Siemens 3TS11 Series User manual

s
Contactor for capacitor switching:
Type: 3TS11.. to 3TS15.. and
3TS21.., 3TS22.., 3TS25..
IS/IEC:60947-4-1
A. Technical Data
i) Main circuit:
The capacitors are precharged during pick-up via early-make
contacts and integrated pre-charge resistors before the main
contacts close.
This combination may be used for switching of Individual
capacitor for power factor correction of single loads or for
switching capacitor banks in parallel in centralized group
power factor correction system.
• InsulationVoltageUi=690VAC,
Temperature:Storage-25to+55ºC
 Service(withoutderating)-25to+40ºC
Usethedeviceswiththedeclaredcapacitorbankratingsonly.
Contactor Type Load of contactor when switching
3ph-AC capacitor kVAr at 415/440V, 50Hz
3TS21..-0A..5-8K 5
3TS11..-0A..5-8K 7
3TS22..-0A..5-8K 10
3TS12..-0A..5-8K 12.5
3TS13..-0A..5-8K 16
3TS14..-0A..5-8K 20
3TS15..-0A..5-8K 25
3TS25..-0A..5-8K 30
• Switching frequency in Make/Break operations:
180Operatingcycles/hourforallratings
• Maximum back-up fuse rating:ForType-1Coordination
Type-3NA7asperIEC60269
:1.6…1.8Ie
ii) Aux Circuit:
Inbuilt: Auxiliary Contacts
1NO+1NCincaseof3TS1211To3TS1511and3TS2211,
3TS2511
Nobuilt-inauxiliarycontactsfor3TS1200To3TS1500and
3TS2200,3TS2500
1NOincaseof3TS11...and3TS21...
Additional Aux:
Facilitytoadd-on1NOor1NCauxiliarycontactblock
type3TX40..isavailablefor3TS11..,3TS1200,3TS1300,
3TS1400,3TS1500,3TS21..,3TS2200,3TS2500
3TX 40.. Block tment (For 3TS11.., 3TS1200, 3TS1300,
3TS1400, 3TS1500, 3TS21.., 3TS2200, 3TS2500)
Aux Contact Rating:
3TX40
IeAC-15=3.6Aat415V
IeDC-13=0.48Aat220V
Note: Do not remove precharging resistors. If contactor is
switchedonloadwithoutresistor,itmaycausedamageto
the contactor.
iii) Control circuit:
• Controlvoltageismarkedonthecolouredidentication
tag on the coil.
Note:
• Thevoltageistobemaintainedwithinallowablelimits.
• Operationonundervoltageconditionstothecoilmay
causedamagetothecoil/contactor.
• Maximumback-upfuseratingforcontrolcircuit=16A
=6Aifrelaycontactisinthecontrolcircuit.
iv) Internal connection diagram
3TS11..-0A..5-8K
3TS21..-0A..5-8K
3TS13..-0A..5-8K
3TS22..-0A..5-8K
 InbuiltNOincaseof5kVAr&7kVAr
Fig. 1
ConnectionDetailsfor
3TS11…to3TS15...
and3TS21...,3TS22...,
3TS25... is shown in
gure1
Operating Instructions
Avoidoperationduringundervoltage
conditions. Switch only onto discharged
capacitors.Manualoperationnotpermitted
for function testing.
Warning:
Commissioningandmaintenanceby
qualiedpersonnelonly.Followthe
operating instructions.
Do not remove precharging resistors. If
contactorisswitchedonloadwithoutresistor,
it may cause damage to the contactor.
Hazardous Voltage can cause Electric
Shock and burns.
Disconnect Power before proceeding with
any work on this equipment.

B. Installation
1. Permitted mounting positions are indicated in Fig.2
2. Theunitissuitableforscrewmountingonatvertical
surfacewithtwoM4screws.Alwaysuseplainandspring
washers.
3. Alternativelysnapfor3TS11..to3TS15..and3TS21..,
3TS22..,3TS25..ontoa35mmTophatRailTH35asper
DIN:EN60715.
Note:Installtheunitinhousingifitisexposedtodust,dirt,
contamination or aggressive atmosphere.
C. Maintenance
• Removedustbysuction.
• Replacementofcoilavailableasspare.
• Sparecontactkitsavailablefrom3TS12to3TS15and
3TS22,3TS25.
• ContactSiemensSalesofcefordetails.
• Handletheresistorwirescarefully.
D. Note:
NormallythepowerfactorcontrollerinAPFCpanels,hasthe
provision for adjustment under voltage cut out with respect
to voltage and time. Please ensure that the controllers are
present as per values given in the table on right side.
Coil Voltage
available in
MLFB’s
Coil
Voltage
Controller settings
Under Voltage setting Actuating time
3TS11 to 3TS15
and3TS21,
3TS22,3TS25
110V ≥94V <0.1sec
230V ≥196V <0.1sec
415V ≥353V <0.1sec
3TS11 to 3TS15 220-230V ≥187V <0.1sec
400-415V ≥340V <0.1sec
Incase,Powerfactorcontrollerdoesnothavetheprovision
ofabovesettings,itisrecommendedtoprovideaseparate
undervoltagemonitorhavingsettingsaspertable,toensure
satisfactory performance of the contactors. For further details
onsuchanundervoltagemonitor,pleasecontactnearest
Siemensofce.
Fig. 2 Mounting Positions for 3TS11... to 3TS15... and 3TS21...,
3TS22..., 3TS25...
Permissible Conductor Size: Main Terminals
Termination Data -
Contactor Cable 3TS11..-0A..5-8K 3TS12..-0A..5-8K 3TS13..-0A..5-8K 3TS14..-0A..5-8K 3TS15..-0A..5-8K
3TS21..-0A..5-8K 3TS22..-0A..5-8K 3TS25..-0A..5-8K
Solid mm21 x (1 to 2.5) 1x(2.5to6) 1to16 1to16 1to16
Flexible without end sleeve mm2– – 1.5to16 1.5to16 1.5to16
Flexible with end sleeve mm21x(0.75to2.5) 1 x (1.5 to 4) 1.5to16 1.5to16 1.5to16
Screw Size M3.5 M4
Tightening Torque N-m 0.8to1.4 1.0to1.5 2.5 to 3
Insulation cutting length
for wires mm 10
Siemens Limited
OrderNo.A5E03830809000A-AF
Productdevelopmentisacontinuousprocess.Consequently
thedataindicatedinthisLeaetissubjecttochangewithout
priornotice.Forlatestissuecontactoursalesofces.
SACHINENTERPRISE
Disposal
Siemensproductareenvironmentfriendly,whichpredominantly
consist of recyclable materials.
For disposals we recommend disassembling and separation into
following materials:
METALS:SegregateintoFerrous&NonFerroustypesforrecycling
through authorised dealer.
PLASTICS:Segregateaspermaterialtypeforrecyclingthrough
authorised dealer. Because of the long lifetime of Siemens
products the disposal guidelines may be replaced by other national
regulations when taking the product out of service.
The local customer care service is available at any time to answer
disposal-related questions.
CustomerCareTollfreeno.18002090987 Email:[email protected]
S17936
E. Overall Dimensions
Dimensional drawing: 7/12.5, 16, 20, 25, 5, 10, 30kVAr (3TS11/12/13/14/15/21/22/25..-0A..5-8K)
Type A B C D FG H J K L Ø E M Term
Screw
3TS11/3TS21 125 74 60 10 115 78 45 60 35 – 4.8 48 M3.5
3TS1200/3TS2200 136 85 70 14.5 115 85 45 75 35 – 4.8 51 M4
3TS1300..1500/3TS2500 148 85 63 18 120 103 55 75 45 – 5 62.5 M4
3TS1211/3TS2211 136 85 70 14.5 115 85 45 75 35 58 4.8 51 M4
3TS1311..1511/3TS2511 148 85 63 18 120 103 55 75 45 68 562.5 M4