Samsung IDH1800E User manual

AIR CONDITIONER CONTENTS
1. Precautions
2. Product Specifications
3. Operating Instructions
4. Installation
5. Disassembly and Reassembly
6. Troubleshooting
7. Exploded Views and Parts List
8. Block Diagrams
9. PCB Diagrams
10. Schematic Diagrams
11. Wiring Diagrams
SERVICE Manual
DUCT TYPE AIR CONDITIONER
(Cool and Heat)
IDH1800E
IDH2400E
IDH3200E
DH18ZA1(A2)
DH24ZA1(A2)
DH32ZA1(A2)
INDOOR UNIT
ADH1800E
ADH2400E
ADH3200E
DH18ZA1(A2)
DH24ZA1(A2)
DH32ZA1(A2)
TYPE OUTDOOR UNIT
UBH1800E
UBH2400E
UDH3200E
DH18ZAX
DH24ZAX
DH32ZAX
Duct-ADH1800E-front 2/15/01 6:26 PM Page 2

1. Precautions
Samsung Electronics 1-1
1. Warning: Prior to repair, disconnect the
power cord from the circuit breaker.
2. Use proper parts: Use only exact replacement
parts. (Also, we recommend replacing parts
rather than repairing them.)
3. Use the proper tools: Use the proper tools
and test equipment, and know how to use
them. Using defective tools or test equip-
ment may cause problems later-intermittent
contact, for example.
4. Power Cord: Prior to repair, check the power
cord and replace it if necessary.
5. Avoid using an extension cord, and avoid
tapping into a power cord. This practice
may result in malfunction or fire.
6. After completing repairs and reassembly,
check the insulation resistance. Procedure:
Prior to applying power, measure the resis-
tance between the power cord and the
ground terminal. The resistance must be
greater than 30 megohms.
7. Make sure that the grounds are adequate.
8. Make sure that the installation conditions
are satisfactory. Relocate the unit if necessary.
9. Keep children away from the unit while it is
being repaired.
10. Be sure to clean the unit and its surrounding
area.
11. Be sure that the installed conditions are
satisfactory and correct according to the
specifications.
dangerous
Fig. 1-1 Avoid Dangerous Contact
Fig. 1-2 No Tapping and No Extension Cords
Fig. 1-3 No Kids Nearby!
Fig. 1-4 Clean the Unit
Duct-ADH1800E-1 6/27/00 10:36 AM Page 1-1

1-2 Samsung Electronics
MEMO
Duct-ADH1800E-1 6/27/00 10:36 AM Page 1-2

2. Product Specifications
2-1 Table of Specifications (Duct Type)
Samsung Electronics 2-1
IDH1800E/DH18ZA1(A2)
UBH1800E/DH18ZAX
17,400
5,100
18,400
5,400
1.75
1.65
7.8
7.3
50.0
2.8
2.9
900
800
750
700
17
15
14
13
42
41
40
D-fin coil
2x10x1.7(1100)
Sirocco
70
260
1,340
600
41/57
1,000
650
35
55
IDH2400E/DH24ZA1(A2)
UBH2400E/DH24ZAX
23,000
6,700
24,500
7,200
220-240~ 50Hz
2.30
2.40
10.5
11.0
50.0
2.7
2.8
1,080
980
930
880
20
18
16
15
43
42
41
D-fin coil
2x10x1.7(1100)
Sirocco
100
260
1,340
600
41/57
750
400
45
56
IDH3200E/DH32ZA1(A2)
UDH3200E/DH32ZAX
32,000
9,350
34,900
10,200
3.50
3.60
16.0
16.5
60.0
2.5
2.7
1,300
1,200
1,150
1,100
24.0
22
21
20
53
52
51
wave fin coil
3x8x1.4(1100)
Sirocco
170
260
1,340
600
43/59
900
550
50
62
MODEL
Capacity
Power supply
Power input
Running
current
Starting
current
EER
Indoor
unit
Outdoor
unit
INDOOR UNIT
OUTDOOR UNIT
Cooling
Heating
Cooling
Heating
Cooling
Heating
Cooling
Heating
Fan speed
Air
circulation
Noise Level
(Sound
pressure)
Heat
exchanger
Fan
Dimensions
Weight
Fan speed
Air circulation (Hi)
Sound pressure level
H.H
Hi
Med
Low
H.H
Hi
Med
Low
Hi
Med
Low
type
rowxstagesxfin pitch
type
motor output
H
W
D
kg
Hi
Low
But/h
W
Btu/h
W
kW
kW
A
A
A
A
W/W
W/W
r.p.m.
r.p.m.
r.p.m.
r.p.m.
m3/min
m3/min
m3/min
m3/min
dB(A)
dB(A)
dB(A)
W
mm
mm
mm
Net/Gross
r.p.m.
r.p.m.
m3/min
dB(A)
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-1

2-2 Samsung Electronics
IDH1800E/DH18ZA1(A2)
UBH1800E/DH18ZAX
propeller
35
scroll
ZR22K3-PFJ
1.37
Internal
wave fin coil
2x24x1.7(824)
0.494
Capillary
2,000
620x787x320
63/68
27/19
20/15
35/24
7/6
9.52(3/8")
15.88(5/8")
Flare
Max. 15
Max. 30
IDH2400E/DH24ZA1(A2)
UBH2400E/DH24ZAX
propeller
60
scroll
ZR28K3-PFJ
1.74
Internal
D fin coil
2x24x1.7(896)
0.583
Capillary
2,400
638x880x310
67/72
27/19
20/15
35/24
7/6
9.52(3/8")
15.88(5/8")
Flare
Max. 15
Max. 30
IDH3200E/DH32ZA1(A2)
UDH3200E/DH32ZAX
propeller
115
scroll
ZR42K3-PFJ
2.61
Internal
wave fin coil
2x30x1.7(886)
0.665
Capillary
2,500
790x880x310
77/83
27/19
20/15
35/24
7/6
9.52(3/8")
15.88(5/8")
Flare
Max. 15
Max. 30
MODEL
Outdoor
Unit
Condition
Piping
INDOOR UNIT
OUTDOOR UNIT
Fan
Compressor
Heat
exchanger
Refrigerant
Dimensions
Weight
Indoor unit
Outdoor unit
Pipe O.D.
size
Connection method
Between
type
motor output
type
model
motor output
protection
type
rowxstagesxfin pitch
face area
control
(R22)charge
(HXWXD)
kg
Cool(DB/WB)
Heat(DB/WB)
Cool(DB/WB)
Heat(DB/WD)
Liquid
Gas
Height
Pipe length
W
kW
m2
g
mm
Net/Gross
˚C
˚C
˚C
˚C
mm(inch)
mm(inch)
m
m
Product Specifications
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-2

2-2 Dimensions
2-2-1 Indoor unit
Samsung Electronics 2-3
Indoor Unit Dimensions (ADH1800E / 2400E / 3200E)
(DH18ZA1(A2) / DH24ZA1(A2) / DH32ZA1(A2)
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-3

(a) 18K BTU
2-4 Samsung Electronics
(b) 24K BTU
2-2-2 Outdoor Unit
Product Specifications
(Front view) (Rear view)
620
582
787
(Front view) (Rear view)
340
638
660
878
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-4

2-5
(c) 32K BTU
Product Specifications
Samsung Electronics
(Front view) (Rear view)
790 310
660
880
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-5

• Wired Remote Controller - Buttons and Display
2-6 Samsung Electronics
Product Specifications
The wired remote controller is an optional accessory.
Note : - Test button is for your installation specialist. You must NOT press it.
- After cleaning the air filter, press the filter reset button, if the filter has been installed.
Then the wired remote controller will display the FILTER SIGN indicator when the time to
clean the air filter; refer to page 30.
Communication error indicator
On Timer setting
Off Timer setting
Test indicator
On Timer button
Off Timer button
Test button Filter Reset button
Mode selection button
Temperature adjustment
buttons
Removing frost indicator Centralized controller indicator
(In case of installing the Centralized controller)
Temperature setting
Fan speed
Filter Sign indicator
On/Off & Timer
Set/Cancel button
Fan speed
adjustment button
On/Off indicator
Operating mode
The wired remote controller is installed on the wall.
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-6

• Wireless Remote Controller-Buttons and Display
Samsung Electronics 2-7
Product Specifications
The wireless remote controller is an optional accessory.
Note : After cleaning the air filter, press the filter reset button, if the filter has been installed.
Operating mode Mode selection button
Filter Reset button
Timer Cancel button
On Timer button
Off Timer button
On/Off & Timer
Set/Cancel button
Fan speed adjustment
button
Temperature adjustment
buttons
Temperature setting
Fan speed
On Timer setting
Off Timer setting
Battery discharge indicator
Duct-ADH1800E-1 6/27/00 10:36 AM Page 2-7