Saber Compact ATD-80351 User manual

ATD-80351
SABER 15W CORDED UNDERHOOD LIGHT
USER’S MANUAL
FEATURES:
x30 Super Bright SMD LEDs
x18/2 SJTOW 25 cord remains Ňexible in cold weather and water resistant
xABS handle with double injec on, impact protec on and ergonomic design provides comfortable usage
xAluminum alloy hook with PVC cover for pr coated padded hooks help prevent scratching
of the vehicles surface
xThe bar extends from 47" to 75" and easily aches to most SUV's and trucks
x360 degree ratche hooks provide safe and Įƌŵ ment.
xCSA listed
California Prop 65 WARNING:
This product contains chemicals including lead, known to the State of California to cause cancer, birth defects, or other
repr ve harm. Wash hands handling.



GeneralSafetyWarnings:

WARNING:Theinstructionsandwarningscontainedinthismanualshouldbereadandunderstoodbeforeusing
oroperatingthistool.Donotallowanyonetouseoroperatethistooluntiltheyhavereadthismanualandhave
developedathoroughunderstandingofhowthistoolworks.Failuretoobserveanyofthefollowinginstructionscould
resultinseverepersonalinjurytotooluserandbystanders,orcausedamagetothetoolandproperty.Keepthismanual
forfuturereference.

Note:Thewarningsandcautionsdiscussedinthisinstructionmanualcannotcoverallpossibleconditionsand
situationsthatmayoccur.Itmustbeunderstoodbytheoperatorthatcommonsenseandcautionarefactorswhich
cannotbebuiltintothisproduct,butmustbesuppliedbytheoperator.

WARNING:Usesafetyequipment.Usersandbystandersshouldusesafetygogglesorsafetyglasseswithside
shieldswhichcomplywithcurrentnationalstandards,orwhenneeded,afaceshield.UseanANSIapproveddustmaskor
respiratorwhenworkingaroundmetal,wood,andchemicaldustsandmists.Thisappliestoallpersonsintheworkarea.
AlsousenonͲskidsafetyshoes,hardhat,gloves,dustcollectionsystems,andhearingprotectionwhenappropriate.
WARNING:Keepbystandersandchildrenoutoftheworkareawhileoperatingthistool.

WARNING:Alwayskeepyourworkareaclean,uncluttered,andwelllit.Clutteredordarkareasinviteaccidents
andinjuries.DONOTworkonfloorsurfacesthatareslippery.

WARNING:Donotoperatethistoolifyouaretiredorundertheinfluenceofalcohol,drugs,ormedicationsthat
couldaffectyourabilitytousethetoolproperly.

WARNING:Dressproperly.Donotwearlooseclothingorjeweleryastheycanbecaughtinmovingparts.Wear
restrictivehaircoveringtocontainlonghair.

WARNING:Donotreachoveroracrossrunningmachines.Keepproperfootingandbalanceatalltimes.NonͲ
skidfootwearisrecommendedwhenworking.


ElectricalSafetyWarnings:

WARNING:Readallsafetywarningsandinstructions.Failuretofollowallwarningsandinstructionsmayresult
inelectricshock,fireand/orseriousinjuryordeath.

WARNING:Beforeconnectingatooltoapowersupply,alwayschecktoensurethepowersupplycorrespondsto
thevoltageonthenameplateofthetool.Apowersupplywithavoltagegreaterthanthatspecifiedforthetoolcan
resultinseriousinjurytotheuser,aswellasdamagetothetool.Usingapowersupplywithavoltagelessthanthe
nameplateratingisharmfultothemotor.Ifindoubt,donotpluginthetool.


WARNING:Groundedtoolsmustbepluggedintoanoutletproperlyinstalledandgroundedinaccordancewith
allcodesandordinances.Thistoolisequippedwitha3Ͳprongpluganda3Ͳwiregroundingsystem.Neverremovethe
groundingprongormodifythepluginanyway.Donotuseanyadapterplugs.Checkwithaqualifiedelectricianifyou
areindoubtastowhethertheoutletisproperlygrounded.

NOTE:Doubleinsulatedtoolsareequippedwithapolarizedplug(onebladeiswiderthantheother).Thisplug
willfitinapolarizedoutletonlyoneway.Iftheplugdoesnotfitfullyintheoutlet,reversetheplug.Ifitstilldoesn’tfit,
contactaqualifiedelectriciantoinstallapolarizedoutlet.Donotchangethepluginanyway.

WARNING:Toreducetheriskofelectricshock,DONOTuseindampconditions,onwetsurfaces,orexposeto
rain.Donotpluginthistooloroperateitwithwethandsorwhilestandinginwater.

WARNING:Neverusethecordforcarrying,pullingorunpluggingthepowertool.Graspplugandpullto
disconnectfromoutlet.Keepcordawayfromheat,oil,sharpedgesormovingparts.Replacedamagedcords
immediately.

WARNING:Donotcarrythepowertoolwithyourfingerontheswitch.Ensuretheswitchisintheoffposition
beforepluggingthetoolintothepoweroutlet.Intheeventofapowerfailurewhileatoolisbeingused,turntheswitch
offtopreventsurprisestartingwhenthepowerisrestored.

WARNING:Alwaysremovethepowercordfromtheelectricoutletwhenmakingadjustments,changingparts,
cleaningorworkingonthetool.

WARNING:Careshouldbetakentoarrangethecordsoitwillnotbesteppedon,trippedover,orotherwise
subjectedtodamageorstress.

WARNING:Neverattempttopluginoroperateequipmentwithdefectiveordamagedwires,powercordor
powercordplug.Haveanydefectiveordamagedpartsreplacedimmediatelybyqualifiedpersonnel.

WARNING:Avoidbodycontactwithelectricallygroundedsurfaces.Thereisanincreasedriskofelectricshockif
yourbodyisgrounded.

WARNING:IftheworkareaisnotequippedwithapermanentlyinstalledGroundFaultCircuitInterrupteroutlet
(GFCI),useaplugͲinGFCIbetweenthepowertoolorextensioncordandthepowerreceptacle.

WARNING:Ifanextensioncordisnecessary,useonly‘Listed’extensioncords.Ifusedoutdoors,theymustbe
marked“ForOutdoorUse”.Thosecordshavinga3Ͳpronggroundingtypeplugsandmatingreceptaclesaretobeused
withgroundedtools.

WARNING:Useofimpropersizeorgaugeofextensioncordmaycauseunsafeorinefficientoperationofyour
tool,orcausedamagetoyourtool.Besureyourextensioncordisratedtoallowsufficientcurrentflowtothemotor.If
indoubt,alwaysusealargergaugecord.Besuretocheckthevoltagerequirementsofthetooltoyourincomingpower
source.


NOTE:Thetablebelowshowsthecorrectsizetouseaccordingtocordlengthandtheamperagedrawofthetool
(specifiedonthenameplate).Whenindoubt,usethenextheaviergauge.Thesmallerthegaugenumber,theheavier
thecord.(AWG=AmericanWireGauge).

MinimumGaugeforExtensionCords(AWG)
(whenusing120voltsonly)
AmpereRatingTotalLengthofCordinFeet(meters)
MoreThanNotMoreThan25'(7.6m)50'(15m)100'(30.4m)150'(45.7m)
0618161614
61018161412
101216161412
12161412NotRecommended




ATDͲ80351SpecificSafetyInstructions:

WARNING:Read all instructions before using

WARNING:For indoor use only – do not use in or around, tubs, showers, sinks, pools, hot tubs, or in a wet
environment

WARNING:Use only the recommended voltage and frequency requirements

WARNING:Do not move or turn off light by pulling the power cord
WARNING:Do not use if the cords or Clear tube are damaged
WARNING:Keep out of reach of children
WARNING:Do not operate light with wet hands.
WARNING:Keep lamp away from hot objects.

Operating Instructions:
To use, plug the unit into any 110-120 VAC power source, such as a wall receptacle.
Press the on/off switch (l) to turn unit on, press the other side of switch (0) to turn it off.
With the unit plugged in and turned on, the brightness adjust button will toggle your underhood
light between the 7W and the 15W settings. The 7W setting is indicated with 3 LED’s lighting up
while the 15W setting is indicated by all five LED’s lighting up.
The hooks can be adjusted by simply pulling out on them and affixing to whatever surface you like,
such as a car hood. (Up to 75” wide)
Once your light is in place, it can be rotated to the desired position by simply twisting the light. You
will hear ratcheting “clicks” as you rotate it.
OFF 7W 15W

ATD-80351
Visit us at www.atdtools.com
Copyright (C) 2013 ATD Tools, Inc. All rights reserved.
ITEM# ORDERINGPART# PART DESCRIPTION ITEM# ORDERING PART# PART DESCRIPTION
1 PRT80355-01 PULL ROD ASSY 8 PRT80351-09 BRIGHTNESS INDICATE COVER
2 PRT80351-03 LEFT HANDLE SET 9 PRT80351-10 RIGHT HANDLE SET
3 PRT80355-04 SCREW 2.9X6 10 PRT80351-11 ON/OFF SWITCH
4 PRT80351-05 PROTECTING COVER 11 PRT80351-12 BRIGHTNESS INDICATE BOARD
5 PRT80351-06 LED PCB 12 PRT80351-13 POWERCORD
6 PRT80351-07 CLEAR TUBE LOWER 13 PRT80351-18 DRIVER
7 PRT80351-08 SCREW 2.9X16 14 PRT80351-19 ALUMINUMTUBE,UPPER