Sealey SA841HV User manual

INSTRUCTIONS FOR
RETRACTABLE AIR HOSE METAL REEL 15MTR
Ø10MM ID HIGH VISIBILITY TPR HOSE
MODEL NO: SA841HV
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
9 Familiariseyourselfwiththeapplications,limitationsandspecichazardsoftheairhosereel.
WARNING! Disconnect the air hose reel from the air supply before changing accessories, servicing or performing any
 maintenance.
9 Maintaintheairhosereelingoodcondition(useanauthorisedserviceagent).
9 Replaceorrepairdamagedparts.Userecommendedpartsonly.Unauthorisedpartsmaybedangerousandwillinvalidatethe 
 warranty.
9 Mounttheairhosereelinasuitableworkarea.DO NOT position the hose in direct sunlight, or in areas of extreme heat or cold
 andensurethatthereisadequatelighting.
WARNING!Ensurethatthemaximumairpressureisnotexceeded.
9 Keepextendedairhoseawayfromheat,oilandsharpedges.Checkhoseforwearbeforeeachuseandensurethatall 
 connectionsaresecure.
9 Unreelonlysufcienthoseforthetask.DO NOThaveexcesshosecoiledontheoor.
WARNING!Alwayswearapprovedeyeorfaceprotectionwhenoperatingwithcompressedair. 
9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnon-slipshoes.
9 Removeillttingclothing.Removeties,watches,ringsandotherloosejewelleryandcontainand/ortiebacklonghair.
9 Keepchildrenandunauthorisedpersonsawayfromtheworkarea.
8DO NOToperatetheairhosereelifanypartsaredamagedormissingasthismaycausefailureand/orpersonalinjury.
8DO NOTusetheairhosereelforanypurposeotherthanthatforwhichitisdesigned. 
8DO NOTpullthehosefromtheairsupply. 
8DO NOToperatetheairhosereelwhenyouaretiredorundertheinuenceofalcohol,drugsorintoxicatingmedication.
8DO NOTdirectairfromtheairhoseatyourselforothers. 
9 Whennotinuseensurethattheairsupplyisturnedoffandtoolsdisconnected.Retractthehoseontothereel.
WARNING! DO NOTdismantlethehosereel,orattempttoremoveanynutsorbolts,exceptasdescribedintheseInstructions.To
 dosomayresultindamagetothereeland/orpersonalinjuryandwillinvalidatethewarranty.Internalmaintenancemustonlybe
 undertakenbyanauthorisedserviceagent.
2. INTRODUCTION
Steelconstructionwithcorrosionresistantpowdercoatednish.Highvisibilityairhoseforaddedsafetyaroundtheworkshop.Nineposition
guidearmwithfournonsnagrollers.Multipositionratchetlock.L-shapedbracketenablestheunittobewall,oororceilingmounted.
3. SPECIFICATION
Model no: .............................................................. SA841HV
Hose length:.................................................................... 15m
Hosesize(ID/OD)................................................... 10/17mm
Maximum pressure:..................................................... 300psi
Hose type:.......................................................................TPR
Inlet-outlet:.........................................................3/8”-1/4”BSP
Wear eye
protection
Refer to
instruction
manual
SA841HV|Issue121/07/15
Original Language Version
© Jack Sealey Limited

4. MOUNTING THE HOSE REEL
WARNING! Ensure that the hose is disconnected from the air supply. Do not position the reel in direct sunlight, in areas of
extreme heat or cold or where it will be a hazard.
4.1. MOUNTING
4.1.1. Ensure that the wall, floor, ceiling or other structure to which the air hose reel is to be fixed is of sound construction and will hold the
 workingstrainofthehosewheninuse.
4.1.2. Screworboltthereeltothemountingsurface(seefig.1formountingholedimensions).Adjusttheguidearm(7)tosuitthe 
installation.Removethefourclampingnuts(42),washers(41)andbolts(40),repositionthearmandthenreplacethe bolts,
washersandscrews.Typicalexamplesareshowninfig.2.
4.1.3. Fittheinlethose(provided)totheinletfitting(24)usingthreadsealer or PTFEtape.The free end of the inlet hose should be
 connectedtotheairsupply.
4.1.4.
Beforeuse,checkthatallfixingsaresafeandsecure,andthatthehose extends andretractswithease.
5. OPERATION
5.1.  Pullthehoseoutward.Anintermittentclickingnoisewillbenoticedasthehoseextends.
5.2.  Ifyoustoppullingthehosewhilsttheclickingnoisecanbehearditwillremainlockedatthatlength.
5.3.  Toextendthehosefurther,pullandagainstopwhilsttheclickingnoisecanbeheardtolockthehose.
5.4. To unlock the hose and allow it to automatically rewind, extend the hose a little further and release during a quiet stage between
 theperiodsofclicking.DO NOTallowthereeltorewindinanuncontrolledmanner,alwaysfeedthehosetothereel.
5.5.  Ifitisnecessarytoalterthereeltensionproceedasfollows.
WARNING!Ensurethattheairsupplyisdisconnected.
5.6.  Pullapproximately2mtrofhosefromthedrumandallowthedrumtolock.
5.7.  Removethehosebumperblocks(55)anddrawthe2mtrofhosebackthroughthehoseguide.
5.8.  Wrapthehoseoneturnaroundthedrumtoincreasethetensionorunwraponeturntodecreasethetension.
5.9.  Feedtheendofthehosebackthroughthehoseguideandretthebumperblocks.
5.10. Checkthetensionandadjustfurther,asabove,ifnecessary.
6. MAINTENANCE
WARNING!Beforeattemptingmaintenanceorinspection,ventanypressureremaininginthehose.
6.1.  Toensurereliableoperation,cleanthehoseandcasingregularly.DO NOTsprayorwettheproduct,butcleanwithadampcloth. 
DO NOTusesolventsordetergents,asthesemaycausepermanentdamage.
6.2.  Thehosereeldoesnotrequirespecialmaintenanceasitislubricatedforlife.Iftheproductneedsattention,consultyour
 nearestauthorisedserviceagent.
WARNING: DO NOT attempt to loosen, or remove, any casing nuts or bolts yourself, other than to reposition the hose
guide (see 4.1.2.).
6.3.  Replacementofthesupplyhoseshouldbecarriedoutbyskilledpersonnelonly,consultyournearestauthorisedserviceagent.
6.4.  Shouldyouwishtostoretheairhosereel,ensurethatitiscleananddry.Placeinadark,safe,dry,childprooflocation,wherethe
 temperaturewillremainreasonablystable.DO NOTstoreinanylon,orplastic,bagasthiswillencouragecondensation.
NOTE: It is our policy to continually improve products and as such we reserve the right to alter data, specications and component parts without prior notice.
IMPORTANT:Noliabilityisacceptedforincorrectuseofthisproduct.
WARRANTY:Guaranteeis12monthsfrompurchasedate,proofofwhichwillberequiredforanyclaim.
SoleUKDistributor,SealeyGroup.
KempsonWay,SuffolkBusinessPark,
BurySt.Edmunds,Suffolk.
IP327AR
www.sealey.co.uk
[e-mail]
01284757500
01284703534
Web
Environmental Protection
Recycle unwanted materials instead of disposing of them as waste. All tools, accessories and packaging should be
sorted, taken to a recycling centre and disposed of in a manner which is compatible with the environment.
When the product becomes completely unserviceable and requires disposal, drain off any fluids (if applicable)
into approved containers and dispose of the product and the fluids according to local regulations.
Parts support is available for this product. To obtain a parts listing and/or diagram,
please log on to www.sealey.co.uk, email [e-mail] or telephone [phone].
SA841HV|Issue121/0715
Original Language Version
© Jack Sealey Limited
Fig.2
Fig.1