James Ultra 8050D-H User manual

USER GUIDE

INTRODUCTION
!"#$%&'()&*(+&,)'-$.&/"-0&1#230&4+(5)6/0&7/5&)8/+#0($-6&683#$3+9
:8/+#0($-6&683#$-$.&-0&#&)$-;)3&<"3$(23$($9&=-88-($0&(*&/-$'&,),,830&#+3&
6+3#/35&>"3$&)8/+#0($-6&0()$5&-0&<#0035&/"+()."&8-;)-59&?/&-0&/"303&/-$'&
,),,830&6(2,-$35&>-/"&#&").3&<+300)+3&/"#/&6+3#/30&-$6+35-,83&683#$-$.&
+30)8/09
READ+THE+USER+GUIDE
!"3&:8/+#&+#$.3&(*&)8/+#0($-6&683#$3+0&#+3&@3+'&3#0'&/(&)03A&#8/"()."&/(&
.3/&/"3&,30/&*+(2&'()+&$3>&<)+6"#03A&>3&+36(223$5&'()&+3#5&/"-0&:03+&
B)-53&,3*(+3&.3//-$.&5(>$&/(&#$'&03+-()0&683#$-$.9
?/&#80(&6($/#-$0&-2<(+/#$/&0#*3/'&-$*(+2#/-($&#0&>388&#0&<+#6/-6#8&"-$/09
UNPACKING
C32(@3&'()+&:8/+#&DEFEGHI&683#$3+&*+(2&-/0&<#6%#.-$.&#$5&3$0)+3&/"#/&
#8($.&>-/"&/"-0&:03+&B)-53&'()&"#@3&/"3&6(++36/&2#-$0&<8).&*-//35&*(+&'()+&
0)<<8'&#$5&/"3&0<36-*-35&#66300(+-309
C3/#-$&/"3&<#6%-$.&6#+/($&*(+&0/(+#.3&(*&'()+&)$-/A&#$5&#80(&-$&/"3&)$8-%38'&
3@3$/&/"#/&/"3&)$-/&$3350&/(&,3&+3/)+$35&*(+&03+@-63&(+&+3<#-+9
IMPORTANT
!"-0&)$-/&-0&*-//35&>-/"&#&JK&L2<&MNO&JKPKQ&<8).&>-/"&#&K&L2<&*)039
R"3$&+3<8#6-$.&/"3&*)03&($8'&#&KL&LO!L&#<<+(@35&/(&NOJKPS&/'<3&0"()85&,3&
)0359&L8>#'0&,3&0)+3&/(&+3H*-/&/"3&*)03&6(@3+9
?$&/"3&3@3$/&/"#/&'()&$335&/(&6"#$.3&/"3&<8).&/"3$&/"3&*(88(>-$.&-$0/+)6/-($0&
2)0/&,3&*(88(>35&T
L0&/"3&6(8()+0&(*&/"3&>-+30&-$&/"3&2#-$0&83#5&(*&/"-0&#<<8-#$63&2#'&$(/&
6(++30<($5&>-/"&/"3&6(8()+35&2#+%-$.0&-53$/-*'-$.&/"3&/3+2-$#80&-$&'()+&<8).A&
<+(6335&#0&*(88(>0T
!"3&>-+3&>"-6"&-0&6(8()+35&,8)3&2)0/&,3&6($$36/35&/(&/"3&/3+2-$#8&>"-6"&-0&
2#+%35&>-/"&/"3&83//3+&U&(+&6(8()+35&,8#6%9
!"3&>-+3&>"-6"&-0&6(8()+35&,+(>$&2)0/&,3&6($$36/35&/(&/"3&/3+2-$#8&>"-6"&-0&
2#+%35&>-/"&/"3&83//3+&7&(+&6(8()+35&+359
U(&6($$36/-($&-0&/(&,3&2#53&/(&/"3&3#+/"&/3+2-$#8&(*&/"3&<8).9

11
INDEX
2 Safety Instructions
3 Suggested Applications
4 Features and Accessories
5 - 6 Operating Instructions
7 - 8 Different ways of cleaning
9 Maintenance and Storage
9 Specification
Ultra 8050D-HUltra 8050D-H

SAFETY'INSTRUCTIONS
Do#not#operate#this#unit#if#the#cord#or#plug#is#damaged.#Please#
refer#to#a#service#centre#for#examination#and#repair.
To#avoid#electric#shock#never#touch#the#cord#or#socket#with#wet#
hands.
Never#operate#the#unit#when#empty.#Damage#may#occur.
Keep#the#unit#unplugged#before#filling.
Do#not#use#boiling#water#as#damage#to#the#unit#may#occur.
Do#not#exceed#the#"MAX"#marking#on#the#inside#of#the#tank.
Always#unplug#the#unit#immediately#after#use#and#before#emptying.
Do#not#operate#the#unit#next#to#heat#sources#such#as#radiators.#
Operate#on#a#dry#level#surface.
To#avoid#electric#shock#do#not#immerse#the#unit#into#water#or#other#
liquid.#The#unit#should#not#be#exposed#to#dripping#or#splashing#and#
no#objects#filled#with#liquids#should#be#placed#on#top#of#it.
When#emptying,#always#pour#liquid#away#via#the#back,#avoiding#the
ventilation#slots#/#power#inlet#on#the#sides#and#control#panel#on#the#
front#face.
Do#not#fill#the#tank#with#abrasives#or#corrosive#chemicals.#
Repeated#cleaning#cycles#will#enhance#the#cleaning#effect.
The#unit#should#never#be#left#unattended#when#plugged#in.
Do#not#attempt#to#remove#any#screws#or#panels.#There#are#no#user#
serviceable#parts#inside.
2
READ#THIS#BEFORE#USING#YOUR#PRODUCT

Porous&stones&such&as&pearls&etc&
should&not&be&immersed.&Use&the&
optional&watch&stand&to&hold&the&
stones&out&of&the&water.
If&in&doubt&please&refer&to&our&website&
www.jpl.uk.com&for&more&information.
3
Ultra'8050D,H
SUGGESTED'APPLICATIONS
Jewellery
Necklaces,)Rings,)Bracelets)etc.
Watches'and'Glasses'/'Sunglasses
Waterproof)wristwatches,)Watch)chains,
Glasses,)Sunglasses)etc.
Toiletry'Items
Electric)toothbrush)heads,)Electric)shaver)heads,)Razor)blades,)
Combs,)Toothbrushes,)Dentures)etc.
Dental'Instruments
A)variety)of)metal)or)plastic)dental)equipment)can)be)cleaned)
quickly)and)efficiently.
Office'Equipment
Printer)heads,)Fountain)pen)nibs,)wax)or)rubber)stamps)etc.
Tableware'/'Cutlery
Wood)or)Bone)handled)tableware)/)cutlery)should)not)be)
immersed.)Only)all)metal)or)plastic)tableware)should)be)cleaned.
Metal'Items
Bearings,)Gears,)valves,)machine)nozzles,)small)metal)parts,)old)
coins,)metal)badges,)etc.
WHAT)CAN,)AND)WHAT)CAN'T)I)CLEAN?
Watches&should&be&fully&
waterproof&(30m&or&more).&
For&watches&that&are&not&
waterproof,&the&optional&
Watch&Stand&can&be&used.
Any&unfirm&or&inlaid&item&may&become&loose.&Items&that&are&easy&to&be&discoloured&are&not&
recommended&for&ultrasonic&cleaning.&eg:&Textiles,&Leather&products,&woodware&etc.
DO&NOT&put&a&watch&or&mobile&phone&which&is&NOT&waterproof&into&the&tank&as&damage&may&
occur.
DO&NOT&put&any&spectacle&frame&or&artware&which&is&made&from&shell&or&hawksbill&into&the&
tank&for&cleaning&as&damage&may&occur.

4
VIEW%WINDOW
LID
STAINLESS
STEEL%TANK
HOUSING
CONTROL%PANEL
TRAY POWER%CORD
ACCESSORIES
FEATURES%AND%ACCESSORIES

55
Ultra 8050D-HUltra 8050D-H
OPERATING INSTRUCTIONS
Open the lid. Place the items to be cleaned on
the tray (supplied) and place the tray in the tank.
Add water in the stainless steel tank, ensuring
that the items and tray are covered but the water
level is between the "MIN" and "MAX" marking.
Do not exceed the "MAX" marking on the inside
of the tank.
HOW DO I USE THE ULTRA 8050D-H CLEANER
NEVER OPERATE THE UNIT WITHOUT WATER IN THE CLEANING TANK
- DAMAGE MAY OCCUR
NEVER USE BOILING WATER - DAMAGE MAY OCCUR
1To avoid the possibility of scratches from
friction during operation, do not overlap
items. Ensure items are spaced apart.
2
Close the lid. Ensure your hands are dry, and
plug the detachable mains cord into the unit (as
shown), and into the wall socket.
When the unit is plugged in, the display will
default to the '3 minute - 180 second' setting. If a
different time is required then pressing the SET
button will cycle the time through the five settings
180s - 280s - 380s - 480s - 90s. When the
display shows your required time, move to next
step.
Press the ON button to start cleaning. The green
operation LED will illuminate while the unit is in
operation. The built in timer will count down the
time automatically.
When the timer counts down to the unit
will automatically stop. If required you can stop /
pause the cleaning process at any time by
pressing the OFF button, pressing ON again will
resume the cleaning and the countdown will
continue. When cleaning has finished, you can
repeat the process by pressing ON button again.
Note : During operation the unit will "buzz", this is
normal.
3

6
OPERATING*INSTRUCTIONS
HOW$DO$I$USE$THE$ULTRA$8050D1H$CLEANER
NEVER%OPERATE%THE%UNIT%WITHOUT%WATER%IN%THE%CLEANING%TANK%
2%DAMAGE%MAY%OCCUR
NEVER%USE%BOILING%WATER%2%DAMAGE%MAY%OCCUR
Using$the$HEATER$function.
Pressing$the$"TC"$button$starts$the$built$in$heater.$
The$red$LED$on$the$left$of$the$control$panel$will$
illiuminate.$The$water$will$heat$to$a$maximum$of$
65$degrees$C.
To$start$the$cleaning$process$press$the$ON$button
(as$described$in$point$3).
If$required,$you$can$stop$/$pause$the$cleaning$
process$at$any$time$by$pressing$the$OFF$button,$
pressing$ON$again$will$resume$the$cleaning$and$
the$countdown$will$continue.
The$program$can$be$reset$at$any$time$by$pressing$
the$SET$button.
When$cleaning$is$finished,$unplug$the$mains$cord$
from$the$wall$socket$and$from$the$unit,$and$open$
the$lid$to$remove$the$item(s).
Poor$away$the$water$(see$note)$and$wipe$the$
stainless$steel$tank$with$a$clean$dry$cloth.
Note$:$When$emptying,$always$pour$liquid$away$
via$the$back,$avoiding$the$ventilation$slots$/$power$
inlet$on$the$sides$and$control$panel$on$the$front$
face.
This%Ultrasonic%Cleaner%has%built%in%circuit%protection%to%avoid%overheating.%If%
the%circuit%protection%comes%on%then%the%right%hand%red%LED%will%illuminate,%
and%the%unit%will%not%operate.%After%approx%15%minutes,%after%allowing%the%unit%
cool%down,%operation%can%be%resumed%by%pressing%the%ON%button.
4
5

77
Ultra 8050D-HUltra 8050D-H
NEVER OPERATE THE UNIT WITHOUT WATER IN THE CLEANING TANK
- DAMAGE MAY OCCUR
NEVER USE BOILING WATER - DAMAGE MAY OCCUR
DIFFERENT WAYS OF CLEANING
HOW DO I USE THE ULTRA 8050D-H CLEANER
GENERAL CLEANING
Use only plain tap water. Place the item to be
cleaned on the tray and place in the unit. Pour in
the water and ensure the water level is between
the "MIN" and "MAX" marking. Plug the unit in.
Using the default setting of 180s is normally
sufficient for general cleaning.
Note: The water should be changed between
cycles when it becomes dirty. Always ensure the
unit is unplugged when changing water.
When emptying, always pour liquid away via the
back, avoiding the ventilation slots / power inlet on
the sides and control panel on the front face.
1
ENHANCED CLEANING using the heater
If the item is very dirty or has oil or grease smears
then the enhanced cleaning effect of heating the
water can have amazing effects.
Use only plain tap water. Place the item to be
cleaned on the tray and place in the unit. Pour in
the water and ensure the water level is between
the "MIN" and "MAX" marking. Plug the unit in.
Press the "TC" button, and the heater will warm
the water to a maximum of 65 degrees C.
Using the time setting of 280s - 480s is
recommended for enhanced cleaning.
Note: The water should be changed between
cycles when it becomes dirty. Always ensure the
unit is unplugged when changing water.
When emptying, always pour liquid away via the
back, avoiding the ventilation slots / power inlet
on the sides and control panel on the front face.
2

8
NEVER%OPERATE%THE%UNIT%WITHOUT%WATER%IN%THE%CLEANING%TANK%
2%DAMAGE%MAY%OCCUR
NEVER%USE%BOILING%WATER%2%DAMAGE%MAY%OCCUR
DIFFERENT(WAYS(OF(CLEANING
HOW$DO$I$USE$THE$ULTRA$8050D1H$CLEANER
EXTENSIVE(CLEANING
If$the$item$needs$extensive$cleaning$or$sterilising,
then$then$first$using$the$enhanced$cleaning$effect$
of$heating$the$water$can$have$amazing$effects.$
This$should$be$followed$by$adding$a$few$drops$of$
washing$up$liquid$or$liquid$soap$to$the$tank$and$
repeating$the$cleaning$procedure$as$described$in$
ENHANCED$CLEANING.
Care$should$always$be$taken$to$ensure$when$
putting$multiple$items$in$the$cleaner$they$are$not$
rubbing$against$each$other$as$this$can$cause$
scratches$or$damage$to$the$items.
A$final$cleaning$cycle$using$plain$water$is$recommended$after$using$soaps$or$
detergents$to$clean$any$remaining$residue$from$the$items$being$cleaned.
Note:$The$water$should$be$changed$between$cycles$if$it$becomes$dirty.$Always$
ensure$the$unit$is$unplugged$when$changing$water.
When$emptying,$always$pour$liquid$away$via$the$back,$avoiding$the$ventilation$
slots$/$power$inlet$on$the$sides$and$control$panel$on$the$front$face.
3
CLEANING(LARGE(ITEMS
If$the$item$is$too$large$to$fit$completely$in$the$tank,$then$you$can$use$the$ultrasonic$
cleaner$with$the$item$to$be$cleaned$part$immersed,$with$the$lid$open.$Ensure$the$
"MAX"$marking$is$not$exceeded$when$immersing$the$item.
IMPORTANT(NOTES
1.(Care(should(be(taken(when(using(different(types(of(cleaning(soaps(or(
detergents.(Always(ensure(they(are(suitable(for(the(item(you(are(cleaning.(If(in(
doubt,(please(ask(James(Products(Ltd(or(check(www.jpl.uk.com
2.(The(Cleaning(tray(absorbs(approximately(20%(of(the(ultrasonic(cleaning(
ability(of(the(cleaner.(If(the(item(will(not(be(damaged,(then(the(tray(can(be(
omitted(for(a(stronger(clean.
3.(The(use(of(SOLVENTS(or(ALCOHOL(in(the(tank(or(on(any(part(of(the(cleaner(
will(damage(your(ultrasonic(cleaner(and(void(any(warranty.

Ultra 8050D-HUltra 8050D-H 9
MAINTENANCE AND STORAGE
SPECIFICATION
After use, ensure unit is unplugged.
Pour the water away (see note), and wipe the stainless steel
tank and housing with a clean dry cloth.
To avoid electric shock DO NOT wash the unit with water.
Note : When emptying, always pour liquid away via the back,
avoiding the ventilation slots / power inlet on the sides and
control panel on the front face.
The Ultra 8050D-H cleaner has circuit protection to stop
overheating. Never use the product without water as damage
will occur. To prolong the life of the unit, it is recommended to
stop using the unit for 15 minutes after every 3 working cycles.
The unit should be stored in a cool dry place, away from any
heat sources (radiators etc) and sources of moisture
(bathrooms etc).
Ideally, the unit should be stored in its original packing for
maximum safety.
KEEPING MY CLEANER IN PERFECT CONDITION
Model Name : ULTRA 8050D-H
Timer Settings : Digital with 5 time settings:
90s - 180s (default) - 280s - 380s - 480s
automatic shut-off
Tank Size : 2500ml stainless steel - 2200ml (MAX) 600ml (MIN)
Ultrasonic Frequency : 42,000Hz (42 kHz)
Power Consumption : 170W Max
Power Supply : AC 220-240V 50Hz
Unit Dimensions (lxwxh) : 290 x 235 x 165mm
Tank Dimensions (lxwxh) : 245 x 146 x 70mm MAX
Weight (NET) : 2.5kg (5.5lbs)
Mains Fuse : 3A
(UK plug only) When replacing the fuse only a 3A ASTA approved to
BS1362 type should be used and be sure to re-fit the
fuse cover.
2
3
1