Hydro International Up-Flo User manual
Up-Flo®Filter Operation and Maintenance Manual
Operation and Maintenance Manual
Up-Flo® Filter
Filtration System for Stormwater Treatment
Stormwater Solutions
94 Hutchins Drive
Portland, ME 04102
Tel: (207) 756-6200
Fax: (207) 756-6212
www.hydro-int.com
Up-Flo®Filter Operation and Maintenance Manual
3 Up-Flo®Filter
- Overview
- General Product Description
- Maintenance Services
4 Operation
- Introduction
- Pollutant Capture
- Best Practices
5 Inspection & Maintenance
- Overview
- Inspection
- Solids Disposal
13 Up-Flo®
14 Up-Flo®
16 Up-Flo®
COPYRIGHT STATEMENT:
Hydro International plc. Up-Flo®®
DISCLAIMER:
International plc’s Up-Flo®
IMPORTANT - IMPORTANT
Phone: 207-756-6200
Fax: 207-756-6212
Email: [email protected]
Up-Flo®Filter Operation and Maintenance Manual
®
A. Inlet Pipe
B.
C. Filter Module
D.
E. Bypass Hood/Siphon
F. Outlet Module
G. Outlet pipe
H.
B
A
BF
G
D
C
E
a. Manhole
Fig.2 The Up-Flo®®
Filter.
Fig.1 The Up-Flo®Filter - Media Filtration
Up-Flo®Filter Operation and Maintenance Manual
Fig.3 The Up-Flo®Filter - Ribbon Filtration
The Up-Flo®
The Up-Flo®
Fig.1
®
®
®
ensures optimal performance of the system.
Up-Flo®Filter Operation and Maintenance Manual
The Up-Flo®
®Filter.
®vessel and those that are performed
®vessel.
The Up-Flo®Fig.3).
®Filter vessel
is required
Fig.3.
The minimum required frequency for replacement of the
Media Ribbon is annually, whereas the minimum required
frequency for removal of accumulated sediment from the
sump is dependent on the Up-Flo®
module will require less frequent removal of accumulated
removal is required.
Up-Flo®Filter Operation and Maintenance Manual
Up-Flo®Filter and its components prior to inspection.
®
•
•
•
•
• ®)
• Hydro International Up-Flo®
•
provide access to the Up-Flo®Filter. Safety equipment should notify
2. Re
®, measure the depth
of sediment that has collected in the sump of the vessel.
Maximum sediment depth is 16 inches (41 cm).
-
7.
removed, and the depth of sediment measured. Also note any appar-
9. Remove safety equipment.
-
Up-Flo®Filter Operation and Maintenance Manual
• Activities Not Requiring®Filter
removal of sediment from the sump.
• Activities Requiring®Filter
®
-
ment from the sump, and to dewater the vessel for replacement of
Completion of all the maintenance activities for a typical 4-ft (1.2m)
-
3(0.5 m3) of sediment
International.
removal of sediment from the sump.
•
•
•
•
•
• ®)
•
•
• Hydro International Up-Flo®
®Filter. Safety equipment should
4.
3(0.2 m3
manhole Up-Flo®
5. Retract the vactor hose from the vessel.
Up-Flo®Filter Operation and Maintenance Manual
•
•
• Pole
done with vactor hose)
• ®)
•
•
• Up-Flo®Filt
Hydro International)
• Hydro International Up-Flo®
•
Up-Flo®Filter
4
• NOTE:
.
7. Exit the Up-Flo®
__or lid.
•
9. Remove safety equipment.
10.
The access port located at the top of the manhole or vault provides access to the Up-Flo®vessel for maintenance personnel to enter the
®-
inside the vessel.
Up-Flo®Filter Operation and Maintenance Manual
Activity Frequency
Inspection
- Twice per year or as needed
Sediment Removal
®
- Once per year
activated after two consecutive storms
disposal requirements.
Up-Flo®Filter Operation and Maintenance Manual
®
®FILTER LOCATION:
SITE NAME:
SITE LOCATION:
OWNER: SITE CONTRACTOR:
CONTACT NAME: CONTACT NAME:
COMPANY NAME: COMPANY NAME:
ADDRESS: ADDRESS:
TELEPHONE: TELEPHONE:
FAX: FAX:
®
Hydro International (Stormwater), 94 Hutchins Drive, Portland ME 04102
Up-Flo®Filter Operation and Maintenance Manual
Hydro International (Stormwater), 94 Hutchins Drive, Portland ME 04102
®
Inspection Frequency Key: A=annual; M=monthly; S=after major storms
Inspection Items
Inspection
Frequency
Inspected?
(Yes/No)
Maintenance
Needed?
(Yes/No)
Comments/Description
Debris Removal
M
M
M
®
Filter)
A
Grass mowed? M
Water retention where required
A
Evidence of erosion? A
Sediment Deposition
A
full?
A
Structural Components
Any evidence of structural deterioration? A
A
A
A
Other
A
M
A
Owner Name: _______________________________________________________________________________________________
Site Status: _________________________________________________________________________________________________
Date: _______________ Time: _______________ Site conditions*: ____________________________________________________
Up-Flo®Filter Operation and Maintenance Manual
Hydro International (Stormwater), 94 Hutchins Drive, Portland ME 04102
Inspector Comments: ________________________________________________________________________________________
__________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
Overall Condition of Up-Flo®
®Filter Operation & Maintenance Manual:
Maintenance Action Needed Due Date
The next routine inspection is schedule for approximately: (date) _________________________
Up-Flo®Filter Operation and Maintenance Manual
Hydro International (Stormwater), 94 Hutchins Drive, Portland ME 04102
®
Owner Name: _______________________________________________________________________________________________
Site Status: _________________________________________________________________________________________________
Date: _______________ Time: _______________ Site conditions: _____________________________________________________
Sediment depth measured in sump prior to removal: _________________________________________________________________
Inspector Comments: ________________________________________________________________________________________
__________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
Overall Condition of Up-Flo®
Up-Flo®Filter Operation and Maintenance Manual
Trash, sediment and polluted water is stored inside treatment
in order to prepare the system for maintenance and install any
• Solids removal
• Removal of liquid pollutants
•
Sanitation services providers not intimately familiar with stormwater
-
• -
nents appropriately.
•
•
your Hydro warranty plan
•
Up-Flo®Filter Operation and Maintenance Manual
•
• Stormwater separators
•
•
•
•
• Stormwater ponds
•
Up-Flo®Filter Operation and Maintenance Manual
Stormwater Solutions
94 Hutchins Drive
Portland, ME 04102
Tel: (207) 756-6200
Fax: (207) 756-6212
www.hydro-int.com
®
Other manuals for Up-Flo
1
Other Hydro International Water Filtration System manuals
Popular Water Filtration System manuals by other brands
Cuno
Cuno CFS6000 series Installation and operating instructions
Apex Digital
Apex Digital RO5 instruction manual
Waterdrop
Waterdrop WD-C05 installation instructions
Insignia
Insignia NS-HAF-CIN-1 Quick setup guide
Nimbus Water Systems
Nimbus Water Systems Five Water Maker WM5-50 Instruction
PREMIER TECH
PREMIER TECH Rewatec Ecoflo EC-2.8 Quick reference guide