Sun Seeker e-DELTA User manual

Find us online at SunSeeker.Bike Revised 11/2020
e-DELTA
Supplemental Owner’s Manual

1
Contents
1. Introduction............................................................................. 2
2. Specications ......................................................................... 2
3. ReferenceViews .................................................................... 3
4. AssemblyReference .............................................................. 4
5. AssemblyGuide ..................................................................... 5-13
6. ReadBeforeRiding ................................................................ 13
7. Pre-rideChecklist ................................................................... 14
8. Precautions&Warnings ......................................................... 15
9. Motor ...................................................................................... 16
10.Display.................................................................................... 17
11.TranzXDisplayUser'sGuide................................................. 18-21
12.ErrorCodeList ...................................................................... 22
13.Battery .................................................................................... 23-28
14.Charger................................................................................... 29-30
15.BluetoothAppManual ............................................................ 31-34
16.Notes ...................................................................................... 35

2
Model: e-DELTA-SX
Style: DeltaElectricAssistTrike
Frame: Hi-TensileSteel
Fork: Hi-TensileSteel
Handlebar: Steel
SteeringSystem: OverSeat
Seat: 1-piece–PaddedBasew/SteelFrame&FullMesh
Wheelbase: 55”(140cm)
OverallLength: 73”(186cm)
Width: 31”(78.7cm)
BottomBracketHeight: 15”(38cm)
SeatHeight: 22-24”(56-61cm)
Weight: 77lbs.
X-Seam: 28-44”(72-113cm)
WeightLimit: 300lbs.
Headset: ThreadedSteel
Grips: EVAFoamw/LockRing
Pedals: ToeClipCompatible
Crankset: SingleAlloy170mm42T
BottomBracket: Integratedw/Motor
Chain: KMC1/2x3/32"
RearDerailleur: Sunrace
Freewheel: 13-32T7-speed
ShifterLevers: Sunrace
Motor: TranzXMidDriveMotor36V/250W
Battery: TranzX36V/13.4Ah,w/BMS
BatteryCarrier: DownTubeBatteryType
Charger: DC36V,O/P:DC42V/2A
Display: TranzXLCDw/Bluetooth
BrakeLevers: PromaxAlloyLockingLinearPull
BrakeCaliperFront/Rear: PromaxLinearPull/PromaxMechanicalDisc
FrontHub: Alloy13Gx28H
RearHub: Alloy13Gx36H
Rims/Spokes: AlloySingleWall/13GSteel
Tires/Size: KendaKWEST16”/20”x1.50
WaterBottleCageMount: 2-Handlebar/2-SeatBack
Note:Specicationssubjecttochangewithoutnotice.
Introduction
CONGRATULATIONS!
CongratulationsandwelcometotheSunSeekerRecumbentfamily!Youhaveselectedoneofthemostcomfortableand
advancedrecumbentsonthemarket.PleasereadthismanualbeforeridingyourSunSeekerRecumbent.Inthismanual
youwillndthatwecoverthebasicsforsettingupandunderstandingyournewrecumbent.
IMPORTANT:
ThismanualisonlyasupplementtothemainRecumbentBicycle/TricycleOwner’sManual.
Pleasereaditbeforeyoutaketherstrideonyournewrecumbentbicycle/tricycle,andkeepitforreference.
NOTE:
Thismanualisnotintendedasacomprehensiveuse,service,repair,ormaintenancemanual.Pleaseseeyourdealerfor
allservice,repairsormaintenance.Yourdealermayalsobeabletoreferyoutoclasses,clinicsorbooksonbicycleuse,
service,repair,ormaintenance.
e-DELTA-SX Specications

3
Side View
Top View
e-DELTA Reference Views

4
e-Delta Assembly Reference
e-DELTAPartsList
ITEM DESCRIPTION QTY
1MainFrame&ForkAssembly 1
2RearUnitAssembly 1
3RearUnitBolts 2 Set
4FrontWheelAssembly 1
5RightRearWheelAssembly 1
6LeftRearWheelAssembly 1
7RearWheelNylockRetainingNut(M14) 2
8RearWheelWasherOuter(M15x2mm) 2
9RearWheelWasher(M17x2mm) 2
10 RearWheelSpacer(Alloy22.15mm) 1
11 Handlebar&StemAssembly 1
12 SeatFrameAssembly 1
13 BoltforSeatFrame(M8x90mm) 1
14 QuickReleaseSeatPin 1
15 SeatMesh(NotPicturedAbove) 1
16 UpperSeatStrut(16.0x150mm) 2
17 LowerSeatStrut(12.7x380mm) 2
18 SeatStrutPin 2
19 SeatStrutHardwareSetwithHalf-MoonNylonWashers(NotPicturedAbove) 1 Set
20 RearDerailleur 1
21 Chain&ChainTubeAssembly 1
22 Pedals(9/16") 1Pair
23 SeatMountBracket 1
12
14
23
13
5
6
2
3
8
9
10
9
87
1
16
17
18
4
7
11
20
21
22

5
Assembly Guide
Frame & Rear Unit Installation
1.Install#2RearUnitAssemblyonto#1Mainframeusing#3RearUnitBolts.SeeFigureA.
2.Tighten#3RearUnitBolts.SeeFigureB.
A
B
1
2
3
Tightento12Nm
(104In.Lbs)

6
C
4
Assembly Guide
Front Wheel Installation
1.Insert#4FrontWheelAssemblyintotheforkdropouts.SeeFigureC.
Rear Wheel Installation
1.Assemble#10RearWheelSpacer,#9RearWheelWasher,#6RearWheelAssemblyontoleftside(non-
driveside)rearaxle,using#8RearWheelOuterWasherand#7RearWheelNylocRetainingNutand
tighten.SeeFigureD.
2.Assemble#9RearWheelWasher,#5RearWheelAssemblyontorightside(driveside)rearaxle,using
#8RearWheelOuterWasherand#7RearWheelNylocRetainingNutandtighten.SeeFigureE.
NOTE:Donotovertightenthe#7RearWheelNylocRetainingNutontheLEFTside(non-driveside).
SeeFigureD.TheNutshouldbetightenedthenbackedoff1/2turntoleaveapproximately1to2mmof
sideplay.
E
5
7
8
9
D
6
7
8
9
10

7
Assembly Guide
Handlebar & Stem Installation
1.Install#7HandlebarandStemAssemblyintofork.SeeFigureF.
Seat Frame Assembly and Strut Installation
1.Install2#16UpperSeatStrutsand1/2moonnylonwashersto#12SeatFrametabswiththeprovided
hardware.SeeFigureG.
2.Insert2#17LowerSeatStrutsinto#16UpperSeatStrutsanduse2#18SeatStrutPinstosecurethe
struts.
3.Install#23SeatMountBracketusing#13M8x90mmBoltthrough#12SeatFrametabsandsecurewith
nutprovided.SeeFigureH.
F
GH
Tightento10Nm
(87In.Lbs)
Lubricate
stem&
wedge
before
inserting
10
18
16
17
12 12
13
23

8
Assembly Guide
Seat Frame Assembly and Strut Installation (continued)
4.Install#23SeatMountBracketonto#1MainFrameandsecurewith#14QuickReleaseSeatPin.
SeeFigureI.
5.Install2#16LowerSeatStrutsontotherearframemounttabsonthe#2RearUnitAssemblyandsecure
withtheprovidedhardware.
Rear Derailleur Installation
1.Install#20RearDerailleurontothe#2RearUnitAssemblyderailleurtabandsecurewiththeprovided
hardware.
SeeFigureJ.
I
J
Tightento8-9Nm
(70-85ln.Lbs)
12
14
17
20
23 1

9
K
Assembly Guide
Chain & Chain Tubes Installation
1.Insertthechainintothechaintubes.Beginningfromthebottomchaintube,insertchainfromreartofront,
thenintotopchaintube,fronttorear. Makesurethe“Y”springbracketisopentowardthefrontofthetrike.
2.Routetheopenendofthechainoverthecassetteandthroughtherearderailleurthenclosethechain.
3.Install#21Chain&ChainTubeAssemblyontothemainframeandsecurewithprovidedhardware.
SeeFigureK.
4.Installchainontocrankandpullenoughchaintogoaroundchainring.
5.Adjustchaintubestopreventcontactwithchainring.
21

10
Assembly Guide
Pedal Installation
1.Applygreasetothethreadsofthepedalspindle.Thiswillprotectboththethreadsofthepedalandcrank
armovertime.
2.Usepedalwasherswhererequired.Usingyourhands,threadthepedalspindleintothecrankarmby
turningittowardthefrontofthebike.Oncethethreadscatchuseyourpedalwrenchtonishtightening
downthepedals.SeeFigureL.
Torquedownthepedalstoaminimumof290in-lbsoftorque.
Cable Routing, Brake
1.Connecttheright/leftbrakecableonthebrakeleverstothelinearpullfrontbrakeandreardiscbrake
caliper.SeeFigureM&N.
L
MN
Tightento29Nm
(260In.Lbs)
Tightento6-8Nm
(52-69In.Lbs)
Tightento6-8Nm
(52-69In.Lbs)
22

11
Assembly Guide
Cable Routing, Rear Derailleur
1.RouteRearShifterHousingthroughtheinsideoftheframe,andconnectthecableintotherearderailleur
withabout50mmcablereserved.Cuttheexcesspart,clampwithaferrule.SeeFigureO&P.
Electrical Wire Routing
LCDDisplay
Motor
OptionalThrottleCableConnector
Battery
Battery
Connector
Wheel
Sensor
DisplayConnector
OP

12
Q
R
Q
R
Assembly Guide
Handlebar and Stem Adjustment
Handlebarstemheightcanbeadjustedtoprovidedesiredtoeclearanceduringpedalstroke.SeeFigureQ.
NOTE: DO NOT extend handlebar stem past its marked safety line.
Handlebarcanberotatedupordownfordesiredcomfort.Topreventnumbnessofthehandsorngersbe
suretokeepyourhandpositionjustbelowthelevelofyourheartwhileseated.
Oncehandlebarpositionissetyoucannowadjustthebrakeandshiftcontrolsforcomfort.
Seat Adjustment
Loosen#14QuickReleaseSeatPinandslidethe#23SeatMountBracketrearwardonthe#1MainFrame
untilinacomfortableseatingposition.Adjusttheseatanglebyremovingthe#18SeatStrutPinsandsliding
theSeatStrutsintoanewpositionifnecessary.NOTE:therearebothfrontandrearseattabsonthe#2
RearUnitAssemblytofurtheradjustproperseatposition.SeeFigureR.
FrontTabs RearTabs
18
23
2
14

13
Assembly Guide
Optional Thumb Throttle Installation
1.Removerighthand#24Shifterand#25BrakeLever.Install#26Throttle,reinstall#25BrakeLeverand
#26Shifter.SeeFigureS.
2.Removecapfrom#27OptionalThrottleCableConnector.SeeFigureT.
3.Install#26ThrottleCableinto#27OptionalThrottleCableConnector.SeeFigureU.
OptionalThrottlemaynotbelegalinallstates.
Pleasecheckyourlocaljurisdictionbefore
installing.
27
26
26
26
25
24
27
S
TU

14
PLEASE READ THIS BEFORE RIDING YOUR SUN SEEKER RECUMBENT
Thismanualisintendedtobereadcarefullysothatyoumayenjoyyournew
recumbentandbeaninformedriderawareofthebenetsaswellasthewarnings
andsafetyissuesinridingthisrecumbent.
Arecumbenttrikeisnotabicycleandthismanualcontainsspecicinformationand
warningsthatwillletyouenjoyyourSunSeekerRecumbentTrikeincomfortand
safety.
Tricyclingisasport,andamodeoftransportation.Withitcomestheriskofan
accidentthatcouldresultininjuryandevendeath.Byridingthisrecumbent,you
assumethatrisk.
Wewanttogiveyouasmuchinformationaspossibletomakeyouasaferrider.We
cannotcoverallcontingencies,butwecanmakeyoumoreawareandinformed.Be
awarethat:
 •Municipalbicycleregulationsalsoapplytorecumbents.Moststatesand
municipalitieshavebikeregulations.It’suptoyoutoresearchthose
regulationsandbecomeinformed.Yourlocaldealerwillbeabletohelpyouwith
thisinformation.Sinceyouwillbesharingtheroadattimeswithothervehicles,
agoodruletofollowis“Ifyoucan’tdoitwithabicycle,don’tdoit
witharecumbent”.
 •Arecumbenttrike’swidestpointcouldbebehindyouattherearwheels.Ifthe
frontgoesbyanobstaclethereisnoguaranteethattherearwheelswillalso
clear.Whenriding,youmustgiveclearancetotheedgeoftheroadorsidewalk.
Giveextraroomwhenpassingnearpedestriansandobstacles.
Stayclearofpotholesandbeawarethatyoucanlosecontrolifanywheels
shoulddropintoaholeorcatchanimmobileobject.
Alwaysridedefensivelyandwatchoutfortheunexpected.Thismeanseverything
fromcarstokids,pets,androughorhazardousroadsurfaces.Bepreparedtoavoid
dangerandALWAYSWEARABICYCLEHELMET.Werecommendbuyingyour
helmetfromalocaldealerthatcantandinstructyouonthecorrectwaytowear
thishelmet.Protectingyourheadisyourprimarysafetyresponsibility.
AlwayswearaCPSC,ANZI,ASTMS,orSNELLapprovedbicyclehelmet.CPSC
approvalistheU.S.FederalStandardtowhichallhelmetsmustcomply.

15
PRE-RIDE CHECKLIST
1.Checkyourtiresforproperairpressure.Keeptirepressurebetweenthe
minimumandmaximumairpressureratingprintedonthetiresidewall.Donot
inateoverthemaximumairpressureratingonthetiresidewall.
2.Testyourbrakesandmakesuretheystoptherecumbent.Ifyouhaveany
doubts,donotride,andseeyourdealerforservice.
3.Checkthatthehandlebaristightandthattheendsareplugged.Checkthe
saddlefortightness.
4. Movetherecumbentforwardandback.Ifyouhearorfeelanyresistance,do
not ride.
Ifyoufeelthatsomethingisnotrightafterperformingyourcheck,DONOTRIDE.
Takeyourrecumbenttoyourlocaldealerforinspection.

16
PRECAUTIONS AND WARNINGS
Arecumbenttrikedoesnothandlelikeabicycle.Youcannotleanintoaturn.Turns
mustbemademorecarefullyandataslowerspeedthanabicycle.
Allwheelsmustbeonthegroundatalltimes.Donotmakesuddenchangesin
directionthatcouldunbalancetherecumbentandcauseanaccident.
Whenbeginningtoride,stayataslowspeed.Youmustacclimateyourselfto
handlingandturningthisrecumbent.Ifyoufeelinsecure,slowdownandproceed
ataslowerpace.Withpractice,youwillbecomecomfortableridingandstopping.
Theabilitytoclimbhillsonthiselectricrecumbentwilldependonthegrade,rider
weight,pedalinput,andmomentum.Itisnotadvisedtorelysolelyonthemotor
assist.Bestresultswillcomefromacombinationofmotorandpedalassist.
Tippinghazard.Turningsharplyorturningatspeedsabove5mphcancausethe
recumbenttobecomeunbalancedandtipoverresultinginpossibleinjuryordeath.
Foryoursafety,themaximumpower-assistedspeedofthisrecumbentislimitedto
15 MPH.
Keepbothhandsonthehandlebaratalltimes.Ridingwithnohandscancause
therecumbenttobecomeunstableandtipover,resultinginpossibleinjuryor
death.
Werecommendthatyounotrideatnightorattimesofreducedvisibility.
Ifyoumustrideatnightorduringreducedvisibility,youmustouttyourrecumbent
withawhitefrontlightandredrearlight.Relyingonreectorsisnotadequate
protection.Mostmunicipalitiesrequirelightsfornightriding.Yourlocalbicycle
dealercanhelpyouinselectingtherightlightingsystemforyourneeds.
INTENDEDFORRIDERS13YEARSOFAGEOROLDER.
MAXIMUMWEIGHTLIMITFORRIDERANDCARGOCOMBINEDIS300LBS.

17
MOTOR
Brand:TranzX
Model:M16GTMidDriveMotor
RatedVoltage:36VDC
RatedPower:250W
Efciency(%):>78%
NoiseLevel:75dBA
WaterResistanceRating:IPX5
OperatingTemperatureRange:-4°F~104F
Weight:8.6LBS

18
DISPLAY
Brand:TranzX
Model:DP29
RatedVoltage:36VDC
Communication:CANBUS
WaterResistanceRating:IPX5
Certicates:CE/ROHS
OperatingTemperatureRange:32°F-131°F
FEATURES:
Largefontsareeasytoread,withlight-sensitiveswitches,three-buttonsimple
operation,batterydisplay,kilometer/mileswitchdisplay,four-stagepowerassist
mode,front/rearlightswitch,USBchargingsupport.
Bluetooth
ThedisplaysupportsBluetoothconnection.
FordetailsofBluetoothoperation,pleaserefertotheTranzxAPPmanual.
www.gpstuner.com/tranzx-app-documentation-2/
UserManual:Forcompletedetailsontheoperationanduseofthisdisplayrefer
totheTranzXUserManualincludedinthefollowingsection.
For your safety, the
maximum power assisted
speed of this recumbent is
limited to 15 MPH.

19
DP29 Display Operation Manual
Control pad
CONTROL PAD BUTTONS
A Short Press Increase assist mode
Long Press Walking Assist
B Short Press Decrease assist mode
Long Press Light ON/OFF
C Short Press Turn On / Switch modes
(Speed/Assist mode /Range)
Long Press Turn Off
D Battery mode (5 -LED)
E Speed / Assist mode / Range
DP29DisplayOperationManual
DISPLAY USER'S GUIDE