Sony TA-EX66 User manual

MICROFILM
AEP Model
UK Model
E Model
SERVICE MANUAL
TA-EX66/EX77
INTEGRATED STEREO AMPLIFIER
TA-EX66/EX77istheamplifiersection
inMHC-EX66,DHC-EX77MD/MD77.
SPECIFICATIONS
Photo:TA-EX77 (AEP, UK model)
General
Power requirements
AEP, UK model: 220 – 230 V AC, 50/60 Hz
HK, SP model: 220 – 240 V AC, 50/60 Hz
Power consumption 125 watts
Design and specifications are subject to change without notice.
• Abbreviation
HK : Hong Kong
SP : Singapore
AEP, UK model:
DIN power output 45 + 45 watts (6 ohms at 1 kHz, DIN)
Continuous RMS power output
60 + 60 watts (6 ohms at 1kHz, 10% THD)
Music power output 105 + 105 watts
HK, SP model:
Continuous RMS power output
55 + 55 watts (6 ohms at 1 kHz, 5% THD)
Inputs
CD IN, MD IN (phono jacks): voltage 450 mV, impedance 47 kilohms
TUNER IN, TAPE IN, VIDEO1 IN, VIDEO2/AUX IN (TA-EX66/
EX77:AEP, UK model),VIDEO2 IN (TA-EX77: HK, SP model) (phono
jacks): voltage 250 mV, impedance 47 kilohms
MIX MIC (phone jack):
sensitivity 1 mV, impedance 10 kilohms or more
Outputs
MD OUT, TAPE OUT, VIDEO1 OUT (phono jacks):
voltage 250 mV, impedance 1 kilohm
PHONES (stereo phone jack):
accepts headphones of 6 ohms or more.
SPEAKER: accepts impedance of 6 to 16 ohms.
Dimensions (w/h/d) incl. projecting parts and controls:
Approx. 280 ×122.5 ×298 mm
Mass Approx. 5.3 kg
All manuals and user guides at all-guides.com
all-guides.com

– 2 –
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK !OR DOTTED
LINE WITH MARK !ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
TABLE OF CONTENTS
1. GENERAL ....................................................................3
2. DISASSEMBLY ...........................................................6
3. DIAGRAMS
3-1. IC Pin Function Description .............................................9
3-2. Schematic Diagram .........................................................14
3-3. Printed Wiring Boards .....................................................19
4. EXPLODEDVIEWS ................................................22
5. ELECTRICAL PARTS LIST .................................24
MODEL IDENTIFICATION
– BACK PANEL –
4-985-927-
TA-EX77 (AEP, UK model) : 1πCED/CEK
TA-EX77 (Singapore model) : 2πSP
TA-EX77 (Hong Kong model): 3πHK
TA-EX66 (AEP, UK model) : 4πCED/CEK
TA-EX66 (Singapore model) : 5πSP
All manuals and user guides at all-guides.com

– 3 –
SECTION 1
GENERAL This section is extracted
from instruction manual.
All manuals and user guides at all-guides.com

– 4 –
All manuals and user guides at all-guides.com

– 5 –
All manuals and user guides at all-guides.com

– 6 –
SECTION 2
DISASSEMBLY
•This set can be disassembled in the order shown below.
CONNECTOR BOARD
(Page 7)
BACK PANEL
(Page 7)
MAIN BOARD
(Page 8)
CASE, FRONT PANEL ASS’Y
(Page 6)
1 screw (BVTT3 × 8)
2 two screws
(case 3 TP2)
2 two screws
(case 3 TP2)
3 case
4 two screws
(BVTP3
× 10)
5 two legs (F)
6 three screws
(BVTP3
× 10)
7 claw
7 two claws
7 two claws
8 front panel ass’y
CASE, FRONT PANEL ASS’Y
Note: Follow the disassembly procedure in the numerical order given.
All manuals and user guides at all-guides.com
all-guides.com

– 7 –
BACK PANEL
CONNECTOR BOARD
1 connector
(CN911)
2 connector
(CN504)
3 screw
(BVTP3
× 8)
3 three screws
(BVTP3
× 10)
3 five screws
(BVTP3
× 10)
4 claw
5 Remove the back panel to
direction of the arrow
A .
A
EX77
1
connector
(CN501)
2 Remove the connector (CN553) to
direction of the arrow
A .
3 Remove the connector (CN554) to
direction of the arrow
B .
4 Remove the connector board to
direction of the arrow
C .
A
B
C
All manuals and user guides at all-guides.com

– 8 –
MAIN BOARD
1 two screws
(BVTP3
× 16)
2 four screws
(BVTT3
× 6)
3 Remove the MAIN board to
direction of the arrow.
All manuals and user guides at all-guides.com

– 9 –
SECTION 3
DIAGRAMS
3-1. IC PIN FUNCTION DESCRIPTION
• PANEL BOARD IC101 MB89193A-157 (SYSTEM CONTROLLER)
Pin No. Pin Name I/O Function
1 MIC-IN I Plug in detection signal input of the MIX MIC jack (J201)
Insert the microphone plug with the jack when “H”
2 STANBY O Power on/off control signal output terminal “H”: power on, “L”: standby mode
3 K-PON O Control signal output to the KARAOKE PON circuit “H”: KARAOKE PON on
4 KEY0 I Key input terminal (A/D input) POWER key (S101) input
5 VSS — Ground terminal
6 RST I Power on reset signal input from the reset signal generator (IC103) “L”: reset
For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H”
7 XIN I System clock input terminal (4 MHz)
8 XOUT O System clock output terminal (4 MHz)
9 VSS — Ground terminal
10 AUB-OUT O Output terminal of the audio bus signal
11 AUB-IN I Input terminal of the audio bus signal
12 SIRCS-IN I Sircs signal input from the remote control receiver (IC102)
13 VOL-UP O Motor control signal output to the volume up/down motor driver IC (IC104)
“H”: volume up
14 VOL-DOWN O Motor control signal output to the volume up/down motor driver IC (IC104)
“H”: volume down
15 –20dB MUTE O Control signal output of the –20 dB mute “H”: –20 dB mute on
16 DIRECT O Control signal output to the SOURCE DIRECT circuit “H”: SOURCE DIRECT on
17 DBFB LEVEL O DBFB level select signal output terminal “H” : DBFB LOW, “L”: DBFB HIGH
18 MUTE O Control signal output of the line mute “H”: line mute on
19 KEY1 I Key input terminal (A/D input)
–20 dB MUTING, SOURCE DIRECT, KARAOKE PON, DBFB keys (S104 to S107) and rotary
encoder (S110) for the FUNCTION
20 DBFB ON/OFF O Control signal output to the DBFB circuit “H”: DBFB off, “L”: DBFB on
21 OPEN — Not used (open)
22 VSS — Ground terminal
23 VCC — Power supply terminal (+5V)
24 ANALOG/
DIGITAL IDigital/analog recording mode select input (ANALOG/DIGITAL select switch (S901) input) of
the AUX/VIDEO 2 IN terminal “H”: analog recording mode, “L”: digital recording mode
(TA-EX77 only)
25 FUNCA O
26 FUNCB O Function select signal output terminal *1
27 FUNCC O
28 VCC — Power supply terminal (+5V)
*1
TAPE “H” “H” “H”
VIDEO 2 “L” “H” “H”
VIDEO 1 “H” “L” “H”
MD “L” “L” “H”
CD “L” “H” “L”
TUNER “H” “L” “L”
Terminal
Function FUNCA
(pin @∞)FUNCB (pin @§)FUNCC (pin @¶)
All manuals and user guides at all-guides.com

– 10 –
•IC Block Diagrams
IC104 BA6208
1 2 3 4 5 6 7 89
NC
OUTPUT 2
Vcc
GND
NC
INPUT 2
INPUT 1
NC
MOTOR
DRIVE
MOTOR
DRIVE
REG
SWITCH
SWITCH
OUTPUT1
IC105 SN74HC138AN
15 14 13 12 11 10 9
8765
4
321 GNDY7
G1
G2B
G2AC
B
A
A
B C G2A Y7
G1
G2B
Y6
Y5
Y6Y5Y4Y3Y2Y1Y0
16
VCC
DATA OUTPUTS
OUTPUT
ENABLE
SELECT
Y4Y3Y2Y1Y0
IC203, 503 MC14052BCP
12 14 15 11 9
16 13 10
1 5 2 4
3 6 7 8
V DD
SELECT A
SELECT B3210 3210
INH 7 V EE V SS
All manuals and user guides at all-guides.com

– 11 –
IC701 µPC1237HA
1 2 3 4 5 6 7 8
OVER LOAD DET
F/F
OFFSET DET
LATCH/
AUTORESET
V
CC ON
MUTE
AC OFF
DET
V
CC
•Waveforms
1IC101 7(XIN)
5.5 Vp-p
4 MHz
2IC101 8(XOUT)
5.7 Vp-p
4 MHz
All manuals and user guides at all-guides.com
all-guides.com

– 12 –
•Circuit Boards Location
PRIMARY board
SECONDARY board
PANEL board
VOL board MAIN board
SW board
(EX77)
CONNECTOR board
All manuals and user guides at all-guides.com

All manuals and user guides at all-guides.com

All manuals and user guides at all-guides.com

All manuals and user guides at all-guides.com

– 22 –
NOTE:
•-XX and -X mean standardized parts, so they
may have some difference from the original
one.
•Color Indication of Appearrance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑↑
Parts Color Cabinet's Color
•Abbreviation
HK : Hong Kong
SP : Singapore
(1) CASE, FRONT PANEL SECTION
•Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
•The mechanical parts with no reference num-
ber in the exploded views are not supplied.
•Hardware (# mark) list are given in the last of
the electrical parts list.
SECTION 4
EXPLODED VIEWS
The components identified by mark
!or dotted line with mark !are
critical for safety.
Replace only with part number
specified.
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
1 4-985-925-01 KNOB (JOG)
2 X-4947-837-1 KNOB (VOL) ASSY
3 4-985-926-01 KNOB
4 X-4947-655-1 PANEL ASSY, FRONT (EX77: SP, HK)
4 X-4948-359-1 PANEL ASSY, FRONT (EX66)
4 X-4948-436-1 PANEL ASSY, FRONT (EX77: AEP, UK)
5 4-985-922-01 RING, ORNAMENTAL
6 4-962-708-01 EMBLEM (4-A), SONY
7 4-985-918-01 INDICATOR (POWER)
8 4-985-917-01 BUTTON (POWER)
9 4-985-920-01 INDICATOR (6)
*10 A-4398-059-A PANEL BOARD, COMPLETE (AEP, UK)
*10 A-4398-061-A PANEL BOARD, COMPLETE (SP, HK)
11 4-951-620-01 SCREW (2.6X8), +BVTP
12 4-977-699-11 LEG (F)
*13 1-665-663-11 VOL BOARD
14 3-363-099-01 SCREW (CASE 3 TP2)
15 4-978-245-11 CASE
1
2
3
4
5
6
7
8
9
10
12
13 14
15
#1
supplied with J201
supplied
with RV204
not supplied
not supplied
11
11
#1
#2
14
All manuals and user guides at all-guides.com
all-guides.com

– 23 –
(2) MAIN SECTION
Ref. No. Part No. Description Remark
The components identified by mark
!or dotted line with mark !are
critical for safety.
Replace only with part number
specified.
Ref. No. Part No. Description Remark
*51 1-663-932-11 CONNECTOR BOARD
*52 1-665-662-11 SECONDARY BOARD
*53 1-665-661-11 PRIMARY BOARD
*54 A-4398-060-A MAIN BOARD, COMPLETE (EX77: AEP, UK)
*54 A-4398-062-A MAIN BOARD, COMPLETE (EX77: HK, SP)
*54 A-4403-012-A MAIN BOARD, COMPLETE (EX66: SP)
*54 A-4403-013-A MAIN BOARD, COMPLETE (EX66: AEP, UK)
*55 3-703-244-00 BUSHING (2104), CORD
!56 1-575-651-11 CORD, POWER (AEP, HK, SP)
!56 1-696-570-21 CORD, POWER (UK)
*57 4-949-235-01 HOOK (AEP, SP)
*58 4-985-927-11 PANEL, BACK (EX77: AEP, UK)
*58 4-985-927-21 PANEL, BACK (EX77: SP)
*58 4-985-927-31 PANEL, BACK (EX77: HK)
*58 4-985-927-41 PANEL, BACK (EX66: AEP, UK)
*58 4-985-927-51 PANEL, BACK (EX66: SP)
*59 1-663-933-11 SW BOARD (EX77)
60 4-965-822-01 FOOT
!61 1-569-008-11 ADAPTOR, CONVERSION 2P (SP)
!62 1-770-019-11 ADAPTOR, CONVERSION PLUG 3P (HK)
63 4-956-370-02 BAND, PLUG FIXED (UK, HK)
!T901 1-431-301-11 TRANSFORMER, POWER
51
52
53 54
55
56
58
59
60
61
62
63
HK
AEP, HK, SP
UK
56
AEP, SP UK, HK
57
EX77
not supplied
not
supplied
not supplied
T901
#3
#4
#5
#3
#3
#1
#4
#1
#4
SP
All manuals and user guides at all-guides.com

– 24 –
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
NOTE:
•Due to standardization, replacements in the
parts list may be different from the parts speci-
fied in the diagrams or the components used on
the set.
•-XX and -X mean standardized parts, so they
mayhavesome differencefromthe original one.
•RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
•Abbreviation
HK : Hong Kong
SP : Singapore
•Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when order-
ing these items.
•SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. . uPA. . : µPA. .
uPB. . : µPB. . uPC. . : µPC. .
uPD. . : µPD. .
•CAPACITORS
uF: µF
•COILS
uH: µH
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
*1-663-932-11 CONNECTOR BOARD
*****************
< CAPACITOR >
C821 1-136-153-00 FILM 0.01uF 5% 50V
C831 1-136-153-00 FILM 0.01uF 5% 50V
< CONNECTOR >
*CN531 1-569-499-11 PIN, CONNECTOR 3P
CN541 1-770-966-11 PIN, CONNECTOR (PCB) (V TYPE) 6P
CN552 1-764-325-11 PIN, CONNECTOR (PCB) (V TYPE) 2P (EX77)
*CN553 1-569-504-11 PIN, CONNECTOR 9P
< DIODE >
D808 8-719-023-05 DIODE 11E2-TA2B
D818 8-719-023-05 DIODE 11E2-TA2B
************************************************************
*A-4403-012-A MAIN BOARD, COMPLETE (EX66: SP)
*A-4403-013-A MAIN BOARD, COMPLETE (EX66: AEP, UK)
*A-4398-060-A MAIN BOARD, COMPLETE (EX77: AEP, UK)
*A-4398-062-A MAIN BOARD, COMPLETE (EX77: HK, SP)
*********************
*4-942-204-01 PLATE, GROUND
7-685-871-01 SCREW +BVTT 3X6 (S)
< CAPACITOR >
C301 1-126-045-11 ELECT 2.2uF 20% 50V
C302 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C303 1-162-282-31 CERAMIC 100PF 10% 50V
C304 1-126-868-11 ELECT 47uF 20% 50V
C305 1-126-868-11 ELECT 47uF 20% 50V
C306 1-124-122-11 ELECT 100uF 20% 50V
C307 1-126-059-11 ELECT 10uF 20% 50V
C308 1-126-233-11 ELECT 22uF 20% 50V
C309 1-164-159-11 CERAMIC 0.1uF 50V
C310 1-136-163-00 FILM 0.068uF 5% 50V
C311 1-136-163-00 FILM 0.068uF 5% 50V
C312 1-126-868-11 ELECT 47uF 20% 50V
C318 1-162-200-31 CERAMIC 11PF 5% 50V
(AEP, UK)
C331 1-162-306-11 CERAMIC 0.01uF 20% 16V
(AEP, UK)
C340 1-126-059-11 ELECT 10uF 20% 50V
C351 1-126-045-11 ELECT 2.2uF 20% 50V
C352 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C353 1-162-282-31 CERAMIC 100PF 10% 50V
C354 1-126-868-11 ELECT 47uF 20% 50V
C355 1-126-868-11 ELECT 47uF 20% 50V
C356 1-124-122-11 ELECT 100uF 20% 50V
C357 1-126-059-11 ELECT 10uF 20% 50V
C358 1-162-200-31 CERAMIC 11PF 5% 50V
(AEP, UK)
C360 1-136-163-00 FILM 0.068uF 5% 50V
C361 1-136-163-00 FILM 0.068uF 5% 50V
C401 1-164-159-11 CERAMIC 0.1uF 50V
(AEP, UK)
C402 1-164-159-11 CERAMIC 0.1uF 50V
(AEP, UK)
C403 1-164-159-11 CERAMIC 0.1uF 50V
(AEP, UK)
C451 1-164-159-11 CERAMIC 0.1uF 50V
(AEP, UK)
C452 1-164-159-11 CERAMIC 0.1uF 50V
(AEP, UK)
C453 1-164-159-11 CERAMIC 0.1uF 50V
(AEP, UK)
C501 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C502 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C503 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C504 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C505 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C506 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C507 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C508 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C509 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C510 1-162-282-31 CERAMIC 100PF 10% 50V
C531 1-162-306-11 CERAMIC 0.01uF 20% 16V
C532 1-162-306-11 CERAMIC 0.01uF 20% 16V
C533 1-162-306-11 CERAMIC 0.01uF 20% 16V
C534 1-162-306-11 CERAMIC 0.01uF 20% 16V
SECTION 5
ELECTRICAL PARTS LIST
The components identified by mark
!or dotted line with mark !are
critical for safety.
Replace only with part number
specified.
When indicating parts by reference
number, please include the board.
CONNECTOR MAIN
All manuals and user guides at all-guides.com

– 25 –
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C551 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C552 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C553 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C554 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C555 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C556 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C557 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C558 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C559 1-162-286-31 CERAMIC 220PF 10% 50V
(AEP, UK)
C560 1-162-282-31 CERAMIC 100PF 10% 50V
C601 1-162-294-31 CERAMIC 0.001uF 10% 50V
C602 1-162-306-11 CERAMIC 0.01uF 20% 16V
C603 1-162-282-31 CERAMIC 100PF 10% 50V
C604 1-162-215-31 CERAMIC 47PF 5% 50V
C605 1-126-022-11 ELECT 47uF 20% 16V
C606 1-126-059-11 ELECT 10uF 20% 50V
C651 1-162-294-31 CERAMIC 0.001uF 10% 50V
C652 1-162-306-11 CERAMIC 0.01uF 20% 16V
C653 1-162-282-31 CERAMIC 100PF 10% 50V
C654 1-162-215-31 CERAMIC 47PF 5% 50V
C655 1-126-022-11 ELECT 47uF 20% 16V
C656 1-126-059-11 ELECT 10uF 20% 50V
C701 1-162-294-31 CERAMIC 0.001uF 10% 50V
C702 1-104-666-11 ELECT 220uF 20% 6.3V
C703 1-126-045-11 ELECT 2.2uF 20% 50V
C704 1-126-052-11 ELECT 100uF 20% 10V
C711 1-126-233-11 ELECT 22uF 20% 50V
C712 1-126-233-11 ELECT 22uF 20% 50V
C761 1-126-233-11 ELECT 22uF 20% 50V
C762 1-126-233-11 ELECT 22uF 20% 50V
C804 1-136-165-00 FILM 0.1uF 5% 50V
C805 1-126-138-11 ELECT 4700uF 20% 50V
C807 1-126-052-11 ELECT 100uF 20% 35V
C808 1-126-052-11 ELECT 100uF 20% 10V
C809 1-124-997-11 ELECT 470uF 20% 10V
C814 1-136-165-00 FILM 0.1uF 5% 50V
C815 1-126-138-11 ELECT 4700uF 20% 50V
C817 1-126-052-11 ELECT 100uF 20% 35V
C818 1-126-052-11 ELECT 100uF 20% 10V
C819 1-124-997-11 ELECT 470uF 20% 10V
C822 1-126-942-61 ELECT 1000uF 20% 25V
C824 1-124-997-11 ELECT 470uF 20% 10V
C825 1-164-159-11 CERAMIC 0.1uF 50V
< CONNECTOR >
CN11 1-770-158-21 HOUSING, CONNECTOR 7P
(SYSTEM CONTROL)
CN501 1-770-966-11 PIN, CONNECTOR (PCB) (V TYPE) 6P
CN502 1-569-490-11 SOCKET, CONNECTOR 3P
CN801 1-764-289-11 PIN, CONNECTOR (PC BOARD) 22P
< DIODE >
D301 8-719-987-63 DIODE 1N4148M
D302 8-719-987-63 DIODE 1N4148M
D315 8-719-987-63 DIODE 1N4148M
D351 8-719-987-63 DIODE 1N4148M
D352 8-719-987-63 DIODE 1N4148M
D365 8-719-987-63 DIODE 1N4148M
D702 8-719-987-63 DIODE 1N4148M
D803 8-719-987-63 DIODE 1N4148M
D804 8-719-510-68 DIODE D5SBA20F01
D809 8-719-933-54 DIODE HZS9A2L
D813 8-719-987-63 DIODE 1N4148M
D819 8-719-933-54 DIODE HZS9A2L
< IC >
IC301 8-749-900-24 IC STK-4162MK2
IC501 8-759-000-47 IC MC14051BCP
IC502 8-759-000-47 IC MC14051BCP
IC503 8-759-000-48 IC MC14052BCP
IC504 8-759-000-49 IC MC14066BCP
IC601 8-759-634-51 IC M5218AP
IC701 8-759-111-68 IC uPC1237HA
IC802 8-759-231-53 IC TA7805S
< JACK/PIN JACK >
J202 1-764-256-21 JACK (LARGE TYPE) (PHONES)
J501 1-770-015-11 JACK, PIN 6P (TUNER IN, CD IN, MD OUT)
J502 1-770-015-11 JACK, PIN 6P (MD IN, TAPE OUT, TAPE IN)
J503 1-770-015-11 JACK, PIN 6P (AUX/VIDEO2 IN, VIDEO1 OUT,
VIDEO1 IN) (EX66/EX77: AEP, UK)
J503 1-770-015-11 JACK, PIN 6P (VIDEO2 IN, VIDEO1 OUT,
VIDEO1 IN) (EX77: HK, SP)
< COIL >
L301 1-420-872-00 COIL, AIR-CORE (AEP, UK)
L351 1-420-872-00 COIL, AIR-CORE (AEP, UK)
< TRANSISTOR >
Q301 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q302 8-729-422-73 TRANSISTOR UN4212
Q303 8-729-620-05 TRANSISTOR 2SC2603-EF
Q351 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q809 8-729-140-96 TRANSISTOR 2SD774-34
Q819 8-729-140-97 TRANSISTOR 2SB734-34
< RESISTOR >
R301 1-249-417-11 CARBON 1K 5% 1/4W
R302 1-249-438-11 CARBON 56K 5% 1/4W
R303 1-249-415-11 CARBON 680 5% 1/4W
R304 1-249-438-11 CARBON 56K 5% 1/4W
R305 1-260-103-11 CARBON 2.2K 5% 1/2W
MAIN
All manuals and user guides at all-guides.com

– 26 –
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R532 1-249-429-11 CARBON 10K 5% 1/4W
R533 1-249-429-11 CARBON 10K 5% 1/4W
R534 1-247-807-31 CARBON 100 5% 1/4W
R535 1-247-807-31 CARBON 100 5% 1/4W
R536 1-247-807-31 CARBON 100 5% 1/4W
R551 1-249-417-11 CARBON 1K 5% 1/4W
R552 1-249-425-11 CARBON 4.7K 5% 1/4W
R553 1-249-417-11 CARBON 1K 5% 1/4W
R554 1-249-425-11 CARBON 4.7K 5% 1/4W
R555 1-249-417-11 CARBON 1K 5% 1/4W
R556 1-249-417-11 CARBON 1K 5% 1/4W
R557 1-249-417-11 CARBON 1K 5% 1/4W
R558 1-249-417-11 CARBON 1K 5% 1/4W
R559 1-249-417-11 CARBON 1K 5% 1/4W
R562 1-249-429-11 CARBON 10K 5% 1/4W
R564 1-249-429-11 CARBON 10K 5% 1/4W
R571 1-249-417-11 CARBON 1K 5% 1/4W
R572 1-249-417-11 CARBON 1K 5% 1/4W
R573 1-249-417-11 CARBON 1K 5% 1/4W
R601 1-249-437-11 CARBON 47K 5% 1/4W
R602 1-249-434-11 CARBON 27K 5% 1/4W
R603 1-249-437-11 CARBON 47K 5% 1/4W
R604 1-249-437-11 CARBON 47K 5% 1/4W
R605 1-249-437-11 CARBON 47K 5% 1/4W
R606 1-249-441-11 CARBON 100K 5% 1/4W
R607 1-249-441-11 CARBON 100K 5% 1/4W
R651 1-249-437-11 CARBON 47K 5% 1/4W
R652 1-249-434-11 CARBON 27K 5% 1/4W
R653 1-249-437-11 CARBON 47K 5% 1/4W
R654 1-249-437-11 CARBON 47K 5% 1/4W
R655 1-249-437-11 CARBON 47K 5% 1/4W
R656 1-249-441-11 CARBON 100K 5% 1/4W
R701 1-249-424-11 CARBON 3.9K 5% 1/4W
R702 1-249-441-11 CARBON 100K 5% 1/4W
R703 1-249-430-11 CARBON 12K 5% 1/4W
R704 1-249-437-11 CARBON 47K 5% 1/4W
!R705 1-215-890-11 METAL OXIDE 470 5% 2W F
R706 1-249-438-11 CARBON 56K 5% 1/4W
R707 1-249-437-11 CARBON 47K 5% 1/4W
R711 1-260-095-11 CARBON 470 5% 1/2W
R713 1-249-441-11 CARBON 100K 5% 1/4W
R761 1-260-095-11 CARBON 470 5% 1/2W
R763 1-249-441-11 CARBON 100K 5% 1/4W
R803 1-249-429-11 CARBON 10K 5% 1/4W
R805 1-260-103-11 CARBON 2.2K 5% 1/2W
R807 1-260-103-11 CARBON 2.2K 5% 1/2W
R809 1-249-421-11 CARBON 2.2K 5% 1/4W
R813 1-249-429-11 CARBON 10K 5% 1/4W
R815 1-260-103-11 CARBON 2.2K 5% 1/2W
R817 1-260-103-11 CARBON 2.2K 5% 1/2W
R819 1-249-421-11 CARBON 2.2K 5% 1/4W
< RELAY >
RY701 1-755-126-11 RELAY
R306 1-260-103-11 CARBON 2.2K 5% 1/2W
!R309 1-212-881-11 FUSIBLE 100 5% 1/4W F
!R310 1-217-151-00 RES, METAL PLATE 0.22 2W
R311 1-249-417-11 CARBON 1K 5% 1/4W
R312 1-249-431-11 CARBON 15K 5% 1/4W
R314 1-260-099-11 CARBON 1K 5% 1/2W
R316 1-260-099-11 CARBON 1K 5% 1/2W
R318 1-260-076-11 CARBON 10 5% 1/2W
R320 1-260-076-11 CARBON 10 5% 1/2W
(AEP, UK)
R322 1-249-429-11 CARBON 10K 5% 1/4W
R323 1-247-881-00 CARBON 120K 5% 1/4W
R324 1-249-437-11 CARBON 47K 5% 1/4W
R325 1-249-417-11 CARBON 1K 5% 1/4W
R326 1-249-439-11 CARBON 68K 5% 1/4W
R327 1-249-437-11 CARBON 47K 5% 1/4W
R328 1-249-426-11 CARBON 5.6K 5% 1/4W
R329 1-249-433-11 CARBON 22K 5% 1/4W
!R330 1-212-849-00 FUSIBLE 4.7 5% 1/4W F
R335 1-249-441-11 CARBON 100K 5% 1/4W
R341 1-249-425-11 CARBON 4.7K 5% 1/4W
R351 1-249-417-11 CARBON 1K 5% 1/4W
R352 1-249-438-11 CARBON 56K 5% 1/4W
R353 1-249-415-11 CARBON 680 5% 1/4W
R354 1-249-438-11 CARBON 56K 5% 1/4W
R355 1-260-103-11 CARBON 2.2K 5% 1/2W
R356 1-260-103-11 CARBON 2.2K 5% 1/2W
!R359 1-212-881-11 FUSIBLE 100 5% 1/4W F
!R360 1-217-151-00 RES, METAL PLATE 0.22 2W
R361 1-249-417-11 CARBON 1K 5% 1/4W
R362 1-249-431-11 CARBON 15K 5% 1/4W
R368 1-260-076-11 CARBON 10 5% 1/2W
R370 1-260-076-11 CARBON 10 5% 1/2W
(AEP, UK)
R385 1-249-441-11 CARBON 100K 5% 1/4W
R401 1-260-076-11 CARBON 10 5% 1/2W
(AEP, UK)
R451 1-260-076-11 CARBON 10 5% 1/2W
(AEP, UK)
R501 1-249-417-11 CARBON 1K 5% 1/4W
R502 1-249-425-11 CARBON 4.7K 5% 1/4W
R503 1-249-417-11 CARBON 1K 5% 1/4W
R504 1-249-425-11 CARBON 4.7K 5% 1/4W
R505 1-249-417-11 CARBON 1K 5% 1/4W
R506 1-249-417-11 CARBON 1K 5% 1/4W
R507 1-249-417-11 CARBON 1K 5% 1/4W
R508 1-249-417-11 CARBON 1K 5% 1/4W
R509 1-249-417-11 CARBON 1K 5% 1/4W
R512 1-249-429-11 CARBON 10K 5% 1/4W
R514 1-249-429-11 CARBON 10K 5% 1/4W
R521 1-249-417-11 CARBON 1K 5% 1/4W
R522 1-249-417-11 CARBON 1K 5% 1/4W
R523 1-249-417-11 CARBON 1K 5% 1/4W
R531 1-249-429-11 CARBON 10K 5% 1/4W
The components identified by mark !or
dotted line with mark !are critical for
safety.
Replace only with part number specified.
MAIN
All manuals and user guides at all-guides.com