Sony Wahoo CLM-V55 User manual

SERVICE MANUAL
Sony Corporation
Published by Sony Techno Create Corporation
CLM-V55
SPECIFICATIONS
CLIP-ON LCD MONITOR
9-893-115-01
2011B05-1
© 2011.02
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
Chinese Model
Ver. 1.0 2011.02
Picture performance
LCD panel TFT Normally Black
Picture size 5 type
Viewing angle 90°/90°
Ecient picture size (w × h) Approx. 108 mm × 64.8 mm
(4 3/8 in. × 2 5/8 in.)
Resolution 800 × 480 pixels
Aspect ratio 15:9
Input/output
Input
HDMI input jack HDMI (Type A) (1)
DC IN jack DC 7.6 V
Output
Built-in speaker output Approx. 0.5 W Monaural
Headphones output jac 3.5 Stereo mini jack (1)
General
Power DC 7.2 V Sony M series battery
DC 7.6 V AC-PW10AM
Power consumption Approx. 5 W
Dimensions (w/h/d) Approx. 129 mm × 88.5 mm × 20 mm (5 1/8 in.
× 3 1/2 in. × 13/16 in.)
(Excluding projecting parts)
Mass Approx. 250 g (main unit only) (8.9 oz)
Operating temperature Approx. 0 °C to 40 °C (32 °F to 104 °F)
Storage temperature Approx. -20 °C to +60 °C (-4 °F to +140 °F)
Accessories supplied Shoe adaptor (2), HDMI cable (Type A Type
C) (1), Sun shade hood (1), Carrying pouch (1),
Set of printed documentation
Available signal formats
e unit is applicable to the following signal formats.
System Total
lines
Active
lines
Frame
rate Scanning Aspect
ratio
575/50I (PAL) 625 575 25 2:1 interlace 16:9/4:3
480/60I (NTSC) 525 483 30 2:1 interlace 16:9/4:3
576/50P 625 576 50 Progressive 16:9/4:3
480/60P 525 483 60 Progressive 16:9/4:3
640x480/60P 525 480 60 Progressive 4:3
1080/50I 1125 1080 25 2:1 interlace 16:9
1080/60I 1125 1080 30 2:1 interlace 16:9
720/50P 750 720 50 Progressive 16:9
720/60P 750 720 60 Progressive 16:9
1080/50P 1125 1080 50 Progressive 16:9
1080/60P 1125 1080 60 Progressive 16:9
Design and specications are subject to change without notice.
Trademark
is a trademark of Sony Corporation.
HDMI, the HDMI logo and High-Denition Multimedia Interface are
trademarks or registered trademarks of HDMI Licensing LLC.
Note: The mount parts except some connector, jack and switch on board
installed in this set cannot exchange with single. When parts that
not are described on this manual (page 4) are damaged, exchange
the block including the entire mounted board.

CLM-V55
2
SECTION 1
DISASSEMBLY
• This set can be disassembled in the order shown below.
1-1. DISASSEMBLY FLOW
Note: Follow the disassembly procedure in the numerical order given.
1-2. REAR PANEL ASSY (RA1)
SET
1-2. REAR PANEL ASSY (RA1)
(Page 2)
1-3. MOUNTED BOARD BLOCK
(Page 3)
1-4. DC JACK (DC1),
FRONT PANEL ASSY
(Page 3)
Note: Please spread a sheet
under a set not to injure
front panel.
– Rear side view (Bottom side) –
6
3panel screw
3panel screw
3two panel screws
3two panel screws
7speaker connector 8battery pack
terminal
connector
4claw
1two screw covers
1screw
cover
2Open the jack cover.
9jack cover
0DC jack cover
qa rear panel assy (RA1)
4claw
5four claws

CLM-V55
3
1-3. MOUNTED BOARD BLOCK
1-4. DC JACK (DC1), FRONT PANEL ASSY
1DC jack connector
2four mount screws
4LCD flexible board
5mounted board block
3
– Rear side view (Bottom side) –
Note: Please spread a sheet
under a set not to injure
front panel.
Note: Please spread a sheet
under a set not to injure
front panel.
– Rear side view (Bottom side) –
3two panel screws
1illminator
7DC jack (DC1)
8shoe bracket
9chassis block
0LCD
2button
4five claws
qa front panel assy
6
5

CLM-V55
4
SECTION 2
EXPLODED VIEW
1 4-282-663-01 SCREW, PANEL
2 4-283-660-01 SCREW, ROTARY
3 4-283-659-01 DIAL
4 4-282-214-01 SCREW, MOUNT
5 4-282-212-01 BRACKET, SHOE
6 X-2581-538-1 PANEL ASSY, FRONT
7 4-282-216-01 BUTTON (1)
8 4-282-232-01 ILLUMINATOR
9 4-283-719-01 COVER, SCREW
10 4-282-213-01 COVER, JACK
11 4-282-215-01 COVER, DC JACK
CON3 1-967-837-11 CONNECTOR, HDMI (HDMI (TYPE A))
CON3701 1-967-836-11 JACK, HP (i)
DC1 1-967-834-11 DC JACK (DC IN)
9MA1 X-2581-408-1 MAIN ASSY (Including LCD, Mounted board)
RA1 X-2581-406-1 PANEL ASSY, REAR
(Including Speaker, Battery pack terminal)
SW6 1-967-838-11 SWITCH, POWER (1)
SW7 1-967-852-11 SWITCH, ROTARY (OPERATION DIAL)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
Note:
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine ser-
vice. Some delay should be anticipated
when ordering these items.
• The mechanical parts with no reference
number in the exploded views are not sup-
plied.
• Color Indication of Appearance Parts Ex-
ample:
KNOB, BALANCE (WHITE) . . . (RED)
↑↑
Parts Color Cabinet’s Color
The components identified by mark 9con-
tain confidential information.
Strictly follow the instructions whenever the
components are repaired and/or replaced.
Les composants identifiés par la marque
9contiennent des informations confiden-
tielles.
Suivre scrupuleusement les instructions
chaque fois qu’un composant est remplacé
et / ou réparé.
Note: When you exchange the dial (Ref. No. 3) or the rotary switch
(Ref. No. SW7), please exchange both parts at the same time.
4
5
3
1
9
1
1
10
11
2
not supplied
(mounted board)
not supplied
CON3701
SW6
MA1
RA1
SW7
6
7
8
9
not supplied
1
1
CON3
DC1
• Rear side view

CLM-V55
5
Ref. No. Part No. Description Remark
SECTION 3
ACCESSORIES
1-967-831-11 CABLE, HDMI (Approx. 45 cm, Type A ↔Type C)
4-279-123-02 MANUAL, INSTRUCTION (JAPANESE,
SIMPLIFIED CHINESE) (Chinese)
4-279-123-12 MANUAL, INSTRUCTION (ENGLISH, FRENCH)
(EXCEPT Chinese)
4-279-123-22 MANUAL, INSTRUCTION (PORTUGUESE,
RUSSIAN, TRADITIONAL CHINESE, KOREAN,
ARABIC) (AEP, UK, E, Australian)
4-279-123-32 MANUAL, INSTRUCTION (SPANISH, GERMAN,
DUTCH, SWEDISH, ITALIAN)
(AEP, UK, E, Australian)
4-282-211-01 POUCH (Carrying pouch)
1 X-2581-403-1 ADAPTER, SHOE ( )
(for auto lock accessory shoe)
2 X-2581-404-1 ADAPTER, SHOE (ISO) (for accessory shoe)
3 X-2581-405-1 HOOD, LCD (Sun shade hood)
2
Shoe adaptor
(for accessory shoe)
3
Sun shade hood
1
Shoe adaptor
(for auto lock accessory shoe)

CLM-V55
REVISION HISTORY
Checking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.
Ver. Date Description of Revision
1.0 2011.02 New