SportRack SR9035 User manual

501-5995_01
ROOF BASKET - SR9035
PARTS INCLUDED
WARNINGS / LIMITATIONS
• Thoroughly read instructions and guidelines before
attempting to install and use your cargo basket.
• Do not exceed the weight capacity of your vehicle’s
rack system.
• Your carrying weight is the combined weight of the
basket and its contents (Basket weight = 35lbs.).
• Where possible, position the vehicle’s load bars
towards the back of the vehicle. This will help
with fuel efficiency and wind noise.
•Check SportRack’s Fit Guide for approved fits
on factory installed racks.
• Secure loads with SportRack’s cargo net (SR9031,
sold separately).
part description part number qty.
A — 2
B— 4
C—11
D— 4
E— 4
F— 4
G— 1
H— 3
I— 3
J
Welded Basket Assembly
Clamp Plates
Threaded Knob
Machine Screw
U-Bolt
Bar Saddle
Wind Deflector
Screw
Plastic Washer
Allen Key — 1
A G
B
H I J
C
D
E F

501-5995_01
1
•Slide the two halves of the basket (A) together. Align the holes in the bottom and top tubes and install screws (D) on both sides using the allen key (J).
2
•Install wind deflector (G) using screws (H), plastic washers (I) and knobs (C) as shown.
J
J
D
C
I
G
H
Top view

501-5995_01
3
• Put the basket on the factory or aftermarket crossbars to determine where the
bar saddles (F) are to be located. For optimal support on the rack, place the
bar saddles as close to the ends of your crossbars as possible. The diagram
at left shows the attachment area shaded in gray. You may have to adjust the
distance between your rack’s crossbars to align with the bar s addles.
• Snap the bar saddles in place between the rails of the basket.
• Bar saddle placement varies based on your crossbar shape (see diagram).
CAUTION DO NOT ATTACH BAR SADDLES TO CENTER BRACKET RAILS AS SHOWN BELOW.

501-5995_01
4
• Attach to crossbars by placing u-bolt (E) under the crossbar and up through the bar saddle (F). Slip the clamp plate (B) over the threaded ends of the u-bolt. Clamp plate
must rest on the top of the basket rail. Tighten with the threaded knobs (C). Check for overall fit and that all parts are tight.
C
E
B
F
C
F
E
B
Threaded Knob (C)
Bar Saddle (F)
Clamp Plate (B)
Take your vehicle's cargo capacity to a whole new level with the roof racks we offer.