Scheu Products Company SPC-21-PHTTS User manual

STOP
QUESTIONS?
MISSING / DAMAGED PARTS
Please do not return this product to the store.
If a part is damaged or missing, simply e-mail us at
[email protected],orvisitourwebsiteat
http://allpro-heaters.com,orcallourCustomer
Service Department at [phone].
Wewill be happyto assist you!
Youcanregisteryourheateronlineat
http://allpro-heaters.com/warranty.
© 2002 Scheu Products Company
OWNERS MANUAL
PROPANE PATIO HEATERS
Models
SPC-21-PHTTS
RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE
TABLE OF CONTENTS
HEATER SPECIFICATIONS................................................................................................................ 2
WARNINGS .................................................................................................................................. 2
OPERATING PRECAUTIONS............................................................................................................. 3
SAFETY PRECAUTIONS.................................................................................................................... 3
ODOR FADE WARNING...................................................................................................................... 4
ASSEMBLY INSTRUCTIONS ............................................................................................................. 5
OPERATING INSTRUCTIONS ......................................................................................................... 5-6
SERVICING ......................................................................................................................................... 6
PARTS LISTING .................................................................................................................................. 7
WARRANTY......................................................................................................................................... 8
SERVICE CENTERS .......................................................................................................................... 8
INSTRUCTIONS FOR ORDERING PARTS ........................................................................................ 8
WARRANTY REGISTRATION............................................................................................................. 9

Models
SPC-21PHTTS
Page-2-
GENERALHAZARDWARNING:
FAILURETOCOMPLYWITHTHEPRECAUTIONSANDINSTRUCTIONSPROVIDEDWITHTHISHEATER,CANRESULTIN
DEATH,SERIOUSBODILYINJURYANDPROPERTYLOSSORDAMAGEFROMHAZARDSOFFIRE,EXPLOSION,BURN,
ASPHYXIATION,CARBONMONOXIDEPOISONING,AND/ORELECTRICALSHOCK.
ONLYPERSONSWHOCANUNDERSTANDANDFOLLOWTHEINSTRUCTIONSSHOULDUSEORSERVICETHISHEATER.
IFYOUNEEDASSISTANCEORHEATERINFORMATIONSUCHASANINSTRUCTIONSMANUAL,LABELS,ETC.CONTACT
THEMANUFACTURER.
WARNING: FIRE, BURN, INHALATION, AND EXPLOSION HAZARD. KEEP SOLID COMBUSTIBLES, SUCH AS
BUILDINGMATERIALS,PAPERORCARDBOARD,ASAFEDISTANCEAWAYFROMTHEHEATERASRECOMMENDED
BYTHEINSTRUCTIONSNEVERUSETHEHEATERINSPACESWHICHDOORMAYCONTAINVOLATILEORAIRBORNE
COMBUSTIBLES,ORPRODUCTSSUCHASGASOLINE,SOLVENTS,PAINTTHINNER,DUSTPARTICLESORUNKNOWN
CHEMICALS.
HEATER SPECIFICATIONS
Type of Gas: For use with Propane Only (16.4 oz. Propane Gas Cylinder)
Gas Supply Pressure
to regulator Maximum: 150 psig (1034.2 kPa) Minimum: 5 psig (34.5 kPa)
regulator out 11" W.C. (2.74 kPa)
Ignition: Piezoelectric Pilot Ignitor
Flame Safety: Thermocouple Operated Gas Valve
Model: SPC21PHTTS
Rating: 10,000 - 15,000 BTU/hr (2.93 - 4.40 kW)
Consumption: 2.0 -1.25/hr., 0.46-0.70 lbs/Hr (0.21-0.32 Kg/Hr)
(per 16 oz. LP Cylinder)
WARNING:NOTFORHOMEORRECREATIONALVEHICLEUSE
WARNINGS
YOUR SAFETY IS IMPORTANT TO YOU AND TO OTHERS, SO PLEASE
READ THESE INSTRUCTIONS BEFORE YOU OPERATE THIS HEATER.
Scheu Products Company, Incorporated
Mail: P.O. Box 250, Upland, CA 91785
Plant: 8855 Baker Ave., Rancho Cucamonga, CA 91730
Telephone:[phone]
www.scheuco.com
[email protected] 8524
September 2002

Models
SPC-21PHTTS
Page-3-
OPERATING PRECAUTIONS
This is a propane, direct-fired heater.
Propane is heavier than air. If propane leaks from a connection
or fitting, it sinks to the floor, collecting there with the
surrounding air, forming a potentially explosive mixture.
Obviously, propane leaks should be avoided, so set up the
propane supply with utmost care. Read enclosed Odor Fade
and Propane Sheet for additional information about detecting
propane leaks. Leak check new connections or reconnections
with a soap and water solution and follow all connection
instructions herein. Also, ask your propane dealer for advice on
the propane application and supply installation and ask him to
check it if there are any questions.
Direct-Fired means that all of the combustion products enter the
heated space. Even though this heater operates very close to
100 percent combustion efficiency, it still produces small
amounts of carbon monoxide. Carbon monoxide (called CO) is
toxic. We can tolerate small amounts but not a lot. CO can build
up in a heated space and failure to provide adequate ventilation
could result in death. The symptoms of inadequate ventilation
are: headache dizziness
burning eyes and nose nausea
dry mouth or sore throat
So, be sure to follow advice about ventilation in these operating
instructions.
When the heater is to be operated in the presence of other
people the user is responsible for properly acquainting those
present with the safety precautions and instructions, and of
thehazardsinvolved.
SAFETY PRECAUTIONS
1.This heater is designed for OUTDOOR USE ONLY. Even
so, make sure there is ample fresh air ventilation. Do not
use in buildings, garages, of other structures.
2.Items or material, when stored under the heater will be
subjected to radiant heat and could be seriously
damaged.
3.Maintain minimum clearances to people or normal
combustible materials: 10"- Horizontal from reflector and
ceiling, 30" from floor.
4.Always position heater on a firm level surface.
5.Do not operate this appliance in windy conditions.
Maximum allowable wind speed is 10MPH (16m/h).
6.Do not operate this appliance in temperature conditons
below 40ºF (5ºC).
7.Install this heater such that it is not directly exposed to
water spray, rain and/or dripping water.
8.Carefully supervise children and animals when heater is
in use.
9.Due to high surface temperatures, adults and children
must observe clearances to avoid burns or clothing
ignition.
10.Do not hang clothing or flammable materials either on or
near heater.
11.Do not spray aerosols near the heater during use or
shortly thereafter.
Warning: For Outdoor Use Only
12. Keep the heater away from areas where flammable liquids,
vapors or solids are stored or used.
13. Do not alter or modify the heater in any manner, and do not
operate a heater that has been modified from its original
condition.
14.Use only propane gas.
15.Use only VAPOR WITHRAWAL propane supply. If there is
any question about vapor withdrawal, ask your propane
dealer.
16.The propane cylinder must be arranged for vapor-withdraw,
in accordance with the Compress Gas Associations, Small
Propane Bottle Assembly.
17.Use only soapy water (1-part liquid dishwashing detergent
to 3-parts water) to conduct Leak Tests whenever a Propane
cylinder is connected. Bubbles indicate a leak.
18.Never use a heater if the ballast weight is not assembled
onto the base. The base must be weighted to avoid tipping.
19.Use only the regulator assembly provided with the heater.
20.Use only in accordance with local codes or in the absence
of local codes, with the National Fuel Gas Code
ANSIZ223.1.
21.Do not adjust gas regulator. If you are unsure of your
appliances gas type or pressure, call out a gas fitter or
plumber.
22.Place the control knob on "OFF" position when heater is not
in use.
23.Always disconnect the gas supply after the heater is turned
"OFF".
24.Do not move, handle or service the heater while hot or
burning.
25.Allow 45 minutes to cool down after use before attempting
to move heater.
26.Do not clean heater with combustible or corrosive cleaners.
Use warm, soapy water.
27.If wire cage is removed for servicing, it must be re-installed
before operating.
28.Inspect heater before each use, and have it inspected
annually by a qualified service person.
29.Check control compartment, burners and circulation air
passageways for free air passage. Make sure that there are
no obstructions. These are common areas for spider webs,
and other insect infestation which can present a dangerous
condition, damage the heater and render it unsafe for use.
The heater must be checked if any of the following
conditions exist:
a) Gas smell along with predominate yellow tipping of the
burner flames.
b) Heater does not reach temperature.
c) Uneven burner glow.
d) Burner makes popping noises during normal use,
other than during shutdown.

Models
SPC-21PHTTS
Page-4-
ODOR FADE WARNING
FUELGASODOR
LP gas and natural gas have man-made odorants added specifically for detection of fuel gas leaks.
If a gas leak occurs you should be able to smell the fuel gas. Since Propane (LP) is heavier than air you should smell for the gas
odorlowtothefloor.ANYGASODORISYOURSIGNALTOGOINTOIMMEDIATEACTION!
• Do not take any action that could ignite the fuel gas. Do not
operate any electrical switches. Do not pull any power
supply or extension cords. Do not light matches or any other
source of flame. Do not use your telephone.
• Get everyone out of the building and away from the area
immediately.
• Close all propane (LP) gas tank or cylinder fuel supply
valves, or the main fuel supply valve located at the meter if
you use natural gas.
• Propane (LP) gas is heavier than air and may settle in low
areas. When you have reason to suspect a propane leak,
keep out of all low areas.
• Use your neighbor’s phone and call your fuel gas supplier
and your fire department. Do not re-enter the building or
area.
• Stay out of the building and away from the area until
declared safe by the firefighters and your fuel gas supplier.
• FINALLY, let the fuel gas service person and the firefighters
check for escaped gas. Have them air out the building and
area before you return. Properly trained service people must
repair any leaks, check for further leakages, and then relight
the appliance for you.
ODORFADING-NOODORDETECTED
• Some people cannot smell well. Some people cannot smell
the odor of the man-made chemical added to propane (LP)
or natural gas. You must determine if you can smell the
odorant in these fuel gases.
• Learn to recognize the odor of propane (LP) gas and natural
gas. Local propane (LP) gas dealers will be more than
happy to give you a scratch and sniff pamphlet. Use it to
become familiar with the fuel gas odor.
• Smoking can decrease your ability to smell. Being around
an odor for a period of time can affect your sensitivity to that
particular odor. Odors present in animal confinement
buildings can mask fuel gas odor.
•The odorant in propane (LP) gas and natural gas is
colorless and the intensity of its odor can fade under
some circumstances.
• If there is an underground leak, the movement of gas
through the soil can filter the odorant.
• Propane (LP) gas odor may differ in intensity at different
levels. Since Propane (LP) gas is heavier than air, there
may be more odor at lower levels.
• Always be sensitive to the slightest gas odor. If you
continue to detect any gas odor, no matter how small, treat it
as a serious leak. Immediately go into action as discussed
previously.
ATTENTION-CRITICALPOINTSTOREMEMBER!
• Propane (LP) gas has a distinctive odor. Learn to recognize
these odors. (Reference Fuel Gas Odor and Odor Fading
sections above.
• Even If you are not property trained in the service and repair
of the heater, ALWAYS be consciously aware of the odors of
propane (LP) gas and natural gas.
• If you have not been properly trained in repair and service of
propane (LP) gas then do not attempt to light heater,
perform service or repairs, or make any adjustments to the
heater on the propane (LP) gas fuel system.
heater dataplate, or contact the Scheu Products Company to
determine combustion air ventilation requirements of the
heater.
• Lack of proper ventilation air will lead to improper
combustion.
• Improper combustion can lead to carbon monoxide
poisoning leading to serious injury or death. Symptom of
carbon monoxide poisoning can include headaches
dizziness and difficulty in breathing.
WARNING
AsphyxiationHazard
• Do not use this heater for heating human living quarters.
• Do not use in unventilated areas.
• The flow of combustion and ventilation air must not be
obstructed.
• Proper ventilation air must be provided to support the
combustion air requirements of the heater being used.
• Refer to the specification section of the heater’s manual,
• A periodic sniff test around the heater or at the heater’s
joints; i.e. hose, connections, etc., is a good safety practice
under any conditions. If you smell even a small amount of
gas,CONTACTYOURFUELGASSUPPLIERIMMEDIATELY.
DONOTWAIT!

Models
SPC-21PHTTS
Page-5-
ASSEMBLY INSTRUCTIONS
COMPONENTSPACKEDINCARTON:
BurnerandControlAssembly 1
Base 1
Dome 1
OwnersManual 1
Hardwarebag 1
HARDWAREBAGCONSISTSOFTHEFOLLOWING:
CapNut (D) 3
TOOLSREQUIRED:
#2PhilipsHeadScrewdriver 1
StandardPliers 1
Step 1
Attach the Burner and Controls Assembly (B) to the
Base Assembly (C) with 4 screws (E). Use Phillips
HeadScrewdrivertotighten them (Figure 2). Place the
OperatingInstructionlabelunderthecontrolknobfor
easyreview.
Step 2
Align the 3 Dome holes with the 3 studs protruding from
the burner top, then place the Dome (A) onto the studs.
Attach 3 Cap Nuts (D) and tighten with pliers (Figure 1).
THEINSTALLATIONMUSTCONFORMWITHLOCAL
CODESORINABSENCEOFLOCALCODES,THE
NATIONALFUELGASCODE,ANSIZ223.1.
OPERATING INSTRUCTIONS
Preparationbeforelighting
a) Make sure Contol Knob is in the "OFF" position.
b) Open the door to fuel chamber by turning the latching knob
counter-clockwise and pulling on the door.
c) Check regulator inlet and propane cylinder for contamination
such as dirt, webs, etc. Clean if needed.
d) Screw threaded end of canister into threaded regulator inlet
clockwise until hand tight.
IMPORTANT: Use only standard 16.4 oz propane cylinder
constructed and marked in accordance with the U.S. Dept. of
Transportation (D.O.T.) No. 600 connection type. Disconnect
the cylinder when the appliance is not in use.
e) Check for Leaks: Make 1-2oz of leak solution by mixing
1-part liquid dishwashing soap and 3-parts water. Apply
several drops of the solution to the connection between
regulator and propane cylinder.
If no bubbles appear, the connection is leak tight,
continue the next step.
If bubbles appear, there is a leak. Disconnect, recheck
connections and reconnect the propane cylinder.
If the leak persists, conult us by calling toll-free at
1-888-619-7060.
f) Close the door and secure it by turning the knob clockwise
until latched.

Models
SPC-21PHTTS
Page-6-
OPERATING INSTRUCTIONS (Continued)
START
1.Push in and rotate the Control Knob counter-clockwise to
"ON" position to light burner, continue cycle clockwise -
counter-clockwise rotation of Control Knob until burner
lights. This rotation may need to be repeated several times.
2.Continue to depress the Control Knob for 30 seconds when
burner is lit, then release.
3.If the burner doesn't stay lit, turn Control Knob clockwise to
"OFF" immediately, wait 5 minutes then repeat the
instructions above to light burner.
If burner doesn't light after several tries, consult us by
calling toll-free at 1-888-619-7060 or e-mail us at
[email protected] for assistance
and advice.
HEATADJUSTMENT
1.Turn Control Knob to desired heat setting, anywhere from
HIGH to LOW to get desired heat comfort level.
SHUTDOWN
1.Turn Control Knob clockwise to "OFF" position to shut down
the heater.
2.Unscrew propane cylinder counter-clockwise and remove
when the heater is not in use.
3.Do not relight heater for 5 minutes after the propane cylinder
has been removed.
RESTART
1.Turn the Control Knob clockwise to "OFF" position.
2.Wait 5 minutes.
3.Restart following "START" procedure.
MAINTENANCE
To obtain the best performance from your heater, make sure
you perform the following maintenance activities on a regular
basis:
a) Keep exterior surfaces clean. Use warm soapy water
for cleaning. Never use flammable or corrosive
cleaning agents. Be sure to keep the area around the
burner and control assembly dry at all times.
b) Air flow must be unobstructed. Spiders and insects
can nest and live in outdoor appliances, especially in
the burners and orifices. This can be a very dangerous
situation. The heater must be inspected for insect
infestation of the burner and orifice annually, or when
one of the following occur:
1) Gas smell along with predominate yellow tipping of
the burner flames.
2) Heater does not reach temperature.
3) Uneven burner glow.
4) Burner makes popping noises during normal use,
other than during shutdown.
c) Carbon deposits may create a fire hazard. Clean dome
and emitter with warm soapy water if required.
d) Check your heater for signs of damage or wear and
replace components as necessary.
SERVICING
A hazardous condition may result if a heater is used that has
been modified or is not functioning properly. When the heater is
working properly:
* The flame is contained within the heater.
* The flame is essentially blue with perhaps some yellow
tipping.
* There is no strong disagreeable odor, eye burning or other
physical discomfort.
* There is no smoke or soot internal or external to the heater.
* There are no unplanned or unexplained shut downs of the
heater.
The parts lists show the heater as it was constructed. Do not
use a heater which is different from that shown. In this regard,
use only the regulator cylinder connection supplied with the
heater. Do not use alternates. For this heater, the regulator
must be set as shown in "specifications". If there is any
uncertainty about the regulator setting, have it checked.
A heater which is not working right must be repaired, but only by
a trained, experienced service person. To find the service center
closest to you, visit our website at www.scheuco.com. or call
[phone].
You may also obtain in-warranty or out-of-warranty service by
taking the product to your local service center. In-warranty
products will be repaired with no charge for either parts or labor.
Please include a brief statement indicating date, place of
purchase, the nature of the problem and proof of purchase.
Out-of-warrranty products will be repaired with a charge for
parts and labor.
WARNING: FORYOURSAFETY
If you smell gas*:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. If odor continues, immediately call
your gas supplier.
*Seefuelsafetyprecautionsonpage2
ofthismanualformoreinformation.
STORAGE
1.Allow 45 minutes for the heater to cool down after using,
remove cylinder.
2.Store the propane cylinder in a cool, dry and well-ventilated
area.
3.Store the heater upright in a sheltered area away from
inclement weather and dust.
4.If desired, cover the heater after the heater is cool.

Models
SPC-21PHTTS
Page-7-
Item Part No. Description Qty.
SPC-21PHTTS - PARTS
Item Part No. Description Qty.
1 8527 Base 1
2 8528 Ballast Plate 1
3 8529 CylinderHousing 1
4 8556 Door 1
5 8552 Regulator 1
6 8543 RegulatorMtgBracket 1
7 8555 Tilt Switch 1
8 8542 RegulatorConnector 1
9 8544 ValveMtg.Bracket 1
10 8553 Valve 1
11 8554 Knob 1
12 8541 ThermocoupleClip 1
13 8551 Thermocouple 1
14 8550 Electrode 1
15 8540 ThermocoupleBracket 1
16 8537 BurnerAss'y 1
17 8535 WireGuard 1
18 8533 Emitter Screen Ass'''y 1
19 8534 Reflector 1
20 8532 Emitter Bottom 1
21 8539 Nozzle 1
22 8538 HeatShield 1
23 8536 Post 1
24 8531 ValveHousingRing 1
25 8530 ValveHousing 1
26 8549 Gas Pipe Ass'y 1
27 8545 CompressionFerrule 2
28 8548 CompressionNut 2
29 8547 CompressionFitting 1
30 8557 DoorKnob 1
31 8558 DoorLatch 1
* 8524 Manual,OperatingInstructions 1
* 8546 O-Ring 1
* 8559 Label,OperatingInstructions 1
* 8560 Label,Model 1
* 8561 Label,Warning 1

Models
SPC-21PHTTS
Page-8-
WARRANTY
We are pleased that you have selected our product and take
this opportunity to assure you that qualified service facilities are
available if required. With the cooperation of independent
dealers, a nationwide network of authorized servicing dealers is
available for your servicing requirements.
Should your product require servicing, read the section of the
manual entitled “Servicing”.
Who gets the warranty? The warranty is limited to the consumer
who originally purchases the product.
What is covered? This limited warranty covers all imperfections
in workmanship and material.
What is not covered? This limited warranty does not cover
damage resulting from accident, misuse or abuse, lack of
proper maintenance, affixing of any attachments not provided
with the products, or loss of parts. IN NO EVENT SHALL
SCHEUPRODUCTSCOMPANYBELIABLEFORANYSPECIAL,
INCIDENTALORCONSEQUENTIALDAMAGESNORFORANY
DAMAGESRESULTINGFROMMISUSEORMODIFICATIONOF
THIS PRODUCT.
Registering this heater within 10 days of date of purchase
ensures the buyer the protection as stated on our limited
warranty form.
LIMITEDWARRANTY
The company warrants this product to be free from
imperfections in material or workmanship, under normal and
proper use in accordance with instructions of The Company, for
a period of one year from the date of delivery to the buyer. The
Company, at its option, will repair or replace (f.o.b. factory,
California) products returned by the buyer to the factory,
California, transportation prepaid within said one year period
and found by the Company to have imperfections in material or
workmanship.
If a part is damaged or missing, simply e-mail us at
[email protected], visit our website at scheuco.com, or call
our Technical Support Department at [phone].
Address any Warranty Claims to the Customer Service
Department, Scheu Products Company, Incorporated, P.O. Box
250, Upland, California 91785, or e-mail us at
[email protected]. Include your name, address and telephone
number and include details concerning the claim. Also, supply
us with the purchase date and the name and address of the
dealer from whom you purchased our product.
The foregoing is the full extent of the responsibility of the
Company. There are no other warranties, express or implied.
Specifically there is no warranty of fitness for a particular
purpose and there is no warranty of merchantability. In no event
shall the Company be liable for delay caused by imperfections,
for consequential damages, or for any charges of the expense
of any nature incurred without its written consent. The cost of
repair or replacement shall be the exclusive remedy for any
breach of warranty. There is no warranty against infringement of
the like and no implied warranty arising from course of dealing
or usage of trade. This warranty will not apply to any product
which has been repaired or altered outside of the California
factory in any respect which in our judgment affects its condition
or operation.
Some states do not allow the exclusion or limitation of
incidental or consequential damages, so the above limitation or
exclusion may not apply to you. This Warranty gives you specific
legal rights, and you may have other rights which vary from state
to state.
SERVICE CENTERS
Scheu Products Company has over 1,000 service centers
throughout North America. Call [phone] or email
[email protected] to request the service center nearest you.
Include the Make and model of your heater in any emails.
We recommend that only parts supplied by the manufacturer be
used on this unit. A locally purchased part may appear to be
identical, although in reality it might endanger the heater or the
persons operating the heater.
The heater should be serviced only by a trained, experienced
service person.
Read the section on "Servicing" before ordering parts.
For parts orders, call 888-619-7060 or e-mail us at
[email protected]. Please have the model number of your
heater and the replacement part number when placing your
order.
INSTRUCTIONS FOR ORDERING PARTS

Warranty Registration
First Name
Hand print only. Use black or blue ink pen to fill in this form. Cross or check inside the circle.
Your Information
Last name
Postal code
State
City
Mailing Address
E-mail Address
Product Information
State
Date of Purchase (MM/DD/YY)
Store Name City
Cost of Heater ($)
-
/ /
Annual house hold income before tax <$9,999 $10,000 to $19,999 $20,000 to $34,999 $20,000 to $34,999 >$50,000
Age of Purchaser 20-29 years 30-39 years 40-49 years 50-59 years >60 years<20 years
S/N (Located on a silver label on heater)
-
Model Number (Located on a black and white label on heater)
Brand Name All Pro Universal National Riverside
Store Information where heater was purchased
Type of Store Hardware Home Center Warehouse Retailer Discount Store Farm Supply Contractor’s Supply Other
Your Preferences
How did you learn
about our heater? Advertising Relative/friend
Store display Previously owned heater
Other
What prompted you to
buy your heater?
Sudden cold weather Emergency backup heat
Heater on sale
Replaces old model Hard to heat location
Construction project
Other
Where will you use the
heater? Construction site Warehouse
Shop Patio
Other
Who selected the heater? Male Female Both
Heater will be used by? Individual Business
In choosing your heater the following categories
were:
Important
Somewhat
Important Very Important
Features
Portability
Price
Quality
Heat Output
Warranty
Serviceability
Ease of use
Fuel economy
Size
Registering this heater within 10 days of purchase ensures the buyer the protection as stated on our limited warranty form.
Fold Here
Fold Here

Visit our website for product information, technical support, customer service, and warranty registration at:
WWW.ALLPRO-HEATERS.COMforAll-ProproductsorWWW.UNVERISAL-HEATERS.COMfor Universal products.
SCHEU PRODUCTS COMPANY, INC
ATTN:MARKETINGDEPARTMENT
8855BAKERAVENUE
RANCHO CUCAMONGA, CA 91730