Nokia NBB5005000 - IP VPN 5i User manual

Part No. N451658002 Rev A
Published July 2005
Nokia 5i and 10i
Installation Guide

2 Nokia 5i and 10i Installation Guide
COPYRIGHT
©2005 Nokia. All rights reserved.
Rights reserved under the copyright laws of the United States.
RESTRICTED RIGHTS LEGEND
Use, duplication, or disclosure by the United States Government is subject to restrictions as set
forth in subparagraph (c)(1)(ii) of the Rights in Technical Data and Computer Software clause at
DFARS 252.227-7013.
Notwithstanding any other license agreement that may pertain to, or accompany the delivery of,
this computer software, the rights of the United States Government regarding its use,
reproduction, and disclosure are as set forth in the Commercial Computer Software-Restricted
Rights clause at FAR 52.227-19.
IMPORTANT NOTE TO USERS
This software and hardware is provided by Nokia Inc. as is and any express or implied
warranties, including, but not limited to, implied warranties of merchantability and fitness for a
particular purpose are disclaimed. In no event shall Nokia, or its affiliates, subsidiaries or
suppliers be liable for any direct, indirect, incidental, special, exemplary, or consequential
damages (including, but not limited to, procurement of substitute goods or services; loss of use,
data, or profits; or business interruption) however caused and on any theory of liability, whether in
contract, strict liability, or tort (including negligence or otherwise) arising in any way out of the use
of this software, even if advised of the possibility of such damage.
Nokia reserves the right to make changes without further notice to any products herein.
TRADEMARKS
Nokia is a registered trademark of Nokia Corporation. Other products mentioned in this
document are trademarks or registered trademarks of their respective holders.
050110

Nokia 5i and 10i Installation Guide 3
Nokia Contact Information
Corporate Headquarters
Regional Contact Information
Nokia Customer Support
Web Site http://www.nokia.com
Telephone [phone] or
1-650-625-2000
Fax [phone]
Mail
Address Nokia Inc. 313 Fairchild Drive
Mountain View, California
94043-2215 USA
Americas Nokia Inc.
313 Fairchild Drive
Mountain View, CA 94043-2215
USA
Tel: [phone]
Outside USA and Canada: [phone]
email: [email protected]
Europe,
Middle East,
and Africa
Nokia House, Summit Avenue
Southwood, Farnborough
Hampshire GU14 ONG UK
Tel: UK: [phone]
Tel: France: [phone]
email: [email protected]
Asia-Pacific 438B Alexandra Road
#07-00 Alexandra Technopark
Singapore 119968
Tel: [phone]
email: [email protected]
Web Site: https://support.nokia.com/
Email: [email protected]
Americas Europe
Voice: 1-888-361-5030 or
1-613-271-6721 Voice: [phone]
Fax: [phone] Fax: [phone]
Asia-Pacific
Voice: [phone]
Fax: [phone]
050602

4 Nokia 5i and 10i Installation Guide

Nokia 5i and 10i Installation Guide 5
Contents
About This Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
In This Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Conventions This Guide Uses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Notices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Command-Line Conventions. . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Text Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Related Documentation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
1 Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
About the Nokia 5i and 10i Gateways . . . . . . . . . . . . . . . . . . . . . . 17
Preparing the Installation Environment . . . . . . . . . . . . . . . . . . . . . 17
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Humidity and Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Product Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Site Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
2 Installing a Nokia 5i and 10i Gateway . . . . . . . . . . . . . . . . . . . . 23
Resetting the Gateway to Factory Default. . . . . . . . . . . . . . . . . . 24
Performing the Initial Hardware Configuration . . . . . . . . . . . . . . . . 25
Connecting the Console Port . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Connecting Power and Turning the Power On . . . . . . . . . . . . . . 29
Connecting Network Interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Connecting to Ethernet Ports . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

6 Nokia 5i and 10i Installation Guide
3 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
A Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Physical Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Space Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Random Access Memory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Data Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
B Compliance Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Declaration of Conformity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Compliance Statements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
FCC Notice (US) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Nokia 5i and 10i Installation Guide 7
Figures
Figure 1 Rear View of the Nokia 5i and Nokia 10i Gateways . . . 23
Figure 2 Pin Assignments for Console and AUX Connections . . 28
Figure 3 Power Cord Receptacle on the Nokia 5i and Nokia 10i 30
Figure 4 System Status LEDs for the Nokia 5i and Nokia 10i . . . 31
Figure 5 Output Connector for the Ethernet Cable . . . . . . . . . . . 34
Figure 6 Ethernet Crossover-Cable Pin Connections . . . . . . . . . 35

8 Nokia 5i and 10i Installation Guide

Nokia 5i and 10i Installation Guide 9
Tables
Table 1 Command-Line Conventions . . . . . . . . . . . . . . . . . . . . . 13
Table 2 Text Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Table 3 Rear Panel connection descriptions of the Nokia 5i and
Nokia 10i . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Table 4 Pin Assignments for DB9 and DB25 Interface Cables . . 29
Table 5 System Status LEDs for the Nokia 5i and Nokia 10i . . . 31

10 Nokia 5i and 10i Installation Guide

Nokia 5i and 10i Installation Guide 11
About This Guide
This guide describes the installation and use of the Nokia 5i and 10i gateways.
Installation and maintenance should be performed only by experienced
technicians or Nokia-approved service providers.
This preface provides the following information:
In This Guide
Conventions This Guide Uses
Related Documentation
In This Guide
This guide is organized into the following chapters and appendixes:
Chapter 1, “Overview,” presents a general overview of the Nokia 5i and
10i gateways.
Chapter 2, “Installing a Nokia 5i and 10i Gateway,” explains how to
install and how to physically connect the 5i and 10i to a network and
power.
Chapter 3, “Troubleshooting,” discusses problems you might encounter
and proposes solutions to these problems.

12 Nokia 5i and 10i Installation Guide
Appendix A, “Technical Specifications,” provides technical
specifications.
Appendix B, “Compliance Information,” includes compliance and
regulatory information.
Conventions This Guide Uses
The following sections describe the conventions this guide uses, including
notices, text conventions, and command-line conventions.
Notices
Warning
Warnings advise the user that bodily injury might occur because of a
physical hazard.
Caution
Cautions indicate potential equipment damage, equipment
malfunction, loss of performance, loss of data, or interruption of
service.
Note
Notes provide information of special interest or recommendations.

Conventions This Guide Uses
Nokia 5i and 10i Installation Guide 13
Command-Line Conventions
This section defines the elements of commands that are available in Nokia
Internet Communications products. You might encounter one or more of the
following elements in a command-line path.
Table 1 Command-Line Conventions
Convention Description
command A user-generated instruction typically sent using a console
or terminal. The command statement and its associated
syntax must be entered exactly as shown in lowercase
letters.
italics Indicates a variable in a command that you must supply. For
example:
delete interface if_name
Supply an interface name in place of the variable. For
example:
delete interface nic1
angle brackets < > Indicates arguments for which you must supply a value:
retry-limit <1–100>
Supply a value. For example:
retry-limit 60
-flag A flag is usually an abbreviation for a function, menu, or
option name, or for a compiler or preprocessor argument.
You must enter a flag exactly as shown, including the
preceding hyphen.

14 Nokia 5i and 10i Installation Guide
Text Conventions
Table 2 describes the text conventions this guide uses.
.ext A filename extension, such as .ext, might follow a variable
that represents a filename. Type this extension exactly as
shown, immediately after the name of the file. The extension
might be optional in certain products.
( . , ; + * - / ) Punctuation and mathematical notations are literal symbols
that you must enter exactly as shown.
Table 1 Command-Line Conventions (continued)
Convention Description
Table 2 Text Conventions
Convention Description
monospace font Indicates command syntax, or represents computer or
screen output, for example:
Log error 12453
bold monospace font Indicates text you enter or type, for example:
# configure nat
Key names Keys that you press simultaneously are linked by a
plus sign (+):
Press Ctrl + Alt + Del.
Menu commands Menu commands are separated by a greater than
sign (>):
Choose File > Open.

Related Documentation
Nokia 5i and 10i Installation Guide 15
Related Documentation
In addition to this guide, documentation for this product includes the
following:
Nokia IP VPN Gateway Configuration Guide v6.3 describes how to
configure and manage Nokia IP VPN Gateways by using the Nokia VPN
Manager software.
Nokia IP VPN Gateway Command-Line Summary v6.3 is a reference for
the command-line interface (CLI) for Nokia IP VPN gateways.
Release Notes in an ASCII-text file on the installation CD.
The words enter and type Enter indicates you type something and then press
the Return or Enter key.
Do not press the Return or Enter key when an
instruction says type.
Italics •Emphasizes a point or denotes new terms at the
place where they are defined in the text.
•Indicates an external book title reference.
•Indicates a variable in a command:
delete interface if_name
Table 2 Text Conventions (continued)
Convention Description

16 Nokia 5i and 10i Installation Guide

Nokia 5i and 10i Installation Guide 17
1Overview
This chapter provides an overview of the Nokia 5i and 10i gateways and the
requirements for using the gateways. The following topics are covered:
About the Nokia 5i and 10i Gateways
Preparing the Installation Environment
Product Disposal
Site Requirements
About the Nokia 5i and 10i Gateways
The Nokia 5i and Nokia 10i gateways enable advanced home and office
networking. Business users can securely connect to the corporate network.
Both the Nokia 5i and Nokia 10i are designed for placement on a desk, table,
or other flat surface.
Preparing the Installation Environment
Before you install the gateway, make sure that the installation environment is
clean, dry, and dust free. Take the following precautions to maintain a safe
working environment and to avoid accidents:
Inspect the area for hazards, such as bare wires and standing water.

1Overview
18 Nokia 5i and 10i Installation Guide
Remove scarves and neckties, jewelry, and other loose items before you
install the gateway.
Do not remove the gateway cover under any circumstances.
Ventilation
Gateways can generate substantial heat during operation and therefore require
adequate ventilation. You might need to install the gateway in an air-
conditioned room to ensure that its internal cooling system can maintain
acceptable temperatures during operation.
Warning
Do not block any ventilation slots on the gateway. Internal components
might overheat and be damaged.
Humidity and Temperature
During operation, ambient relative humidity should never exceed ninety
percent and ambient air temperature must remain between 32°F and 113° F
(0° C and 45°C).
Safety Precautions
Follow these safety instructions whenever you are working with the gateway.
Caution
Read and follow all of these precautions before you work near any
power source.
Circuit breakers must be installed in the fixed wiring on all circuits to
which the gateways are connected. Ensure that all of the circuit breakers
are easily accessible.

Preparing the Installation Environment
Nokia 5i and 10i Installation Guide 19
For installations in North America, use a 120 VAC, 20A fuse circuit
breaker for the circuit branch.
For installations outside North America that use 230 VAC, use a
230 VAC, 2A fuse circuit breaker.
Use the gateway device within the electrical ratings indicated on the back
of the device and in the product documentation.
Follow the requirements of all building and electrical codes before, during,
and after installation of the gateway.
Warning
The gateway requires protection against short-circuits (overcurrent).
Always use overcurrent protection on all conductors of electrical current
to which the gateway is connected.
Electrical Grounding
The gateway must always be connected using a grounding-type plug.
Warning
Make sure that the facility where the gateway is installed has proper
electrical grounding and is connected to that ground at all times during
operation.
Protection Against Lightning
Warning
Do not work on the gateway during an electrical storm. Do not connect or
disconnect any wires, including network or power connections. Whenever
the threat of lightning danger exists, avoid touching the gateway. This
precaution is sensible for any electrical device during periods of lightning
activity.

1Overview
20 Nokia 5i and 10i Installation Guide
Electrical Power Source
Warning
Do not open the gateway or remove the network interface card (NIC) from
the gateway. No user-serviceable or user-replaceable parts are present in
the gateway. Only authorized service personnel should repair or open the
gateway.
Warning
To reduce the risk of fire, electric shock, and injury, disconnect the power
cord and any cables that connect to the gateway before you open the
chassis and expose internal components. Even though the power switch
is turned off, power is still present inside the gateway.
The gateway requires a clean and well-regulated power source, free from
power surges and line noise. When the gateway is configured as a cluster
(rather than as a standalone gateway), each gateway should have its own
power source installed on a circuit separate from all other gateways in the
cluster. This ensures that a power failure on one circuit can affect only one
device within the cluster.
All gateways incorporate an autosensing power supply device that uses either
low range (100 to 130 VAC), or high range (200 to 240 VAC) at
50 to 60 Hz. Check the gateway safety label for specifics.
Product Disposal
At the end of its useful life, the gateway must be disposed of in accordance
with all national, state, and local laws and regulations. The device contains
components (such as its lithium battery) that must be disposed of properly to
prevent damage to the environment. Contact your local waste management
agencies for specific guidelines.