Honeywell 16060 - Portable HEPA-Type Air Cleaner User manual

Portable
Air Cleaner
READ AND SAVE THESE INSTRUCTIONS
Owner’s Manual
For Model 1606X Series Air Cleaner
O
l
l
l
l
l
l
JULY
The Science of Clean Air®
®

PLEASE READ AND SAVE THESE SAFETY INSTRUCTIONS BEFORE USING
THIS AIR CLEANER.
When using electrical appliances, basic precautions should always be followed to reduce
the risk of fire, electric shock and injury to persons including the following:
1. Read all instructions before operating the air cleaner.
2. Place air cleaner where it is not easily knocked over by persons in the
household.
3. Always turn the air cleaner to the OFF (O) position and unplug when not in use.
4. To disconnect the air cleaner, first turn the air cleaner to OFF (O) position, grip the
plug and pull it from the outlet. Never pull by the cord.
5. Do not use any product with a damaged cord or plug or if product malfunctions, is
dropped or damaged in any manner. Keep the cord away from heated surfaces.
6. Do not use air cleaner outdoors.
7. Never use air cleaner unless it is fully assembled.
8. Do not run power cord under carpets, and do not cover with throw rugs. Arrange
cord such that it will not be tripped over.
9. Do not use air cleaner where combustible gases or vapors are present.
10. Do not expose the air cleaner to rain, or use near water, in a bathroom, laundry
area or other damp location.
11. The air cleaner must be used in its upright position.
12. Do not allow foreign objects to enter ventilation or exhaust opening as this
may cause electric shock or damage to the air cleaner. Do not block air outlets
or intakes.
13. Locate air cleaner near power outlet and avoid using an extension cord.
14. This appliance has a polarized plug (one blade is wider than the other). To reduce
risk of shock, this plug is intended to fit only one way in a polarized outlet. If the
plug does not fit fully in the outlet, reverse the plug. If it still does not fit, contact a
qualified electrician. DO NOT attempt to defeat this safety feature.
15. A loose fit between the plug and the AC outlet (receptacle) may cause
overheating and a distortion of the plug. Contact a qualified electrician to replace
loose or worn outlet.
16. Do not sit, stand or place heavy objects on the air cleaner.
17. Disconnect power supply before servicing.
WARNING: To reduce risk of fire or electric shock, do not use this product with
any solid-state speed control device.
Important Safety Instructions

Congratulations
You now own a quality portable air cleaner that has been engineered and crafted for
your satisfaction.
Our Consumer Relations representatives will be pleased to help with any questions or
concerns you may have about your air cleaner. Please call our Consumer Relations
Dept. at [phone] for assistance or email us at [e-mail].
For Best Performance
We recommend that you operate your air cleaner 24 hours a day because indoor air can be
quickly contaminated by activity in a room, infiltration of outside air and from sources of
contamination. While all the air in a room will not be processed by the air cleaner, the more
air circulated through the filter, the more filtered air returned to the room. Portable air
cleaners will be much more effective in rooms where all doors and windows are closed.
Place the air cleaner on a flat, level unobstructed surface. For best performance, the air
outlet slot should not be blocked for at least 3 feet (1 meter) in all directions.
NOTE: Due to the large volume of air drawn towards the air cleaner, surrounding areas
should be cleaned and/or vacuumed frequently to prevent buildup. If the unit is placed on a
light colored carpeting, a small mat or rug should be used to ease cleaning and prevent any
permanent staining. This is particularly important in homes with heavy contamination from
smoking or fireplaces.
General Description of Features
(See Diagram)
A. Speed Control/Power Switch
B. Filter-Change Calendar
C. Power Indicator Light
D. Air Intake
E. Filter Door for replacement cartridge
F. Air Outlet
Features
O
l
l
l
l
l
l
JULY
FA
C
B
E
D
Operation
The Honeywell 1606X Series air cleaner is a three speed air cleaner operated by
moving the speed control knob on the top panel from the OFF (O) position to the
HIGH (III) position. Allow the unit to operate for a few minutes at HIGH speed, then
leave the control knob in the HIGH position for faster, more powerful room cleaning,
or move the knob to the lower (I) setting for quieter operation.

Filter Replacement
Replace filter cartridge once every 6-9 months or sooner depending on usage.
Use Filter-Change Calendar to keep track of your filter replacement schedule.
NOTE: Filter is not washable and washing will damage the filter.
Our recommendations regarding filter replacement intervals are intended as
guidelines only. Life expectancy of any filter media is dependent on the concentration
of the contaminants to which the system is exposed. If there are sources of large
amounts of contaminant generation (such as dust from woodworking or heavy
smoking) the useful life of the filter media in your air cleaner may be reduced.
CAUTION: TURN OFF THE AIR CLEANER AND DISCONNECT FROM POWER
SUPPLY BEFORE SERVICING
The only part requiring any service is the filter cartridge. No tools are needed to
change the filter. Change filter as shown here.
Step 1: Turn the Air Cleaner OFF (O) and unplug from the wall outlet
Step 2: Open filter replacement door on bottom of air cleaner by pushing in tabs and
swinging door open (Fig. 1).
Step 3: Remove old filter by pulling the filter at the finger recesses inside filter door
(Fig. 2). Slide out filter and remove.
Step 4: Discard old filter and remove packaging from new filter.
Step 5: Slide new filter into air cleaner in direction of the arrows. Make sure that
black side faces the front of the air cleaner.
Step 6: Close and secure filter replacement door (Fig. 2).
Step 7: Return air cleaner to operable position and plug in.
Step 8: Roll the Filter Replacement Reminder ahead 6-9 months (Fig. 3).
Bottom of product
Front of product
Push tabs and pull to open
Fig. 1
Bottom of product
Front of product
swing and snap
to close door
Pull to Remove
Fig. 2
JULY
Fig. 3
Replacement Filter
Model Series Filter Cartridge
1606X 16960
Replacement filters may be purchased from the retail store or ordered from the dealer
where you purchased the product. If you cannot locate one, please call our Consumer
Relations Dept. at [phone], email us at: ser[email protected] or visit our
website at www.honeywell.com/yourhome.

FILTER REPLACEMENT REMINDER
The filter cartridge needs to be replaced at least every 6-9 months for maximum
performance.
Upon start up of your Air Cleaner and upon every filter replacement, roll the Filter-
Change Calendar ahead 6-9 months to indicate when filter replacement is necessary.
•Start on HIGH (III) for a few minutes, then adjust to desired speed.
•This product may emit a “new”smell which will disappear over a relatively short period of
operation.
•Check to make sure that the power cord is correctly connected to the outlet.
•Test that the outlet is functioning properly using another appliance or lamp
•Check the fuse or circuit breaker. The outlet may be overloaded if other appliances
are also in use. Determine and correct the cause of the overload.
•If none of the above procedures restores operation, return your unit to the store. If
the store’s return policy does not allow the return, return the complete unit per the
instructions in the warranty section of this owner’s manual. Do not attempt to repair
the unit yourself as it may cause injury, and the warranty does not cover damage
resulting from unauthorized attempts to repair or from any use not in accordance
with this manual.
Troubleshooting

Three Year Limited Warranty
Honeywell enviracaire®Air Cleaner
Model No. Series 1606X
This product has been engineered
and crafted with great care for your
satisfaction. Be sure to fill out and
return the enclosed card within
7 days of purchase.
A. This limited warranty applies to repair
or replacement of product found to be
defective in material or workmanship
within 3 years of the date of purchase.
This warranty does not apply to damage
resulting from commercial, abusive,
unreasonable use or supplemental
damage. Defects that are the result of
normal wear and tear will not be
considered manufacturing defects under
this warranty. HONEYWELL IS NOT
LIABLE FOR INCIDENTAL OR
CONSEQUENTIAL DAMAGES OF ANY
NATURE. ANY IMPLIED WARRANTY,
INCLUDING MERCHANTABILITY OR
FITNESS FOR A PARTICULAR
PURPOSE, ON THIS PRODUCT IS
LIMITED IN DURATION TO THE
DURATION OF THIS LIMITED
WARRANTY. Some regions do not allow
the exclusion or limitation of incidental or
consequential damages or limitations on
how long an implied warranty lasts, so
the above limitations or exclusions may
not apply to you. This warranty gives you
specific legal rights, and you also may
have other rights which vary from region
to region. This warranty applies only to
the original Purchaser of this product.
B. At its option, Honeywell will repair or
replace this product if it is found to be
defective in material or workmanship within
the limited warranty period. Defective
product should be returned to the place of
purchase in accordance with store policy
or to Honeywell.
C. This warranty does not cover
damage resulting from unauthorized
attempts to repair or from any use not
in accordance with this manual.
D. This warranty DOES NOT cover
the filter cartridge of this product except
for material or workmanship defects.
E. Return defective product to the
following address with a brief description
of the problem. Include proof-of-
purchase and a U.S. $10.00 / Canadian
$15.00 check or money order for
handling, return packing and shipping
charges. Please include your name,
address and daytime phone number. You
must prepay shipping charges. Mark
carton “Attention Returns Department”
Ship to:
In USA:
Honeywell Consumer Products
Returns Department
4755 Southpoint Drive
Memphis, TN 38118
U.S.A.
In Canada:
Honeywell Consumer
Products Canada
510 Bronte St. South
Milton, Ontario Canada L9T 2X6
If you experience a problem with your air
cleaner, please see owner's guide for
instructions. Please do not attempt to
repair the air cleaner yourself. Doing so
may void the warranty and could cause
damage or personal injury. If the problem
still persists, please call:
Honeywell
Consumer Relations Dept.
Toll Free 1-800-332-1110.
Mail Questions or Comments to:
Honeywell
Consumer Relations Dept.
250 Turnpike Road
Southborough, MA 01772 U.S.A.
or e-mail us at: ser[email protected]
Visit our website at
www.honeywell.com/yourhome
© 2000 Honeywell. All Rights Reserved.
AC7005.00 035-00388-000 Rev 0