Hatco 07.04.668.00 User manual

Pop-Up Toaster
TPTD Series
Installation and Operating Manual
Replacement Parts List
P/N 07.04.668.00
© 2013 Hatco Corporation
Register Online!
(see page 2)
hatcocorp.com
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual contains important safety
information concerning the maintenance,
use, and operation of this product. If
you’re unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
o muerte. Este manual contiene
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual por favor pregunte a su
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le non-respect des instructions
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manuel contient des informations
importantes concernant l'entretien,
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
dans un endroit sûr pour pouvoir vous y
référer plus tard.
WARNING
ADVERTENCIA
AVERTISSEMENT

Form No. TPTDM-1113
CONTENTS
2
This manual provides the installation, safety, and operating
instructions for the Edward Don Pop-Up Toaster. Edward Don
and Hatco recommend all installation, operating, and safety
instructions appearing in this manual be read prior to installation
or operation of the unit.
Safety information that appears in this manual is identified by
the following signal word panels:
WARNING indicates a hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION indicates a hazardous situation which, if not
avoided, could result in minor or moderate injury.
NOTICE is used to address practices not related to personal
injury.
NOTICE
CAUTION
WARNING
INTRODUCTION
The Edward Don Pop-Up Toaster is perfect for self-serve buffet
areas, lighter volume restaurants, diners, and cafes. The unit
evenly toasts a variety of bread products including bagels, texas
toast, waffles, and english muffins. The Pop-Up Toaster makes
a great addition to your conveyor toaster for those non-peak
periods when an occasional order of toast is needed.
The Pop-Up Toaster features a durable stainless steel housing,
four self-centering extra-wide slots, individual toasting controls,
removable crumb trays for easy cleaning, and a 6′ (1829 mm)
cord with plug.
The Edward Don Pop-Up Toaster is a product of extensive
research and field testing. The materials used were selected
for maximum durability, attractive appearance, and optimum
performance. Every unit is inspected and tested thoroughly
prior to shipment.
Important Owner Information ..............................................2
Introduction...........................................................................2
Important Safety Information...............................................3
Model Description.................................................................4
Model Designation................................................................4
Specifications........................................................................5
Plug Configurations ............................................................5
Electrical Rating Chart........................................................5
Dimensions.........................................................................5
Installation.............................................................................6
General...............................................................................6
Operation...............................................................................7
General...............................................................................7
Maintenance ..........................................................................8
General...............................................................................8
Daily Cleaning ....................................................................8
Troubleshooting Guide ........................................................9
Replacement Parts List ......................................................10
atco Limited Warranty......................................................12
Service Information ............................................................13
Authorized Parts Distributors............................Back Cover
IMPORTANT OWNER INFORMATION
Record the model number, serial number, voltage, and
purchase date of the unit in the spaces below (specification
label located on the bottom of the unit). Please have this
information available when calling Hatco for service assistance.
Model No. ________________________________________
Serial No. ________________________________________
Voltage __________________________________________
Date of Purchase __________________________________
Register your unit!
Completing online warranty registration will prevent delay in
obtaining warranty coverage. Access the Hatco website at
www.hatcocorp.com, select the Parts & Service pull-down
menu, and click on “Warranty Registration”.
Business
Hours: 8:00 AM to 5:00 PM Central Standard Time (CST)
(Summer Hours: une to September—
8:00 AM to 5:00 PM CST Monday–Thursday
8:00 AM to 2:30 PM CST Friday)
Telephone: [phone]
e-mail: [email protected]
Fax: [phone] (Parts and Service)
414-671-3976 (International)
Additional information can be found by visiting our web site at
www.hatcocorp.com.
24 Hour 7 Day Parts and Service
Assistance available in the United States
and Canada by calling 800-558-0607.
NOTE: E war Don Pop-Up Toasters are manufacture by
the Hatco Corporation. Please contact Hatco for
Service Assistance, Replacement Parts, or Warranty
Information.

Form No. TPTDM-1113 3
IMPORTANT SAFETY INFORMATION
In case of fire, disconnect toaster from power source
immediately. This allows unit to cool, making it easier and
safer to put out the fire.
Make sure all operators have been instructed on the safe and
proper use of the unit.
This unit is not intended for use by children or persons with
reduced physical, sensory, or mental capabilities. Ensure
proper supervision of children and keep them away from unit.
This unit has no “user-serviceable” parts. If service is
required on this unit, contact an Authorized atco Service
Agent or contact the atco Service Department at
800-558-0607 or 414-671-6350; fax [phone]; or
International fax [phone].
BURN AZARD:
• Some exterior surfaces on unit will get hot. Use caution
when touching these areas.
• Do not remove crumb trays for cleaning until toaster is
cool.
Locate unit at proper counter height in an area that is
convenient for use. Location should be level to prevent unit
or its contents from falling accidentally and strong enough
to support weight of unit and contents.
Always operate toaster with crumb trays installed.
Toasting of coated or buttered products such as garlic
bread, cheese sandwiches, and sweet rolls is NOT
recommended. Residue will reduce toaster performance
and could ignite inside toaster. Using toaster with food
products listed above will void unit warranty.
Do not lay unit on the side with the control panel or damage
to the unit could occur.
Use non-abrasive cleaners and cloths only. Abrasive
cleaners and cloths could scratch finish of unit, marring
its appearance and making it susceptible to soil
accumulation.
This unit is intended for commercial use only — NOT for
household use.
NOTICE
CAUTION
WARNING
ELECTRIC S OCK AZARD:
• Plug unit into a properly grounded electrical receptacle
of correct voltage, size, and plug configuration. If plug
and receptacle do not match, contact a qualified
electrician to determine and install proper voltage and
size electrical receptacle.
• Unplug power cord and allow unit to cool before
performing maintenance, cleaning, or attempting to
clear a jam.
• DO NOT submerge or saturate with water. Unit is not
waterproof. Do not operate if unit has been submerged
or saturated with water.
• Unit is not weatherproof. Locate unit indoors where the
ambient air temperature is a minimum of 70°F (21°C).
• Do not pull unit by power cord.
• Discontinue use if power cord is frayed or worn.
• Do not attempt to repair or replace a damaged power
cord. Cord must be replaced by atco, an Authorized
atco Service Agent, or a person with similar
qualifications.
• Do not steam clean or use excessive water on unit.
• This unit is not “jet-proof” construction. Do not use jet-
clean spray to clean unit.
• NEVER insert a knife, fork, or similar object into
toasting chamber.
• Do not pick up toaster by inserting fingers into toaster
slots and grasping heating elements.
• Do not clean unit when it is energized or hot.
• Do not allow liquids to spill into unit.
• Unit must be serviced by qualified personnel only.
Service by unqualified personnel may lead to electric
shock or burn.
FIRE AZARD:
• Locate unit a minimum of 1″ (25 mm) from combustible
walls and materials. If safe distances are not
maintained, combustion or discoloration could occur.
• Do not place anything on top of toaster. Do not place
toaster near or underneath curtains or other
combustible materials. Items near or on top of toaster
could catch fire causing injury and/or damage to
toaster.
EXPLOSION AZARD: Do not store or use gasoline or
other flammable vapors or liquids in the vicinity of this or
any other appliance.
WARNING
Read the following important safety information before using this equipment to avoid serious
injury or death and to avoid damage to equipment or property.

Form No. TPTDM-1113
4
MODEL DESCRIPTION
All Models
Edward Don Pop-Up Toasters are perfect for buffet areas and
lighter volume restaurants. The TPTD series toasters have four
self-centering, extra wide slots with individual progressive
toasting controls. Models TPT-208D and TPT-240D are
equipped with bagel/bun buttons for one-sided toasting. The
durable stainless steel housing contains removable crumb trays
for easy cleaning.
TPTD Series Pop-Up Toasters
Model TPT-120D
Models TPT-208D/TPT-240D
MODEL DESIGNATION
T P T - X X X D
Pop-Up Toaster
Unit Voltage
Edward Don

Model Voltage Watts Amps Plug Configuration Shipping Weight
TPT-120D 120 1800 15.0 NEMA 5-15P *15 lbs. (7 kg)
TPT-208D 208 2600 12.5 NEMA 6-15P †15 lbs. (7 kg)
TPT-240D 240 2600 10.9 NEMA 6-15P 15 lbs. (7 kg)
Form No. TPTDM-1113 5
SPECIFICATIONS
Dimensions
12-3/8"
(313 mm)
13-5/8"
(346 mm)
8-1/16"
(204 mm)
12"
(304 mm)
8-1/16"
(204 mm)
TPTD Series Slot Openings = 1-1/4" W x 5-1/2" D x 4-1/2" H (32 x 140 x114 mm)
Front View Side View
Plug Configurations
Units are supplied from the factory with an electrical cord and
plug installed. Plugs are supplied according to the application.
ELECTRIC S OCK AZARD: Plug unit into a properly
grounded electrical receptacle of correct voltage, size, and
plug configuration. If plug and receptacle do not match,
contact a qualified electrician to determine and install
proper voltage and size electrical receptacle.
NOTE: Specification label locate on the bottom of the unit.
See label for serial number an verification of unit
electrical information.
WARNING
Plug Configurations
NOTE: Receptacle not supplie by Hatco.
NEMA 5-15P NEMA 6-15P
NEMA 6-20P
NEMA 5-20P
Electrical Rating Chart
*5-20P for Canada
†6-20P for Canada

INSTALLATION
6Form No. TPTDM-1113
General
The Pop-Up Toaster is shipped with all components pre-
assembled. Care should be taken when unpacking the shipping
carton to avoid damage to the unit and the components enclosed.
ELECTRIC S OCK AZARD: Unit is not weatherproof.
Locate unit indoors where ambient air temperature is a
minimum of 70°F (21°C).
EXPLOSION AZARD: Do not store or use gasoline or
other flammable vapors or liquids in the vicinity of this or
any other appliance.
FIRE AZARD:
• Locate unit a minimum of 1″ (25 mm) from combustible
walls and materials. If safe distances are not
maintained, combustion or discoloration could occur.
• Do not place anything on top of toaster. Do not place
toaster near or underneath curtains or other combustible
materials. Items near or on top of toaster could catch fire
causing injury and/or damage to toaster.
NOTE: TPTD Series toasters require a e icate circuit.
WARNING
1. Remove the unit from the carton.
NOTE: To prevent elay in obtaining warranty coverage,
complete online warranty registration. See the
IMPORTANT OWNER INFORMATION section for
etails.
2. Remove tape and protective packaging from all surfaces of
the unit.
3. Place the unit in the desired location.
• Locate the unit in an area where the ambient air
temperature is constant and a minimum of 70°F (21°C).
Avoid areas that may be subject to active air movements
or currents (i.e., near exhaust fans/hoods and air
conditioning ducts).
• Make sure the unit is at the proper counter height in an
area convenient for use.
• Make sure the countertop is level and strong enough to
support the weight of the unit and food product.
• Make sure all the feet on the bottom of the unit are
positioned securely on the countertop.
TOAST/BAGEL
Button
Operating Lever
TPT-208D/TPT-240D
Crumb
Tray
Toasting Slot
TPT-120D
COLOR
CONTROL
Knob
Components

Form No. TPTDM-1113 7
OPERATION
General
The Pop-Up Toaster is designed for ease of operation. Perform
the following procedure to operate the toaster.
Read all safety messages in the IMPORTANT SAFETY
INFORMATION section before operating this equipment.
1. Plug the unit into a properly grounded electrical receptacle
of the correct voltage, size, and plug configuration. See the
SPECIFICATIONS section for details.
2. Set the COLOR CONTROL knob(s) to the desired toast
darkness setting. The “1” setting on the COLOR CONTROL
knobs represents the lightest toast setting and the “7”
setting represents the darkest.
3. For TPT-208D and TPT-240D toasters, make sure the
TOAST/BAGEL button(s) is in the correct position. Push the
TOAST/BAGEL button(s) to change its setting, if necessary.
• When the TOAST/BAGEL button(s) is in the TOAST
position (depressed), both heating elements in each
toasting slot will energize to toast both sides of the
product.
• When the TOAST/BAGEL
button(s) is in the BAGEL
position (released), only
the inner heating elements
in each pair of toasting
slots will energize to toast
the inner side of the
product.
4. Place bread product in
toasting slot(s). If toasting only
one side of the product, make
sure to place the toasting side
toward the center of each pair
of toasting slots.
WARNING
5. Push down on the operating lever(s) to lower product into
the toaster.
• As soon as the operating lever is pushed down, the
heating elements inside the toaster energize and begin
heating.
BURN AZARD: Some exterior surfaces on unit will get hot.
Use caution when touching these areas.
• When the toasting cycle is complete, the heating
elements shut off and the operating lever(s) rises
automatically.
NOTE: The operating lever(s) can be lifte manually uring
toasting for pro uct removal. This will en the toasting
cycle.
ELECTRIC S OCK AZARD:
• Unplug power cord and allow unit to cool before
performing maintenance, cleaning, or attempting to clear
a jam.
• NEVER insert a knife, fork, or similar object into toasting
chamber.
6. Remove and empty the crumb trays periodically in between
toasting cycles.
Always operate toaster with crumb trays installed.
Toasting of coated or buttered products such as garlic bread,
cheese sandwiches, and sweet rolls is NOT recommended.
Residue will reduce toaster performance and could ignite
inside toaster. Using toaster with food products listed above
will void unit warranty.
WARNING
CAUTION
CAUTION
COLOR CONTROL
Knob
COLOR CONTROL
Knob
TOAST/BAGEL Button TOAST/BAGEL Button
TPT-208D and TPT-240D Control Panel

Form No. TPTDM-1113
8
MAINTENANCE
General
The Pop-Up Toaster is designed for maximum durability and
performance with minimum maintenance.
ELECTRIC S OCK AZARD:
• Unplug power cord and allow unit to cool before
performing cleaning, adjustments, maintenance, or
attempting to clear a jam.
• DO NOT submerge or saturate with water. Unit is not
waterproof. Do not operate if unit has been submerged
or saturated with water.
• This unit is not “jet-proof” construction. Do not use jet-
clean spray to clean this unit.
• Do not steam clean or use excessive water on unit.
• Do not allow liquids to spill into unit.
• Unit must be serviced by qualified personnel only.
Service by unqualified personnel may lead to electric
shock or burn.
This unit has no “user-serviceable” parts. If service is
required on this unit, contact an Authorized atco Service
Agent or contact the atco Service Department at
800-558-0607 or 414-671-6350; fax [phone]; or
International fax [phone].
NOTE: Submerging or saturating the unit with water will
amage the unit an voi the unit warranty.
WARNING
Daily Cleaning
To preserve the finish of the toaster, it is recommended that the
metal surfaces be wiped daily with a non-abrasive, damp cloth.
ELECTRICS OCK AZARD: Do not clean unit when it is
energized or hot.
1. Unplug the power cord and allow the unit to cool.
2. Remove and empty the crumb trays. CAUTION! BURN
AZARD—Do not remove crumb trays for cleaning until
toaster is cool.
3. Wash the crumb trays with warm water and a mild
detergent. Rinse with water.
4. Allow the crumb trays to air dry or hand dry with a soft cloth
before placing back into the toaster.
5. Wipe the exterior surface of the toaster with a damp cloth.
NOTICE: Use non-abrasive cleaners and cloths only.
6. Wipe dry with a clean, dry, non-abrasive cloth.
WARNING

Symptom Probable Cause Corrective Action
Toast too light. COLOR CONTROL knob set on a light
setting.
Turn COLOR CONTROL knob to a darker
setting.
Supply voltage to unit is low. Verify the supply voltage to the toaster
matches the unit specifications.
Toast too dark. COLOR CONTROL knob set on a dark
setting.
Turn COLOR CONTROL knob to a lighter
setting.
Supply voltage to unit is high. Verify the supply voltage to the toaster
matches the unit specifications.
Unit takes too long to toast. The first few batches can take longer
because the toaster needs time to heat up
when initially turned on.
Push down the operation lever(s) for a toasting
cycle before inserting bread product to allow
the toaster to heat up.
Supply voltage to unit is low. Verify the supply voltage to the toaster
matches the unit specifications.
Unit toasts on one side only. TOAST/BAGEL button is in the BAGEL
position (one-sided toasting).
Push the TOAST/BAGEL button to set it to the
TOAST position (two-sided toasting).
Heating element defective. Visually check the heating element inside the
toaster with the operation lever engaged. With
the lever pushed down, the heating element
should glow red. If the element does not glow,
Contact Authorized Service Agent or Hatco for
assistance.
Heating element does not come
on at all when the operating lever
is pushed down.
The switch may be broken. Contact Hatco for assistance.
The operating lever does not
latch.
Latch mechanism is broken. Contact Hatco for assistance.
Toaster trips the circuit breaker
or GFCI.
Circuit breaker is not sized properly for the
toaster.
NOTE: TPTD Series toasters require a
e icate circuit.
Check circuit breaker for proper sizing.
Wiring fault inside toaster. Contact Hatco for assistance.
Form No. TPTDM-1113 9
TROUBLES OOTING GUIDE
Unit must be serviced by qualified personnel only. Service
by unqualified personnel may lead to electric shock or
burn.
WARNING
ELECTRIC S OCK AZARD: Unplug power cord and allow
unit to cool before performing cleaning, adjustments,
maintenance, or attempting to clear a jam.
WARNING
Troubleshooting Questions?
If you continue to have problems resolving an issue, please
contact the nearest Authorized Hatco Service Agency or Hatco
for assistance. To locate the nearest Service Agency, log onto
the Hatco website at www.hatcocorp.com and click on
Fin Service Agent, or contact the atco Parts and Service
Team at:
Telephone: [phone] or 414-671-6350
e-mail: p[email protected]
Fax: [phone] or 414-671-3976

Form No. TPTDM-1113
10
Specification label
on bottom of unit.
1
2
6
15
4
5
3
10
12
11
9
7
8
13
14
16
21
17
18
19
20
22
23
SIDE
SIDE
CENTER
SIDE
SIDE
CENTER
T P T - X X X D
Pop-Up Toaster
Unit Voltage
Edward Don
ATCO POP-UP TOASTER
TPT-120D, TPT-208D, and TPT-240D Models
Model Designation
Use of replacement parts other than those supplied by
atco Corporation may result in damage to unit or injury to
personnel and will void all warranties.
CAUTION
24 Hour 7 Day Parts and Service
Assistance available in the United States
and Canada by calling 800-558-0607.
REPLACEMENT PARTS LIST