Renogy 100W Solar Suitcase User manual

1
Solar Suitcase
Renogy 100W Solar Suitcase Manual w/o CC Manual
2775 E. Philadelphia St., Ontario, CA 91761
1-800-330-8678

2
Important Safety Instructions
Please save these instructions.
This manual contains important safety, installation, and operating instructions for the charge
controller. The following symbols are used throughout the manual to indicate potentially
dangerous conditions or important safety information.
WARNING: Indicates a potentially dangerous condition. Use extreme caution when
performing this task.
CAUTION: Indicates a critical procedure for safe and proper operation of the controller
NOTE: Indicates a procedure or function that is important to the safe and proper operation
of the controller.
General Safety Information
•Read all of the instructions and cautions in the manual before beginning the installation.
•It is HIGHLY recommended to install a charge controller in order to charge your batteries.
It is dangerous for unregulated panels to be connected to battery banks.
Battery Safety
•Use only sealed lead-acid, flooded, or gel batteries which must be deep cycle.
•Explosive battery gases may be present while charging. Be certain there is enough
ventilation to release the gases.
•Be careful when working with large lead acid batteries. Wear eye protection and have
fresh water available in case there is contact with the battery acid.
•Carefully read battery manuals before operation.
•Do NOT let the positive (+) and negative (-) terminals of the battery touch each other.
•Recycle battery when it is replaced.
•Over-charging and excessive gas precipitation may damage the battery plates and
activate material shedding on them. Too high of an equalizing charge or too long of one
may cause damage. Please carefully review the specific requirements of the battery used
in the system.

3
Table of Contents
General Information.........................................................................................................................................4
Identification of Parts.....................................................................................................................................4
Installation.............................................................................................................................................................5
Recommended Wiring....................................................................................................................................7
Frequently Asked Questions.....................................................................................................................8
Technical Specifications..............................................................................................................................9
Solar Panel Parameters...............................................................................................................................9
Dimensions........................................................................................................................................................ 10

4
General Information
The Renogy Solar Suitcases combines 2 highly efficient 50W monocrystalline solar panels. This
system is specifically designed for mobile off-grid applications, where space and weight limitations
are abundant. The Solar Suitcase models support 12V deep cycle battery varieties such as
sealed, lead acid, gel, and flooded. With built-in tilting stands, these panels can be adjusted at
different angles to maximize the power output throughout the seasons.
Key Features
•Monocrystalline
•Adjustable corrosion resistant aluminum stand.
•Heavy duty handle and latches for longevity
•Convenient storage case for easy transportation.
•Expandable with other solar suitcases based on space availability
NOTE: The suitcases require an adapter kit, a charge controller, and a tray cable. These
components require a separate purchase.
Identification of Parts
Key Parts
1
4
3
5
2

5
1. Junction Boxes
2. Tilt Stands
3. Latches
4. Handle
5. MC4 Connections
Installation
1. Unlatch and unfold unit
2. Unscrew butterfly nut tilt to desired angle and lock butterfly nut

6
To maximize the output, adjust the angle of the suitcase regularly to track the sun’s movement
throughout the season
Summer
𝜃 = 𝐿𝑎𝑡𝑖𝑡𝑢𝑑𝑒 – 15°
Fall and Spring
𝜃 = 𝑎𝑡 𝑙𝑎𝑡𝑖𝑡𝑢𝑑𝑒
Winter
𝜃 = 𝐿𝑎𝑡𝑖𝑡𝑢𝑑𝑒 + 15°
𝜃

7
Recommended Wiring
The 100W Solar Suitcase is shipped by itself without any additional components. In order to
utilize the suitcase efficiently, it is highly recommended that users put their system together with
the following components:
1. Adapter kit—has an MC4 connection on one end and bare wire on the other end for
connecting to a charge controller.
2. Charge controller—regulates the solar panel power to efficiently charge batteries.
3. Traycable—has a bare wire on one end anda battery “O-ring” on the other end for connecting
the charge controller to the battery bank.
4. Battery bank—where power from the solar panels will be stored.
NOTE: Depending on the user’s preference, different gauge wires, wire lengths, charge
controllers, and cables could possibly be used.
1. Use tray cable to connect battery bank to charge controller’s battery terminals
2. Connect adapter kit to MC4 connections coming from the suitcase’s junction box
3. Connect adapter kit to charge controller PV terminals

8
Frequently Asked Questions
Q. What type of batteries can be used with this kit?
A. Any sealed lead acid, gel, or flooded 12V battery (typically used in caravans, motorhomes,
boats etc.) is appropriate for use with this kit.
Q. Can this kit charge a 24V battery?
A. No, because this kit is designed to charge a 12V battery. Technically, it’s possible to change
solar panel connections to enable the kit to work in 24V mode; however, a qualified,
knowledgeable individual should only do this.
Note: unauthorized modification to 24V will void the warranty.
Q. Can the kit charge two or more 12V batteries connected in parallel?
A. Yes, it’s possible if the batteries have the same type and capacity and are wired in parallel as
a single 12V battery bank.
Q. Is there any risk that the solar kit will over charge my battery?
A. One of the functions of the solar charge controller is to ensure that your battery is not over
charged; therefore there is no risk of overcharge.
Q. Can I extend the battery leads?

9
A. Yes, it’s possible – please choose the same size of cable for extension. However, there longer
the extension, the greater the line loss. Bigger gauge will be required for longer runs.
Q. Do I need to clean the solar panels?
A. Yes, it is recommended for better performance. Dust and dirt should first be swept off the
panel surface using a soft brush. When the sweeping is complete, use a wet cloth to wipe the
panel surface to remove remaining dirt and grime.
Q. Can rain damage the solar kit?
A. The solar panels are fully waterproof (IP66 class), the controller is not. We recommend
protecting the kit from rain, since water into controller may damage the internal circuitry.
Technical Specifications
Solar Panel Parameters
Description
100 W Parameters
Maximum Power
100 W
Open Circuit Voltage (Voc)
21.6 V
Short Circuit Current (Isc)
6.17 A
Maximum Power Voltage (Vmp)
18.0 V
Maximum Power Current (Imp)
5.71 A
Cell Type
Monocrystalline
Operating Temperature
−40°F to +185°F
Folded Size
19.9 x 27.2 x 2.4 in
Net Weight
27.05 lbs.

10
Dimensions
100W Suitcase
•Leg stand length: 18 in. (long part), 14.5in. (short part)
Updated: July 28, 2015