Helion HLNA0188 User manual

1/18th SCALE 4x4
ELECTRIC TRUGGY
OWNER’S MANUAL AND EXPLODED VIEW
HLNA0188
• Enrecontents©2011HelionRC
• Beforeusingyourproduct,reviewalldocumentaonandinspecttheproductscarefully.Ifforsomereason
youdecideitisnotwhatyouwanted,thendonotconnuewithunpacking,setuporoperaonofyour
product.YourlocalHobbyTownUSA®dealercannotacceptaproductforreturnorexchangeaerpartaking
intheaforemenonedacons
• Readandunderstandandfollowallinstruconsandaccompanyingmaterialcarefullybeforeoperangor
assemblingyourvehicletopreventseriousdamagetoyourvehicle.Failuretocompletethesetasksproperly
orintenonalaversiontothecontentwillbeconsideredabuseand/orneglect
• Productspecicaonsaresubjecttochangewithoutnoce.Duetoongoingdevelopment,theactualprod-
uctmayvaryfromimagesshown
• ThisproductcontainschemicalsknowntotheStateofCaliforniatocausecancerandbirthdefectsorother
reproducveharm
• Thisproductisnotatoy!(14+)Recommendedforages14andup.Adultsupervisionrequiredforagesunder
18yearsold.Containssmallparts,keepoutofreachofchildren3yearsofageandyounger
LENGTH 235mm(9.25in)
WIDTH 172mm(6.8in)
HEIGHT 81mm(3.2in)
WHEELBASE 159mm(6.3in)
WHEELDIAMETER 42mm(1.65in)X23mm(0.91in)
TIREDIAMETER 60mm(2.36in)
WEIGHT* 540g(1.2lb)
BATTERY 1,100mAhNiMH6-CELL,7.2v
MOTOR 370SIZE
RADIO 2.4GHz2-CHANNEL
CHARGER ACWALLTRICKLE
*APPROXIMATEOUT-OF-THE-BOXWEIGHT

PACKAGE CONTENTS...
#
ITEMS NEEDED TO COMPLETE...
#
RECOMMENDED TOOLS (NOT INCLUDED)...
#
THE ANIMUS 18TR...
#
2
1. 1xANIMUS18TR
2. 1xBaery
3. 1xRadiotransmier
4. 1xWallcharger
5. 1xDocumentaonpackage
6. 1xAntennatube
7. 1x4-Waycrosswrench
8. 1x1.5mmL-wrench
1. 8x1.5VAAtypealkalinebaeriesfortransmier
a. Tohelptheenvironment,considerreplacingthedisposablebaeriesforthis
transmierandforotherhouseholdelectronicitemswithrechargeablebat-
teries.VisitaHeliondealerforhobbygradechargersandbaeries
b. Paencewhilereadingthoroughlythroughalloftheinstruconsandguides
thatwillhelpensureyougetthemostoutofyournewHelionRCproduct
• Pleaseusecauonandfollowthemanufacturer’srecommendedoperanginstruconsfortheseitems
andalwaysweareyeprotecon
HOBBY KNIFEMETRIC HEX SCREWDRIVER SET SCREWDRIVERS CURVED HOBBY SCISSORS
SIDE CUTTING PLIERS NEEDLE NOSE PLIERS BODY REAMER CA GLUE
GEARCOVER
MOTOR
BATTERY
ANTENNA
SERVO
ON/OFF
ANTENNA
MOUNT
ESC/
RECEIVER
BATTERY
PLUG
MOTORPLUG

1/18th SCALE 4x4
ELECTRIC TRUGGY
GETTING STARTED...
#
CHARGING THE BATTERY...
#
3
1. Carefullyremovetheboxcontentsusingsidecungplierstocuttheestraps
2. Removebodyandbaerybaeryfromvehicletoprepareforcharging
a. Readcharginginstruconsandunderstandallwarningsandcauonsbeforeproceeding.This
product is not a toy and should not be charged, operated, or maintained without supervision of
an adult
b. Returntothisguideinthepresenceofthechargingbaery,rememberingnevertoleavethebat-
teryunaendedwhilecharging
3. Installantennatubebyslidingantennaintotubeandinserngtubeintomountonreceiver.Becareful
nottopinchtheantennaduringinstallaon.Installsetscrewvercallynexttotheantennawithincluded
Lwrenchtosecuretheantennainplace.NOTE:DoNOTfoldendofantennaoverendoftube,thiswill
reducetherangeoftheradiosystemandcancauseinterferencewhenoperangyourvehicle
4. Installthe[8]AAtypealkalinebaeriesintothetransmier
5. Installthefullychargedbaeryintothevehicle,besuretoinstallthepinsintothelowerofthetwoholes
inthebaerymounngposts
6. EnsurethemotorispluggedintotheESC
7. EnsuretheswitchisintheOFFposionandconnectthebaerytotheESC
8. Readandunderstandtransmiercauonsandsenginstruconsbeforeuse
a. Conrmsengsforsteeringandthroletrim
9. Installbodywith4suppliedclips;turnyourequipmentON(radiorst!)andenjoy!
• Neverleavethebaeryunaendedwhilecharging
• Neveroperatethechargerwithoutadultsupervision
• Neverchargeawarmbaery,alwaysallowthebaerytocooltoroomtemperaturebeforecharging
• Neverdropthechargerorbaery
• Neveraempttochargeadamagedbaery
• Inspectthebaeryandchargerbeforeuse.Neverchargeabaeryorchargerifthewireorconnectorhas
beendamagedorifthebaeryhasexperiencedashort
• Incorrectuseofthebaery,connecons,orchargingequipmentcancausepersonalinjuryorproperty
damage
• Neverallowbaeriesorchargertocomeincontactwithmoistureatanyme
• Stopchargingimmediatelyifthebaeryorchargerbecomeshotorchangesformduringuse
NOTE: Only use chargers designed for use with NiMH baeries for the RC industry, using the supplied con-
nector. Use of other (non-RC specic) chargers or connectors can permanently damage the baery and/or
connected equipment. Genuine NiMH replacement baeries are available at your local HobbyTown USA®.
1. PlugthechargerintoaproperlygroundedstandardUSwallplug
2. Plugthebaeryintothechargerandplacethebaeryon/inanon-ammablesurface/containerand
awayfromanyammableobjects
3. Afullydischargedbaeryshouldchargeinapproximately4-5hours
a. Cauon: Periodically monitor the temperature of the baery while charging, if the temperature
exceeds 115°F (45°C), disconnect the baery from the charger and allow it to cool before recon-
necng
4. Unplugthebaeryfromthechargerwhenthebaeryisslightlywarmtothetouch,indicangthebat-
teryhadbeenfullycharged
a. NOTE:Usingapeakdeteconchargerisrecommendedandwillprovideyouwithafasterandbet-
terchargingexperience.WerecommendthePrimalMul-ChemistrychargerbyRadientRC.
b. Warning: Never charge the included baery at a charge current exceeding 1.5A
5. Removechargerfromwallplug

UNDERSTANDING YOUR TRANSMITTER...
#
4
Features:
1. Steeringwheel:controlsle/rightmoon(designedtobeoperatedwithrighthand)
2. Throletrigger:controlsforward/reversemoon(designedtobeoperatedwithleindexnger)
3. Handle:Forholdingthetransmier(designedtobeheldwithlehand)
4. Antenna:Transmitssignaltothereceiverlocatedinthevehicle
5. Controlpanelcover:Coverscontrolpanelhousingradiosengcontrols
6. ON/OFFSwitch:TurnsthepowerON/OFFforthetransmier
7. Indicatorlights:MulfunconGreenLED
a. SolidGreen:Adequatebaeryvoltageforproperoperaon
b. FlashingGreen:Lowbaeryvoltagewarning,baeriesshouldbereplaced/rechargedbefore
connueduse
8. Bindbuon:Usedforbindingthetransmiertothereceiver
9. SteeringTrim:Controlsthe“hands-o”le/rightdireconofthevehicle
10. ThroleTrim:AdjuststhemotorspeedtoSTOPwhentriggerisin“hands-o”(neutral)posion
11. Baerycompartment:houses[8]AAbaeriesforpoweringthetransmier
12. Boomcover:Closesthebaerycompartment,containingtheAAbaeries
Baeries:
WARNING: Do not aempt to charge non-rechargeable baeries
• Removethelowerdoorfromthetransmiertoaccessthebaerycompartment
• Install8xAAtypebaeriesintothecompartment
› Paycloseaenontobaerypolarity(+/-)indicatorsduringinstallaon
• Nevermixbrandsorold/newbaeries
• Alwaysremovedeadbaeriesfromthetransmier
• Ifusingrechargeablebaeries,besuretofollowthemanufacturer’scareanduseinstrucons
• Rechargeablebaeriesmustberemovedfromtransmierbeforecharging
• Alwaysbesuretoberesponsibleandprotecttheenvironmentwhendisposingbaeries.Yourlocal
HobbyTownUSA®dealerprovidesaFREEbaerydisposalservice
1
2
3
4
5
6
78
910
11
12

1/18th SCALE 4x4
ELECTRIC TRUGGY
...TRANSMITTER CONTINUED...
#
5
Standard operaon:
• TurningthetransmierwheeltothelefromcentermakesthewheelsonthevehicleturnLEFT
• TurningthetransmierwheeltotherightfromcentermakesthewheelsonthevehicleturnRIGHT
• Pullingthetransmiertriggerbacktowardsthehandlewillmakethevehicleaccelerateforward
• Pushingthetransmiertriggerforwardawayfromthehandlewillhavethefollowingaectsdepending
onthelocaonofthetriggerpriortopushingitforward
› Fromastopatneutral:thevehiclewilltravelinreverse
› Frompulledback:thevehiclewillapplybrakestoslowthespeed
» Asecondpushforwardofthetriggerwillapplyreversethrole
»WARNING: Causing the vehicle to make quick transions from forward/reverse moon to
the opposite direcon using the throle control can cause damage to your vehicle and will
void the warranty
Using your transmier for the rst me:
1. TurnthetransmierONandensuretheLEDislitSOLIDindicangthebaeriesaresupplyingadequate
voltageforproperoperaon
2. Sengthethroletrim
a. Ifthewheelsspininaforwarddireconwhenthetriggerisintheneutralposion,turndownthe
trimunlthemotorstops
b. Ifthewheelsspininareversedireconwhenthetriggerisintheneutralposion,turnupthetrim
unlthemotorstops
c. Therewillbea“deadband”areawherethetrimcanbeadjustedaslightamountineitherdirec-
onandthewheelswillnotbegintomove.Itisidealtohavethetrimsetinthemiddleofthis
“deadband”
3. Sengthesteeringtrim
a. Withyourvehicleandtransmierturnedon(andproperlyrespondingtotransmierinputs),set
thevehicledownonthegroundandslowlyaccelerateinadirecondirectlyawayfromyou.Ifthe
vehicleveersslightlyeithertotheleorright,stopthevehicleandadjusttheSteeringTrimknob
intheoppositedireconoftheveerinsmallincrements
b. Resetthevehicleandre-test;adjustthetrimasneededunlthevehicletravelsinastraightline
whilethetransmierwheelremainsatcenterlocaon(“hands-o”)
[PULL]
FORWARD
THROTTLE
[PUSH]
REVERSE
THROTTLE
TURNLEFT TURNRIGHT
BIND/ESCSETBUTTON
LEDINDICATOR
ON/OFFSWITCH

...TRANSMITTER CONTINUED...
#
ADJUSTMENTS AND TUNING...
#
6
Binding the radio system:
Theprocessofallowingcommunicaontooccurbetweena2.4GHztransmierandreceiveriscalled“bind-
ing”(somemesreferredtoas“matching”or“pairing”).Theradiosystemincludedwithyourproductcomes
pre-conguredandboundfromthefactory.Intheeventyoursystemlosesbinding,oroneofthecompo-
nentshasbeenreplaced,youwillneedtore-bindthetransmierandreceiver.Followthebelowstepsfor
re-bindingyourradiosystem
1. Ensurethetransmierhasgood(neworcharged)baeriesinstalledandthatitispoweredOFFbefore
starng
2. ConnectafullychargedbaerypacktotheelectronicsmoduleandensureitispoweredOFFbefore
starng
3. Useatoothpick(orothersmall,non-metal,non-sharpobject)todepressandholdthebindbuonon
theelectronicsmoduleandmovetheswitchtotheONposion
4. Releasethebindbuonontheelectronicsmodule
5. TheredLEDwillashquicklyontheelectronicsmodule
6. Usingthetoothpick(orother),depressandholdthebindbuononthetransmierandmovetheswitch
totheONposion
7. Releasethebindbuononthetransmier
8. ThegreenLEDonthetransmierwillashslowlyandtheredLEDonthereceiverwillturno,thenback
on,ashingslowly
9. MovethepowerswitchestotheOFFposion,rstontheelectronicsmodule,thenonthetransmier
10. MovethepowerswitchestotheONposion,rstthetransmier,thenontheelectronicsmodule
11. Ensurenormaloperaonofthroleandsteering
12. Ifyouexperienceanythingotherthannormaloperaon,repeattheprocess
Seng your ERS unit’s ESC:
ProperlysengtheESCtothetransmierensurestheESC“knows”whenyouaretryingtoapplyfullthrole
orfullbrake/reverse.NOTE:Itisbesttoperformthisprocedurewithallbaeriesfullycharged
1. Withthroletriggerinneutralposion,presstheBind/Setbuonfor3secondsunlLEDashes
2. Withouttouchingthethroletrigger,leaveinneutralposion,presstheBind/Setbuononcequickly
3. Withthroletriggerinfullthroleposiiton,presstheBind/Setbuononcequickly
4. Withthethroletriggersetinfullbrakeposion,pressthebind/setbuononcequickly
5. YourESCisnowset,turnothepowertoyourvehicleandturnitbackon
6. YourESCisnowsettoyourtransmier.Alwaysre-performthisprocedureaerbindingyourradio
TheAnimus18TRhasbeenengineeredwithsomeavailabletuningoponslistedhereforreference.
Ride height adjustment: ItispossibletoadjusttherideheightofyourAnimus18TRbyinstallingandor
removingadjustmentclipslocateddirectlyabovetheshocksprings
• Addingmoreclipswillraisetherideheightofthevehicleandifdoneexcessivelymaydecreasestability.
• Removingclipswilllowertherideheightandmaycausethechassistodragontheground.
• Itisidealtohavethedriveshaslevelwiththegroundwhilethevehicleissingonaatsurfacewith
thebodyinstalled.Addorremoveclipstoachievethedesiredrideheight
Shock Posion: Therearetwoshockinstallaonlocaonsforthetopmounnglocaonoftheshocks.The
defaultposionisinside(locatedclosertothecenterlineofthechassis)
• Movingtheshockmounnglocaontotheouterlocaonwillresultinaslightlymoreresponsivefeelon
thefrontorrearofthevehicle
• Alwayscheckandadjust,ifnecessary,therideheightofyourvehicleaermovingtheshockmounng
locaons
Baery posion: ItispossibletorunyourAnimus18TRwiththebaeryeitherinaforwardorrearposion.
• Thebaeryislocatedintherearposionfromthefactory.Thisisidealforopmumtraconandstability.

1/18th SCALE 4x4
ELECTRIC TRUGGY
SAFETY TIPS...
#
ADJUSTMENTS AND TUNING CONTINUED...
#
7
Althoughgreatforrstmeusers,HelionRCproductsareindeedadvancedradiocontrolledvehicleswith
sensiveelectronicsandmovingpartscapableofcausinginjuryifusedimproperly.Alwaysusecauonand
commonsenseasfailuretooperateyourHelionRCproductinasafeandresponsiblemannercanresultin
damagetotheproductorotherproperes.Thereforethisproductisnotintendedforuseormaintenance
bychildrenwithoutdirectadultsupervision.HelionRCandHobbyTownUSA®shallnotbeliableforanyloss
ordamages,whetherdirect,indirect,special,incidental,orconsequenal,arisingfromtheuse,misuse,or
abuseofthisproductoranyproductrequiredtooperateormaintainit
• Donotoperateyourvehicleinrain,electrical,orthunderstorms
• ThevehicleshouldneverbeturnedONwithoutthetransmierbeingturnedON
• Neveroperateyourvehiclewhenwithlowtransmierbaeries
› IndicatedbyashingLEDonthetransmier
• Alwayscheckforproperradiosystemoperaon(steeringandthrole)priortolenggoofthevehicle.If
thevehicledoesnotrespondproperlytotransmierinput,turnthevehicleOFFandinspectallconnec-
onsandoperangenvironment.AlsoseetheTroubleshoongguideinthismanual
• Operateinadry(nopuddles),openenvironmentawayfromtrac,andcars(neverrunintothestreet
foranyreason)
• AlwaysturnobothtransmierandESCanddisconnectthebaeryfromtheESCaeruse
• Exerciseextremecauonwhentouchingthemotorimmediatelyaerrunningyourvehicle,itmaybe
HOTandmaycauseaburn
• Alwaysallowthemotorinyourvehicletocoolbeforeusingagain
NOTE: Only use genuine replacement or aermarket parts available from your local HobbyTown USA® to
ensure proper operaon of your Helion RC product.
• Ifyoudesiremoreresponsivesteeringandlessstability,movingthebaerytotheforwardposionwill
providethisfeeling
Body Mount Height: ThebodymountsontheAnimus18TRarecapableofvercaladjustmentwith4height
oponsavailable
• Thedefaultsengallowsforthelowestbodyposionwhilemaintainingcomponentclearance
• Adjustthebodymountstoachieveadesiredlook

CARE AND MAINTENANCE...
#
8
General Care:
• Alwaysuseclean,dryclothorsobristlebrushtocleanyourequipment
• Neverusechemicalcleanserstoavoiddamagetothesensiveelectronicsandplascs
Maintenance:
Wewantyoutoenjoyyourproducttoitsfullestpotenal.Forthistohappenitisimportanttokeepyour
productcleanandproperlymaintained.Lackofcleaningandmaintenancecancausecomponentfailure.For
bestandconnuedperformancefromyourproductitisrecommendedtobrieyinspectyourproductfor
damageeveryfewruns.Typically,agoodmetodothisiswhenchangingthebaeryorwhileitischarging.
Ifaproblemisdiscovered,stopuseimmediatelyandseekrepairs.Connueduseoffailedcomponentscan
causemoreunnecessarydamagetoyourproduct.Alwaysremembertousegenuinereplacementpartsfrom
yourlocalHobbyTownUSA®dealer.Belowisalistofitemsforinspecon.Inspeconshouldnotbelimitedto
thislist;ifyounoceanyproblem,listedornot,itisrecommendedtogiveitproperaenon
1. Electronics:Theelectronicsincludedinyourvehiclearenotwaterproof.Itiscricalthattheybekept
awayfrommoistureandthatanymoisturenocedonoraroundthembeimmediatelycleanedup
a. Antenna:Toachievefulloperangrangewithyourradiosystem,itiscricalthatthereceiver
antennabeinstalledproperlyandundamaged
i. Inspectanyexposedantennaforcutsorabrasions
ii. Ensuretherearenokinksintheantennaorantennatube
iii. Neverfoldtheendoftheantennaoverthetube,thiswillreducetherangeanddamagethe
antenna
2. Gears:Periodicallyremovethegearcovertoinspectthegearsandensurethereisnodebrisinthegear
compartment
a. Propergearmeshsengiscrucialforproperoperaonandlifeofgearsinyourproduct.Itis
importanttohavethepiniongear(aachedtomotor)asclosetothespurgear(aachedtodrive
sha)aspossibleyetwhileprovidingaminimalamountofbacklash.Backlashistherotaonone
gearhastomakebeforecontacngtheother.Havingthegearmeshsettooghtwillcauseexcess
loadontheelectricalcomponentsandmaycauseprematurefailure.Havinggearmeshsettoo
loosewillcauseexcesswearandpossibleskippingofteethduringoperaonthuscausingexcess
wearandprematurefailure
b. Checkingthegearmesh
i. Removethespurgearcover
ii. Pressdownwardonthetopdeckclosetothespurgeartoholdinplace
iii. Checkhowmuchmovementisallowedofthespurgearbeforethepiniongearmoves(thisis
purelybyfeel,notvisual)
iv. Ifthespurgearisallowedtomovemorethanaverysmallamount,orifitthereisnoback-
lash,thegearmeshmustbeadjusted
v. Sengthegearmesh
01).Loosenthetwoscrewsontheboomofthechassistheholdthemotorinplace
02).Slidemotorallthewaytothespurgear,sothereisnobacklash
03).Movebackslightlyandholdthemotorsnuglyinposionwhilereghteningthebot-
tomscrews
04).Re-checkthegearmeshandadjustagainifnecessary
vi. Re-installthespurgearcover
WARNING: Never operate your vehicle with the spur gear cover removed. Severe injury, damage to electri-
cal components, and excessive wear and tear on drivetrain may result.

1/18th SCALE 4x4
ELECTRIC TRUGGY
...MAINTENANCE CONTINUED...
#
9
3. Shocks:Periodicallyinspecttheshocksforsmooth/freemoon,leakingoilanddirtresiduebuildup
aroundthesha
a. Donotallowdirttobuilduparoundtheshockshaandboomoftheshock.Doingsowillreduce
thelifeoftheshockandcauseashocktoleakoil.Besuretocleantheshocksregularlywitha
cleananddrysobristlebrushand/orrag
b. Signstolookoutfordeterminingifyourshockneedstobemaintainedorrebuilt
i. Oilaroundtheshameanstheoilleakedfrominsideandneedstobereplaced
ii. Persistentoilaroundtheshockshaorlowerporonoftheshocktypicallypointstodam-
agedO-ringswhichwillneedreplacing.SeeyourlocalHobbyTownUSA®forreplacement
parts
iii. Rellingyourshocks:
01).Removeshockfromvehicle,removespringandtopcap
02).Withshockshaextended,addoiltotopofbody(useonly100%siliconeoil)
03).Slowlycompresstheshocksha50%oftravelusingatowelorpapernapkintoclean
upoverowedoil
04).Slowlyreinstalltheshockcapandcheckforfreemoonofshock
05).Itisnormalfortheshocktorebound(withthespringremoved)aerfullcompression
andrelease
iv. ReplacingtheO-rings:
01).Disassembleshockandremoveshafromthebody
02).Carefullyremovelowercapbypryingwithangernailorsimilarobject
03).RemovetheO-ringsandreplacewithgenuinereplacementparts
04).Re-assembletheshockfollowingtheRellinginstruconsabove
4. Tiresandwheels:
a. Inspecttherestoensuretheyareproperlygluedtothewheels.Theresonyourvehiclecome
pre-gluedfromthefactory;howeveraerrunningyourvehicleitispossibleforthegluetocome
looseinsomeareas.
i. Toreaachtheretothewheel,usehobbygradeCyanoacrylate(CA)glueandapplysmall
amounts(onedropatame)betweenthereandwheel.Allowthegluetofullydrybefore
operangyourvehicle
Cauon: Be sure to use extreme care when using hobby-grade CA glue. It is specially formulated to cure
quickly and create a strong bond. It will bond skin and can cause injury if used improperly. Follow manu-
facturer’s warnings and direcons when using CA glue. It is always recommended to wear eye protecon
when maintaining your vehicle.
ii. Whenreinstallingres,usecauonwhenghteningthenutsthatsecurethewheelstothe
vehicle.Ensuretheyrotatefreelybutdon’twobbleexcessively.Overghteningthewheels
willcauseexcessstrainontheelectricalandmechanicalcomponentsofyourvehicle.Oper-
angyourvehicleunderthesecondionswillvoidyourwarranty
iii. Tirewear:Consequentlyrunningyourvehiclewillcausetherestoeventuallywearout.Be
suretoobtainandusegenuinereplacementpartsfromyourlocalHobbyTownUSA®dealer
5. Generalwearandtear:
a. Useofyourvehiclewillcausegeneralwearandtearwhichisnotcoveredunderwarrantyyetmay
necessitatereplacementofcomponents.Connuedoperaonofyourproductwithuseofworn
componentsmaycauseconnueddamagetoothercomponents
b. Besuretoregularlyinspectyourvehicleandaccessoriesforexcesswearanddamagedcompo-
nents

STORAGE AND DISPOSAL...
#
TROUBLESHOOTING GUIDE...
#
10
Storage:
• Alwaysstoreallequipmentinacooldryplacewhennotinuse
• Alwaysdisconnectthebaeriesbeforestorage
• Neverstorethebaery,vehicleortransmierindirectsunlightforextendedperiodsofme
• Neverstorethetransmierwithbaeriesinstalledforextendedperiodsofme.Doingsomayallowthe
baeriestoleakandcausepermanentdamagetothetransmier
Disposal:
YourproductisequippedwithNiMHbaerieswhichareconsideredelectronicwasteandshouldneverbe
discardedinstandardgarbagecontainers.PleasevisityourlocalHobbyTownUSA®dealerandusetheFREE
baerydisposalcenterforproperdisposal/recycling
Problem / Symptom Possible Cause Possible Soluon
Vehiclewillnotturnon
Baeryvoltagetoolow Chargebaery
Baerynotconnected Re/connectbaery
Damagedbaery Replacebaery
Transmierwillnot
turnon
Baeryvoltagetoolow Chargeorchangebaeries
Baery/iesinstalledimproperly Correctinstallaon
Shortradiorange(Ve-
hiclestopsresponding
totransmieratshort
distances)
Damagedorimproperlyinstalled
receiverantenna
Checkreceiverantennafordamage.Ensure
antennaisproperlyinstalledintubeand
mount,extendingperpendicularfromthe
ground
Transmierbaeryvoltagetoo
low Replacebaeries
Spurgearsstripping
Gearmeshtooloose Tightengearmeshforproperbacklash
Fastenerslooseormissing Checkforloosefastenersonspurgearcover
andmotormount
Steeringnotresponding
asexpected
Trimnotsetproperly Adjuststeeringtrim
Screwstooghtonsteering
components Adjustscrewstoallowforfreemoon
Vehiclenotresponding
asexpectedtotransmit-
ter
Trimsnotsetproperly Adjustthroleand/orsteeringtrim
Radiosystemlostbind Re-bindradiosystem
Badelectricalconnecons Checkmotorandbaeryplugstoensurethey
arefullyconnected
Vehicletopspeedand
acceleraonisslow
Baeryvoltagetoolow Chargebaery
Drivetrainhastoomuchfricon Checkandslightlyloosenwheelnuts
Gearmeshtooght Loosengearmesh
Piniongearisloose Checkandghtensetscrewonmotorpinion
Drivepinmissingorstripped Checkformissingwheelpins(behindwheel
hexes),ordogbonepins
Shocksand/orarmscov-
eredinoil
ShockO-ringsealsareworn ReplaceO-ringsandrellshockwithoil
Topshockcaptoolooseorover
ghtened Checkghtness(ngerght),rellshockoil
Boomshockcapdislodged Checkinstallaon,rellshockoil

1/18th SCALE 4x4
ELECTRIC TRUGGY
SPARE PARTS LIST...
#
11
HLNA0038........ANIMUS18TR4X4ELECTRICTRUGGY.......................................................................................
HLNA0002........MAINCHASSIS(ANIMUS)..........................................................................................................
HLNA0003........TOPPLATE,BATTERYSTRAP,FOAM&POSTS(ANIMUS)...........................................................
HLNA0004........GEARCOVERS,GEARBOXES(ANIMUS)....................................................................................
HLNA0005........FRONT&REARSUSPENSIONARMS(ANIMUS).........................................................................
HLNA0006........FRONT&REARSHOCKTOWERS(ANIMUS)...............................................................................
HLNA0007........CASTER&STEERINGBLOCKS,REARHUBS(ANIMUS)...............................................................
HLNA0008........STEERINGBELLCRANKS&SERVOSAVER(ANIMUS)................................................................
HLNA0009........DRIVESHAFTSFRONT/REAR&CENTER(ANIMUS)...................................................................
HLNA0010........MOTORMOUNT&INSERT(ANIMUS).......................................................................................
HLNA0011........CAMBER,STEERING&SERVOLINKSWITHBALLSTUDS(ANIMUS)..........................................
HLNA0012........FRONT&REARSHOCKSETWITHBALLSTUDS(ANIMUS).........................................................
HLNA0013........SHOCKSEALS(ANIMUS)............................................................................................................
HLNA0014........SHOCKSPRINGS(ANIMUS)........................................................................................................
HLNA0015........HINGEPINSANDWASHERS(ANIMUS)......................................................................................
HLNA0016........DIFFERENTIALOUTDRIVES&AXLES(ANIMUS)........................................................................
HLNA0017........DRIVEPINS,WHEELHEXES,BODYCLIPS,ANTENNATUBES(ANIMUS).....................................
HLNA0018........AXLEBEARINGSET(ANIMUS)...................................................................................................
HLNA0019........GEARBOXBEARINGSET(ANIMUS)............................................................................................
HLNA0020........SPURGEARS,45T(ANIMUS)......................................................................................................
HLNA0021........PINIONGEARS,11T,12T,13T,14T.............................................................................................
HLNA0022........COMPLETEDIFFERENTIAL&PINIONGEAR(ANIMUS)..............................................................
HLNA0024........WHEELS&TIRES,LEFT&RIGHT(ANIMUS,SC).........................................................................
HLNA0026........HARDWARE&SCREWS(ANIMUS).............................................................................................
HLNA0027........ESC,RECEIVER,SERVO(ERS)MODULE(ANIMUS).....................................................................
HLNA0028........BATTERY,7.2v1,100mAh,NiMH...............................................................................................
HLNA0029........MOTOR,3704,200RPM...........................................................................................................
HLNA0030........WALLCHARGER,TRICKLE,MICROPLUG...................................................................................
HLNA0032........HELION2.4GHZ2-CHANNELTRANSMITTER..............................................................................
HLNA0039........ANIMUS18TRBODY,BLACK-BLUE.............................................................................................
HLNA0040........ANIMUS18TRBODY,BLACK-RED..............................................................................................
HLNA0041........ANIMUS18TRBODY,BLACK-YELLOW........................................................................................
HLNA0042........ANIMUS18TRBODY,CLEAR......................................................................................................
HLNA0043........WHEELS&TIRES,LEFT&RIGHT(ANIMUS,TR).........................................................................
HLNA0044........BUMPERSANDBODYMOUNTS(ANIMUS,TR)..........................................................................
HLNA0045........ANIMUS18TROWNER’SMANUALANDEXPLODEDVIEW........................................................
HLNA0050........REPLACMENTSERVO,ANIMUS(FS)..........................................................................................
See your local Helion shop for the latest in genuine replacement parts and accessories for your Helion RC
product

12
...ANIMUS 18TR
HLNA0043
HLNA0002
HLNA0015
HLNA0007
HLNA0017
HLNA0015
HLNA0012
HLNA0005
HLNA0044
HLNA0006
HLNA0009
HLNA0011
HLNA0009
HLNA0008
HLNA0011
HLNA0029
HLNA0027
HLNA0008
HLNA0043
HLNA0003
HLNA0019
HLNA0050
HLNA0044

1/18th SCALE 4x4
ELECTRIC TRUGGY
13
EXPLODED VIEW...
HLNA0028
HLNA0015
HLNA0019
HLNA0003
HLNA0021
HLNA0010
HLNA0006
HLNA0012
HLNA0044
HLNA0009
HLNA0015
HLNA0005
HLNA0007
HLNA0017
HLNA0022
HLNA0015
HLNA0019
HLNA0016
HLNA0011
HLNA0019
HLNA0020
HLNA0004
HLNA0019
HLNA0044
HLNA0018

SHOCKS EXPLODED VIEW...
#
DIFFERENTIAL EXPLODED VIEW...
#
14
HLNA0014
HLNA0013 HLNA0012
HLNA0016
HLNA0019 HLNA0019
HLNA0022
HLNA0016
HLNA0026
HLNA0022

1/18th SCALE 4x4
ELECTRIC TRUGGY
DECLARATION OF CONFORMITY...
#
NOTES...
#
15
Declaraon of Conformity (DOC)
Hereby,themanufacturerdeclaresthatthisproductisincompliancewiththeessenalrequirementsand
otherrelevantprovisionsofDirecves.
Thedeclaraonofconformitymaybeconsultedatwww.helionrc.com
Intended Use
Theremotecontrolisdesignedexclusivelyforprivateuseinmodelconstrucon.Theremotecontrolisnot
forindustrialuse,e.g.tocontrolmachinesandequipment,determined.
Anyuseotherthanasdescribedabove,canleadtodamageoftheproduct,andbeyondthis,withthe
associatedrisks,suchasshortcircuit,re,electricshock,etc..
Contactwithwatermustbeavoided!
Theremotecontrolmustnottechnicallybechangedorrebuilt!
Thesafetyprecauonsareessenaltofollow!
Youasauseraresolelyresponsibleforthesafeoperaonofyourremotecontrolandyourmodel!
Disclaimer
Ascompliancewiththeinstrucons,theoperaonsandcondionswhenusingthedeviceatnomecanbe
monitoredbythemanufacturer;themanufacturerassumesnoliabilityfordamages,costsand/orlosses
arisingfromincorrectuseand/orincorrectoperaonorinanywayconnected.
Disposal
 Electronicproductsarerawmaterialsanddonotbelonginthetrash.Ifthe
 deviceisattheendofitsusefullife,disposethedeviceinaccordancewith
 applicablestatutoryregulaonsatthemunicipalcolleconpoints.
 Disposingofhouseholdwasteisprohibited.

1/18th SCALE 4x4
ELECTRIC TRUGGY
HLNA0045 [REV A]
0678
• ©2011HelionRC
• Technicalspecicaons,featuresanddesignaresubjecttochange.
• Distribuon:RobitronicElectronicGmbH+4319820920www.robitronic.com