Manitou 150 AETJ C User manual

768740EN (19/02/2008)
THIS PERSONNEL LIFTING PLATFORM IS DESIGNED TO MANOEUVRE IN WORKSHOPS,
INDUSTRIAL WAREHOUSES OR ON CONSTRUCTION SITES.
This document is a simplied reminder of how to drive a personnel lifting platform and, under no circumstances, should be used as a substitute for the
instructions manual required by CE Directive 98/37/CE Appendix 1 § 1.7.4, which the operator must have previously read and fully understood and which
must be available in the lifting platform’s basket. All the safety instructions and advice described in the manual and not repeated in this document must
continue to be applied and observed.The operator must have received adequate training and must comply with the prevailing ground trac regulations.
BASIC INSTRUCTIONS SHEET 150 AETJ C
TECHNICAL CHARACTERISTICS
GROUND CONTROL & EMERGENCY STATION
BASKET CONTROL STATION
WEIGHT OF THE LIFTING PLATFORM
Unladen 6700 kg
Under nominal load 6900 kg
BASKET CAPACITY
2 people, indoors 200 kg
WEIGHT OF THE ONBOARD EQUIPMENT IN THE BASKET
1 person in the basket 120 kg
2 people in the basket 40 kg
SPEED
Work speed 0.6 km/h
Transport speed 5 km/h
DIMENSIONS
A = 6050 mm
A1 = 4400 mm
B = 2000 mm
C = 1965 mm
C1 = 2080 mm
D = 1500 mm
E = 143 mm
1 - EMERGENCy STOP
2 - KEy-OPERATED CONTROL SELECTOR SWITCH AT GROUND
LEVEL OR IN THE BASKET
3 - OVERLOAD LAMP
4 - «MACHINE MAINTENANCE» AND VARIATOR FAULTS LAMP
5 - «BATTERy CHARGE STATE» LAMP
6 - «DEAD MAN» BUTTON
7 - BATTERy CHARGE INDICATOR AND THE HOUR METER
8 - BASKET ROTATION CONTACTOR
9 - RAISE AND LOWER CONTACTOR OF THE ExTENSION ARM
10 - ROTATION CONTACTOR FOR ROTATED jIB (OPTION)
11 - TELESCOPE OUTPUTS AND INPUTS CONTACTOR
12 - RAISE AND LOWER CONTACTOR OF THE SUPERIOR ARM
13 - INFERIOR ARMS LIFTING / RAISING CONTACTOR
14 - TURRET ROTATION CONTACTOR
15 - BASKET TILT CONTACTOR
16 - EMERGENCy STOP
17 - BASKET TILT SWITCH
18 - ExTENSION ARM LIFTING / LOWERING CONTACTOR
19 - TELESCOPE OUTPUTS / INPUTS CONTACTOR
20 - SUPERIOR ARM LIFTING / RAISING CONTACTOR
21 - SUPERIOR ARMS LIFTING / RAISING CONTACTOR
22 - OVERLOAD LAMP AND VARIATOR DEFECTS
23 - TILT LAMP
24 - jOySTICK
25 - CONSOLE PROTECTIVE COVER
26 - TRANSLATION CONTACTOR
27 - BASKET TILT SWITCH
28 - BUZZER CONTROL BUTTON
D
E
B
C1
A1
C
A
8
345
613
10
911 12
14
1
215
7
22
23
24
16
17
18
19
20
21
26
27
28
25
www.duma-rent.com
www.duma-rent.com

768740EN (19/02/2008)
DAILY MAINTENANCE
CHECK THE BATTERY CHARGE CHARGE THE BATTERIES BATTERY TRAYS ELECTROLYTE LEVEL IN THE
BATTERIES
CHECK THE HYDRAULIC OIL
LEVEL
OPERATING THE PLATFORM
ELECTRICAL RISK TILT AND OVERLOAD
TURRET ROTATION BLOCKING
MANUAL EMERGENCY PUMP
• Before using the platform, check the condition of the ground and the supporting surfaces. • Do not use the lifting platform, if the wind speed is over 45km/h.
• Remember to mark out the lifting platform’s complete operating area.
Do not travel or work near any sources of electricity.Maximum permissible tilt or slope: 5% or 3°
When the maximum permissible tilt is reached, a buzzer sounds intermittently.Overload :
If the basket is overloaded, a buzzer sounds continuously.Do not forget to remove it when using the platform.This manual pump allows all movements of the platform to allow a return to the ground in case of failure (see adhesive in the right cover of the turret). Only to be used in the event of breakdown of the electrical control system.We draw the attention of operators on the risks associated with the use of the lifting platform, including:
- Risk of loss of control.
- Risk of loss of lateral stability of the lifting platform.
- Wearing a safety helmet and a safety harness is REQUIRED when using the lifting platform.
EMERGENCY PROCEDURE
If the operator should be taken ill or should become incapable of manoeuvring the machine, the person on the ground can take over the lifting platform’s controls by following the instructions below: - Move switch 2 to position A to take over control of the lifting platform’s movements. - Proceed to lower the basket. Pay attention to any structures or items that may be located under the basket.MANIPULATOR BELLOWS
STATE
3°
A
2
www.duma-rent.com
www.duma-rent.com