Jumpking JKOV1517SL2 User manual

YJ USA Corp., 3970 Lindbergh Drive Addison, TX 75001
WARNING
www.jumpking.com
1-877-927-8777
15ft x17ft Oval Combo
Model#JKOV1517SL1 /
JKOV1517SL2
100 220

2

3
15ft x17ft Oval Combo
3
3
king

2. Must place the trampoline on lawn, bark wood chip, sand or cushioning materials.
3. Maintain a free space of minimum 2500mm on all sides of the trampoline. This area should not included
concrete, bitumen, brick, or other hard surfaces as these can cause serious injuries.
recommended.
Provide clearance for wires, tree limbs, and other possible hazards.
and trampoline enclosure away from walls, structures
fences, and others play areas. Maintain a clear space on all sides of the trampoline and trampoline
enclosure.
6. Place the trampoline and trampoline enclosure on a level surface before use.
7. Use the trampoline and trampoline enclosure in
required for indoor or shady areas.
8. Secure the trampoline and trampoline enclosure against unauthorized and unsupervised use.
10. The trampoline enclosure is only to be used as an enclosure for a trampoline of a size for which the
enclosure is designed.
mpoline. Landing on the head or neck can cause serious
injury, paralysis, or death, even when landing in the middle of the bed.
13. Do not allow more than one person on the trampoline and trampoline enclosure. Use by more than one
sult in serious injuries.
14. Use trampoline and trampoline enclosure only with mature, knowledgeable supervision.
15. Trampoline over 20 in. (51 cm) tall are not recommended for use by children under 6 years of age.
16. The trampoline is designed for users weighing 100 kg (220 lbs.) or less.
17. Misuse and abuse of the trampoline is dangerous and can cause serious injuries.
trampoline or while jumping. Stay in the center of the bed when jumping. Do not use the trampoline
without the frame pad securely in place to cover the frame. The frame pad is not designed or intended to
support the weight of the user. Do not step or jump directly onto the frame pad.
19. The trampoline is a rebounding device that propels the user to unaccustomed heights and into a variety
riking the frame or springs, or improperly landing
on the bed may cause injury.
20. Do not jump on the trampoline while holding an object, rp or breakable.
21. Inspect the trampoline and trampoline enclosure before each use. Make sure the frame padding, barrier
and the enclosure support (frame) padding is corre
e the trampoline as a
springboard to other objects.
t with the trampoline bed. Learn this skill before
s series and
thout feet bounces between them.
25. Avoid bouncing too high. Stay lo landing in the center of the
tram
p
oline can be accom
p
lished. Control is more im
p
ortant than hei
g
ht.

5
26. While keeping the head erect, focus eyes on the trampoline toward the perimeter. This will help control
bounce.
27. Avoid bouncing when red. Keep turns short.
28. Properly secure the trampoline when not in use. Protect it against unauthorized use. If a trampoline
ladder is used, the supervisor should remove it from the trampoline when leaving the area to prevent
unsupervised access by children under 6 years of age.
29. Keep objects away which could interfere with the performer. Maintain a clear area around the
trampoline.
30. Do not use the trampoline while under the inuence of alcohol or drugs.
31. For addional informaon concerning the trampoline equipment, contact the customer services Hotline
number 1-877-927-8777.
32. For informaon concerning skill training, contact a cered trampoline instructor.
33. Bounce only when the surface of the bed is dry. Wind or air movement should be calm to gentle. The
trampoline must not be used in gusty or severe winds.
34. Real all instrucons before using the trampoline and trampoline enclosure. Warnings and instrucons for
the care, maintenance, and use of this trampoline and trampoline enclosure are included to promote
safe, enjoyable use of this equipment.
35. Users may become entangled in or strangled by loose cords or in gaps between trampoline and
enclosure.
36. Keep enclosure ghtly fastened to the trampoline in accordance with manufacturer’s instrucons. Failure
to properly assemble and maintain a ght, secure trampoline/enclosure boundary may result in serious
injury, strangulaon, or death.
37. Do not aempt to jump over the barrier.
38. Do not aempt to crawl under the barrier.
39. Do not intenonally rebound o the barrier.
40. Do not hang from, kick, cut, or climb on the barrier.
41. Wear clothing free of drawstrings, hooks, loops or anything that could get caught while using the
trampoline/enclosure and result in entanglement or strangulaon, or both.
42. Do not aach anything to the barrier that is not a manufacturer-approved accessory or part of the
enclosure system.
43. Enter and exit the enclosure only at the enclosure door or barrier opening designated for that purpose.
44. The trampoline frame and the enclosure are made of metal. They are not grounded, and they will
conduct electricity. Therefore, an electrocuon hazard exists.
45. Keep all frame and heat sources away from the product.
24. Learn fundamental bounces and body posions thoroughly before trying more advanced skills. A variety
of trampoline acvies can be carried out by performing the basic fundamentals in various series and
combinaons, performing one fundamental aer another, with or without feet bounces between them.
25. Avoid bouncing too high. Stay low unl bounce control and repeated landing in the center of the
trampoline can be accomplished. Control is more important than height.

6
The placard shown at the below must be attached to the trampoline enclosure by the owner (see assembly
page 21). If the placard is missing or illegible, call our Customer Hotline toll free at 1-877-927-8777,
Monday through Friday, 8 a.m. until 5 p.m. Central Time, to order a free replacement placard.
Note: The placard is not shown actual size.
JKOV1517SL1
Do not attempt or allow
somersaults. Serious injuries,
paralysis, or death may result.
To reduce the chance of
landing on your head or neck,
do not do somersaults(flips).
Do not allow more than one person
on the trampoline at a time.
While keeping the head erect, focus eyes on the trampoline toward the perimeter.
Avoid bouncing when tired.
JKOV1517SL1
WARNING
Use trampoline only with mature,
knowledgeable supervision.
Not recommended for children under 6
years of age.
Read instructions before use.
Inspect before use and replace any worn,
defective or missing parts.
JKOV1517SL1
page 19

1-877-927-8777,

8
21
21

100 220

the
sharply
spot.

15
Lay out all of the parts in groups :
6 Toprails with T-connector with welded tube A marking.
4 Toprails with T-connector B marking.
2 Toprails with T-connector with welded tube C marking.
6 “W” Shaped legs.
12 Extension legs. A
B
C
A
A
x 6 pcs
x 4 pcs
x 2 pcs
x 6 pcs
x 12 pcs
Connect toprail in 6 sections: A+A, B+A, C+B
Layout the W legs and extension legs so that it makes a ‘W’ shape. Join the
3 pieces so the screw holes line up. Repeat this step with the remaining
pieces to make 6 x ‘W’ legs.
B
B
A
Push down on the end of the center leg to fully inset the extension leg into
the T-connector.
Repeat the steps until you have assembled the 6 sections of the trampo-
lines frame.
C

16
You will need two people for this next step.
AA
A
Turn over 1 x Assembly 1 (AB) and 1 x
Assembly 1 (AA)
Join by inserting D into T-connector
A. (Make sure spring hole lines up with
gap in connector)
Repeat this step so you are left with 2
halves of Trampoline
Carefully join the 2 halves together.
For the last section, you will need
someone to stand on the opposite side
if the frame and push towards you
whilst you insert Top-rail into T-
Connector.
D
Locate the V-rings with coloredwebbing.
These will be at 180 to each other.
Colored
webbing
B
A
A
AAAA
A
A
AAA
A
A
A
AAAAA
A
B
B
B
B
CB
C
B
B
B
C
B
B
BB
B
CC
C
A

17
Slot one of the springs onto one of the colored
webbing V-rings as shown.
Important: springs must be slotted on the right way
around.
Attach a spring to the opposite yellow stitched
V-Ring.
Important: You will now need to use the spring
tool to attach the spring to the frame.
Hook the spring tool onto end of spring, and pull
until the spring can be slotted into the spring slot
on the top of the frame.
IMPORTANT: Ensure the spring is fully
inserted into the slot on the top of the frame.
Attach ten more springs on each side of V-Rings then
attach them to the frame next to the top tube.
Continue to attach springs in the same sequence
as above.
Important: The stitched bed is designed like
elastic to be bouncy, which means that during
assembly it may look like it won’t Please
note that it will stretch to the correct size when
attaching the springs, this may take some force.
The stitched bed is now and you have
completed step 3.

18
Lay the Frame Pad (9) on the frame.
Do not use the trampoline without the
Frame Pad (9), which is designed to reduce the
likelihood of injury to the user from coming in con-
tact with the trampoline frame. If you do not
have a Frame Pad, call our Customer Hot Line
toll-free at 1-877-927-8777, Monday-Friday,8 a.m.
-5 p.m. Central Time.(Excluding Holidays)
Properly install the Frame Pad before using the
trampoline.
Thread one end of Elastic Tie-Down, then tie a knot
on V-Ring.
Repeat this step with the remaining straps which at
middle position of each pad section (not shown).
Elastic Tie-Down
Spring
V-Ring
V-Ring
ABC
Frame Pad Frame Pad
Frame Pad
Top tube
Top tube
Top tube
Webbing Webbing Webbing
D-ring D-ring
D-ring
Look under the trampoline and locate the pairs
of straps near the edge of bed(8) and Double
D-ring and webbing near the frame.
See the inset drawing. A, B and C. Repeat this
step with the remaining straps (not shown).
Elastic Tie-Down
Strap with Double D-ring on the pad edge
Safety pad(9)
Safety pad(9)
D-ring
T-connector Webbing
Webbing
Double D-ring in the middle of pad should be
fixed exactly close to the right of T connector
on the top rail.
Double D-rings on the middle of pad should be fixed
exactly on the right of each T-connector of frame.

Using the included plastic tie, attach the Safety
Placard (11) to the frame near the point where
jumpers will climb onto and off the trampoline.
The trampoline is now fully assembled. Make
sure that all parts are securely attached.
Familiarize yourself and all users of the tram-
poline with the safety precautions, use and
instructional materials, and care and mainte-
nance instructions in this manual before using
the trampoline.
Frame
Lay a Straight Tube(12) and a Top Tube (13)
with Plastic Cap on the ground.
Make sure that the Straight Tube (12) is oriented
so the small holes are in the position shown.
Slide a Foam Sleeve (18) onto each of the tubes;
note that the ends of the Straight Tube (12) should
not be covered.
Insert the Straight Tube (12) into the Top tube(13).
Tighten a Self-tapping Screw (14) into the small hole
in the Tube (12,13).
Assemble the remaining Straight Tubes (12), Top
Tubes (13), and Foam Sleeves (18) in the same
way.
Tighten Self-tapping Screw
Into Small Hole
Small Hole
Plastic Cap
(16)
12
13
14
12
19
18
11
18
18
18
Plastic Cap
(16)
T-connector(5)
Straight tube (12)
Insert the end of Straight Pole (12,13) into the hole
of T-connector+Welded tube (5).
Attach the other three Straight Pole (12,13) in the
same way. See inset drawing.
12
13

20
Lay out Top G3 Pole (15), joint each section
Connector to a straight line as shown.
Assemble the remaining Top G3 Pole (15) in the
same way.
Spread the Netting (17) on the trampoline bed,
insert a Top G3 Pole (15) into the opening of
Top Sleeve on the Netting (17). Insert the
other Top G3 Pole (15) into the opposite
opening of Top Sleeve on the Netting (17).
Insert the pole into sleeve of the Netting(17)
Netting(17)
Opening
Joint the end of each pole by Clip of Connector
Start:
Finish
Door of Netting
Top Sleeve
Joint each end of Top G3 Pole (15) by the clip of
connector at each opening. The Top Sleeve of the
Netting (17) become a round shape.
Top G3 Pole (15)
Spread out G3 Pole and Joint each section
to one straight line.
(15)