Life Fitness 90R Configuration guide

10-XXX0-R09R09elcyCefiL
pudna100001ARLN/SylbmessAlareneG
Description Part No.
Service Manual M051-00K39-A012
Operation Manual M051-00K39-A020
Accessory Tray AK39-00052-0003
Hardware Bag GK39-00002-0008
Polar Upgrade Kit GK39-00002-0001
Console Overlay
Bezel Assembly
Left Pedal
End Cap
Leveler
Accessory Tray
& Seat Pads
Wheel
Right
Pedal
Console
Support
Assembly
Belts
Resistor
Assembly
Shrouds
Power
Control
Board
Alternator
Assembly
Crank Shaft&
Bearing Assembly
Intermediate Shaft&
Bearing Assembly
Idler Bracket
Seat Assembly
Extrusion
Assembly
Lock
Assembly
Cable
Seat Frame
Assembly
Seat Assembly
Bottom
revised Nov 2014

2
Life Cycle 90R 90R-0XXX-01
Console Assembly S/N LRA100001 and up
Part No.
Language Console Assembly
Overlay Bezel
Eng Met AK39-00072-0001 AK63-00167-0001
Eng Met AK39-00072-0002 AK63-00167-0002
Ger Met AK39-00072-0003 AK63-00167-0003
Spn Met AK39-00072-0004 AK63-00167-0004
Frn Met AK39-00072-0007 AK63-00167-0007
Itl Met AK39-00072-0008 AK63-00167-0008
Dut Met AK39-00072-0009 AK63-00167-0009
Por Met AK39-00072-0010 AK63-00167-0010
Console Board -Upper
A084-92220-A006
Console Case Assembly
AK63-00121-0000
Case
0K63-01028-0001
Battery Door
0K63-01029-0001
Phillips Pan Screws(13)
0017-00101-1650
Overlay Bezel/Switch Assembly
Decal
0K63-01277-0000
9V Battery
0017-00003-0757

3
Life Cycle 90R 90R-0XXX-01
Console Support Assembly S/N LRA100001 and up
10-Pin Connector
Main Wiring Cable
Console Support
AK39-00003-0001
Console Mounting
Screw(4)
0017-00101-1744
Frame Post
Frame Post Bolt(4)
0017-00101-1756
Grip(2)
0K39-01005-0001

4
Life Cycle 90R 90R-0XXX-01
Shrouds, End Cap, Crank Arm S/N LRA100001 and up
End Cap
AK39-00050-0005
Decal
0K51-01085-0001
End Cap Screws(2)
0017-00101-1614
Left Shroud
AK39-00033-0008
Decal
0K39-01070-0000
Left Pedal
AK63-00123-0004
Pedal Strap
(not shown)
0K63-01237-0004
Shroud Screws(4)
0017-00101-1741
Right Shrou
d
AK39-00033-0007
Decal
0K39-01070-0000
Right Pedal
AK63-00123-0003
Pedal Strap (not shown)
0K63-01237-0003
Crank Arm, RT
0K39-01042-0005
Screws(3)
0017-00101-1702
Shroud Screws(7)
0017-00101-1741
Crank Arm, LT
0K39-01042-0006
Screws(3)
0017-00101-1702
Seal
0K39-01002-0001

5
Life Cycle 90R 90R-0XXX-01
Belts S/N LRA100001 and up
Alternator Belt
0017-00009-0735
Intermediate
Pulley Belt
GK63-00002-0079
Screw
0017-00101-1193

6
Life Cycle 90R 90R-0XXX-01
Resistor Assembly S/N LRA100001 and up
Resistor
100E-00002-0084
Resistor Cable
Pan Screw(2)
0017-00101-1282
W
asher(2)
0017-00104-0309
Retainer
0K39-01043-0000
Hex Nut(3)
0017-00103-0081
Mounting Rod
0K63-01166-0000
Bracket
0K39-01036-0000

7
Life Cycle 90R 90R-0XXX-01
Power Control Board S/N LRA100001 and up
Bracket
0K39-01027-0000
Philips Screws (4)
0017-00101-0832
Bracket Screws (2)
0017-00101-1193
Plastic Gromments (4)
0017-00042-0821
Power Control Board
B084-92064-A000

8
Life Cycle 90R 90R-0XXX-01
Alternator Assembly – AK63-00093-0000 S/N LRA100001 and up
A
lternator Pulley
0K61-02500-0001
A
lternator
0017-00009-0841
Locking Nut
0017-00103-0117 Washer
0017-00104-004
4
Bolt
0017-00101-0956
Brushes
0017-00009-0895

9
10-XXX0-R09R09elcyCefiL
Crank Shaft and Bearing As pudna100001ARLN/Sylbmes
*Small Thrust Washer(2)
0K63-01129-0000
*Needle Bearing(2)
0K63-01344-0000
*Large Thrust Washer(2)
0K63-01129-0001
*Small Snap Ring(2)
0017-00100-0241
*Bowed Retainer Ring(2)
0017-00100-0243
Washer(2)
0017-00104-0409
Bolt(2)
0017-00101-1705
Flywheel Screws(3)
0017-00101-1715
Washers(3)
0017-00104-00458
Pulley Assemlby
AK63-00051-0000
Pully
0K63-01018-0000
Crank Arm Hub
*Crank Shaft
*Crank Shaft & Bearing Kit
GK63-00002-0077
Crank Arm Hub(2)
0K63-01095-0001

10
Life Cycle 90R 90R-0XXX-01
Intermediate Shaft and Bearing Kit Assembly S/N LRA100001 and up
Intermediate
Bearings (2,
not available
separately)
Spacer (not
available
separately)
Intermediate Pulley
(not available separately)
Intermediate Shaft and
Bearing Assembly Kit
GK63-00002-0007
Magnet
118E-00001-0124
(not included in kit)
Retaining Ring
0017-00100-0242
Delrin Washers (2)
0017-00104-0455
Clutch Assembly
GK63-00002-0079
(not included in kit)