Outdoor Gourmet Deluxe LP User manual







EXHIBIT C-6
TO
M. HERMES DECLARATION

Assembly Instructions
Deluxe LP Griddle & Gas & Charcoal Grill
Model #: DLX2013
- Please keep this instruction manual for future reference
Monday thru Friday
(Made in China)

FOR YOUR SAFETY:
1.Read this Grill Guide before attempting to assemble or
operate your grill.
2.Follow all safety instructions.
3.Check for leaks according to directions in this Grill Guide
before operating your grill, even if you purchased this grill
assembled.
4.Keep this Grill Guide for future reference.
5.Contact 1-888-922-2336 should you need assembly
assistance or have any questions.
THIS GRILL IS FOR OUTDOOR USE ONLY.
if stored indoors, then detach and leave propane cylinder
outside.
TO THE INSTALLER OR PERSON ASSEMBLING THIS GRILL:
Leave this Grill Guide with the consumer.
TO THE CONSUMER:
Retain this Grill Guide for future reference.

Safety Precautions
Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill
Guide. Failure to follow these notices may result in property damage, bodily injury, or death.
1. Grill installation must conform with local codes, or in their absence, with either the National Fuel
Gas Code, ANSI Z223.l/NFPA 54, Natural Gas and Propane Installation Code, CSA Bl49.l, or
Propane Storage and Handling Code, B1492.
This gas grill, when installed, must be electrically grounded in accordance with local codes, or, in
the absence of local codes, with the National Electrical Code, ANSI Z2l.58—2007, or the Canadian
Electrical Code, CSA 16-2007.-
This gas grill is intended for outdoor use only, and should not be used in a building, garage, or any
other enclosed area.
This gas grill is not intended to be installed in or on recreational vehicles and/or boats.
Never use any other type of fuel for this grill other than LP gas (propane).
Only use the pressure regulator with a type 1 connector that is supplied with this gas grill
Before each use, check the gas hose for excessive abrasion, cracking, fraying, wear, or cuts.
Replace a hose assembly showing those signs with the hose assembly specified in the parts list
before using the grill. '
8. Always perform a Leak Test before operating your grill.
FJ
L;-J
.“4S3‘.U‘.-‘3
A WARNING
1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
any other appliance.
2. An LP cylinder not connected for use should not be stored in the vicinity of this or any other
appliance.
A DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from appliance and call your local fire department.

Table of Contents
- Tools and Parts
- Hardware
- Assembly Instructions
- Care and Maintenance
- Warranty Information

Tools Required
Description
Adjustable wrench
(not provided)
Description
Screwdriver
(not provided)

Parts List _ _. A
L Parts List 7
('1) Cooking Grid - Spcs (2) Handie (Small) — 4:165 (3) Lid Handle - Zpcs (4) Thermometer u Zpcs
(5) Stack (Gas) - Zpcs (5) Warming Rack- 23365 (7) Charcoal Basket — 1pc: (8) Lift System - 1pc
4vW<~.\\:\\i\'\.=.:-.7
{’|‘I)Ash Pan —1pc (12) Left Back Leg -‘ipc
(10) Flame tamer - Spcs
{'15) Ash Pan Handie - 25305 (16) Receiving Tray - 2pc
(20) Knob Base - 1pc
(28) Right Back Leg - 1pc
J
(32) Left Door -1pc
Y
M”
(29) Right Front Leg - 1pc (30) Electrode - 7P0

(33) Knob - 79¢: (34) Left Side CGIT Panel - 1pc (35) Drip Tray Guide(Cen1er) - Tpc (36) Right Door - 1pc
(39) Drip Tray Guide(Right) - (pt: (40) Brace(Ffrbox)- 1pc —)
(43) Air\/ant Handle - 2pc5
c:q@
(46) HInges(Lid) — 4pcs (47) Hinges(Body) — tflpcs
J.
(51) Lower storge sheff leg - 1pc (52) Direction.-,1| caste; - gpcs
(49) Right side cart panel - 1pc
, .
-NI! ' Iffiil ‘-1)
III! II)! (III [III
III!
III!
nu _.
nu »
an _
, Mu -
111/
.
(56) Front Fence Rail - 1pc
(54) Oil cup(Gn'ddIe) - 1pc (55) Tank retainer screw - 1pc
(53) Left Fence Rail ~ 1pc
/
(57) Back Fence Rail - 1pc
\
(58) Magnetic Door Stopper - Zpcs

Hardware
Hardware List
(A) BOLT M4X8
(14PCS)
(B) BOLT M6X12
(wqpc)
(C) BOLT M6X35
(12903)
(D) BOLT M6X4O
(spas)
€■_■ (E) PIN Roll 7*22*2
(ZPCS)
In) €œO■ €œO■ ½a■
(4F’CS)
{G} "K" Nut M4
(zpcs)
’ O (H) NUT M6 FLANGE LOCK
\ 4 (1q)=cs)
(I) "R" PIN 15* 28
{6F'CS)
(J) Battery{AA)
(196)

Assembly Instructions
Step 1:
Assemble four Iegs(12,13,28,:29_ to
the body(38) using BOLT M6X12(B)-
14pcs.
Step 2:
Assemble bottom shelf (18) to the
four legs using BOLT M6X12 (B)-
4pcs.

Assembly Instructions
Step 3:
Assemble four directional casters
(‘[7’) to the four legs and two
directional casters (52) to the
bottom shelf.
Step 4:
Turn over the grill body and
assemble the left side can panel (34)
to the body using BOLT M6X12 (B)-
4pcs.
-If}

Assembly Instructions
Step 5:
Assemble lower back panel (48) to
the back of body using BOLT
M6X12 (B)—4pcs.
Step 6:
Assembfe the right side cart panel
(49) to the right legs using BOLT
M6X12 (B)-4pcs.
4-1

_ (B)—4pcs.
Assembllnstructions % J
Step 7:
Assemble right drip tray guide (39)
and center drip tray guide (35) to the
bottom of right body. Using M6X12
Step 8:
Assemble brace (40) to the right
legs using BOLT M6X12 (B)-4pcs
and PIN Roii 7*37*2 (F)—4pcs

Assembly Instructions .
Step 9:
Install the lower stroge shelf leg (51)
to the bottom shelf using BOLT
ll/l6X12(B)-2pcs. Then assemble
lower storge shelf (50) to the panel
and legs using BOLT M6X12(B)-
4pcs.
Step 10:
Assemble three frence rails
(53,56,57) to the left legs and panel
using BOLT M6X12 (B)—12pcs.
4'1

9 Assembly Instructions
Step 11:
Assemble small handle (2) to the
firebox (27) using BOLT M6X12 (B)-
2pcs. Then install the air vent
handle (43) to the firebox.
And then install door handle (42) to
the air vent using BOLT M6X12-
lpcs and NUT M6 FLANGE LOCK-
1pcs.
Last assemble accessory holder
(41) to the firebox using BOLT
M4X8 (A)—4pcs.
Step 12:
Assemble firebox (27) to the body
using BOLT 8X12 (B)-4pcs.
4/I

Assembly Instructions i
Step 13:
Put the bottom cap (37) to the
bottom of grill. Then put Firebox
charcoal pan (25) into the firebox.
WARNING:
IF YOU WANT TO CLEAN THEASH PAN,
PLEASE MOVE THE BOTTOM CAPINADVANCE
Step 14:
Attach the handle (43) to the grill air
vent. Then assemble charcoal
basket lift handle (26) to the left side
of grill using PIN Roll 7*22*2(E)-
1pcs and "R" PIN 1.5*28 (I)-lpcs
‘H11

Assembly Instructions
Step 15:
Assemble lift system (8) to the left
side grili using BOLT M6X12 (B)-
4pcs. See the back view. Then using
PIN Roll 7*22*2 (E)-1pcs and "R" PIN
1.5*28 (i)-tpcs.
Back View
Front View
Step 16:
Install two thermometers (4) to the iid
(44,45). Then assemble two lid
handles (3) to the lid using BOLT
M6X12 (B)—4pcs.

Assembly Instructions
Step'17:
Assemble four hinges (46) to the lid
using BOLT M6X35 (C)-Spcs.
Step 18:
Assemble four hinges (47) to the
body using BOLT M6X4O 8pcs. Then
put the lid on the body using PIN Roll
7*3T*2 (F) 4pcs and "R" PIN 1.5*28
(l) 4:303 to fix the hingeses.
17

Assembly Instructions % -
Step 19: ö■■ s
Assemble two gas stacks (5) to the ; `■■■ "
gas lid and charcoal stack (24) to ’ f V; -T
the charcoal rid using BOLT M6X12 - ‘ ‘
(B) ‘I2pcs and NUT M6 FLANGE - ' ’
LOCK (H)-12pcs. __ — _’ _ _ _“ _ _"*
Step 20:
Assemble warming rack (6) to the
grill using BOLT |Vl6X35 (C)-4pcs.
40

Assembly Instructions _ I
Step 21:
Assemble grease pan connector (19)
to the right side of gas grill using
BOLT M6X12 (B)—2pcs.
Step 22:
Assemble grease pan connerctor (19)
to the left side of gas grill using BOLT
M6X12 (B)—2pcs.