Kogan KIDS RIDE-ON FIRE ENGINE User manual

KIDS RIDE-ON FIRE ENGINE
KARDONFRENA

•Remove batteries from the toy once depleted, including rechargeable batteries.
•Rechargeable batteries are only to be charged under adult supervision.
•Not to be used in traffic.
•This toy has no brakes.
•The toy should be used with caution as skill is required to avoid falls or collisions
causing injury to the user or third parties.
•Inserted batteries with the correct polarity.
•Do not attempt to repair this product yourself. If the product or its power supply
experiences any malfunction or damage, stop using it immediately and contact
Kogan.com to arrange a repair.
Caution for Safety
•The product must be assembled by adults. Before use, check whether the adult
assembles correctly according to the instructions.
•Keep children away from plastic bags and especially from covering their heads as
plastic bags pose a choking hazard.
•Do not allow children under 3 years of age to use the product as it contains small
parts which may pose a hazard.
•Children should wear safety helmets during use and must be supervised by adults
at all times.
•The product is for use by one person at a time only. The weight limit is 20kg and
the general recommended age is 3–8 years.
•The product should only be driven on flat surfaces and not on streets, slopes or in
any other dangerous places.
•When the product moving, the user should not be free to turn forward, backward
switch, after the product stopped, then can switch the forward and backward
switch.
•Do not push the product while it is being driven as this may pose a risk of rollover.
•The battery charger must only be operated by an adult. Do not let children charge
the battery.
•Do not wash the product with water or allow it to be exposed to rain.
•The wiring, plugs, electrical system, housing, steering systems and fastening
should be inspected by an adult every two weeks for normal function. If there is any
abnormality, do not use the product.
SAFETY & WARNINGS

•Use only the supplied compatible battery and charger and charge at a stable
voltage to ensure safety when charging and extend battery life.
•Spare parts should only be replaced by an adult. The battery is very heavy and any
contact with liquid must be avoided, especially if there is any leakage. If there is
any accidental contact with battery acid, rinse the affected area with cold water
for at least 15 minutes and seek medical treatment.
•Avoid power short circuits to prevent the risk of burning.
•Do not store the product in sunlight, high-temperature places or near fire as plastic
parts may melt and some parts are flammable
•Do not replace the fuse with one of different specification.
•Don’t recharge non-rechargeable batteries and don’t mix old and new batteries or
different types of batteries. Dispose of batteries safely and in an environmentally-
friendly manner.
•If the product will not be used for a long period of time, remove the battery and set
the power to off.
•Store the packaging and documentation for future reference.
Fused Tube
The vehicle uses a self-tapping fuse.
When overloading or improper use is detected, the fuse will automatically cut off in 10-20
seconds before automatically connecting power.
To avoid power cutoff, note the following:
•The maximum weight capacity of the product is 20kg.
•Do not stall the product while it is running tow any heavy loads.
•Do not expose the product to or immerse it in liquid as this may cause a short
circuit.
•Do not alter the vehicle’s circuitry or structure.

Exploded Diagram
OVERVIEW

①
Body x1
②
Wheel x3
③
Driving wheel x1
④
Round of shares x1
⑤
Steering wheel x1
4x45 Machine screws x1
4MM nut x1
⑥
10mm spacer x7
⑦
8 MM NUT x4
⑧
Motor x1
⑨
Bubble gun x1
⑩
Bubble bottle x1
⑪
Charger x1

Assembly Chart
Attach the Bubble
bottle to the
Bubble Gun
ASSEMBLY

Attention: Before assembling the steering wheel, connect the parts on the steering wheel
with the matching parts on the car body.
When assembling the bubble gun, connect the plug on the bubble gun to the body and
align the card buckle on the bubble gun with the card slot on the body. Then rotate
clockwise to attach the bubble gun to the body.

Charging
Connect the charger from the vehicle’s charging port to a stable AC power point.
Note:
•Charging should only be performed by adults.
•Charge for 8-12 hours before first use.
•Do not charge the battery for over 15 hours.
•Cannot open or decompose the battery and charger, should use the matched
charger and battery.
•Do not store the battery upside down while it is charging.
OPERATION

Product Functions
Step on the pedal switch to engage the vehicle.
Press the forward/backward switch to move the vehicle front and back.
Use the power switch for to turn the car on or off.
See other functions as labelled below:
Operation time is up to 1 hour on a full charge, depending on load.
Bubble Gun Switch
Power
Forward Backward
Switch
Alarm lamp Switch
Pedal Switch
HORN
MUSI
C

•Use a soft, dry cloth to wipe the exterior of the product. Do not wash the product
with water or allow it to be exposed to rain. Do not use abrasive cleaners as they
may lead to corrosion or damage the electrical systems.
•The wiring, plugs, electrical system, housing, steering systems and fastening
should be inspected by an adult every two weeks for normal function. If there is any
abnormality, do not use the product.
•Do not store the product in sunlight, high-temperature places or near fire as plastic
parts may melt and some parts are flammable
•If the product will be stored for a long time, charge the battery fully, remove it and
set the power to off. Recharge it every 3 months to extend battery lifetime.
External dimensions
88x42x52cm
Power Mode
Rechargeable
Recommended age
3-8 years
Charging Spec
6V 500mA
Weight limit
20 KGS
Charging Time
8-12 hours.
Speed
3 km/hr
Power life
Approx. 280 recharges
Battery Spec
6V 4.5AH
Fuse Type
Self-resetting
CLEANING & CARE
SPECIFICATIONS

Vehicle does not move
•Ensure forward and back switch is not in neutral (middle) position
•Ensure the power’s positive and negative cord is connected firmly
•Check for the fuse for damage
•Ensure the product is disconnected from the charger
•Ensure the foot switch and is not stuck
•Ensure the wheels are clear of debris
Vehicle moves slowly
•Charge the vehicle
•Ensure the wheels are clear of debris
•Ensure the vehicle is not overloaded
•Ensure the charger is functional and undamaged
Battery cannot be fully charged
•Ensure the charger and battery are functional and undamaged
•Ensure the charger and battery connections are not loose
TROUBLESHOOTING

Body*1
Wheel*3
Driving Wheel*1
Round of shares*4
Steering wheel*1
4*45 Machine screw*1
4MM nut*1
10mm spacer*7
8MM nut*4
Motor*1
Bubble gun*1
Bubble Bottle*1
Charger*1
IN THE BOX

NOTES

Need more information?
We hope that this user guide has given you
the assistance needed for a simple set-up.
For the most up-to-date guide for your product,
as well as any additional assistance you may require,
head online to help.kogan.com