Monessen Hearth Berkeley Oak BO18-F User manual

Monessen • Berkeley Oak Installation Instructions • 4604-911 Rev. A • 04/18 1
Log Placement Instructions
Models: BO18-R, BO18-F, BO24-R,
BO24-F, BO30-R, BO30-F
REF. DESCRIPTION QTY BO18-R BO18-F BO24-R BO24-F BO30-R BO30-F
1 Ember Chunk 1 81D0110 81D0109 81D0110 81D0109 81D0110 81D0109
2 Right Front Log 1 81D0059 81D0083 81D0067 81D0091 81D0075 81D0099
3 Right Rear Log 1 81D0060 81D0084 81D0068 81D0092 81D0076 81D0100
4 Left Rear Log 1 81D0061 81D0085 81D0069 81D0093 81D0077 81D0101
5 Left Front Log 1 81D0062 81D0086 81D0070 81D0094 81D0078 81D0102
6 Middle Left Log 1 81D0063 81D0087 81D0071 81D0095 81D0071 81D0095
7Left Top Log 1 81D0064 81D0088 81D0072 81D0096 81D0072 81D0096
8Right Top Log 1 81D0065 81D0089 81D0073 81D0097 81D0073 81D0097
WARNING!
The positioning of the logs is critical to the safe, clean operation of this gas log set. Sooting and other problems may
result if the logs are not properly positioned per these instructions. Failure to position in accordance with the diagrams
below, or failure to use only parts specically approved for this log set may result in property damage or personal injury.
2
3
4
5
6
7
8
1
BENEATH #8

Monessen • Berkeley Oak Installation Instructions • 4604-911 Rev. A • 04/18
2
NOTE: Installation instructions are the same for 18”,
24”, and 30” log sets. Pictures used in this manual
illustrate the 24” set. Some variation may exist
between the images and the set included with this
manual.
INSTALL 18”, 24” AND 30” (F, R) BERKLEY
OAK LOGS ON NATURAL BLAZE BURNER
1. Place the #1 log (the “chunk”) on the grate bar right
side of the burner adjacent to the controls. Figure 1.
2. Place front right log (#2) on right pin located on burner
and right grate bar. Figure 2. slide Log #1 forward so
that it is tight against log #2.
LOG INSTALLATION
Ember Chunk
Log #1
LG620
Figure 1. Place Ember Chunk log #1
3. Place right rear log (#3) on pin located on rear
support bracket and rest left side of log on front right
log. See Figure 3.
Right Front
Log #2
Figure 2. Place Right Front Log #2
Right Rear
Log #3
Figure 3. Place Right Rear Log #3
4. Place left rear log (#4) on pin located on rear support
bracket on left side. See Figure 4.
Left Rear
Log #4
Figure 4. Place Left Rear Log #4
5. Place left front log (#5) on left pin located on burner
and left grate bar. Rest top right portion of log on right
front log. See Figure 5.
Left Front Log #5
Figure 5. Place Left Front Log #5

Monessen • Berkeley Oak Installation Instructions • 4604-911 Rev. A • 04/18 3
6. Place top left log (#6) on unit by placing grooved
portion of log onto left grate bar with bark facing
outward. Rest front part of log in groove on left front
log. See Figure 6.
Middle Left
Log #6
Figure 6. Place Middle Left Log #6
7. Place left top log (#7) on left rear log (#4) and left
front log (#5) using locating grooves on bottom of #7
and locating blocks on logs #4 and #5. See Figure 7.
Left Top Log #7
Figure 7. Place Left Top Log #7
8. Place right top log (#8) onto right rear (#3) and right
front (#2) logs using locator on bottom of right top log.
See Figure 8.
Right Top
Log #8
Figure 8. Place Right Top Log #8
PLACE THE DECORATIVE ROCK
Optional volanic rock may be placed around the unit on
the oor of the rebox. Be sure to avoid any areas on
the burner itself.
CAUTION
DO NOT sprinkle volcanic rock on the logs,
around the pilot, or on or near burners. This
may cause sooting. Place volcanic rock only
on the oor of the replace.
During initial operation of the new heater,
new burning logs and/or rock wool will give
off a paper burning smell and orange ames
will be present. Simply open the windows
for a few hours to vent the odor.
Monessen, a brand of Hearth & Home Technologies
7571 215th Street West, Lakeville, MN 50044
www.monessenhearth.com