosion! Failure to install appliance to these instructions can lead
Appliance Install YES IF NO, WHY?
Venting/Chimney Section 4 (Pg. 10-19)
Electrical Section 1 (Pg. 4)
Appliance Setup Section 5 (Pg. 20-21)
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1743-90-00680i
C. Mobile Home Approved
A Harman® Outside Air Kit must be installed in a mobile
home installation.
Note:
ASTM E1509-2012, ULC S628-93, (UM) 84-HUD
E. Electrical Codes
Note:
®
1
THE STRUCTURAL INTEGRITY OF THE MANUFACTURED
HOME FLOOR, WALL, AND CEILING/ROOF MUST BE
MAINTAINED.
DO NOT INSTALL IN SLEEPING ROOM.
WARNING
!
Note:
***EPA BTU Output:
****BTU Input
Vent Size:
Hopper Capacity:
Fuel:
MODEL:
LABORATORY:
REPORT NO.
TYPE:
STANDARD(s):
ELECTRICAL
RATING
GLASS
SPECIFICATIONS
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1753-90-00680i
A
.
Design and Installation Considerations
1. Appliance Location
Marginal Location:
Marginal Location:
Figure 2.1
2 Getting Started
• Air Conditioner
NOTE: Check building codes prior to installation.
NOTE: Locating the appliance in a location of considerable
air movement can cause intermittent smoke spillage from
appliance. Do not locate appliance near:
• Frequently open doors
• Central heat outlets or returns
WARNING
!
Risk of Fire!
Damaged parts could impair safe operation.
Do NOT install damaged, incomplete or
substitute components.
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1763-90-00680i
May also need:
B. Tools And Supplies Needed
Tools and building supplies normally required for
installation, unless installing into an existing masonry
C. Inspect Appliance and Components
• Read all of the instructions before starting the
installation. Follow these instructions carefully during
DO NOT:
• Install or operate a damaged appliance.
• Modify appliance.
• Install other than as instructed by Hearth & Home
Technologies.
• Operate the appliance without fully assembling all
components.
• Install any component not approved by Hearth &
Home Technologies.
• Install parts or components not Listed or approved.
• Disable safety switches.
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
installer, service agency or your dealer.
WARNING
!
Risk of Fire, Explosion or Electric Shock! DO NOT use
and to replace any part of the control system which
WARNING
!
RISK OF FIRE OR EXPLOSION!
DAMAGED PARTS COULD IMPAIR SAFE
DO NOT install damaged,
Keep appliance dry.
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1773-90-00680i
3 Clearances
Figure 3.1
A. Appliance Dimension Diagram
28-7/16”
722 mm
31-1/8”
791 mm
29-7/16”
748 mm
26-3/4””
679 mm
28-5/8””
727 mm
24-3/8””
619 mm
4-1/16”
103mm
14-3/4”
375mm
8-11/16”
228mm
12-1/2”
318m
Outside Air
Intake
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1783-90-00680i
NOTICE
Figure 3.2
Floor Protection
0" (0mm)
6" (152mm)
6" (152mm)
CAUTION
!
THIS APPLIANCE MUST BE VENTED TO THE OUTSIDE.
WARNING
!
RISK OF FIRE OR BURNS! Provide adequate
clearance around air openings and for service
Due to high temperatures, the appliance should
draperies.
Illustrations
as they satisfy the measurement requirements shown
Floor Protection
6.25”
(159mm)
6.25”
(159mm)
ASTM E 136,
Standard Test Method for Behavior of Materials in
a Vertical Tube Furnace at 750° C and UL763
D. Clearances to Combustibles
Note: Top of unit must be a minimum of 12” (305mm) to
ceiling
42” High
36” Wide
Height = 48”, Width = 36, Depth = 24”
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1793-90-00680i
Floor Protection
Requirements US Canada
J 6"
K
L
F. Mobile Home Installation
•
•
Corner Installation:
Note: Floor protector WILL NOT touch the wall using
Figure 3.3
Figure 3.4
E. Floor Protection
Parallel Installation:
but does not need to extend any further.
as they satisfy the measurement requirements shown
L
J
K
Door Opening
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1710 3-90-00680i
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances
Figure 4.1
Figure 4.2
#1 Preferred method (Figure 4.1)
Note: Do not place joints within wall pass-through.
THE CHIMNEY MUST BE OF A TYPE SUITABLE FOR
SOLID-FUEL BURNING.
#2 Preferred method (Figure 4.2)
If the stove is installed below grade be sure the vent
termination is at least 12" above grade (with outside air
only). The outlet must also be 12” from the house/building.
Note
CAUTION
!
Keep combustible materials (such as grass, leaves,
outside of the building.
3 Ft.
to
Combustibles
3 Ft.
to Combustibles
3 Ft.
to
Combustibles
3 Ft.
to Combustibles
DO NOT USE MAKESHIFT COMPROMISES WHEN
INSTALLING THIS APPLIANCE. DAMAGE AND/OR
INJURY MAY RESULT.
CAUTION
!
WARNING
!
THE CHIMNEY AND CONNECTOR MUST BE
MAINTAINED IN GOOD CONDITION AND KEPT CLEAN.
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1711 3-90-00680i
Figure 4.3
Figure 4.4
#3 Installing into an existing chimney (Figure 4.3)
Refer to Method 5 & 6
(Figure 4.4)
Refer to Method 5 & 6.
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1712 3-90-00680i
4.5) w/Full Liner
#6 Installing into an existing chimney (Figure 4.6) w/Full liner
Figure 4.5
Figure 4.6
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1713 3-90-00680i
12"
min. wall to outlet
36"
min. clearance to any
combustable material
#7 Installing through the ceiling (Figure 4.7)
Note: Do not place joints within wall pass-through.
Figure 4.7
Figure 4.8
Figure 4.9
Area within dotted circle represents the minimum clearance to
combustible materials such as shrubbery, mulch or tall grasses.
12"
min. above ground level
It is recommended that outside air be
Smoke spillage may be possible during
a power outage.
PL vent manufacturer's
restop spacer and support
1" MIN.
No insulation or other
combustible materials
are allowed within 1"
of the PL vent pipe.
ashing
storm collar
1" MIN.
1" MIN.
12" MIN
1” MIN.
DO NOT USE MAKESHIFT COMPROMISES WHEN
INSTALLING THIS APPLIANCE. DAMAGE AND/OR
INJURY MAY RESULT.
CAUTION
!
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1714 3-90-00680i
Optional Top Vent Pipe Clearances #8 Installing into an existing chimney using the Optional
Top Vent option. (Figure 4.10)
4"/102mm from back of top
Minimum 6” (25mm)
from top of pipe to ceiling
6"/152mm from
pipe to wall
Figure 4.10
Single wall 6” Chimney
connector
Chimney Connectors
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1715 3-90-00680i
B. Chimney Diagram
V=Vent Terminal A=Air Supply Inlet =Area where termination is not permitted
Door
Sidewalk
Fixed
Closed
Openable
Openable Fixed
Closed
Inside Corner
Detail
Porch or
Openable
Deck
or Fixed
Requirements for Terminating the Venting
Figure 4.10
with outside air installed, 6 feet
(B. also)
The clearance to vegetation and other exterior combustibles
such as mulch is 36” as measured from the center of the
outlet or cap. This 36” radius continues to grade.
See NFPA 211 for more installation clearance reductions
when using outside air.
Where passage through a wall, or partition of combustible
construction is desired, the installation shall conform to
CAN/CSA-B365. (if in Canada)
WARNING
!
Venting terminals must not be recessed into a wall
or siding.
be used when venting through combustible materials.
Always take into consideration the effect the prevailing wind
/or smoke when placing the termination.
In addition, the following must be observed:
with outside air installed, 12”
to side and below
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1716 3-90-00680i
C. Venting & Use of Elbows
Figure 4.11
= Positive static pressure
= Negative static pressure
+
-
+
+
-
Equivalent Vent Length: The equivalent vent length for
common pellet vent components are:
The total allowable equivalent vent length is:
Example: First Floor Installation
The equivalent vent length is:
Example: Connection to Masonry Chimney
The equivalent vent length is:
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1717 3-90-00680i
C. Venting & Use of Elbows continued
Note:
Note:
Example:
No Change of Combustion
Blower Fan Blade Needed
0 Ft5 Ft 5 Ft
10,000
9,000
8,000
7,000
6,000
5,000
4,000
3,000
5 Ft
0 Ft
10 Ft
Combustion Blower Fan
Blade Changeover Line
Altitude
10 Ft
15 Ft
20 Ft
25 Ft
30 Ft
5 Ft
0 Ft
15 Ft
Equivalent Vent Length (EVL)
Maximum Horizontal Run
• INSTALL VENT AT CLEARANCES SPECIFIED BY THE VENT MANUFACTURER.
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1718 3-90-00680i
Outside Air:
Hearth & Home Technologies recommend attaching
outside air in all installations, especially lower level and
D. Outside Air
Part #1-00-677177
Figure 4.14
Part# 1-10-09542
Figure 4.13
goes here.
Figure 4.12
Remove knockout to
install outside air.
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1719 3-90-00680i
E. Locating Your Appliance & Chimney
G. Negative Pressure
F. Draft
Minimum Vacuum Requirements: .20
refer to “Appliance Set-Up” Section C.
CAUTION
!
all
Risk of Asphyxiation!
WARNING
!
NOTICE
Harman® • XXV-TC Installation Manual_R3 • 2016 -___ • 02/1720 3-90-00680i
H. Avoiding Smoke and Odors
Negative Pressure, Shut-down, and Power Failure:
To reduce the probability of back-drafting or burn-back in
the pellet burning appliance during power failure or shut-
down conditions, the stove must be able to draft naturally
Outside Air
Vent Pipe
Hearth & Home Technologies assumes no responsibility
for, nor does the warranty extend to, smoke damage
caused by reverse drafting of pellet appliances under
shut-down or power failure conditions.
Other manuals for XXV-TC
1
Table of contents
Other Harman Stove manuals
Harman
Harman P61-C User manual
Harman
Harman PC45 User manual
Harman
Harman P42i-TC User manual
Harman
Harman Super-Magnum Coal Stoker Stove Safety guide
Harman
Harman Clarity 929 DV Installation instructions
Harman
Harman Oakwood Installation instructions
Harman
Harman P43 User manual
Harman
Harman Oakleaf Wood Stove User manual
Harman
Harman P43 User manual
Harman
Harman SF 250 User manual
Harman
Harman Super-Magnum User manual
Harman
Harman P35i-C User manual
Harman
Harman Allure50 User manual
Harman
Harman XXV User manual
Harman
Harman Absolute63 User manual
Harman
Harman P43 User manual
Harman
Harman DVC-500 Installation instructions
Harman
Harman TLC 2000 User manual
Harman
Harman P43 User manual
Harman
Harman P43 User manual
Popular Stove manuals by other brands
Breckwell
Breckwell Big E SP1000PWA owner's manual
FRANCO BELGE
FRANCO BELGE Montfort MK2 Technical manual
EdilKamin
EdilKamin ARIS PLUS Installation, use and maintenance
Heat Design
Heat Design FW4SE Installation and operating instructions
Solas-Nua
Solas-Nua FS-16N RV Installation & operation manual
Harrie Leenders
Harrie Leenders Pharos Manual and installation instructions
Konigshutte
Konigshutte Vela 28/875 instruction manual
LOHBERGER
LOHBERGER Varioline LM 50 Installation
ACR STOVES
ACR STOVES MV2CL Technical manual
Diamond
Diamond RECH/1G-N Instructions for use and installation
Tiger
Tiger CAST-IRON MULTI-FUEL STOVE v5.2 Installation and operating instructions
Vigan Mammoth
Vigan Mammoth SKV2C user manual
Palazzetti
Palazzetti MULTIFIRE IDRO NT 15 GENERAL INFORMATION - WARNINGS - INSTALLATION - MAINTENANCE
Hamlet
Hamlet BK055 Operating & installation manual
Vogelzang International
Vogelzang International VG150 owner's manual
ADURO
ADURO P1 series manual
Vermont Castings
Vermont Castings 3340 Homeowner's installation and operating manual
Lennox Hearth Products
Lennox Hearth Products 1003C Installation and operation manual