Hussmann Impact C5NLE User manual

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
D
D
E
B
E
A
C
E
P/N 0441000
Merchandisers
®
Item Part # Description Wiring Item #
FAN ASSEMBLIES AND THERMOSTATS
A. 9W Fan Assembly (1)
0047000 Fan Motor, Evaporator
0401532 Fan Blade
embossing toward motor
B. 0411744 Standard Non-adjustable (2)
Defrost Thermostat
C. 0137880 Optional Adjustable (3)
Refrigeration Thermostat
Item Part # Description Wiring Item #
LAMPS AND BALLASTS
D. 0376409 Ballast, 2 lamps (4)
D. 0376410 Ballast, 3 lamps (4)
D. 0376411 Ballast, 4 lamps (4)
E. Fluorescent Lamp (5)
Replace with like fixtures
C5NLE
Data Sheet Set
P/N 0441000
NSF®Certified
May, 2003

Electrical
Waste Outlet
A
(see note*) Refrigeration Outlet
B
C
D
40 5/8
(1032)
27
(686)
27 1/2
(699)
4 1/2 (114)
25 1/2
(648)
33
(840)
40 5/8
(1030)
5 1/2 (140)
1 3/8 (035)
4
(102)
Water Seal
55/8
(143)
40 5/8
(1032)
29 1/8
(739)
41/4 (107)
72 1/4 (1835)
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A. C5NLE Data Sheet Set
2 of 6
Engineering
Plan Views
C5NLE
Narrow Footprint
Convertible
Dairy and
Delicatessen
5-2003
Dimensions shown as in. & (mm).
8 ft 12 ft
General
(A) Case Length (without ends or partitions) 96 3/8(2448) 144 1/2(3670)
Maximum O/S dimension of case back to front (includes bumper) 40 5/8(1030) 40 5/8(1030)
Back of case to front of splashguard 33 (840) 33 (840)
Back of case to O/S edge of front skid rail 25 1/2 (646) 25 1/2 (646)
Width of skid rail 4 1/2(114) 4 1/2(114)
RH end of case to outside edge of external support 5 1/2(140) 5 1/2(140)
Distance between edges of external support and center support 40 5/8 (1032) 40 5/8 (1032)
Distance between edges of center supports NA 44 (1118)
Stub-up area between front skid rail and splashguard 5 5/8(143) 5 5/8(143)
Electrical Service (Electrical Field Wiring connection point)
(B) RH End of case to center of farthest knockout 88 3/8(2245) 136 1/2 (3467)
(C) Back of case to center of knockout 29 1/8(739) 29 1/8(739)
Length of electrical raceway 35 5/8 (903) 35 5/8 (903)
Waste Outlet
(D) RH End of case to the center of waste outlet 24 1/8(613) 74 1/4(1835)
LH End of case to the center of waste outlet 74 1/4(1835) 74 1/4(1835)
Water Seal
Edge of water seal to center of waste outlet 4 (102) 4 (102)
Outside diameter of the drip pipe 1 1/2 (38) 1 1/2 (38)
*NOTE: Water seal outlet must clear front skid rail;
water seal rotation in forward direction only due to low base.
Refrigeration Outlet
Back of case to center of refrigeration outlet 27 1/2 (699) 27 1/2 (699)
(E) RH end of case to center of refrigeration outlet 9 (230) 9 (230)

3 of 6P/N 0441000 HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
(Optional
2 Row
Lights)
Refrigeration Outlet
FAN
381/8(969)
31/8(79)
71/2
(190)
251/2(646)
27 (687)
271/2(699)
291/8(739)
33 (840)
405/8(1030)
19
(483)
C
O
I
L
41/4
(114)
53/4
(146)
55/8
(143)
C5NLE
33/4(95)
561/4
(1429)
813/8
(2067)
241/2
(623)
(Optional
Rail Lights)
(Optional 16 in. Shelves)
61
(1549)
Impact C5NLE
Dairy / Delicatessen
Dimensions shown as in. & (mm).
REFRIGERATION DATA
Note: This data is based on store temperature
and humidity that does not exceed 75°F and
55% R.H. C5NLE
Deli Dairy
Discharge Air (°F) 29 31
Evaporator (°F) 21 24
Unit Sizing (°F) 19 22
Btu/hr/ft*
LIT &U
NLIT SHELVES Deli Dairy
Parallel 1580 1500
Conventional 1720 1635
HUSSMANN PEG SHELVES
Parallel 1630 NA
Conventional 1760 NA
*For all refrigeration equipment other than
Hussmann, use conventional Btu values.
DEFROST DATA
C5NLE
Frequency (hr) 6
Defrost Water (lb/ft/day) 10.25
(± 15% based on case configuration and
product loading).
OFFTIME C5NLE
Temp Term (°F)48°F
Failsafe (minutes) 35
ELECTRIC OR GAS Not Recommended
Standard Defrost Thermostat
Close on rise: close 48°F — open 33°F
CONVENTIONALCONTROLS
Low Pressure Backup Control
CI/CO** Deli Dairy
14°F / 4°F 17°F / 7°F
Indoor Unit Only, Pressure Defrost
Termination** 48°F
**Use a Temperature Pressure Chart to
determine PSIG conversions.
PHYSICAL DATA
Merchandiser Drip Pipe (in.) 1 1/2
Merchandiser Liquid Line (in.) 3/8
Merchandiser Suction Line (in.) 7/8
Estimated Charge (lb)***
8 ft 3.2
12 ft 4.5
***This is an average for all refrigerant types.
Actual refrigerant charge may vary by
approximately half a pound.
Length (in.) added to Lineup by Each
End or Insulated Partition 1 1/2
NOTE: The bumper is 4 in. (102 mm) wide. The center of the top bumper
is 14 1/8in. (359 mm) from the floor and the center of the bottom
bumper is 6 in. (152 mm) from the floor.
Multi-deck, 5 Display Levels, Narrow Footprint
NSF Certification
These merchandisers are manufactured to meet ANSI /National
Sanitation Foundation (NSF®) Standard #7 requirements.

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A. C5NLE Data Sheet Set
4 of 6
Impact C5NLE
Dairy / Delicatessen
Electrical Data 8 ft 12 ft
Number of Fans — 9W 4 6
Amperes Watts
Merchandiser 8 ft 12 ft 8 ft 12 ft
Fans
Standard: 120V 60 hz 2.80 4.20 220 330
Energy Efficient: 120V 60 hz 1.52 2.28 100 150
Export: 230V 50 hz 1.12 1.68 176 264
Anti-sweat Heaters
Constant on NA NA
Cycling NA NA
Minimum Circuit Ampacity
With Standard Fans 3.00 4.40
With Energy Efficient Fans 1.72 2.48
With Export Fans 1.32 1.88
Maximum Over Current Protection 20 20
Supplemental Gas Heaters NA NA
208V 1ΦΦElectric Defrost NA NA
Standard Lighting
1 Row Canopy 0.51 0.77 59 85
Optional Lighting
1 Row Canopy and 1 Row Rail 1.02 1.54 118 170
2 Rows Canopy 1.02 1.54 118 170
2 Rows Canopy and 1 Row Rail 1.53 2.31 177 255
1 Row Ledge Lights 0.51 0.77 59 85
Optional Shelf Lighting
1 Row of Shelves 0.51 0.77 59 85
2 Rows of Shelves 1.02 1.54 118 170
3 Rows of Shelves 1.53 2.31 177 255
4 Rows of Shelves 2.04 3.08 236 340

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A. 5 of 6P/N 0441000
Defrost
Termination
Thermostat
Refrigeration
Thermostat
Dark Blue
3
To
Condensing
Unit
}
Light Blue
2
Fan Wiring
Off-time Defrost
4 & 6 Fans 120V NEUTRAL
BROWN BAND
120V POWER Fans 1
BROWN BAND
Grayed components in 12 foot models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS
Connector
Connector
G
Connector
Connector Connector
Connector Connector
Optional Shelf Harness and Light Circuits for
One Row of Shelves
120 V
Power
B
WGB
BL BL
BL G
G
RR
BL BL G
W
BL
Shelf Harness
Shelf Light Circuits
BL
G
R
5
4
W
BL R
5
BL R
G
G
R
R
R
G
Shelf Lighting
G G
R
BL
5
BL
Connector
Connector
B

C5NLE Data Sheet Set6 of 6 HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
BL
RR
BL
BL
4
55
5
R
120V NEUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V POWER
ORANGE OR TAN
BAND
B
BL R
R
BL
BL
4
55
5
R
W
B
Optional Lighting — 2 Rows Canopy
120V NEUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V POWER
ORANGE OR TAN
BAND
B
BL
RR
BL
BL
4
55
5
R
Standard Lighting — 1 Row Canopy
Optional Lighting — 1 Row Rail or 1 Row Ledge
Light Circuits
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
= 120V POWER = 120V NEUTRAL
Grayed components in 12 foot models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS