Sailfish 220 WAC User manual

10/15/2014 Sailsh270CCOwner’sManual|sailshboats.com 1
05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 1
Sailsh 220 CC
Title
Demand The Difference
Sailfish 220 WAC Owner’s Manual

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 1
2. Boat Specication
3. Sailsh Boats Trailer Measurement Chart
4. Boat Layout
5. Seating Locations
6. Breaker Panel Schematic
7. Switch Panel Schematic
8. Distribution Harness
9. Adapter Harness
10. Battery Installation - Perko Switch
11. Fuel System Layout
12. Plumbing Diagram
13. Helm Area
14. UFLEX Steering System
15. Ignition Switches, Engine Shut-Off Cord/Lanyard
16. Plug and Play Wiring
16. Fuel-Water Separator - Yamaha
17. Console / Head Area
18. Bilge Access and Explanation
19. Bilge Pumps
20. Raw Water Washdown System
21. Freshwater Washdown and Shower System
22. Livewell Operation
23. Trim Tab Maintenance
24. Optional Porta Potti
26. Vinyl Care and Cleaning
27. Aluminum Cosmetic Corrosion (Pitting)
28. Caring for Aluminum
29. Caring for Stainless Steel
30. Windshield, Window and Hatch Care Instructions
31. Gel Coat
Table of Contents

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 2
Sailsh 220 WAC Specications
SPECIFICATIONS
LOAHullOnly........................................ 21’3”
LengthRigged....................................... 23’6”
Beam....................................................... 8’6”
FuelCapacity................................ 93Gallons
FreshWater.................................... 6Gallons
Weight.............................................4,950lbs.
CockpitDepthRear................................... 26”
MaxHorsepowerSingle...................... 200hp
Draft(HullOnly)........................................ 18”
DeadRise(Multiangle).......................22°-24°
BatteryCapacity........................................... 2
RodHolders(Standard)............................. 10
BridgeClearancewithTop...................... 8’4”
PersonCapacity........................................... 8
STANDARDFEATURES
Boat
• BoardingLadder(3step)
• BuiltInRiggingTubes(FromBilgetoHelmwithpull
tapes)
• CarbonFiber&Kevlar®ReinforcedDeck&Hull
• ClosedCellFoamFlotation
• CockpitBolsters
• ExclusiveDotMatrixNon-Skid
• ExclusiveVDSHullDesign(VariableDeadrise
SteppedHull)
• FaucetatSink
• HydraulicSteeringw/TiltWheel&PowerKnob
• MercuryVeradoFuelFilter/WaterSeparator
• RecessedSSTCupHolders(5)
• SailTechCompositeFullLengthTransom
• SailTechFoamFilledFiberglassStringerSystem
• StainlessSteeringWheelw/PowerKnob
• WalkThruTransomDoorwithWaveGuardStep
• Yamaha10MicronFuelFilter/WaterSeparatorw/
SSBase
CabinAmenities
• Cabin25Qt.Cooler
• CabinButaneStove/Sink/Freshwater/Table
• CabinV-BerthCushionsandFillerCushions
• Mirror
Electrical
• AccessorySwitchPanelw/CircuitBreakers
• CabinLighting
• Compass
• DualBatterySwitch
• ElectricHorn
• FullDigitalInstrumentation
• LEDInteriorCockpit&BilgeLighting
• LEDNavigationalBow&AnchorLight
• RemoteControlForStereoatHelm
• Stereo(BluetoothCapable,AM/FMw/4Speakers)
• TrimTabsWithIndicatorSwitch&BuiltInAuto
RetractFeature
• 12VoltDCAccessoryPlug
Fishing
• Baitwellw/LEDLighting-25gal.Transom
• Built-InTackleStorage(AftUnderTransomDoor)
Hardware
• BowAnchorRoller
• FenderCleatsAft(2)
• FlushMountHingesandLatches&DeckPlates
• HeavyDutyStainlessSteelBow&SternEyes
HeavyDutyStainlessSteelRubRail
• MarineGradeStainlessSteelHardware
• SailshEngravedTransomPlate
• StainlessSteel&BronzeThruHullFittings
• StainlessSteelFullBowRail
• StainlessSteelPropeller(s)
• StainlessSteelRodHolders(4)
Helm
• LargeDashArea(Capableofushmounting10”
Screen)
Plumbing
• AutomaticBilgePump(2000GPH)
• FreshwaterShowers(2)-TransomandCabin
• HighSpeedLivewellPickup
• PortaPotti
• RawWaterWashDown
• SelfBailingCockpit
• SinkwithFaucet(InCabin)
Storage
• AnchorLocker(w/BowRoller)
• BatteryStorage(BilgeCompartment)
• Insulated-FishBox/Storage(LeaningPost)
• RecessedRodStorage-Port&Starboard
Seating
• LeaningPost(L/P4)Fiberglassw/FishBox&Cooler
OPTIONS
BoatOptions
• 25qt.IglooCoolers(pr)
• BiminiTop
• CommandLinkPlus(CSeriesMotorsOnly)
• LeaningPostCover
• UnderwaterLEDLights(2)
• VesselView4”
ElectricalOptions
• Built-In2BankBatteryCharger
• FusionSatelliteRadioUpgrade
• GarminB60AirmarThruHullTransducerw/oCHIRP
• GarminB75MAirmarThruHullTransducerw/CHIRP
• GarminGPSMap741xsw/oTransducer
• GarminGPSMap840xsw/oTransducer
• GarminVHFRadio&Antenna
• SolarBatteryCharger,HardTopOnly
HardwareOptions
• Mid-ShipFenderCleats(2)
• SkiTowBar(Retractable)
SeatingOptions
• RearJumpSeats
OptionalPackages
• OffshoreTournamentPack
HardTop,PowderCoatedw/Built-InRadioBox,
FlushMountCleats&TransomRodHolders(3)
EngineOptions
Yamaha
• F150XB
• F200XB
• F200XCA
Mercury
• 150XL
• 200XLVerado

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 3
Sailsh Boat Trailer Measurement Chart
Boat Models B C D E F G H I
208 CC 78 in. 53 in. 28 in. 11 in. 82 in. 218 in. 235 in. 27 in.
1900 BB 88 in. 66 in. 37 in. 10.5 in. 99.5 in. 198 in. 217 in. 24 in.
2100 BB 88 in. 66 in. 37 in. 10.5 in. 99.5 in. 220 in. 240 in. 24 in.
220 CC & 220 WAC 87 in. 59 in. 31 in. 14.5 in. 102.5 in. 216.5 in. 243 in. 32 in.
236 CC & 241 CC & 245 DC 91 in. 57.5 in 30 in. 14 in. 103 in. 250 in. 273 in. 36 in.
240 CC & 240 WAC & 242 CC 92 in. 59 in. 31 in. 15 in. 107 in. 241 in. 272 in. 30 in.
270 CC & 270 WAC & 275 DC 94 in. 59 in. 31 in. 15 in. 107 in. 268 in. 302 in. 30 in.
290 CC 94.5 in. 61 in. 32 in. 15.5 in. 107 in. 301 in. 336 in. 30 in.
320 CC & 320 EXPRESS & 325 DC 105 in. 65 in. 33 in. 16.5 in. 115 in. 315 in. 349 in. 38 in.

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 4
Sailsh 220 WAC Boat Layout
Key Description
1Boarding Ladder
230 Gallon Livewell
3Fresh Water Fill
4Bilge Access
5Fuel Sender and Pick-up Access
6Removable Cooler
7Leaning Post
Key Description
8Helm Area
9Cabin Door
10 Fuel Fill
11 Full Wraparound Windshield
12 Anchor Locker
13 Full Bow Rail
14 Anchor Roller
q
i
yd
f
g
o
a
e
w
r
tu
s

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 5
Sailsh 220 WAC Seating Locations

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 6
Breaker Panel Schematic
Download High Resolution Diagram

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 7
Switch Panel Schematic
HORN NAV
ACCYACCYBAITWELL
6"
PLUG "A"
12WAYF
W/PINS
A
PLUG "B"
12WAYF
W/PINS
B
6" 6"
2
ANC
FRESH
WATER
DECK
LIGHTS
SPREADER
LIGHTS
WASH
DOWN
BILGE
PUMP
Download High Resolution Diagram

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 8
Distribution Harness
Download High Resolution Diagram

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 9
Adapter Harness
Download High Resolution Diagram

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 10
Battery Installation: Perko Switch
Battery 1
Battery 2

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 11
Fuel System Layout
Key Description
1Primer Bulb - N/A on Verado
2Fuel Filter Access - Yamaha & Verado Only
3Fuel Tank Location
4Fuel Pickup
5Fuel Sender
6Fuel Fill
y
e
ee
e
q
w
y
r
t

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 12
Plumbing Diagram - 220 WAC

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 13
Helm Area
Key Description
1Compass
2Optional Garmin Unit
3Brand Specic Motor Guages
4Switch Panel
5Trim Tab Actuator Switches
6Binnacle
7Tilt Helm w/ Stainless Wheel and Power
Knob
8Breaker Panel
9Ignition Switches and Emergency Shut-
off Cord
q
i
u
o
w
er t
y
e

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 14
Sailsh 220 WAC
UFLEX Steering
System
UFLEX has been the choice for steering for
Sailsh boats for the last three years because of
the quality of the USA built products.
Every helm comes standard with a full stainless
steel shaft; cylinders are built with carbon steel
pistons, coupled with extra-large end caps to
prevent leakage.
All of their connection materials are 304 stain-
less steel that has been electro-polished and
passivated.
For more information on the service and main-
tenance of your UFLEX system please refer to
your UFLEX owner’s manual or view it elec-
tronically at http://uexusa.ultraexgroup.com/
public/File/UFLEX2013_USA.pdf

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 15
Sailsh 220 WAC
Ignition Switches, Engine
Shut-off Cord/Lanyard
Each Sailsh boat will be equipped with a Yamaha or
Mercury ignition switch with an emergency engine shut off
cord/lanyard.
This lanyard should be worn at all times while operating
the vessel, if the vessel operator falls or moves a unsafe
distance away from the helm controls the lanyard will pull
out causing the engine to shut down.
Make sure the lanyard is not attached to a part of your
clothing that could be easily torn free causing the switch
not to pull. See your YAMAHA or MERCURY owner’s
manual for more information on this safety feature.
Engine Break-In Period
Each new outboard motor will need to go through a break
in period to make sure all of the internal moving parts and
components have a chance to correctly mate.
For more information on the break in period specic to
your engine please refer to your YAMAHA or MERCURY
Owner’s manual.

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 16
Sailsh 220 WAC
Plug and Play Wiring
Deutsch Connectors are quick disconnect plugs
used for durability and ease of replacing compo-
nents in your Sailsh Boat.
These water resistant plugs are for use in
electrical systems where moisture, salt spray, dirt
and dust could affect the electrical connections
or systems.
Fuel-Water Separator
Sailsh has rigged either Yamaha or Mercury, (Verado
Only), water fuel separators in the bilge compartment.
Each engine will have its own lter. These lters can be
accessed through the bilge access doors, in the back of
the boat. For more information on these lters, please
review your Yamaha or Mercury Owner’s Manuals.

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 17
Console/Head Area
Key Description
1Large panel for easy access
to Console Components
2Portable Stove
3Freshwater Sink
4Cooler Storage
5Cabin Door
6Standard Stereo
7Optional Porta Potti
u
t
y
r
q
we

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 18
Sailsh 220 WAC
Bilge Access and Explanation
The bilge of your boat can be accessed through the large door in
the aft of the boat. This large door allows easy access too many
of the boats components.
You may also access it through the two access plates in the
splash-well.
The bilge area of your sailsh boat should be
checked before, during and after each operation.
A small amount of water in this area is normal but large amount of
water could point to a major issue such as a leak. If this situation
presents itself please contact your Authorized Sailsh Dealer
Immediately.
Key Description
1Recessed Battery Selector Switch
2Battery Storage
q
w

05/30/2017 Sailsh220WACOwner’sManual|sailshboats.com 19
Sailsh 220 WAC
Bilge Pumps
All Sailsh Boats are furnished with Rule Bilge Pumps, The Rule
2000 GPH (gallon per hour) pump has a built in automatic oat
switch. This is engaged when the water level rises in the bilge
and the oat rises in the pump causing the pump to turn on.
These pumps can be tested by turning them upside down, the
pump should turn on, once turned back over it will run for a few
more seconds and then shut off. The pumps also have a manual
switch function on the main switch panel.
These pumps are wired into your boat bypassing the battery
switch so that they have power at all times, this allows the
automatic feature to work while you are away from the boat and
the batteries are turned off.
Sailsh boats 241CC and larger are equipped with a forward
bilge pump that is an electronic sensor pump. These pumps
have a state of the art internal water sensor that detects water
and automatically activates the pump when there is enough
present to be pumped out.
These pumps can be tested by placing your nger over the “Test
Area” on the back of the pump for 5 seconds, the pump will
turn on to let you know it is functioning correctly. All wiring and
switches to these pumps are the same as the Rule 2000GPH
pumps.