Kenmore 635.83142 User manual

SAVE THIS MANUAL
FOR FUTURE REFERENCE
OWNERS
MANUAL
MODEL NO.
635.83142
FOR YOUR
SAFETY"
READ ALL
INSTRUCTIONS
CAREFULLY
f
%.
Kenmore TM
Air Cleaning System
Compact Console
Electronic Air Cleaner
irit ,. r
HELP LINE
Ifyou have any questions
_or comments on your Air Cleaning System |_ll
after reading this ;;nual, call: /
1-800-227 3917 _
• Warranty Information
• Getting Started
•Cleaning and Care Tips
•Diagnostic Checklist
•Replacement Parts
• Special Tips J
Sold by Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.

f
The Kenmore Warranty
If, within one year from the date of purchase, this air cleaner falls due to adefect In material or workmanship,
gears will repair or replace It, free of charge.
Warranty service is available by simply _eturnlng the air cleaner to the nearest Sears Service Center
throughout the Unlted States.
This warranty gives you specific legal rights and you may also have other rights which may vary from state
to state.
This warranty DOES NOT cover the charcoal replacement filter.
Department 817WA, Hoffman Estates, IL 60179
f
Introduction
Congratulations!
You are the owner of a Kenmore Air Cleaning System-- one of the best air cleaners made to help improve the
quality of the indoor air you breathe! Your air cleaning system is designed to help you enjoy breathing fresh air.
Your Kenmore Air Cleaner, Model #83142, is ideal for large size rooms (20' x 25_ and has been manufactured for
continuous operation. For best results, operate your air cleaner constantly on low speed.
Please take time to thoroughly read through your owner's manual. Your air cleaning system features a washable
Electronic Filter - just wash, dry and reuse. The Charcoal After-Filter is the only filter you will need to
replace- change approximately every 3 months or as needed. These filters are available at your local Sears
Retail Stores - request Sears Stock #7317.
The outside of the air cleaner can be cleaned using a soft, clean, damp cloth. Never immerse the unit in water.
Ifyou have any questions about the operation of your Kenmore Air Cleaning System, contact the Help Line at
1-800-227-3917.
J
Trust the air you breathe to Kenmor'e.

How the Air Cleaner Works
Four Stages to Cleaner, Fresher Air
The air cleaner fan circulates room air through tl_e unit's
Our different processing stages to help remove pollutants
and household odors.
1=
2.
3,
4.
Large particles like hair and lint are trapped by the
(washable) Pre-Filter.
Smeller particles - dust, smoke, pollen, etc. - pass
through the (washable) Electronic Filter where they
receive an electrical charge.
The charged particles are attracted to aseries of
alternately charged aluminum plates, These particles
remain in the Electronic Filter until removed by
washing,
As the final step in the process, air then passes through
a Charcoal Filter that helps remove household odors.
Getting Started
The air cleaner can be use(] in any room in the house or in
any workspace. Be sure to place it so that air can freely
circulate into the back grill and out through the front grill,
The unit should never be placed on soft surfaces such as
beds or sofas; near computers, radios or TV's; or near
sources ot heat (such as stove tops or ovens). If placing
the back grill against the wall, allow at least 6-8 inches
clearance,
Carefully remove the unit from the protective carton and the
plastic bag coveting the unit. Remove the Filter Access
Cover. Using the filter handle, remove the Electronic Filter
from the cabinet and remove the plastic bag covering
the Charcoal Filter, Return the Charcoal Filter back in its
original position in the Electronic Filter, Install the Electronic
Filter in the air cleaner and replace the Filter Access Cover.
Your air cleaner is now ready for operation, Plug it into a
standard household electrical outlet. (For your conve-
nience, there is a label on the bottom of the unit indicating
electrical specifications and power consumption.)
Charcoal
Filter
F_ont Grill
f
SUPERCLE._
Operation
The operation of the unit is very simple. Turn iton by
setting the rotary switch to the desired speed -- High,
Medium, or Whisper Quiet. (Dry is provided to assist in
drying the filters after cleaning.) The Clean Air light (green)
indicates that the filter is on and working properly.
At any of the three performance speeds (High, Medium or
Whisper Quiet ) you can get an extra power boost by
moving the rocker switch on the control panel from the
Normalto the Super Clean position. Although you won't
hear a difference, the Super Clean position can be used to
increase the cleaning efficiency of the unit.
The speed should be set on High for one minute before switching
to the desired speed to initially start-up the unit.

Cleaning and Care
Periodic cleaning of filters and components will keep your
Kenmore Compact Electronic Air Cleaner running at peak
pedormance. Maintenance is easy and all cleaning can be
done using Zap-ft! (available at Sears, Stock #8395) or
common household cleaners. The following will explain
everything you'll need to know.
There are three components that require attention --- the
Electronic Filler, the Pre-Filter and the Charcoal Filter,
These components should be cleaned about once every
one to two months of continuous use.
Please note that the Charcoal Filter is not to be washed,
However, it can be vacuumed during routine cleaning to
remove lintand dirt build up, This filter will need to be
replaced periodically for maximum effectiveness to help
e/iminafe household odors.
Cleaning Instructions
If the air cleaner is in constant use, the Electronic Filter
requires washing about once a month or once every other
month to remove the particles collected from room air, If
the unit snaps frequently during operation, this is an
indication that the Electronic Filter needs to be cleaned.
Washing the Electronic Fitter
Removing the Electronic Filter
Remove the Filter Access Cover and liftthe filter out of the
cabinet using the handle on the top of the filter.
Removing and Reinstalling
the Filter Access Cover
In order to conduct routine maintenance you'll need to
access the components inside the unitby liftingup and
removing the Filter Access Cover.
After cleaning components inside the air cleaner, reinstall
the Filter Access Cover. Because of a safety feature, the
air cleaner will nut operate if the Filter Access Cover is not
replaced correctly.
Removing Filter Access Cover
];
Before cleaning the Electronic Filter, both the Pre-Filter and
the Charcoal Filter need to be removed.
•Slide the Pro-Filter upward from the front of the Electronic
Filter
• Slide the Charcoal Filter upward from the back ofthe
Electronic Filter
The Electronic Filter is designed so that it can be cleaned
using Zap-lt! or common household detergents. Using dish
washing detergent and hot water, make a good soaking
solution. Completely immerse the Electronic Filler and soak
for 20 to 30 minutes. After the Electronic Filter has soaked
sufficiently, it should be gently agitated in the water until
clean. If the Electronic Filter is extremely dirty, spray itwith
Zap-lt, a cleaning solution made specifically for this air
cleaner. (You can also use a common household cleaner.)
Let the filter soak for five minutes then proceed with the
washing instructions.
Thoroughly rinse both sides of the Electronic Filter. If a
sprayer is available, spray with water. Check to make sure
each layer of the Electronic Filter is clean, Shake as much
water out of the Electronic Filter as possible. Wipe along
the ionizing wires carefully with a cotton swab and alcohol.
After reinstalling the Electronic Filter, operate the unit in the
Dry position for one hour to ensure that it is thoroughly dr_
Failure to do so could cause permanent damage to
Electronic Filter.
The Help Une I 800/227-3917

The Pre-FIIter
The Pre_Filter is located in the front of the [ElectronicFilter.
To clean it, slide it out and rinse thoroughly with clean
warm water. Set it aside to dry.
The Charcoal Ffiter
Althoughthe Charcoal Filter is an optional replacement
filter, we recommend its use for the operation of your air
cleaner to help maintain efficiency.
During normal use, lint and di_t may build up on the Char-
coal Filter and can be removed with a vacuum cleaner
using a brush attachment.
The effectiveness of this Charcoal FUterwill gradually
diminish over time. If your unit is used continuously, it
should be replaced every three months. Replacement
filters are available at Sears retail stores #7317.
Reinstalling the Electronic Filter
First, slide the Pre,Filter into tile slots in the front of the
Electron=c Filter and slide the Charcoal Filter into the slots
provided i_1the back. Using the handle, slide the
Electronic Filter inside the cabinet wall
Note: The Pre.Filter will face the outer wall
Washing Tips:
When handling the Electronic Filter, be careful not to
damage wires or metal plates since this could cause
excessive snapping.
After the first cleaning, the metal surface of the Electronic
Filter may not be as shiny as before. This is normal and
does not reduce effectiveness.

Diagnostic Checklist
Should you ever have any questions or concerns about the
operation of your Kenmore Air Cleaning System, you may
want to check this chart first. It the problem persists, call
our Help Line.
Condition Checkpoints
Unitwon't come on
Unit does not operate st
Whisper Quiet Speed
Unit does not remove
pollutants
Unit snaps
(sparks, crackles, pops)
Interference with Radio and TV
Unit does not operate
properly
Make sure that the power cord
isplugged in
Set the Rotary Switch to the
desired speed
Make sure the Filter Access
Cover is properly installed
Make sure Electronic Filter is
properly installed
Run on High for one minute
then reset to Whisper Quiet
Speed
Wash Electronic Filter
Rernove plastic bag from
Charcoal Filter
Wash the Electronic Filter and
make sure that it is thoroughly
dry
Make sure ionizing wires in
Electronic Filter are not
broken
Check for bent plates in
Electronic Filter - straighten ff
0ossible
Check for large particles such
as hair or lint on ionizing
wires. Remove if possible
Move unit to adifferent
location away from TV or
Radio, Do not operate
unit on the same electrical
outlet as'IV or Radio
Clean Electronic Filter ff dirty
Call Help Line/
Have unit serviced
QUESTIONS & ANSWERS
How can I get the most out of my air cleaner?
For peak efficiency in maintaining air quality, we recom-
mend that the unit be run continuously at least at itsIowes!
speed. The daily operating cost of an electronic air cleaner'
running at the lowest speed is about the same as for a
single 60 watt light bulb, Just pennies aday.
When you use the air cleaner, you'll want to have your
windows closed for maximum efficiency.
My air cleaner makes a snapping sound..,
You may notice an occasional snapping sound coming from
four unit. This is a normal occurrence. It happens when
large particles are charged in the Electronic Filter. Pro-
longed or continuous arcing is an indication that the filter
should be cleaned or that the filter has been damaged.
High humidity may also activate arcing. During those times
when humidity isexcessive, operate your air cleaner in the
Dry speed until the Electronic Filter is completely dry,
Sometimes I notice an unfamiliar smell when I turn the
unit on.
Some owners may notice a "new smell" (like outdoors after_
an electdcal storm) during the first few weeks of operation.
This is not unusual during the break-in pedod. This unit
emits very low levels of ozone; tess than a typical electrical
appliance in your home like a television.
Is the Charcoal Filter necessary for the unit to work?
Although the Charcoal Filter is optional and not required for
f'our air cleaner to function, we do recommend its use to
help reduce household odors.
The Help Line: 1 800/227-3917

fReplacement Parts
Use the model number when requesting service or replacement parts. You'll find it on the name plate attached to
the bottom of the unit, Always order by Part Number, not Key Number,
Key Number _Part Number
1 Filter Access Cover 445826-001
2 Safety Interlock Switch 242404-002
3 Control Switch (5 position) 142581-001
4 Screw, Phillip-Pan Machine #6 x 1/4" (2 required) 137790-001
5 Power Boost Switch 145820-002
6 Control Label 346053-OO1
7 Rotary Switch Knob 242235-002
8 Front Grill 442839-005
9 Screw, Phitlip Sheet Metal #4 x 1/2" (4 required) 143754-002
10 Grill Top 445825-001
11 Pre-Filtar 123324-003
12 Charcoal Filter _3 _ LO0 _.
13 Electronic Filter 422167-005
14 Power Supply Assembly 342402- |_
15 Step-Down Transformer 242331-006
16 Motor 246047-001
17 Fan Blade (order Key# 18 also) 346010-001
18 Screw, PhilUp Sheet Metal #8 x 1/2" 135738-203
19 Coster (4 required) 245998-001
20 Screw, Phillip Hi-Lo #8-18 x 3/8" (4/caster required) 222879-001
21 HV Contact Assembly 242986-002
22 Owner's Manual (not shown) 146070-001
J

Tips from the Kenmore Air Cleaning Specialists
Allergens
As many as one in every six people suffer from allergies, with some of the most common -- hay fever, asthma
and allergic rhinitis -- affecting the respiratory system. Typical allergens are pollen from flowers, grass and trees;
household dust and dust mites; spores from mold and mildew. The Kenmore Air Cleaner can be helpful in filtering
out allergens especially during peak seasons for discomfort.
Tobacco Smoke
The Kenmore Air Cleaner can help alleviate the discomfort of breathing second-hand smoke in your home or
office. The unitfilters visible and microscopic smoke particles and ash particles that can irritate both nonsmokers
and smokers.
Pet Dander
Across the USA, there are millions of cats and dogs in our homes. Although we love our pets, hair end dander
can cause problems and be a nuisance to people. The Kenmore Air Cleaner can help remove these substances
from the air.
Viruses/Bacteria
The Kenmore Air Cleaner helps reduce morn air of viruses and bacteria that can spread germs throughout your
home or workspace.
Technical Spec_lfications
Dimensions:
Weight:
CFM:
Input Voltage:
Power Consumption:
Model No:
12" Lx 12"Wx 19.5"H
38 Ibs
By settings
High 2O0
Medium 165
Whisper Quiet 80
120V, 60 Hz
120 Watts on High Setting
635.83142
J
Sears Roebuck and Co.
3333 Beverly Road
Hoffman Estates, IL 60179
The Help Line: 1/800/227-3917
Part No. 146070-001