Mcs master B 35cel Manual

B 35CEL - B 65CEL - B 95CEL - B 145CEL

B 35CED - B 70CED - B 100CED - B 150CED - B 300CED

B 35CEG - B 70CEG - B 100CEG - B 150CEG

USER AND MAINTENANCE BOOK

en

LIBRETTO USO E MANUTENZIONE

it

BEDIENUNGS- UND WARTUNGSANLEITUNG

de

MANUAL DE INSTRUCCIONES PARA EL USO Y MANTENIMIENTO

es

MANUEL D’UTILISATION ET DE MAINTENANCE

fr

HANDLEIDING VOOR GEBRUIK EN ONDERHOUD

nl

MANUAL DE USO E MANUTENÇÃO

pt

VEJLEDNING OM BRUG OG VEDLIGEHOLDELSE

da

KÄYTTÖ- JA HUOLTO-OHJE



HEFTE FOR BRUK OG VEDLIKEHOLD

no

ANVÄNDAR- OCH UNDERHÅLLSHANDBOK

sv

INSTRUKCJA OBSŁUGI I KONSERWACJI

pl

РУКОВОДСТВО ПО ЭКСПЛУАТАЦИИ И ТЕХНИЧЕСКОМУ ОБСЛУЖИВАНИЮ

ru

PŘÍRUČKA PRO POUŽITÍ A ÚDRŽBU

cs

HASZNÁLATI ÉS KARBANTARTÁSI KÉZIKÖNYV

hu

PRIROČNIK Z NAVODILI ZA UPORABO IN VZDRŽEVANJE

sl

KULLANIM VE BAKIM K

i

TAPÇIĞI

tr

KNJIŽICA O UPORABI I ODRŽAVANJU

hr

NAUDOJIMO IR PRIEŽIŪROS KNYGELĖ

lt

LIETOŠANAS UN TEHNISKĀS APKOPES GRĀMATIŅA

lv

KASUTUS- JA HOOLDUSJUHEND

et

MANUAL DE UTILIZARE ŞI ÎNTREŢINERE

ro

PRÍRUČKA PRE POUŽITIE A ÚDRŽBU

sk

НАРЪЧНИК ЗА ИЗПОЛЗВАНЕ И ПОДДРЪЖКА

bg

КЕРІВНИЦТВО З ЕКСПЛУАТАЦІЇ Й ТЕХНІЧНОГО ОБСЛУГОВУВАННЯ

uk

KNJIŽICOM O UPOTREBI I ODRŽAVANJU

bs

ΕΓΧΕΙΡΙΔΙΟ ΧΡΗΣΗΣ ΚΑΙ ΣΥΝΤΗΡΗΣΗΣ

el

使用和维护手册

zh

ПАЙДАЛАНУ МЕН ТЕХНИКАЛЫҚ ҚЫЗМЕТ КӨРСТЕУ БОЙЫНША ЖЕТЕКШІЛІК

kk

4100.206 Edition 19 - Rev. 07

Dantherm S.p.A.

Via Gardesana 11, -37010-

Pastrengo (VR), Italy

Dantherm S.p.A.

Виа Гардесана 11, 37010

Пастренго (Верона), Италия

Dantherm Sp. z o.o.

ul. Magazynowa 5A,

62-023 Gądki, Poland

Dantherm Sp. z o.o.

ул. Магазинова, 5A,

62-023 Гадки, Польша

Dantherm LLC

ul. Transportnaya - 22 ownership 2,

142802, STUPINO, Moscow region, Russia

ООО «Дантерм»

Ул. Транспортная, владение 22/2,

142802, г.Ступино, Московская обл., РФ

Dantherm China LTD

Unit 2B, 512 Yunchuan Rd.,

Shanghai, 201906, China

Dantherm China LTD

Юньчуань роад, 512, строение 2В,

Шанхай, 201906, Китай

Dantherm SP S.A.

C/Calabozos, 6 Polígono Industrial, 28108

Alcobendas (Madrid) Spain

Dantherm SP S.A.

Ц/Калабозос, 6 Полигоно Индустриал,

28108 Алкобендас (Мадрит) Испания

TECHNICAL DATA TABLE - TABELLA DATI TECNICI - TECHNISCHE DATEN

- TABLA DE DATOS TÉCNICOS - TABLEAU DES DONNEES TECHNIQUES -

TABEL TECHNISCHE GEGEVENS - TABELA DE DADOS TÉCNICOS - TABEL

OVER TEKNISKE DATA - TEKNISET TIEDOT SISÄLTÄVÄ TAULUKKO -

TABELL MED TEKNISKE DATA - TABELL ÖVER TEKNISKA DATA - TABELA

DANYCH TECHNICZNYCH - ТАБЛИЦА ТЕХНИЧЕСКИХ ДАННЫХ - TABULKA

TECHNICKÝCH ÚDAJŮ - MŰSZAKI ADATTÁBLÁZAT - PREGLEDNICA

TEHNIČNIH PODATKOV - TEKNÝK VERÝLER TABLOSU - TABLICA SA

TEHNIČKIM PODACIMA - TECHNINIŘ DUOMENŘ LENTELË - TEHNISKO DATU

TABULA - TEHNILISTE ANDMETE TABEL - TABEL DATE TEHNICE - TABUĽKA

TECHNICKÝCH ÚDAJOV - ТАБЛИЦА ТЕХНИЧЕСКИ ДАННИ - ТАБЛИЦЯ

ТЕХНІЧНИХ ДАНИХ - TABELA S TEHNIČKIM PODACIMA - ΠΙΝΑΚΑΣ

ΤΕΧΝΙΚΩΝ ΣΤΟΙΧΕΙΩΝ - 技术参数 - TЕХНИКАЛЫҚ КӨРСЕТКІШТЕР КЕСТЕСІ

B 35CEL B 65CEL B 95CEL B 145CEL

MAX

10 kW-кВт

8.600 kcal/h-ккал/ч

34.200 Btu/h-БТЕ/ч

18,5 kW-кВт

15.900 kcal/h-ккал/ч

63.100 Btu/h-БТЕ/ч

29 kW-кВт

25.000 kcal/h-ккал/ч

99.300 Btu/h-БТЕ/ч

44 kW-кВт

37.900 kcal/h-ккал/ч

150.500 Btu/h-БТЕ/ч

280 m³/h-м³/ч 400 m³/h-м³/ч 800 m³/h-м³/ч 900 m³/h-м³/ч

0,8 kg/h-кг/ч 1,5 kg/h-кг/ч 2,3 kg/h-кг/ч 3,5 kg/h-кг/ч

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

15 l-л 19 l-л 44 l-л 44 l-л

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

0,35 A

0,08 kW-кВт

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

0,8 A

0,18 kW-кВт

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

1 A

0,23 kW-кВт

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

1,2 A

0,28 kW-кВт

RPM 1425 2850 2850 2850

0,20 bar-бар 0,36 bar-бар 0,27 bar-бар 0,34 bar-бар

IMPORTANT: In order to have a correct function you must use an electrical generator in class G3 or more (frequency va-

riation ±1%, tension variation ±2%). The maximum power of electrical generator must be three time the nominal power of device

that you must connected.

B 35CED B 70CED

MAX

10 kW-кВт

8.600 kcal/h-ккал/ч

34.200 Btu/h-БТЕ/ч

20 kW-кВт

17.200 kcal/h-ккал/ч

68.300 Btu/h-БТЕ/ч

280 m³/h-м³/ч 400 m³/h-м³/ч

0,8 kg/h-кг/ч 1,6 kg/h-кг/ч

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

15 l-л 19 l-л

~220-240 V-В

(-15%÷10%)

50/60 Hz-Гц

0,35 A

0,08 kW-кВт

~220-240 V-В

(-15%÷10%)

50/60 Hz-Гц

0,8 A

0,18 kW-кВт

RPM 1425 2850

0,20 bar-бар 0,36 bar-бар

IMPORTANT: In order to have a correct function you must use an electrical generator in class G3 or more (frequency va-

riation ±1%, tension variation ±2%). The maximum power of electrical generator must be three time the nominal power of device

that you must connected.

TECHNICAL DATA TABLE - TABELLA DATI TECNICI - TECHNISCHE DATEN

- TABLA DE DATOS TÉCNICOS - TABLEAU DES DONNEES TECHNIQUES -

TABEL TECHNISCHE GEGEVENS - TABELA DE DADOS TÉCNICOS - TABEL

OVER TEKNISKE DATA - TEKNISET TIEDOT SISÄLTÄVÄ TAULUKKO -

TABELL MED TEKNISKE DATA - TABELL ÖVER TEKNISKA DATA - TABELA

DANYCH TECHNICZNYCH - ТАБЛИЦА ТЕХНИЧЕСКИХ ДАННЫХ - TABULKA

TECHNICKÝCH ÚDAJŮ - MŰSZAKI ADATTÁBLÁZAT - PREGLEDNICA

TEHNIČNIH PODATKOV - TEKNÝK VERÝLER TABLOSU - TABLICA SA

TEHNIČKIM PODACIMA - TECHNINIŘ DUOMENŘ LENTELË - TEHNISKO DATU

TABULA - TEHNILISTE ANDMETE TABEL - TABEL DATE TEHNICE - TABUĽKA

TECHNICKÝCH ÚDAJOV - ТАБЛИЦА ТЕХНИЧЕСКИ ДАННИ - ТАБЛИЦЯ

ТЕХНІЧНИХ ДАНИХ - TABELA S TEHNIČKIM PODACIMA - ΠΙΝΑΚΑΣ

ΤΕΧΝΙΚΩΝ ΣΤΟΙΧΕΙΩΝ - 技术参数 - TЕХНИКАЛЫҚ КӨРСЕТКІШТЕР КЕСТЕСІ

B 100CED B 150CED B 300CED

MAX

29 kW-кВт

25.000 kcal/h-ккал/ч

99.300 Btu/h-БТЕ/ч

44 kW-кВт

37.900 kcal/h-ккал/ч

150.500 Btu/h-БТЕ/ч

88 kW-кВт

75.800 kcal/h-ккал/ч

301.000 Btu/h-БТЕ/ч

800 m³/h-м³/ч 900 m³/h-м³/ч 1.800 m³/h-м³/ч

2,3 kg/h-кг/ч 3,5 kg/h-кг/ч 7 kg/h-кг/ч

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

44 l-л 44 l-л 105 l-л

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

1 A

0,23 kW-кВт

~220-240 V-В

(-15%÷10%)

50/60 Hz-Гц

1,2 A

0,28 kW-кВт

~220-240 V-В

(-15%÷10%)

50/60 Hz-Гц

2,4 A

0,56 kW-кВт

~220-240 V-В

(-15%÷10%)

60 Hz-Гц

1 A

0,23 kW-кВт

RPM 2850 2850 2850

0,27 bar-бар 0,34 bar-бар 0,40 bar-бар

IMPORTANT: In order to have a correct function you must use an electrical generator in class G3 or more (frequency va-

riation ±1%, tension variation ±2%). The maximum power of electrical generator must be three time the nominal power of device

that you must connected.

TECHNICAL DATA TABLE - TABELLA DATI TECNICI - TECHNISCHE DATEN

- TABLA DE DATOS TÉCNICOS - TABLEAU DES DONNEES TECHNIQUES -

TABEL TECHNISCHE GEGEVENS - TABELA DE DADOS TÉCNICOS - TABEL

OVER TEKNISKE DATA - TEKNISET TIEDOT SISÄLTÄVÄ TAULUKKO -

TABELL MED TEKNISKE DATA - TABELL ÖVER TEKNISKA DATA - TABELA

DANYCH TECHNICZNYCH - ТАБЛИЦА ТЕХНИЧЕСКИХ ДАННЫХ - TABULKA

TECHNICKÝCH ÚDAJŮ - MŰSZAKI ADATTÁBLÁZAT - PREGLEDNICA

TEHNIČNIH PODATKOV - TEKNÝK VERÝLER TABLOSU - TABLICA SA

TEHNIČKIM PODACIMA - TECHNINIŘ DUOMENŘ LENTELË - TEHNISKO DATU

TABULA - TEHNILISTE ANDMETE TABEL - TABEL DATE TEHNICE - TABUĽKA

TECHNICKÝCH ÚDAJOV - ТАБЛИЦА ТЕХНИЧЕСКИ ДАННИ - ТАБЛИЦЯ

ТЕХНІЧНИХ ДАНИХ - TABELA S TEHNIČKIM PODACIMA - ΠΙΝΑΚΑΣ

ΤΕΧΝΙΚΩΝ ΣΤΟΙΧΕΙΩΝ - 技术参数 - TЕХНИКАЛЫҚ КӨРСЕТКІШТЕР КЕСТЕСІ

B 35CEG B 70CEG B 100CEG B 150CEG

MAX

10 kW-кВт

8.600 kcal/h-ккал/ч

34.200 Btu/h-БТЕ/ч

20 kW-кВт

17.200 kcal/h-ккал/ч

68.300 Btu/h-БТЕ/ч

29 kW-кВт

25.000 kcal/h-ккал/ч

99.300 Btu/h-БТЕ/ч

44 kW-кВт

37.900 kcal/h-ккал/ч

150.500 Btu/h-БТЕ/ч

280 m³/h-м³/ч 400 m³/h-м³/ч 800 m³/h-м³/ч 900 m³/h-м³/ч

0,8 kg/h-кг/ч 1,6 kg/h-кг/ч 2,3 kg/h-кг/ч 3,5 kg/h-кг/ч

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

DIESEL-KEROSENE

дизель-керосин

15 l-л 19 l-л 44 l-л 44 l-л

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

0,35 A

0,08 kW-кВт

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

0,8 A

0,18 kW-кВт

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

1 A

0,23 kW-кВт

~220-240 V-В

(-15%÷10%)

50 Hz-Гц

1,2 A

0,28 kW-кВт

RPM 1425 2850 2850 2850

0,20 bar-бар 0,36 bar-бар 0,27 bar-бар 0,34 bar-бар

IMPORTANT: In order to have a correct function you must use an electrical generator in class G3 or more (frequency va-

riation ±1%, tension variation ±2%). The maximum power of electrical generator must be three time the nominal power of device

that you must connect.

TECHNICAL DATA TABLE - TABELLA DATI TECNICI - TECHNISCHE DATEN

- TABLA DE DATOS TÉCNICOS - TABLEAU DES DONNEES TECHNIQUES -

TABEL TECHNISCHE GEGEVENS - TABELA DE DADOS TÉCNICOS - TABEL

OVER TEKNISKE DATA - TEKNISET TIEDOT SISÄLTÄVÄ TAULUKKO -

TABELL MED TEKNISKE DATA - TABELL ÖVER TEKNISKA DATA - TABELA

DANYCH TECHNICZNYCH - ТАБЛИЦА ТЕХНИЧЕСКИХ ДАННЫХ - TABULKA

TECHNICKÝCH ÚDAJŮ - MŰSZAKI ADATTÁBLÁZAT - PREGLEDNICA

TEHNIČNIH PODATKOV - TEKNÝK VERÝLER TABLOSU - TABLICA SA

TEHNIČKIM PODACIMA - TECHNINIŘ DUOMENŘ LENTELË - TEHNISKO DATU

TABULA - TEHNILISTE ANDMETE TABEL - TABEL DATE TEHNICE - TABUĽKA

TECHNICKÝCH ÚDAJOV - ТАБЛИЦА ТЕХНИЧЕСКИ ДАННИ - ТАБЛИЦЯ

ТЕХНІЧНИХ ДАНИХ - TABELA S TEHNIČKIM PODACIMA - ΠΙΝΑΚΑΣ

ΤΕΧΝΙΚΩΝ ΣΤΟΙΧΕΙΩΝ - 技术参数 - TЕХНИКАЛЫҚ КӨРСЕТКІШТЕР КЕСТЕСІ

NOTE:_____________________________________________________________

____________________________________________________________________

FIGURES - FIGURE - ABBILDUNGEN - FIGURAS - FIGURES - FIGUREN - FI-

GURAS - FIGURER - KUVAT - FIGURER - BILDER - RYSUNKI - РИСУНКИ - OB-

RÁZKY - ÁBRÁK - SLIKE - ŞEKİLLER - SLIKE - PAVEIKSLĖLIAI - ATTĒLI - JO-

ONISED - FIGURI - OBRÁZKY - СХЕМИ - МАЛЮНКИ - SLIKE - ΕΙΚΟΝΕΣ - 图

- СУРЕТТЕР

7

1

2

34

56

8

9 10

1

FIGURES - FIGURE - ABBILDUNGEN - FIGURAS - FIGURES - FIGUREN - FI-

GURAS - FIGURER - KUVAT - FIGURER - BILDER - RYSUNKI - РИСУНКИ - OB-

RÁZKY - ÁBRÁK - SLIKE - ŞEKİLLER - SLIKE - PAVEIKSLĖLIAI - ATTĒLI - JO-

ONISED - FIGURI - OBRÁZKY - СХЕМИ - МАЛЮНКИ - SLIKE - ΕΙΚΟΝΕΣ - 图

- СУРЕТТЕР

7

1

2

34

56

8

9 10

1

IMPORTANT: READ AND UNDERSTAND THIS OPERATIONAL MANUAL

BEFORE PERFORMING ASSEMBLY, COMMISSIONING OR MAINTENANCE

ON THIS HEATER. INCORRECT USE OF THE HEATER CAN CAUSES

SERIOUS INJURY.

KEEP THIS MANUAL FOR FURTHER REFERENCE.

1. INFORMATION REGARDING

SAFETY

WARNINGS

IMPORTANT: This air heater has

been designed for mobile and temporary

professional applications. It has not been

designed for domestic use nor for thermal

comfort of human.

IMPORTANT: This appliance is not

intended for use by persons (including

children) with reduced physical, senso-

ry and mental capacities or with lack of

experience or knowledge unless super-

vised by a person responsible for their

safety. Children must be supervised to

make sure they neither do nor play with

the appliance.

DANGER: Su󰀨ocation by carbon

monoxide can be fatal.

The rst symptoms of su󰀨ocation by

carbon monoxide are similar to those of

u with headache, light-headedness and/or

nausea. These symptoms could be caused

by the faulty functioning of the heater. IF

THESE SYMPTOMS SHOULD OCCUR, DO

OUTDOORS IMMEDIATELY and have the

generator repaired by a technical after-

sales centre.

►►1.1. TOPPING-UP:

►1.1.1. Sta󰀨 in charge of top-up must be

qualied and understand the manufac-

turer’s instructions and the Standards in

force regarding safe top-up of the heat-

ers.

►1.1.2. Only use the type of fuel express-

ly specied on the heater identication

plate.

►1.1.3. Before topping-up, switch the heat-

er o󰀨 and wait for it to cool down.

►1.1.4. The fuel storage tanks must be in a

separate structure.

►1.1.5. All fuel tanks must be at a minimum

safety distance from the heater, accord-

ing to the Standards in force.

►1.1.6. The fuel must be kept in rooms

where the oor does not allow penetra-

tion and dripping of the same onto ames

below, which can cause ignition.

►1.1.7. The fuel must be stored in compli-

ance with the Standard in force.

►►1.2. SAFETY:

►1.2.1. Never use the heater in rooms

where petrol, solvents for paints or other

highly inammable vapours are present.

►1.2.2. During use of the heater, follow

all local regulations and the Standard in

force.

►1.2.3. The heaters in proximity of tarpau-

lin, curtains or other similar covering

materials, must be situated at a safe dis-

tance from the same. It is advised to use

re-proof covering material.

►1.2.4. Only use in well-ventilated areas.

Set-up a suitable opening according to

the Laws in force, with the purpose of in-

troducing fresh air from outdoors.

►1.2.5. Power the heater only with current

that has voltage and frequency specied

on the heater identication plate.

►1.2.6. Only use extensions with three

wires, appropriately connected to earth.

►1.2.7. Minimum safety distances recom-

mended, running between the heater and

the inammable substances are: front

output = 2,5 m; side, at top and on rear =

1,5 m.

►1.2.8. Put the heater in hot mode or run-

ning, on a stable level surface, in a way to

prevent the risk of re.

►1.2.9. Keep animals at a safe distance

from the heater.

►1.2.10. Disconnect the heater from the

mains socket when not in use.

►1.2.11. When it is controlled by a

thermostat, the heater can switch on at

any time.

►1.2.12. Never use the heater in frequently

inhabited rooms, or in the bedroom.

►1.2.13. Never block the air vent (rear side)

or the air outlet (front side) of the heater.

en

it

de

es

fr

nl

pt

da



no

sv

pl

ru

cs

hu

sl

tr

hr

lt

lv

et

ro

sk

bg

uk

bs

el

zh

►1.2.14.Whentheheaterishotorconnected

to the mains electricity or functioning, it

must never be moved, handled, topped-

up or subject to any maintenance

interventions.

►1.2.15. Do not duct the air entering or

exiting the heater.

►1.2.16. Keep the hot parts of the heater at

an adequate distance from inammable

or termolabile materials (including the

power supply cable).

►1.2.17. If the power supply cable is

damaged, it must be replaced by the

technical after-sales centre, in order to

prevent all risks.

2. UNPACKING

►2.1. Remove all packaging materials used

to wrap and deliver the heater and dispose

of them in compliance with the Standards in

force.

►2.2. Extract all articles from the packaging.

►2.3. Control for any damage undergone

during transport. If the heater appears

damaged, inform the dealer, where the

purchase was made, immediately.

3. ASSEMBLY (29-44 kW)

(SEE FIG. 1)

These models have wheels and handle/s de-

pending on the model. These components,

complete with relative nuts and bolts, are situ-

ated in the heater box.

4. FUEL

WARNING: The heater only functions

with DIESEL or KEROSENE.

Only use diesel or kerosene, to prevent the risk

of re or explosion. Never use petrol, naphtha,

solvents for paints, alcohol or other highly

inammable fuels.

Use non-toxic anti-freeze additives in the case

of very low temperatures.

5. FUNCTIONING PRINCIPLES

The series of compressor products has a wide

range of power. Models are available with

both single and double combustion anked

chambers. For heaters with a double combustion

chamber, the two combustion chambers can

be used simultaneously for maximum power,

or a single combustion chamber can be used

for intermediate power.

(SEE FIG. 2)

A. Combustion chamber and heads,

B. Fan,

C. Motor,

D. Compressor,

E. Tank.

The compressor (D) started by the motor

(C) compresses the air, which through the

atomising nozzle, sucks up the fuel from the

tank (E) due to the “VENTURI EFFECT”. On

contact with the igniter, the atomised fuel

ignites inside the combustion chamber (A).

The combustion products are mixed with the

ow of room air generated by the rotation of

the fan (B) and pushed towards the outside of

the heater. A photoresistance, connected to

a circuit board, constantly checks the correct

functioning of the heater, stopping the cycle in

the event of anomalies.

6. FUNCTIONING

WARNING: Thoroughly read the

”INFORMATION REGADRING SAFETY”,

before switching the heater on.

►►6.1. SWITCHING THE HEATER ON:

►6.1.1. Follow all instructions relative to safety.

►6.1.2. Check the presence of fuel in the tank.

►6.1.3. Close the tank cap.

►6.1.4. Connect the power supply plug to

the mains electricity (SEE VOLTAGE IN

“TECHNICAL DATA TABLE”) (SEE FIG. 3).

►6.1.5. Take the “ON/OFF” switch to the

“ON” (|) position (SEE FIG. 4). The heater

should switch-on within a few seconds. If

the heater does not start, consult the “13.

TROUBLESHOOTING” paragraph.

MODELS WITH A DOUBLE COMBUSTION

CHAMBER: To use the heater at maximum

power turn both “ON/OFF” switches to “ON”

(I). To use the heater at intermediate power

turn only one of the “ON/OFF” switches

to “ON” (I). Indications for managing and

selecting ignition of the single chamber are

on the control panel and on the combustion

chamber.

►6.1.6. For the models with room thermostat,

check the position of the knob (SEE FIG.

9-10).

N.B.: IF THE HEATER SHOULD SWITCH-

OFF DUE TO THE LACK OF FUEL, TOP-UP

THE TANK AND RESET THE HEATER (SEE

PAR. 6.2).

en

it

de

es

fr

nl

pt

da



no

sv

pl

ru

cs

hu

sl

tr

hr

lt

lv

et

ro

sk

bg

uk

bs

el

zh

►►6.2. RESETTING THE HEATER:

In the models with automatic “RESET”, switch

the heater o󰀨 and back on again (SEE FIG.

5-4).

►►6.3. SWITCHING THE HEATER OFF:

DO NOT PULL THE PLUG OUT UNTIL THE

COOLING CYCLE HAS TOTALLY ENDED.

►6.3.1. Take the “ON/OFF” switch to the “OFF”

(O) position (SEE FIG. 5).

►6.3.2. Disconnect the heater from the mains

electricity (SEE FIG. 6).

7. REGULATING THE PRESSURE

OF THE COMPRESSOR (Contact the

technical service center)

(SEE FIG. 7)

THE COMPRESSOR PRESSURE MAY HAVE

TO BE RESTORED WITH WEAR OF THE

HEATER.

►7.1. Use the “TECHNICAL DATA TABLE” to

identify the correct pressure (Bar - PSI - kPa)

of your heater.

►7.2. Remove the screw/cap of the manometer

connection (A).

►7.3. Assemble the manometer (not supplied,

see “ACCESSORIES”).

►7.4. Switch the heater on.

►7.5. Act on the regulation screw by turning it

clockwise to increase the pressure and anti-

clockwise to decrease it (B).

►7.6. Remove the manometer and restore the

screw/cap (A).

8. CLEANING THE TANK FILTER

(SEE FIG. 8)

DEPENDING ON THE QUALITY OF THE

FUEL THAT IS USED, THE TANK FILTER

MAY HAVE TO BE CLEANED.

►8.1. Remove the cap (A) from the tank.

►8.2. Extract the lter (B) from the tank.

►8.3. Clean the lter (B) with clean fuel, paying

attention not to damage it.

►8.4. Re-mount the lter (B) in the tank.

►8.5. Close the cap (A).

9. PRESERVATION AND

TRANSPORT

I ORDER TO KEEP AND/OR TRANSPORTAR

THE HEATER IN THE BEST WAY, STHE

FOLLOWING PROCEDURE MUST BE

FOLLOWED.

►9.1. Empty the fuel tank (some models have

a draining cap on the bottom of the tank. In

this case, remove the drain cap and empty

the fuel).

►9.2. If the presence of residues is noted, pour

clean fuel into the tank and drain o󰀨 again.

►9.3. Close the tank cap and/or the draining

cap and dispose of the fuel appropriately

according to the Standards in force.

►9.4. In order to keep the heater in the best

way possible, it must be kept on a level

surface to prevent the escape of fuel and in

a dry place away from any possible external

threats.

10. ROOM THERMOSTAT

►►10.1. MODELS PRE-SET FOR REMOTE

ROOM THERMOSTAT:

(SEE FIG. 9)

For models preset for remote room thermostat,

remove the cover connected to the heater

(A), connect the thermostat (B) (optional) and

set the desired room temperature. The room

thermostat completely turns o󰀨 the heater once

the set temperature has been reached. If the

temperature drops below the set temperature,

the heater will automatically turn itself on again.

►►10.2. MODELS WITH ROOM

THERMOSTAT INSTALLED ON THE

CONTROL PANEL:

(SEE FIG. 10)

For models with room thermostat installed on

the control panel, when the knob (B) is turned

the desired temperature starts ashing on the

display (A) for a few seconds, after which the

display shows the room temperature. When the

knob (B) is turned completely to the right, the

display (A) shows “CH”, after which the heater

works continuously.

►►10.3. MODELS PRE-SET FOR REMOTE

ROOM THERMOSTAT AND ROOM

THERMOSTAT INSTALLED ON THE

CONTROL PANEL:

(SEE FIG. 9-10)

For models preset for remote room thermostat

and room thermostat installed on the control

panel, remove the cover connected to the

heater (SEE A FIG. 9) and connect the

thermostat (SEE B FIG. 9) (optional). For

correct heater operation, completely turn the

knob to the right (SEE B FIG. 10), the display

(SEE A FIG. 10) shows “CH”, after which set

the desired temperature on the remote room

thermostat.

en

it

de

es

fr

nl

pt

da



no

sv

pl

ru

cs

hu

sl

tr

hr

lt

lv

et

ro

sk

bg

uk

bs

el

zh

11. PREVENTIVE MAINTENANCE SCHEDULE

WARNING: BEFORE PERFORMING ANY MAINTENANCE OR REPAIRS, DISCONNECT

THE POWER SUPPLY CABL FROM THE MAINS AND MAKE SURE THAT THE HEATER IS

COLD.

COMPONENT MAINTENANCE FREQUENCY MAINTENANCE PROCEDURE

Fuel tank Empty and rinse the tank with clean

fuel every 150-200 working hours

Empty and rinse the tank with

clean fuel (SEE PAR. 9)

Filters Clean or replace every 500 working

hours or when necessary

Contact the technical service

center

12. DISPLAY ERRORS (WHERE PRESENT)

(SEE FIG. 10)

CAUSE SOLUTION

F0 1. The “ON/OFF” switch is turned

“ON” (|) when the heater is

plugged in

1. After disconnecting the heater, see that the

switch is in the “OFF” (0) position, plug the

heater in and turn the switch “ON” (|)

F1 1. No fuel

2. Fuel is contaminated

3. Photocell is dirty or damaged

4. Fuel lter is dirty

5. Ignition error

1. Turn the switch “OFF” (0), rell the fuel tank

2. Turn the switch “OFF” (0) empty and rell the

fuel tank. Clean the lter using clean fuel, do not

damage the lter (SEE PAR. 8)

3. Contact the technical service center

4. SEE PAR. 8

5. Contact the technical service center

F2 1. Interrupted cable

2. Sensor is damaged

1. Contact the technical service center

2. Contact the technical service center

F3 1. Internal heater overheating 1. Turn the heater o󰀨, wait until it is cooled down

F4 1. Incorrect voltage 1. Check voltage of your electric supply system

LO 1. External temperature below -5°C 1. Normal condition

CH 1. Continuous operation 1. Normal condition

13. TROUBLESHOOTING

PROBLEM POSSIBLE CAUSE POSSIBLE SOLUTION

The heater

does not

start

1. Generator blocked

2. Starter switch in “OFF”

position (0)

3. No power supply

4. Temperature sensor override

5. Control card blocked

6. Incorrect setting of the room

thermostat (where present)

1. Reset the heater (SEE PAR. 6.2)

2. Take the “ON/OFF” switch to the “ON” (|)

position

3. Insert the power supply cable into the

mains socket correctly

4. Wait at least ten minutes then try to run

ignition again

5a. Reset the heater (SEE PAR. 6.2)

5b. Identify the display error (where present)

6. Act on the room thermostat, taking it to a

higher temperature than that of the work

environment (SEE FIG. 9-10)

The motor

starts but

the ame is

not triggered

1. No fuel

2. Incorrect pump pressure

3. Presence of foreign

substances in the tank

1. Top-up fuel and reset the heater

2. Regulate the pressure of the compressor

(SEE PAR. 7)

3. Empty and ll the tank with clean fuel (SEE

PAR. 9)

en

it

de

es

fr

nl

pt

da



no

sv

pl

ru

cs

hu

sl

tr

hr

lt

lv

et

ro

sk

bg

uk

bs

el

zh

WIRING DIAGRAMS - SCHEMI ELETTRICI - SCHALTPLÄNE - ESQUEMAS

ELÉCTRICOS - SCHEMAS ELECTRIQUES - ELEKTRISCHE SCHEMA’S - ESQUE-

MAS ELÉCTRICOS - ELEKTRISKE SKEMAER - SÄHKÖKAAVIOT - KOPLINGS-

SKJEMA - ELEKTRISKA KOPPLINGSSCHEMAN - SCHEMATY ELEKTRYCZNE

- ЭЛЕКТРИЧЕСКИЕ СХЕМЫ - ELEKTRICKÁ SCHÉMATA - VILLANYBEKÖTÉSI

RAJZOK - ELEKTRIČNE SHEME - ELEKTR EMALARI - ELEKTRIČNE SH-

EME - ELEKTROS SCHEMOS - ELEKTRISKĀS SHĒMAS - ELEKTRISKEEMID

- SCHEME ELECTRICE - ELEKTRICKÉ SCHÉMY - ЕЛЕКТРИЧЕСКИ СХЕМИ

- ЕЛЕКТРИЧНІ СХЕМИ - ELEKTRIČNE ŠEME - ΗΛΕΚΤΡΙΚΑ ΣΧΕΔΙΑ - 线路图 -

ЭЛЕКТРЛІ СҮЛБЕЛЕР

2

3

SOLENOID

VALVES

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP2 TEMP

DUMP

FO TS IN TA

FU

EV

IG

TR

L

N

SC

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP

DUMP

FO IN

FU

IG

TR

L

N

SC

TR

IG

IN

FU

FO

CF

BLACK

WHITE

BLU

RED

CF

BLACK

WHITE

BLU

RED

L

N

IN

TR

IG FU

FO

2 5

14

2 5

14

TA

2 3

1

2

3

SOLENOID

VALVES

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP2 TEMP

DUMP

FO TS IN TA

FU

EV

IG

TR

L

N

SC

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP

DUMP

FO IN

FU

IG

TR

L

N

SC

TR

IG

IN

FU

FO

CF

BLACK

WHITE

BLU

RED

CF

BLACK

WHITE

BLU

RED

L

N

IN

TR

IG FU

FO

2 5

14

2 5

14

TA

2 3

1

B 35CED - B 70CED - B 100CED - B 150CED

CEL

IN Switch - Interruttore - Schalter - Interruptor - Interrupteur - Schakelaar - Interruptor - Afbryder - Katkaisin - Bryter - Brytare

- Włącznik - Включатель - Vypínač - Kapcsoló - Stikalo - Açma kapama düğmesi - Prekidač - Jungiklis - Slēdzis - Lüliti -

Întrerupător - Vypínač - Прекъсвач - Вимикач - Prekidač - Διακόπτης - 开关 - Қосқыш.

MMotor - Motore - Motor - Motor - Moteur - Motor - Motor - Motor - Moottori - Motor - Motor - Silnik - Двигатель - Motor - Motor

- Motor - Motor - Motor - Variklis - Dzinējs - Mootor - Motor - Motor - Двигател - Двигун - Motor - Κινητήρας - 电机 - Тежегіш.

TR Transformer - Trasformatore - Transformator - Transformador - Transformateur - Transformator - Transformador - Transformator

- Muunnin - Transformator - Transformator - Transformator - Трансформатор - Transformátor - Transzformátor - Transformator

- Trasformatör - Transformator - Transformatorius - Transformators - Transformaator - Transformator - Transformátor - Транс-

форматор - Трансформатор - Transformator - Μετασχηματιστής - 点火变压器 - Трансформатор.

CF Flame Control - Controllo Fiamma - Flammkontrolle - Control de la llama - Contrôle de la Flamme - Controle Vlam - Controlo

Chama - Kontrol Flamme - Liekin tarkkailu - Flammekontroll - Flamvakt - Sterowanie Płomieniem - Контроллер пламени - Kon-

trola plamene - Lángőr - Nadzor plamena - Alev Kontrolü - Kontrola Plamena - Liepsnos valdymas - Liesmas Kontrole - Lee-

gikontrolli seade - Control Flacără - Kontrola plameňa - Проверк на искрата - Контроль полум’я - Kontrola Plamena - Έλεγχος

Φλόγας - 火焰控制 - Flame бақылау.

IG Igniter - Accenditore - Anzünder - Encendedor - Allumeur - Ontsteker - Acendedor - Tænder - Sytytin -Tenner - Tändare -

Zapalnik - Зажигатель - Zapalovač - Begyújtó kacsoló - Vžigalo - Ateşleyici - Upaljač - Uždegiklis - Uguns slēdzis - Süütur -

Aprinzător - Zapaľovač - Запалване - П’єзоелектричний - Upaljač - Έναυσμα - 点火器 - Воспламенитель.

FO Photoresistance - Fotoresisteza - Fotowiderstand - Fotorresistencia - Photorésistance - Fotoweerstand - Foto-resistência - Fo-

tomodstand - Valovastus - Fotomotstand - Fotomotstånd - Fotorezystor - Фоторезистор - Fotoelektrický odpor - Fotócella el-

lenállás - Fotoupor - Fotorezistans - Fotootpornost - Fotorezistorius - Fotorezistors - Fototakisti - Fotorezistenţă - Fotoelektrický

odpor - Фоторезистор - Розпалювач - Fotootpornik - Φωτοαντίσταση - 光电感应器 - Фоторезистор.

FU Fuse - Fusibile - Schmelzsicherung - Fusibile - Fusée - Veiligheid - Fusível - Sikring - Sulake - Fuse - Säkring - Bezpiecznik

- Предохранитель - Pojistka - Biztosíték - Fuse - Sigorta - Osigurač - Saugiklių - Drošinātājs - Kaitse - Siguranţă - Poistka -

Предпазител - Запобіжник - Fuse - Ασφάλεια - 保险丝 - Сақтандырғыш.

TA Room thermostat - Termostato ambiente - Raumthermostat - Termostato ambiente - Thermostat d’ambiance -

Omgevingsthermostaat - Termóstato ambiente - Rumtermostat - Huonetermostaatti -Romtermostat - Rumstermostat -

Termostat pokojowy - Комнатный термостат - Termostat prostředí - Szobatermosztát - Sobni termostat - Oda termostatı

- Ambijentalni termostat - Aplinkos termostatas - Vides termostats - Ümbritseva keskkonna termostaat - Termostat ambiental

- Termostat prostredia - Ресет - Термостат температури зовнішнього середовища - Ambijentalni termostat - Θερμοστάτης

περιβάλλοντος - 温控器 - Бөлме термостаты.

SC Control sensor - Sensore di controllo - Kontrollsensor - Sensor de control - Senseur de contrôle - Controlesensor - Sensor de

controlo - Kontrolsensor - Ohjausanturi - Kontrollsensor - Kontrollsensor - Czuinik kontrolny - Контрольный датчик - Kontrolní

senzor - Vezérlő érzékelő - Kontrolni senzor - Kontrol sensörü - Senzor za kontrolu - Valdymo jutiklis - Kontroles sensors -

Kontrollandur - Senzor de control - Kontrolný senzor - Контролен сензор - Світлодіодний - Senzor kontrole - Αισθητήρας

ελέγχου - 控制感应器 - бақылау датчик.

EV Solenoid valve - Elettrovalvola - Elektroventil - Electroválvula - Électrovalve - Elektroklep - Eletroválvula - Magnetventil -

Solenoidiventtiili - Magnetventil - Magnetventil - Zawór elektromagnetyczny - Соленоид - Elektrický ventil - Mágnesszelep

- Elektromagnetni ventil - Elektrovalf - Električni ventil - Elektrinis vožtuvas - Elektrovārsts - Solenoidventiil - Electrovalvă -

Elektrický ventil - Електроклапан - Електроклапан - Električni ventil - Ηλεκτροβαλβίδα - 电磁阀 - Соленоид.

TS Safety thermostat - Termostato sicurezza - Sicherheitsthermostat - Termostato de seguridad - Thermostat de sécurité

- Veiligheidsthermostaat - Termóstato de segurança - Sikkerhedstermostat - Turvatermostaatti - Sikkerhetstermostat -

Säkerhetstermostat - Termostat bezpieczeństwa - Термостат безопасности - Bezpečnostní termostat - Biztonsági termosztát -

Varnostni termostat - Emniyet termostatı - Sigurnosni termostat - Apsaugos termostatas - Drošības termostats - Ohutustermostaat

- Termostat de siguranţă - Bezpečnostný termostat - Предпазен термостат - Запобіжний термостат - Sigurnosni termostat

- Θερμοστάτης ασφαλείας - 过热保护 - Қауіпсіздік термостаты.

LLine - Linea - Leitung - Línea - Ligne - Lijn - Linha - Linje - Linja - Linje - Linje - Linia - Линия - Linka - Sor - Linija - Hat - Linija

- Linija - Līnija - Liin - Linie - Linka - Линия - Фаза - Linija - Γραμμή - 线 - Сызық.

NNeutral - Neutro - Nullleiter - Neutro - Neutre - Neutraal - Neutro - Neutral - Neutraali - Nøytral - Noll - Neutralny - Нейтраль -

Neutrální - Semleges - Nevtralni vod - Nötr - Neutralna - Neutralus - Neitrāls - Neutraal - Nul - Neutrál - Неутрално - Нейтраль

- Neutralna - Ουδέτερο - 零线 - Нейтраль.

WIRING DIAGRAMS - SCHEMI ELETTRICI - SCHALTPLÄNE - ESQUEMAS

ELÉCTRICOS - SCHEMAS ELECTRIQUES - ELEKTRISCHE SCHEMA’S - ESQUE-

MAS ELÉCTRICOS - ELEKTRISKE SKEMAER - SÄHKÖKAAVIOT - KOPLINGS-

SKJEMA - ELEKTRISKA KOPPLINGSSCHEMAN - SCHEMATY ELEKTRYCZNE

- ЭЛЕКТРИЧЕСКИЕ СХЕМЫ - ELEKTRICKÁ SCHÉMATA - VILLANYBEKÖTÉSI

RAJZOK - ELEKTRIČNE SHEME - ELEKTR EMALARI - ELEKTRIČNE SH-

EME - ELEKTROS SCHEMOS - ELEKTRISKĀS SHĒMAS - ELEKTRISKEEMID

- SCHEME ELECTRICE - ELEKTRICKÉ SCHÉMY - ЕЛЕКТРИЧЕСКИ СХЕМИ

- ЕЛЕКТРИЧНІ СХЕМИ - ELEKTRIČNE ŠEME - ΗΛΕΚΤΡΙΚΑ ΣΧΕΔΙΑ - 线路图 -

ЭЛЕКТРЛІ СҮЛБЕЛЕР

2

3

SOLENOID

VALVES

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP2 TEMP

DUMP

FO TS IN TA

FU

EV

IG

TR

L

N

SC

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP

DUMP

FO IN

FU

IG

TR

L

N

SC

TR

IG

IN

FU

FO

CF

BLACK

WHITE

BLU

RED

CF

BLACK

WHITE

BLU

RED

L

N

IN

TR

IG FU

FO

2 5

14

2 5

14

TA

2 3

1

2

3

SOLENOID

VALVES

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP2 TEMP

DUMP

FO TS IN TA

FU

EV

IG

TR

L

N

SC

IGNITIONFANACN ACL

LIGHT

DEPENDENT

RESISTOR

TEMP1 ROCKER TEMP

DUMP

FO IN

FU

IG

TR

L

N

SC

TR

IG

IN

FU

FO

CF

BLACK

WHITE

BLU

RED

CF

BLACK

WHITE

BLU

RED

L

N

IN

TR

IG FU

FO

2 5

14

2 5

14

TA

2 3

1

B 300CED

WIRING DIAGRAMS - SCHEMI ELETTRICI - SCHALTPLÄNE - ESQUEMAS

ELÉCTRICOS - SCHEMAS ELECTRIQUES - ELEKTRISCHE SCHEMA’S - ESQUE-

MAS ELÉCTRICOS - ELEKTRISKE SKEMAER - SÄHKÖKAAVIOT - KOPLINGS-

SKJEMA - ELEKTRISKA KOPPLINGSSCHEMAN - SCHEMATY ELEKTRYCZNE

- ЭЛЕКТРИЧЕСКИЕ СХЕМЫ - ELEKTRICKÁ SCHÉMATA - VILLANYBEKÖTÉSI

RAJZOK - ELEKTRIČNE SHEME - ELEKTR EMALARI - ELEKTRIČNE SH-

EME - ELEKTROS SCHEMOS - ELEKTRISKĀS SHĒMAS - ELEKTRISKEEMID

- SCHEME ELECTRICE - ELEKTRICKÉ SCHÉMY - ЕЛЕКТРИЧЕСКИ СХЕМИ

- ЕЛЕКТРИЧНІ СХЕМИ - ELEKTRIČNE ŠEME - ΗΛΕΚΤΡΙΚΑ ΣΧΕΔΙΑ - 线路图 -

ЭЛЕКТРЛІ СҮЛБЕЛЕР

CEG