Hatco DON User manual

© 2013 atco Corporation
Electric Conveyor Toaster
TC-DON-208 and TC-DON-240 Models
Installation and Operating Manual
Replacement Parts List
P/N 07.04.388.00
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual contains important safety
information concerning the maintenance,
use, and operation of this product. If
you’re unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
o muerte. Este manual contiene
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual por favor pregunte a su
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le non-respect des instructions
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manuel contient des informations
importantes concernant l'entretien,
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
dans un endroit sûr pour pouvoir vous y
référer plus tard.
WARNING
ADVERTENCIA
AVERTISSEMENT
Register Online!
(see page 2)
hatcocorp.com

CONTENTS
2Form No. TCDONM-0713
INTRODUCTION
Important Owner Information ..............................................2
Introduction...........................................................................2
Important Safety Information...............................................3
Model Description.................................................................4
Specifications........................................................................5
Plug Configuration..............................................................5
Electrical Rating Chart........................................................5
Dimensions.........................................................................5
Installation.............................................................................6
General...............................................................................6
Operation...............................................................................7
General...............................................................................7
Maintenance ..........................................................................8
General...............................................................................8
Daily Cleaning ....................................................................8
Additional Cleaning ............................................................8
Troubleshooting uide ........................................................9
Limited Warranty...................................................................9
Replacement Parts List......................................................10
Authorized Parts Distributors............................Back Cover
IMPORTANT OWNER INFORMATION
NOTE: Edward Don El ctric Conv yor Toast rs ar
manufactur d by th Hatco Corporation. Pl as
contact Hatco for S rvic Assistanc , R plac m nt
Parts, or Warranty Information.
Record the model number, serial number (specification label
located on the back of the unit), voltage, and purchase date of
the unit in the spaces below. Please have this information
available when calling atco for service assistance.
Model No. ____________________________________
Serial No. ____________________________________
Voltage ______________________________________
Date of Purchase ______________________________
Register your unit!
Completing online warranty registration will prevent delay in
obtaining warranty coverage. Access the atco website at
www.hatcocorp.com, select the Parts & S rvic pull-down
menu, and click on “Warranty Registration”.
Business
ours: 8:00 AM to 5:00 PM Central Standard Time (CST)
(Summer ours: June to September—
8:00 AM to 5:00 PM CST Monday–Thursday
8:00 AM to 2:30 PM CST Friday)
Telephone: [phone]
e-mail: [email protected]
Fax: [phone] (Parts and Service)
414-671-3976 (International)
Additional information can be found by visiting our web site at
www.hatcocorp.com.
24 Hour 7 Day Parts and Service
Assistance available in the United States
and Canada by calling 800-558-0607.
This manual provides the installation, safety, and operating
instructions for Edward Don Electric Conveyor Toaster. Edward
Don and atco recommend that all installation, operating, and
safety instructions appearing in this manual be read prior to
installation or operation of a unit.
WARNIN indicates a hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION indicates a hazardous situation which, if not
avoided, could result in minor or moderate injury.
NOTICE is used to address practices not related to
personal injury.
NOTICE
CAUTION
WARNING
Edward Don Electric Conveyor Toasters are specially designed
to accelerate the toasting operation. Products for toasting pass
through a heating chamber for rapid and thorough toasting.
Moisture, sugar content, and thickness of bread product affect
the ability to achieve the perfect toasted product. Conveyor
speed determines the toasting color.
Electric Conveyor Toasters are built with quality to meet the
demands of foodservice operations and provide years of
trouble-free performance. The metal-sheathed tubular heating
elements are guaranteed against breakage and burnout for two
years.
Edward Don Electric Conveyor Toasters are products of
extensive research and field testing. The materials used were
selected for maximum durability, attractive appearance, and
optimum performance. Every unit is inspected and tested
thoroughly prior to shipment.

IMPORTANT SAFETY INFORMATION
Form No. TCDONM-0713 3
Read the following important safety information before using this equipment to avoid serious
injury or death and to avoid damage to equipment or property.
ELECTRIC SHOCK HAZARD:
• Plug unit into a properly grounded electrical receptacle
of the correct voltage, size, and plug configuration. If
plug and receptacle do not match, contact a qualified
electrician to determine and install proper voltage and
size electrical receptacle.
• Turn OFF power switch, unplug power cord, and allow
unit to cool before performing maintenance, cleaning,
setup, or attempting to clear a jam.
• Unit is not weatherproof. Locate unit indoors where
ambient air temperature is a minimum of 70°F (21°C)
and a maximum of 85°F (29°C).
• DO NOT submerge or saturate with water. Unit is not
waterproof. Do not operate if unit has been submerged
or saturated with water.
• Do not steam clean or use excessive water on unit.
• This unit is not “jet-proof” construction. Do not use jet-
clean spray to clean this unit.
• Do not clean unit when it is energized or hot.
• Do not allow liquids to spill into unit.
• Do not pull unit by power cord.
• Discontinue use if power cord is frayed or worn.
• Do not attempt to repair or replace a damaged power
cord. Cord must be replaced by Hatco, an Authorized
Hatco Service Agent, or a person with similar
qualifications.
• Never insert a knife, fork, or similar object into toasting
chamber.
• This unit must be serviced by qualified personnel only.
Service by unqualified personnel may lead to electric
shock or burn.
• Use only enuine Hatco Replacement Parts when
service is required. Failure to use enuine Hatco
Replacement Parts will void all warranties and may
subject operators of the equipment to hazardous
electrical voltage, resulting in electrical shock or burn.
enuine Hatco Replacement Parts are specified to
operate safely in the environments in which they are
used. Some aftermarket or generic replacement parts
do not have the characteristics that will allow them to
operate safely in Hatco equipment.
EXPLOSION HAZARD: Do not store or use gasoline or
other flammable vapors or liquids in the vicinity of this or
any other appliance.
If toaster overheats or cooling fan inside unit stops
working, the safety high-limit switch will shut off toaster.
Contact Authorized Service Agent or Hatco for assistance.
WARNING
FIRE HAZARD:
• Allow a minimum clearance of 1" (25 mm) along the
sides and rear of unit. Allow a minimum clearance of
12" (305 mm) in the front. If safe distances are not
maintained, discoloration or combustion could occur.
• Do not locate toaster under shelving or closer than 12"
(305 mm) from the ceiling.
• Do not place anything on top of toaster. Do not place
toaster near or underneath curtains or other
combustible materials. Items near or on top of toaster
could catch fire causing injury and/or damage to the
toaster.
• In case of fire, disconnect toaster from power source
immediately. This allows unit to cool, making it easier
and safer to put out fire.
Make sure all operators have been instructed on the safe
and proper use of the unit.
This unit is not intended for use by children or persons
with reduced physical, sensory, or mental capabilities.
Ensure proper supervision of children and keep them away
from the unit.
This unit has no “user-serviceable” parts. If service is
required on this unit, contact an Authorized Hatco Service
Agent or contact the Hatco Service Department at
800-558-0607 or 414-671-6350; fax [phone]; or
International fax [phone].
BURN HAZARD:
• Some exterior surfaces on unit will get hot. Use caution
when touching these areas.
• Do not remove crumb tray for cleaning until toaster is
cool.
Locate unit at the proper counter height in an area that is
convenient for use. Location should be level and strong
enough to support weight of unit and contents.
Always operate toaster with crumb tray installed.
Toasting of coated or buttered products such as garlic
bread, cheese sandwiches, and sweet rolls is NOT
recommended. Residue will reduce toaster performance
and could ignite inside toaster. Using toaster with food
products listed above will void unit warranty.
CAUTION
WARNING

IMPORTANT SAFETY INFORMATION
4Form No. TCDONM-0713
All Edward Don Electric Conveyor Toasters are fast, reliable,
and versatile. They are capable of toasting up to 700 slices of
bread product per hour. These toasters have the option to toast
a single side or both sides of bread product. The front discharge
only toaster includes a COLOR CONTROL knob, EAT
ON/OFF switches, feed ramp, discharge chute, removable
crumb tray, and factory attached 6' (1829 mm) cord and plug.
The TC-DON-208 and TC-DON-240 models allow for toasting
of bread products up to 1-1/2" (38 mm) thick and 9-5/8"
(245 mm) wide. Each toaster comes equipped with 4" (102 mm)
adjustable legs.
Model Description
Feed Ramp
COLOR
CONTROL
Knob
Crumb Tray
HEAT ON/OFF
Switches
Discharge Chute
Do not locate unit in an area subject to temperatures above
85°F (29°C) or grease from grills, fryers, etc. Excessive
temperatures and grease could cause damage to unit.
Do not locate toaster in an area that restricts air flow
around front or rear of unit. Do not locate toaster in direct
discharge path of air conditioning vent or makeup air vent.
Damage to any countertop material caused by heat
generated from Hatco equipment is not covered under the
Hatco warranty. Contact manufacturer of countertop
material for application information.
NOTICE
Use non-abrasive cleaners and cloths only. Abrasive
cleaners and cloths could scratch finish of unit, marring its
appearance and making it susceptible to soil accumulation.
This unit is intended for commercial use only — NOT for
household use.
Clean unit daily to avoid malfunctions and maintain
sanitary operation.
NOTICE
MODEL DESCRIPTION

Form No. TCDONM-0713 5
SPECIFICATIONS
Plug Configuration
NOTE: R c ptacl not suppli d by Hatco.
NEMA 6-20P
Plug Configuration
Units are supplied from the factory with an electrical cord and
plug installed. Plugs are supplied according to the applications.
ELECTRIC SHOCK HAZARD: Plug unit into a properly
grounded electrical receptacle of the correct voltage, size,
and plug configuration. If plug and receptacle do not
match, contact a qualified electrician to determine and
install the proper voltage and size electrical receptacle.
NOTE: Sp cification lab l locat d on th back of th unit. S
lab l for s rial numb r and v rification of l ctrical
information.
WARNING
Model Volts Hertz Watts Amps Plug Configuration Shipping Weight
TC-DON-208 208 60 3180 15.3 NEMA 6-20P 58 lbs. (26 kg)
TC-DON-240 240 60 3180 13.3 NEMA 6-20P 58 lbs. (26 kg)
Electrical Rating Chart
Dimensions
Width Depth Depth w/ Height Footprint Footprint Chamber
Model (A) (B) Ramp (C) (D) Width (E) Depth (F) Width ( )
TC-DON-280 14-1/2″ 22-1/2″ 26-3/4″ 18″ 13-1/8″ 18″ 10-7/16″
(368 mm) (572 mm) (679 mm) (457 mm) (333 mm) (457 mm) (264 mm)
TC-DON-240 14-1/2” 22-1/2” 26-3/4″ 18” 13-1/8” 18” 10-7/16”
(368 mm) (572 mm) (679 mm) (457 mm) (333 mm) (457 mm) (264 mm)
A
G
C
B
D
F
Front View Side View
E

6Form No. TCDONM-0713
INSTALLATION
Always operate toaster with crumb tray installed.
4. Level the unit by turning the
adjustable tip on each leg, if
necessary. Use a 5/8″ (16 mm)
open-end wrench to make
leveling adjustments.
5. Install the crumb tray.
a. Position the crumb tray
directly below the stop pins under the conveyor belt at
the front of the toaster.
b. Slide the crumb tray into the toaster until the front of the
crumb tray meets the stop pins.
Installing the Crumb Tray
6. Install the discharge chute.
a. With the curved end facing the toaster, slide the
discharge chute underneath the toaster.
b. As the chute nears the rear of the toaster, angle the
curved end of the chute up slightly to place the rear lip
of the chute over the rear pins (one on each side).
Installing the Discharge Chute
Rear
Pin
Discharge
Chute
Lengthen
Shorten
Adjustable Tip
Stop Pins
Crumb Tray
CAUTION
eneral
Use the following procedure to install an Edward Don Electric
Conveyor Toaster.
ELECTRIC SHOCK HAZARD:
• Plug unit into a properly grounded electrical receptacle
of the correct voltage, size, and plug configuration. If
plug and receptacle do not match, contact a qualified
electrician to determine and install the proper voltage
and size electrical receptacle.
• Unit is not weatherproof. Locate unit indoors where
ambient air temperature is a minimum of 70°F (21°C).
FIRE HAZARD:
• Do not install unit above or around combustible surfaces.
Discoloration or combustion could occur. Unit must be
installed in non-combustible surroundings only.
• Allow a minimum clearance of 1″ (25 mm) along the
sides and rear of unit. Allow a minimum clearance of
12″ (305 mm) in the front. If safe distances are not
maintained, discoloration or combustion could occur.
• Do not locate toaster under shelving or closer than 12"
(305 mm) from the ceiling.
• Do not place anything on top of toaster. Do not place
toaster near or underneath curtains or other combustible
materials. Items near or on top of toaster could catch fire
causing injury and/or damage to the toaster.
Locate unit at the proper counter height in an area that is
convenient for use. The location should be level to prevent
the unit or its contents from falling accidentally and strong
enough to support the weight of the unit and contents.
Do not locate unit in an area subject to excessive
temperatures or grease from grills, fryers, etc. Excessive
temperatures could cause damage to the unit.
Do not locate toaster in an area that restricts air flow
around front or rear of unit. Do not locate toaster in direct
discharge path of air conditioning vent or makeup air vent.
1. Remove the unit from the carton.
NOTE: To pr v nt d lay in obtaining warranty cov rag , compl t
onlin warranty r gistration. S th IMPORTANT
OWNER INFORMATION s ction for d tails.
2. Remove tape and protective packaging from all surfaces
of the unit and its removable parts.
3. Place the unit in the desired location.
• Locate the unit in an area where the ambient air
temperature is constant and a minimum of 85°F (29°C).
Avoid areas that may be subject to active air movements
or currents (i.e., near exterior doors, exhaust fans/hoods,
air conditioning ducts, etc...).
• Make sure the unit is at the proper counter height in an
area convenient for use.
• Make sure the countertop is level and strong enough to
support the weight of the unit and food product.
• Make sure all the feet on the bottom of the unit are
positioned securely on the countertop.
NOTICE
CAUTION
WARNING

OPERATION
Form No. TCDONM-0713 7
eneral
Edward Don Electric Conveyor Toasters are designed for ease
of operation. Perform the following procedure to operate the
toaster.
Read all safety messages in the Important Safety
Information section before operating this equipment.
Startup
1. Plug the unit into a properly grounded electrical receptacle
of the correct voltage, size, and plug configuration. See the
SPECIFICATIONS section for details.
2. Move the feed ramp to the desired position.
• For automatic feeding, move the feed ramp to the
automatic feed position. Bread products enter the
toaster by placing them on the feed ramp and releasing.
• For manual feeding, rotate the feed ramp up until it rests
on top of the unit. Bread products can be loaded
manually by placing directly on the conveyor belt.
Positioning the Feed Ramp
Automatic Feed
Position
Manual Feed
Position
WARNING
COLOR CONTROL Knob
TOP HEAT
ON/OFF Switch
BOTTOM HEAT
ON/OFF Switch
BURN HAZARD: Some exterior surfaces on unit will get
hot. Use caution when touching these areas.
3. Switch ON (I) the appropriate EAT ON/OFF (I/O) switch
to toast bread.
• To toast both sides of the bread, switch ON (I) both the
TOP EAT ON/OFF switch and the BOTTOM EAT
ON/OFF switch.
• To toast the top of the bread only, switch ON (I) the TOP
EAT ON/OFF switch only.
• To toast the bottom of the bread only, switch ON (I) the
BOTTOM EAT ON/OFF switch only.
4. Turn the COLOR CONTROL knob to the lightest setting
while the unit warms up. The “1” setting on the COLOR
CONTROL knob represents the lightest toast setting, and
the “7” setting represents the darkest.
NOTE: Allow approximat ly 15 to 20 minut s for th unit to
warm up.
5. After the warm-up period, set the COLOR CONTROL knob
to the medium position and toast two slices of bread
product. Then, re-adjust the COLOR CONTROL knob to
the desired setting.
NOTE: To toast moist products such as English muffins, ry
br ad or whol wh at br ad, slow th conv yor by
turning th COLOR CONTROL knob to a dark r s tting
(clockwis ).
Always operate toaster with crumb tray installed.
The toasting of coated or buttered products such as garlic
bread, cheese sandwiches, and sweet rolls is NOT
recommended. Residue will reduce toaster performance
and could ignite inside the toaster. Using the toaster with
the food products listed above will void unit warranty.
Shutdown
1. Switch OFF (O) the EAT ON/OFF switches.
• The heating elements and the conveyor will shut off.
CAUTION
CAUTION
Control Panel

8Form No. TCDONM-0713
MAINTENANCE
eneral
The Edward Don Electric Conveyor Toasters are designed for
maximum durability and performance, with minimum
maintenance.
ELECTRIC SHOCK HAZARD:
• Turn OFF power switch, unplug power cord, and allow
unit to cool before performing any cleaning, setup, or
maintenance.
• DO NOT submerge or saturate with water. Unit is not
waterproof. Do not operate if unit has been submerged
or saturated with water.
• Do not steam clean or use excessive water on unit.
• This unit is not “jet-proof” construction. Do not use jet-
clean spray to clean this unit.
• Use only enuine Hatco Replacement Parts when
service is required. Failure to use enuine Hatco
Replacement Parts will void all warranties and may
subject operators of the equipment to hazardous
electrical voltage, resulting in electrical shock or burn.
enuine Hatco Replacement Parts are specified to
operate safely in the environments in which they are
used. Some aftermarket or generic replacement parts
do not have the characteristics that will allow them to
operate safely in Hatco equipment.
This unit has no “user-serviceable” parts. If service is
required on this unit, contact an Authorized Hatco Service
Agent or contact the Hatco Service Department at 800-558-
0607 or 414-671-6350; fax [phone]; or International fax
414-671-3976.
Clean unit daily to avoid malfunctions and maintain
sanitary operation.
Use non-abrasive cleaners only. Abrasive cleaners could
scratch finish of unit, marring its appearance and making
it susceptible to soil accumulation.
NOTICE
WARNING
Daily Cleaning
For sanitary operation as well as to preserve the condition of
the unit and maintain performance, it is recommended that the
unit be cleaned daily.
1. Switch OFF (O) the EAT ON/OFF switches and allow the
unit to cool completely.
2. Remove, empty, and clean the crumb tray and the
discharge chute.
• Wash with warm water and a mild detergent. Rinse with
water.
• Allow to air dry or hand dry with a soft cloth before
placing back into the toaster.
3. Remove and clean the feed ramp. To remove, squeeze
inward on the two wire spokes that attach the feed ramp to
the unit.
• Wipe clean with a soft, damp cloth or soak the guide in
a mild solution of 1 cup ammonia and 1 gallon of water
(227 milliliters and 3.785 liters).
4. Wipe the exterior surface of the toaster with a damp cloth.
Stubborn stains may be removed with a good stainless
steel cleaner or a non-abrasive cleaner. ard to reach
areas should be cleaned with a small brush and mild soap.
Additional Cleaning
Over an extended period of use, bread crumbs may buildup on
the reflector. The following steps are recommended to preserve
the condition of the unit and maintain performance.
1. Switch OFF (O) the EAT ON/OFF switches and allow the
unit to cool completely.
2. Remove crumb buildup on the bottom heating reflector.
• Wipe crumbs onto the crumb tray using a bristle brush.
NOTE: Th conv yor g ar motor and conv yor syst m ar
p rman ntly lubricat d and r quir no lubrication.
Troubleshooting Questions?
If you continue to have problems resolving an issue, please
contact the nearest Authorized atco Service Agency or atco
for assistance. To locate the nearest Service Agency, log onto
the atco website at www.hatcocorp.com and click on
Find S rvic Ag nt, or contact the Hatco Parts and Service
Team at:
Telephone: [phone] or 414-671-6350
e-mail: p[email protected]
Fax: [phone] or 414-671-3976

Symptom Probable Cause Corrective Action
Toast too light. COLOR CONTROL knob set on a light
setting.
Turn COLOR CONTROL knob to a darker setting.
Unit not warmed up. Allow approximately 15 to 20 minutes for the unit to
warm up.
Supply voltage to unit is low. Verify the supply voltage to the toaster matches the
unit specifications.
Toast too dark. COLOR CONTROL knob set on a dark
setting.
Turn COLOR CONTROL knob to a lighter setting.
Supply voltage to unit is high. Verify the supply voltage to the toaster matches the
unit specifications.
Toaster trips the circuit
breaker or GFCI.
Circuit breaker is not sized properly for the
toaster.
Check circuit breaker for proper sizing.
Wiring fault inside toaster. Contact Authorized Service Agent or atco for
assistance.
TROUBLESHOOTIN  UIDE
Form No. TCDONM-0713 9
This unit must be serviced by qualified personnel only.
Service by unqualified personnel may lead to electric
shock or burn.
WARNING
ELECTRIC SHOCK HAZARD: Turn power OFF at fused
disconnect switch/circuit breaker and allow unit to cool
before performing any maintenance, adjustments, or
cleaning.
WARNING
LIMITED WARRANTY
1. PRODUCT WARRANTY
atco warrants the products that it manufactures (the “Products”) to be
free from defects in materials and workmanship, under normal use and
service, for a period of one (1) year from the date of purchase when
installed and maintained in accordance with atco’s written instructions
or 18 months from the date of shipment from atco. Buyer must
establish the Product’s purchase date by registering the Product with
atco or by other means satisfactory to atco in its sole discretion.
atco warrants the following Product components to be free from
defects in materials and workmanship from the date of purchase
(subject to the foregoing conditions) for the period(s) of time and on the
conditions listed below:
a) One (1) Year Parts and Labor PLUS One (1) Additional
Year Parts-Only Warranty:
Conveyor Toaster Elements (metal sheathed)
Drawer Warmer Elements (metal sheathed)
Drawer Warmer Drawer Rollers and Slides
Strip eater Elements (metal sheathed)
Display Warmer Elements (metal sheathed air heating)
olding Cabinet Elements (metal sheathed air heating)
eated Well Elements — W and WB Series
(metal sheathed)
b) One (1) Year Parts and Labor PLUS Four (4) Years
Parts-Only Warranty:
3CS and FR Tanks
c) One (1) Year Parts and Labor PLUS Nine (9) Years
Parts-Only Warranty on:
Electric Booster eater Tanks
Gas Booster eater Tanks
d) Ninety (90) Day Parts-Only Warranty:
Replacement Parts
T E FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF
ANY OT ER WARRANTY, EXPRESSED OR IMPLIED, INCLUDING
BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF
MERC ANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE
OR PATENT OR OT ER INTELLECTUAL PROPERTY RIG T
INFRINGEMENT. Without limiting the generality of the foregoing, SUC
WARRANTIES DO NOT COVER: Coated incandescent light bulbs,
fluorescent lights, heat lamp bulbs, coated halogen light bulbs, halogen
heat lamp bulbs, xenon light bulbs, LED light tubes, glass components,
and fuses; Product failure in booster tank, fin tube heat exchanger, or
other water heating equipment caused by liming, sediment buildup,
chemical attack, or freezing; or Product misuse, tampering or
misapplication, improper installation, or application of improper voltage.
2. LIMITATION OF REMEDIES AND DAMA ES
atco’s liability and Buyer’s exclusive remedy hereunder will be limited
solely, at atco’s option, to repair or replacement using new or
refurbished parts or Product by atco or a atco-authorized service
agency (other than where Buyer is located outside of the United States,
Canada, United Kingdom, or Australia, in which case atco’s liability
and Buyer’s exclusive remedy hereunder will be limited solely to
replacement of part under warranty) with respect to any claim made
within the applicable warranty period referred to above. atco reserves
the right to accept or reject any such claim in whole or in part. In the
context of this Limited Warranty, “refurbished” means a part or Product
that has been returned to its original specifications by atco or a atco-
authorized service agency. atco will not accept the return of any
Product without prior written approval from atco, and all such
approved returns shall be made at Buyer’s sole expense. ATCO WILL
NOT BE LIABLE, UNDER ANY CIRCUMSTANCES, FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES, INCLUDING BUT
NOT LIMITED TO LABOR COSTS OR LOST PROFITS RESULTING
FROM T E USE OF OR INABILITY TO USE T E PRODUCTS OR
FROM T E PRODUCTS BEING INCORPORATED IN OR BECOMING
A COMPONENT OF ANY OT ER PRODUCT OR GOODS.

10 Form No. TCDONM-0713
REPLACEMENT PARTS LIST
1
Specification
Label on back
of unit.
16
17
13
18
19
22
23
24
25
26
27
29
30
31
32
33
34
28
21
20
2
3
5
7
6
8
9
10
11
12
15
13
14
4
Use of replacement parts other than those supplied by
Hatco Corporation may result in damage to unit or injury to
personnel and will void all warranties.
CAUTION
Electric Conveyor Toaster
TC-DON-208 and TC-DON-240 Series
24 Hour 7 Day Parts and Service
Assistance available in the United States
and Canada by calling 800-558-0607.

REPLACEMENT PARTS LIST
Form No. TCDONM-0713 11
Parts Common To All TC-DON Models
Item Description Part No. Qty.
1 Side Panel, L. . 04.05.462.00 1
2 Top Cover, Black 04.05.458.00 1
3 Terminal Block, 2 Pole 02.15.045.00 1
4 Feed Ramp 04.05.317.00 1
5 Wire Belt 05.03.035.00 1
6 igh Limit, Thermostat, Sidewall 02.16.146.00 1
7 Speed Control, Rheostat
208 V R02.13.111.00 1
240 V R02.13.125.00 1
8 Diode 02.40.002.00 1
9 Decal, Control Plate 07.01.298.00 1
10 Knob, Color Control 05.30.020.00 1
11 On/Off Switch 02.19.161.00 2
12 Crumb Tray R04.05.356.00 1
13 Shaft Assembly 04.05.386.00 2
14 Terminal Block, 6 Pole 02.15.034.00 1
15 Toast Chute 04.05.457.00 1
16 Gasket *05.06.028.00 3′
17 Side Panel, R. . 04.05.461.00 1
18 Spring Pin 05.08.006.00 1
19 Sprocket, Conveyor 05.09.029.00 1
20 Cord Grip 02.20.259.00 1
21 Power Cord and Plug
208 V 02.18.111.00 1
240 V 02.18.036.00 1
Item Description Part No. Qty.
22 Legs, 4" (10 cm) 05.30.007.00 4
23 Bearing with Nuts 04.05.387.00 2
24 Keps Nut 05.04.023.00 4
25 eating Element, Upper
Front, 750 W
208 V 02.09.243.00 1
240 V 02.09.246.00 1
Rear, 900 W
208 V 02.09.244.00 1
240 V 02.09.247.00 1
26 Bracket, Upper Element 04.05.335.00 2
27 Gearmotor, Conveyor
208 V 02.12.076.00 1
240 V 02.12.077.00 1
28 Drive Chain 05.03.006.00 1
29 Sprocket, Motor 05.09.033.00 1
30 Bracket, Lower Element 04.05.336.00 2
31 eating Element, Lower, 750 W
208 V 02.09.243.00 2
240 V 02.09.246.00 2
32 Retaining Ring 05.11.035.00 2
33 Bearing with Bracket 04.05.286.00 2
34 Circulation Fan 02.12.039.00 1
Electrical Drawing 10-01-466
*Sold by the foot.
NOTE: Th last four digits in a t n digit num rical s rial numb r ar th manufacturing dat cod .
Exampl : S rial numb r 9625060951 has a dat cod of “0951” which indicat s th following:
Week Fifty-One
0951
Year 2009

Printed in U.S.A. July 2013 P/N 07.04.388.00 Form No. TCDONM-0713
AUTHORIZED PARTS DISTRIBUTORS
HATCO CORPORATION
P.O. Box 340500
Milwaukee, WI 53234-0500 U.S.A.
800-558-0607 414-671-6350
Parts and Service Fax [phone]
International Fax [phone]
[email protected]
www.hatcocorp.com
Register your unit online!
See IMPORTANT OWNER INFORMATION
section for details.
ALABAMA
Jones McLeod Appl. Svc.
Birmingham 205-251-0159
ARIZONA
Service Solutions Group
Phoenix 602-234-2443
Byassee Equipment Co.
Phoenix 602-252-0402
CALIFORNIA
Industrial Electric
Commercial Parts & Service, Inc.
untington Beach 714-379-7100
Chapman Appl. Service
San Diego 619-298-7106
P & D Appliance
Commercial Parts & Service, Inc.
S. San Francisco 650-635-1900
COLORADO
awkins Commercial Appliance
Englewood 303-781-5548
FLORIDA
Whaley Foodservice Repair
Jacksonville 904-725-7800
3Wire Nass Service Co., Inc.
Orlando 407-425-2681
B.G.S.I.
Pompano Beach 954-971-0456
Comm. Appliance Service
Tampa 813-663-0313
EOR IA
TWC Services
Mableton 770-438-9797
eritage Service Group
Norcross 866-388-9837
Southeastern Rest. Svc.
Norcross 770-446-6177
HAWAII
Burney’s Comm. Service, Inc.
onolulu 808-848-1466
Food Equip Parts & Service
onolulu 808-847-4871
ILLINOIS
Parts Town
Lombard 708-865-7278
Eichenauer Elec. Service
Decatur 217-429-4229
Midwest Elec. Appl. Service
Elmhurst 630-279-8000
Cone’s Repair Service
Moline 309-797-5323
INDIANA
GCS Service
Indianapolis 317-545-9655
IOWA
Electric Motor Service Co.
Davenport 319-323-1823
Goodwin Tucker Group
Des Moines 515-262-9308
KENTUCKY
Service Solutions Group
Lexington 859-254-8854
Service Solutions Group
Louisville 502-451-5411
LOUISIANA
Chandlers Parts & Service
Baton Rouge 225-272-6620
MARYLAND
Electric Motor Service
Baltimore 410-467-8080
GCS Service
Silver Spring 301-585-7550
MASSACHUSETTS
Ace Service Co., Inc.
Needham 781-449-4220
MICHI AN
Bildons Appliance Service
Detroit 248-478-3320
Commercial Kitchen Service
Bay City 517-893-4561
Midwest Food Equip. Service
Grandville 616-261-2000
MINNESOTA
GCS Service
Plymouth 800-345-4221
MISSOURI
General Parts
Kansas City 816-421-5400
Commercial Kitchen Services
St. Louis 314-890-0700
Kaemmerlen Parts & Service
St. Louis 314-535-2222
NEBRASKA
Anderson Electric
Omaha 402-341-1414
NEVADA
Burney’s Commercial
Las Vegas 702-736-0006
i. Tech Commercial Service
N. Las Vegas 702-649-4616
NEW JERSEY
Jay ill Repair
Fairfield 973-575-9145
Service Plus
Flanders 973-691-6300
NEW YORK
Acme American Repairs, Inc.
Brooklyn 718-456-6544
Alpro Service Co.
Brooklyn 718-386-2515
Appliance Installation
Buffalo 716-884-7425
Duffy’s Equipment Services, Inc.
Buffalo 800-836-1014
3Wire Northern
Plattsburgh 800-634-5005
Duffy’s Equipment Services, Inc.
Sauquoit 800-836-1014
J.B. Brady, Inc.
Syracuse 315-422-9271
NORTH CAROLINA
Authorized Appliance
Charlotte 704-377-4501
OHIO
Akron/Canton Comm. Svc. Inc.
Akron 330-753-6635
Service Solutions Group
Cincinnati 513-772-6600
Commercial Parts and Service
Columbus 614-221-0057
Electrical Appl. Repair Service
Brooklyn eights 216-459-8700
E. A. Wichman Co.
Toledo 419-385-9121
OKLAHOMA
agar Rest. Service, Inc.
Oklahoma City 405-235-2184
Krueger, Inc.
Oklahoma City 405-528-8883
ORE ON
Ron’s Service, Inc.
Portland 503-624-0890
PENNSYLVANIA
Elmer Schultz Services
Philadelphia 215-627-5401
FAST Comm. Appl. Service
Philadelphia 215-288-4800
Appliance Installation & Service
Pittsburgh 412-809-0244
K & D Service Co.
arrisburg 717-236-9039
Electric Repair Co.
Reading 610-376-5444
RHODE ISLAND
Marshall Electric Co.
Providence 401-331-1163
SOUTH CAROLINA
Whaley Foodservice Repair
W. Columbia 803-791-4420
TENNESSEE
Camp Electric
Memphis 901-527-7543
TEXAS
GCS Service
Fort Worth 800-433-1804
Armstrong Repair Service
ouston 713-666-7100
Cooking Equipment Specialist
Mesquite 888-866-9276
Refrigerated Specialist, Inc.
Mesquite 888-866-9276
Commercial Kitchen Repair Co.
San Antonio 210-735-2811
UTAH
La Monica’s Rest. Equip. Service
Murray 801-263-3221
VIR INIA
Daubers
Norfolk 757-855-4097
Daubers
Springfield 703-866-3600
WASHIN TON
3Wire Restaurant Appliance
Seattle 800-207-3146
WISCONSIN
A.S.C., Inc.
Madison 608-246-3160
A.S.C., Inc.
Milwaukee 414-543-6460
CANADA
ALBERTA
Key Food Equipment Service
Edmonton 780-438-1690
BRITISH COLUMBIA
Key Food Equipment Service
Vancouver 604-433-4484
Key Food Equipment Service
Victoria 250-920-4888
MANITOBA
Air Rite, Inc.
Winnipeg 204-895-2300
NEW BRUNSWICK
EMR Services, Ltd.
Moncton 506-855-4228
ONTARIO
R.G. enderson Ltd.
Toronto 416-422-5580
Choquette - CKS, Inc.
Ottawa 613-739-8458
QUÉBEC
Choquette - CKS, Inc.
Montreal 514-722-2000
Choquette - CKS, Inc.
Québec City 418-681-3944
UNITED KIN DOM
Marren Group
Northants [phone]