Sony Handycam HDR-CX240 User manual

SERVICE MANUAL
Revision History
Published by Sony Techno Create Corporation
Sony Corporation
LEVEL 3
HDR-CX240/CX240E/PJ240/PJ240E/PJ270/PJ270E/PJ275_L3
Check the SERVICE NOTE (LEVEL 2) before the service.
983477211.pdf
Digital HD Video Camera Recorder
The components identified by mark
0or dotted line with mark 0are
critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0sont critiques pour la
sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
9-834-772-11
Ver. Date History Contents S.M. Rev.
issued
1.0 2014.01 Official Release — —
2014A08-1
© 2014.01
MODEL GROUP
Projector Model: PJ240/PJ240E/PJ270/PJ270E/PJ275
Non Projector Model: CX240/CX240E
Ver. 1.0 2014.01 US Model
Canadian Model
AEP Model
UK Model
North European Model
E Model
Australian Model
Chinese Model
Korea Model
Brazilian Model
HDR-CX240/CX240E/PJ240/PJ240E/
PJ270/PJ270E/PJ275
Photo: HDR-CX240/Black

– 2 –
HDR-CX240/CX240E/PJ240/PJ240E/PJ270/PJ270E/PJ275_L3
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0OR DOTTED LINE WITH
MARK 0ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST
ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPO-
NENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY
SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REM-
PLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT
LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES
SUPPLÉMENTS PUBLIÉS PAR SONY.
Caution
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
1. Check the area of your repair for unsoldered or poorly-soldered
connections. Check the entire board surface for solder splashes and
bridges.
2. Check the interboard wiring to ensure that no wires are “pinched”
or contact high-wattage resistors.
3. Look for unauthorized replacement parts, particularly transistors,
that were installed during a previous repair. Point them out to the
customer and recommend their replacement.
4. Look for parts which, through functioning, show obvious signs of
deterioration. Point them out to the customer and recommend their
replacement.
5. Check the B+ voltage to see it is at the values specified.
6. Flexible Circuit Board Repairing
• Set the soldering iron tip temperature to 350 °C approximately.
• Do not touch the soldering iron on the same conductor of the circuit
board (within 3 times).
• Be careful not to apply force on the conductor when soldering or
unsoldering.
UNLEADED SOLDER
This unit uses unleaded solder.
Boards requiring use of unleaded solder are printed with the lead free
mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with the
lead free mark due to their particular size.)
: LEAD FREE MARK
Be careful to the following points to solder or unsolder.
• Set the soldering iron tip temperature to 350 °C approximately.
If cannot control temperature, solder/unsolder at high temperature
for a short time.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
Unleaded solder is more viscous (sticky, less prone to
flow) than ordinary solder so use caution not to let solder
bridges occur such as on IC pins, etc.
• Be sure to control soldering iron tips used for unleaded solder and
those for leaded solder so they are managed separately. Mixing un-
leaded solder and leaded solder will cause detachment phenomenon.
注意
如果电池更换不当会有爆炸危险。
只能用同样类型或等效类型的电池来更换。
务必按照说明处置用完的电池。

2-1
Ref. No. Part No. DescriptionRef. No. Part No. Description
HDR-CX240/CX240E/PJ240/PJ240E/PJ270/PJ270E/PJ275_L3
NOTE:
• -XX, -X mean standardized parts, so they may have some differ-
ences from the original one.
• Items marked “*” are not stocked since they are seldom required for
routine service. Some delay should be anticipated when ordering
these items.
• The mechanical parts with no reference number in the exploded
views are not supplied.
• Due to standardization, replacements in the parts list may be dif-
ferent from the parts specified in the diagrams or the components
used on the set.
• CAPACITORS:
uF: μF
• COILS
uH: μH
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
• SEMICONDUCTORS
In each case, u: μ, for example:
uA...: μA... , uPA... , μPA... ,
uPB... , μPB... , uPC... , μPC... ,
uPD..., μPD...
The components identified by mark 0
or dotted line with mark 0are critical
for safety.
Replace only with part number specified.
Les composants identifiés par une mar-
que 0sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
When indicating parts by reference num-
ber, please include the board name.
A-1903-090-A CM-1004 BOARD, COMPLETE
***********************
(CP001 is not supplied, but this is included in CM-1004 COMPLETE BOARD.)
< CAPACITOR >
C6703 1-112-717-91 CERAMIC CHIP 1uF 10% 6.3V
C6708 1-112-717-91 CERAMIC CHIP 1uF 10% 6.3V
C6709 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6710 1-112-717-91 CERAMIC CHIP 1uF 10% 6.3V
C6711 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6712 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50V
C6713 1-165-884-91 CERAMIC CHIP 2.2uF 10% 6.3V
C6714 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6715 1-116-724-11 CERAMIC CHIP 4.7uF 20% 6.3V
C6716 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6717 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6718 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6720 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
C6728 1-112-717-91 CERAMIC CHIP 1uF 10% 6.3V
C6729 1-112-717-91 CERAMIC CHIP 1uF 10% 6.3V
C6743 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50V
C6745 1-114-582-91 CERAMIC CHIP 0.1uF 10% 16V
< CONNECTOR >
*CN6702 1-821-503-11 CONNECTOR, FPC (ZIF) 39P
< COMPOSITION CIRCUIT BLOCK >
CP001 (Not supplied) IMX167CQL-13
< IC >
IC6703 6-715-211-01 IC MM3404A28URE
< RESISTOR >
R6707 1-218-973-11 METAL CHIP 47K 5% 1/16W
1-887-155-11 FP-2060 FLEXIBLE BOARD (PJ270/PJ270E/PJ275)
********************
A-1903-100-A FP-2106 FLEXIBLE BOARD, COMPLETE
(Projector Model)
******************************
< CONNECTOR >
CN5503 1-842-687-11 CONNECTOR, BOARD TO BOARD 42P
1-889-096-11 FP-2183 FLEXIBLE BOARD
********************
1-889-097-11 FP-2184 FLEXIBLE BOARD (Non Projector Model)
********************
1-889-184-11 FP-2190 FLEXIBLE BOARD
********************
1-889-187-11 FP-2193 FLEXIBLE BOARD (Projector Model)
********************
1-889-209-11 FP-2200 FLEXIBLE BOARD (PJ275)
********************
1-889-222-11 FP-2201 FLEXIBLE BOARD
********************
A-1992-840-A GY-1005 BOARD, COMPLETE
**********************
(C2404, C2405, C2407, C2409, C2411, C2412, R2408, R2409, R2412, R2413 and
SE7701 are not supplied, but they are included in GY-1005 COMPLETE BOARD.)
< CAPACITOR >
*C2403 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C2404 (Not supplied) CERAMIC CHIP 0.047uF 10% 6.3V
C2405 (Not supplied) CERAMIC CHIP 0.047uF 10% 6.3V
C2406 1-116-713-11 CERAMIC CHIP 22uF 20% 10V
C2407 (Not supplied) CERAMIC CHIP 0.33uF 10% 6.3V
C2409 (Not supplied) CERAMIC CHIP 0.33uF 10% 6.3V
C2410 1-116-713-11 CERAMIC CHIP 22uF 20% 10V
C2411 (Not supplied) CERAMIC CHIP 0.047uF 10% 6.3V
C2412 (Not supplied) CERAMIC CHIP 0.047uF 10% 6.3V
*C2413 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C7701 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C7702 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C7703 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C7704 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
< CONNECTOR >
CN4201 1-816-655-61 CONNECTOR, FFC/FPC 8P
< IC >
IC2403 6-707-333-01 IC NJM3230SE7
< RESISTOR >
R2216 1-694-535-91 SHORT CHIP 0
R2218 1-694-535-91 SHORT CHIP 0
R2405 1-240-711-91 METAL CHIP 22K 5% 1/20W
R2406 1-240-711-91 METAL CHIP 22K 5% 1/20W
R2408 (Not supplied) METAL CHIP 10K 1% 1/20W
R2409 (Not supplied) METAL CHIP 15K 1% 1/20W
*R2410 1-257-283-11 METAL CHIP 82K 1% 1/20W
*R2411 1-257-283-11 METAL CHIP 82K 1% 1/20W
R2412 (Not supplied) METAL CHIP 15K 1% 1/20W
R2413 (Not supplied) METAL CHIP 10K 1% 1/20W
R2414 1-240-711-91 METAL CHIP 22K 5% 1/20W
R2415 1-240-711-91 METAL CHIP 22K 5% 1/20W
R2417 1-694-535-91 SHORT CHIP 0
R2419 1-694-535-91 SHORT CHIP 0
2-2. ELECTRICAL PARTS LIST
Caution
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
Note 2: Replace the battery holder (BH4500 or BH4600) together
when replacing the lithium storage battery (BT4500 or
BT4600) on the PD-1028 board or PD-1029 board. (The
battery holder removed once cannot be used again.)
When mounting these parts, mount new battery holder first
and attach new lithium battery next.
Note1 : Be sure to read “Precautions for Replacement of Imager”
on page 6-1 when changing the imager.
CM-1004 FP-2060 FP-2106 FP-2183 FP-2184 FP-2190 FP-2193 FP-2200 FP-2201 GY-1005
The components identified by mark contain confidential information.
Strictly follow the instructions whenever the components are re-
paired and/or replaced.
Destroy and discard the prescribed board and IC after they are
replaced.
Les composants identifiés par le symbole contiennent des infor-
mations confidentielles.
Suivez scrupuleusement les instructions chaque fois qu'un com-
posant est remplacé et / ou réparé.
Veuillez détruire et éliminer les circuits imprimés et / ou les circuits
intégrés que vous avez remplacés.
标识有 的元件包含机密信息。
更换或维修元件时，请严格遵守指⽰。
更换后的电路板和IC，应予以报废。
注意
如果电池更换不当会有爆炸危险。
只能用同样类型或等效类型的电池来更换。
务必按照说明处置用完的电池。

2-2
Ref. No. Part No. Description Ref. No. Part No. Description Ref. No. Part No. DescriptionRef. No. Part No. Description
HDR-CX240/CX240E/PJ240/PJ240E/PJ270/PJ270E/PJ275_L3
R2422 1-694-535-91 SHORT CHIP 0
R4201 1-240-716-91 METAL CHIP 68K 5% 1/20W
R4202 1-240-726-91 METAL CHIP 470K 5% 1/20W
< SENSOR >
SE7701 (Not supplied) SENSOR, ANGULAR VELOCITY
A-1992-841-A MM-102 BOARD, COMPLETE (PJ270/PJ270E/PJ275)
**********************
< CAPACITOR >
C8102 1-118-465-11 CERAMIC CHIP 4.7uF 10% 16V
C8103 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8104 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
*C8701 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
< CONNECTOR >
*CN8101 1-816-647-61 FFC/FPC CONNECTOR (LIF) 18P
< IC >
*IC8101 6-721-333-01 IC THGBM5G6A2JBAIRH10
IC8701 6-716-442-11 IC MM3404A29URE
< RESISTOR >
R8101 1-218-965-11 METAL CHIP 10K 5% 1/16W
R8103 1-218-990-81 SHORT CHIP 0
R8104 1-218-990-81 SHORT CHIP 0
R8105 1-218-990-81 SHORT CHIP 0
R8106 1-218-990-81 SHORT CHIP 0
R8107 1-218-990-81 SHORT CHIP 0
R8108 1-218-990-81 SHORT CHIP 0
R8109 1-218-990-81 SHORT CHIP 0
R8110 1-218-990-81 SHORT CHIP 0
R8112 1-218-990-81 SHORT CHIP 0
< COMPOSITION CIRCUIT BLOCK >
RB8101 1-242-962-21 RES, NETWORK 82 (1005X4)
RB8102 1-242-962-21 RES, NETWORK 82 (1005X4)
A-1994-877-A PD-1028 BOARD, COMPLETE (SERVICE)
(Non Projector Model)
******************************
(S4501 is not supplied, but this is included in PD-1028 COMPLETE BOARD
(SERVICE).)
(BT4500 is not included in PD-1028 COMPLETE BOARD (SERVICE).)
< BATTERY HOLDER >
BH4500 1-251-928-21 SOCKET, BATTERY
< BATTERY >
BT4500 1-756-134-15 BATTERY, LITHIUM (SECONDARY)
< CAPACITOR >
*C4501 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C4503 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C8040 1-118-045-11 CERAMIC CHIP 2.2uF 10% 25V
C8041 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8042 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8043 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8044 1-118-040-11 CERAMIC CHIP 2.2uF 10% 16V
C8045 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8046 1-118-039-11 CERAMIC CHIP 1uF 10% 25V
C8047 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8048 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8049 1-118-039-11 CERAMIC CHIP 1uF 10% 25V
< CONNECTOR >
*CN4500 1-821-503-11 CONNECTOR, FPC (ZIF) 39P
*CN8040 1-821-503-11 CONNECTOR, FPC (ZIF) 39P
< COIL >
*L4500 1-481-102-21 INDUCTOR 10uH
< RESISTOR >
R4503 1-218-954-11 METAL CHIP 1.2K 5% 1/16W
R4508 1-218-960-11 METAL CHIP 3.9K 5% 1/16W
R4510 1-218-964-81 METAL CHIP 8.2K 5% 1/16W
R4513 1-218-977-11 METAL CHIP 100K 5% 1/16W
< COMPOSITION CIRCUIT BLOCK >
RB4500 1-234-375-21 RES, NETWORK 1K (1005X4)
RB4501 1-234-388-21 RES, NETWORK 1.5K (1005X4)
< SWITCH >
*S4500 1-786-914-51 SWITCH, TACTILE
S4501 (Not supplied) SWITCH, TACTILE
< SENSOR >
*SE4500 1-487-118-31 GMR SENSOR
A-1994-888-A PD-1029 BOARD, COMPLETE (SERVICE)
(Projector Model)
******************************
(IC8010 and S4601 are not supplied, but they are included in PD-1029 COMPLETE
BOARD (SERVICE).)
(BT4600 is not included in PD-1029 COMPLETE BOARD (SERVICE).)
< BATTERY HOLDER >
BH4600 1-251-928-21 SOCKET, BATTERY
< BATTERY >
BT4600 1-756-134-15 BATTERY, LITHIUM (SECONDARY)
< CAPACITOR >
C3700 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C3701 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
*C4601 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C4603 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C8040 1-118-045-11 CERAMIC CHIP 2.2uF 10% 25V
C8041 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8042 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8043 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8044 1-118-040-11 CERAMIC CHIP 2.2uF 10% 16V
C8045 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8046 1-118-039-11 CERAMIC CHIP 1uF 10% 25V
C8047 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8048 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8049 1-118-039-11 CERAMIC CHIP 1uF 10% 25V
< CONNECTOR >
CN3700 1-821-652-11 CONNECTOR, BOARD TO BOARD (REC
*CN4600 1-821-501-11 CONNECTOR, FPC (ZIF) 51P
*CN8040 1-821-503-11 CONNECTOR, FPC (ZIF) 39P
< FERRITE BEAD >
FB3700 1-469-580-21 INDUCTOR, FERRITE BEAD (1005)
< IC >
IC8010 (Not supplied) IC BU79R272-E2
< COIL >
*L4600 1-481-102-21 INDUCTOR 10uH
< RESISTOR >
R3706 1-240-683-91 METAL CHIP 100 5% 1/20W
R4607 1-218-977-11 METAL CHIP 100K 5% 1/16W
R4608 1-218-954-11 METAL CHIP 1.2K 5% 1/16W
R4613 1-218-960-11 METAL CHIP 3.9K 5% 1/16W
R4614 1-218-964-81 METAL CHIP 8.2K 5% 1/16W
R4619 1-218-970-81 METAL CHIP 27K 5% 1/16W
< COMPOSITION CIRCUIT BLOCK >
RB4600 1-234-375-21 RES, NETWORK 1K (1005X4)
RB4601 1-234-388-21 RES, NETWORK 1.5K (1005X4)
< SWITCH >
*S4600 1-786-914-51 SWITCH, TACTILE
S4601 (Not supplied) SWITCH, TACTILE
*S4602 1-786-914-51 SWITCH, TACTILE
< SENSOR >
*SE4600 1-487-118-31 GMR SENSOR
A-1994-765-A PJ-1009 BOARD, COMPLETE (Projector Model)
**********************
(IC8504, IC8605, IC8606, IC8801 and R8815 are not supplied, but they are included in
PJ-1009 COMPLETE BOARD.)
< CAPACITOR >
*C8510 1-116-720-11 CERAMIC CHIP 10uF 20% 6.3V
C8540 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
*C8543 1-118-035-11 CERAMIC CHIP 0.1uF 10% 25V
C8545 1-116-734-11 CERAMIC CHIP 1uF 20% 16V
C8547 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8548 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8549 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8551 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8602 1-164-856-81 CERAMIC CHIP 18PF 5% 50V
C8603 1-164-856-81 CERAMIC CHIP 18PF 5% 50V
C8605 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8606 1-118-459-11 CERAMIC CHIP 0.01uF 10% 25V
C8607 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8609 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8610 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8618 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8619 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8627 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8628 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8701 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8703 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8710 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8801 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8803 1-118-037-11 CERAMIC CHIP 0.22uF 10% 25V
C8804 1-118-039-11 CERAMIC CHIP 1uF 10% 25V
C8805 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
C8806 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8810 1-116-729-11 CERAMIC CHIP 2.2uF 20% 10V
*C8814 1-116-720-11 CERAMIC CHIP 10uF 20% 6.3V
C8816 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C8817 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8818 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C8824 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
< CONNECTOR >
*CN8502 1-816-643-51 FFC/CONNECTOR, FPC (LIF) 10P
CN8503 1-822-395-51 CONNECTOR, BOARD TO BOARD 60P
CN8504 1-842-897-11 CONNECTOR, FPC (ZIF) 45P
< DIODE >
D8501 6-503-126-01 DIODE DA2S10100K8
D8801 6-502-934-01 DIODE DB2S31100K8
< FERRITE BEAD >
FB8601 1-481-984-21 EMI FERRITE (SMD)(1005)
< IC >
IC8504 (Not supplied) IC MM3411A10URE
IC8605 (Not supplied) IC DPP2601
IC8606 (Not supplied) IC W25X40CLPYA1
*IC8701 6-721-275-01 IC W948D6FBHX5E-ER25
IC8801 (Not supplied) IC PAD1000YFFR
< COIL >
L8801 1-481-035-11 INDUCTOR 10uH
L8802 1-457-526-11 INDUCTOR 2.2uH
< TRANSISTOR >
Q301 6-550-576-01 TRANSISTOR SSM6E01TU
< RESISTOR >
R8518 1-218-959-11 METAL CHIP 3.3K 5% 1/16W
R8519 1-218-977-11 METAL CHIP 100K 5% 1/16W
R8520 1-220-398-11 METAL CHIP 1.5M 5% 1/16W
R8521 1-218-967-11 METAL CHIP 15K 5% 1/16W
R8522 1-218-968-11 METAL CHIP 18K 5% 1/16W
GY-1005 MM-102 PD-1028 PD-1029 PJ-1009

2-3
Ref. No. Part No. Description Ref. No. Part No. Description Ref. No. Part No. DescriptionRef. No. Part No. Description
HDR-CX240/CX240E/PJ240/PJ240E/PJ270/PJ270E/PJ275_L3
R8524 1-218-977-11 METAL CHIP 100K 5% 1/16W
R8611 1-218-941-81 METAL CHIP 100 5% 1/16W
R8612 1-250-567-11 METAL CHIP 1M 1% 1/16W
R8620 1-218-935-11 METAL CHIP 33 5% 1/16W
R8621 1-218-935-11 METAL CHIP 33 5% 1/16W
R8635 1-218-990-81 SHORT CHIP 0
R8638 1-218-977-11 METAL CHIP 100K 5% 1/16W
R8639 1-218-977-11 METAL CHIP 100K 5% 1/16W
R8640 1-218-977-11 METAL CHIP 100K 5% 1/16W
R8702 1-218-971-11 METAL CHIP 33K 5% 1/16W
R8813 1-218-977-11 METAL CHIP 100K 5% 1/16W
R8815 (Not supplied) METAL CHIP 0.1 1% 0.12W
R8818 1-218-935-11 METAL CHIP 33 5% 1/16W
< COMPOSITION CIRCUIT BLOCK >
RB8601 1-234-381-11 RES, NETWORK 100K (1005X4)
RB8604 1-234-381-11 RES, NETWORK 100K (1005X4)
< VIBRATOR >
X8601 1-814-480-11 QUARTZ CRYSTAL OSCILLATOR (16.66667MHz)
A-1992-842-A VC-1023 BOARD, COMPLETE (SERVICE)
(Non Projector Model)
A-1992-843-A VC-1023 BOARD, COMPLETE (SERVICE)
(Projector Model)
******************************
(C3404, C3405, C3406, C3407, C5112, CN4000, D5101, FB3300, IC1651, IC5101,
IC5103, IC6000, IC8000, IC8120, L0105, R1121, R1122, R3303, R6062, R6120,
R6121, R6123, R6124, R6125, TB4900 and TB4901 are not supplied, but they are
included in VC-1023 COMPLETE BOARD (SERVICE).)
< CAPACITOR >
*C0101 1-116-714-11 CERAMIC CHIP 22uF 20% 6.3V
*C0102 1-116-714-11 CERAMIC CHIP 22uF 20% 6.3V
*C0103 1-116-714-11 CERAMIC CHIP 22uF 20% 6.3V
*C0104 1-116-714-11 CERAMIC CHIP 22uF 20% 6.3V
*C0105 1-116-714-11 CERAMIC CHIP 22uF 20% 6.3V
(Projector Model)
C0105 1-116-717-11 CERAMIC CHIP 10uF 20% 10V
(Non Projector Model)
C0106 1-118-039-11 CERAMIC CHIP 1uF 10% 25V
*C0108 1-116-714-11 CERAMIC CHIP 22uF 20% 6.3V
*C1041 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1061 1-116-720-11 CERAMIC CHIP 10uF 20% 6.3V
*C1081 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1082 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1103 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1104 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1106 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1107 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1117 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1119 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1120 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1121 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1122 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1123 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C1125 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C1402 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C1403 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C1404 1-116-713-11 CERAMIC CHIP 22uF 20% 10V
*C1651 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
C1653 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
*C1655 1-116-720-11 CERAMIC CHIP 10uF 20% 6.3V
*C1657 1-116-720-11 CERAMIC CHIP 10uF 20% 6.3V
*C1662 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
C1671 1-118-026-11 CERAMIC CHIP 470PF 10% 25V
C3350 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
(Projector Model)
*C3402 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C3404 (Not supplied) CERAMIC CHIP 0.47uF 10% 6.3V
C3405 (Not supplied) CERAMIC CHIP 0.47uF 10% 6.3V
C3406 (Not supplied) CERAMIC CHIP 0.022uF 10% 10V
C3407 (Not supplied) CERAMIC CHIP 0.022uF 10% 10V
*C3408 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
C3409 1-128-605-11 CERAMIC CHIP 12PF 5% 25V
C3410 1-128-605-11 CERAMIC CHIP 12PF 5% 25V
*C3411 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
C4012 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C5104 1-116-717-11 CERAMIC CHIP 10uF 20% 10V
C5107 1-116-717-11 CERAMIC CHIP 10uF 20% 10V
C5108 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C5109 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C5110 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C5111 1-118-386-11 CERAMIC CHIP 0.1uF 10% 16V
C5112 (Not supplied) CERAMIC CHIP 0.1uF 10% 10V
C5118 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V
C5119 1-118-462-11 CERAMIC CHIP 1uF 10% 10V
C5120 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V
*C5121 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C6005 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6006 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6007 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6009 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6010 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6023 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C6061 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V
C6062 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V
*C6063 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6065 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6066 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6067 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6102 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6122 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6123 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6124 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6126 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6127 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6128 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6132 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6133 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6800 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6801 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6802 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6803 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C6818 1-118-033-11 CERAMIC CHIP 0.047uF 10% 10V
*C6819 1-118-033-11 CERAMIC CHIP 0.047uF 10% 10V
*C6843 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C7101 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C7102 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
*C8120 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8121 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8122 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8123 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8124 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
C8201 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V
(Projector Model)
*C8203 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8204 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
C8205 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V
(Projector Model)
*C8206 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8207 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8209 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8211 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
(Projector Model)
*C8404 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C8405 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C8407 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C8409 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
C8412 1-118-480-11 CERAMIC CHIP 4.7uF 10% 6.3V
*C8413 1-116-738-11 CERAMIC CHIP 1uF 10% 6.3V
*C8414 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V
< CONNECTOR >
*CN1651 1-843-120-21 HEADER ASSEMBRY
CN3201 1-843-066-11 CONNECTOR, HDMI (Projector Model)
CN4000 (Not supplied) SOCKET, USB CONNECTOR
*CN4001 1-779-329-51 CONNECTOR, FFC/FPC 10P
*CN4002 1-821-503-11 CONNECTOR, FPC (ZIF) 39P
CN4004 1-819-934-61 CONNECTOR, FPC (ZIF) 39P
*CN4005 1-816-644-51 FFC/CONNECTOR, FPC (LIF) 12P
*CN4006 1-816-647-61 FFC/CONNECTOR, FPC (LIF) 18P
(Projector Model)
CN4011 1-794-057-21 PIN, CONNECTOR (PC BOARD) 2P
CN4012 1-816-654-61 FFC/FPC CONNECTOR (LIF) 6P
CN4015 1-779-328-51 CONNECTOR, FFC/FPC 8P
*CN4901 1-842-522-21 CONNECTOR, FPC (ZIF) 61P
*CN4902 1-816-650-51 FFC/CONNECTOR, FPC (LIF) 24P
(Projector Model)
CN7101 1-843-144-21 CONNECTOR, CARD MSMICRO/SDMICR
CN9000 1-843-066-11 CONNECTOR, HDMI
< DIODE >
D4010 6-501-216-01 DIODE CL-271HR-C-TS
D5100 6-502-934-01 DIODE DB2S31100K8
D5101 (Not supplied) DIODE RBE05SM20AGJT2R
D6081 6-503-126-01 DIODE DA2S10100K8 (Non Projector Model)
*D6081 6-503-573-01 DIODE 1SS400SMGJT2R (Projector Model)
D6082 6-503-126-01 DIODE DA2S10100K8 (Non Projector Model)
*D6082 6-503-573-01 DIODE 1SS400SMGJT2R (Projector Model)
*D9000 6-502-988-01 DIODE RB480Y-40T2R
< FUSE >
F001 1-576-874-41 FUSE (2.5A/32V)
*F002 1-576-842-31 FUSE (0.63A/32V)
F003 1-523-134-31 FUSE (2A/50V)
< FERRITE BEAD >
*FB1003 1-481-250-11 INDUCTOR, FERRITE BEAD (1005)
FB1061 1-469-580-21 INDUCTOR, FERRITE BEAD (1005)
(Non Projector Model)
FB1061 1-481-984-21 EMI FERRITE (SMD)(1005) (Projector Model)
FB1062 1-400-833-21 SMD EMI FERRITE
FB1083 1-469-580-21 INDUCTOR, FERRITE BEAD (1005)
(Projector Model)
*FB1084 1-481-250-11 INDUCTOR, FERRITE BEAD (1005)
(Projector Model)
FB1085 1-218-990-81 SHORT CHIP 0 (Projector Model)
FB1086 1-218-990-81 SHORT CHIP 0 (Projector Model)
FB1087 1-218-990-81 SHORT CHIP 0 (Projector Model)
FB1088 1-218-990-81 SHORT CHIP 0 (Projector Model)
FB3300 (Not supplied) INDUCTOR, FERRITE BEAD (1005)
(Projector Model)
FB3350 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3351 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3352 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3353 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3354 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3355 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3356 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB3357 1-400-921-21 FERRITE, EMI (SMD) (Non Projector Model)
FB4000 1-400-927-31 BEAD, FERRITE (1005)
FB4001 1-400-927-31 BEAD, FERRITE (1005)
*FB6080 1-481-250-11 INDUCTOR, FERRITE BEAD (1005)
FB6081 1-469-580-21 INDUCTOR, FERRITE BEAD (1005)
< IC >
IC1651 (Not supplied) IC MAX14648EWA+TG1A
IC5101 (Not supplied) IC MB44C031PW-G-ER2E1
*IC5102 6-719-398-01 IC MM3416A10RRE
IC5103 (Not supplied) IC MM3376A50RRE
IC6000 (Not supplied) IC KSZ4G4G01A
IC6800 6-716-760-01 IC R2J30503LG
*IC6802 6-719-361-01 IC MM3416A28URE
IC8000 (Not supplied) IC BU79T272-E2 (Projector Model)
IC8120 (Not supplied) IC MB8AA4590BGL-G-ERE1 (Projector Model)
*IC8200 6-721-219-01 IC ADV7610BBCZ-RL (Projector Model)
IC8400 6-716-838-01 IC BU76381GUW-E2
< COIL >
L0101 1-460-358-11 INDUCTOR 2.2uH
L0102 1-481-036-11 INDUCTOR 4.7uH
L0103 1-481-036-11 INDUCTOR 4.7uH
L0104 1-460-358-11 INDUCTOR 2.2uH
L0105 (Not supplied) INDUCTOR 1.5uH
L0106 1-460-369-11 INDUCTOR 33uH
*L1652 1-460-629-11 COMMOM MODE CHOKE COIL
*L9000 1-460-611-11 COMMON MODE CHOKE COIL
PJ-1009 VC-1023