Thuasne SpryStep AFO Manual

SpryStep AFO
4615 Shepard Street Bakersfield, CA 93313
Tele 800.432.3466 - Fax [phone]
www.ThuasneUSA.com
MADE IN USA BY
TOWNSEND DESIGN
4615 SHEPARD STREET
BAKERSFIELD, CA 93313
T E L 6 6 1. 8 3 7.17 9 5
L-0089 REV. A
Indications
These indications are biomechanical deficits that the orthosis is
intended to address. Assessment by a healthcare professional is
always recommended.
• Fatigueable footdrop
• Footslap
• Footdrop
• Excessive plantarflexion
during swing phase
(secondary to weak
dorsiflexors)
• Weakness of the
pretibial muscles <=3
• Plantar flexor strength 4
• Mild knee instability
during stance phase
• Knee hyperextension
• Circumduction
• Vaulting
• High knee gait
• Hip hiking / contralateral
trunk lean
Contraindications
These contraindications are pathological conditions the orthosis
was not intended to address. In some scenarios the assessment
of a trained CPO can override these suggestions.
• Patients over 250lbs
(please call Thuasne USA
for custom options)
• Moderate to severe
spasticity of the
foot and ankle
• Open ulcers of the foot,
ankle or lower leg
• Moderate to
severe edema
• Moderate to severe
foot deformities
• Moderate to severe
ankle instabilities
• triplanar instability
• Plantarflexion contracture
• Running/high impact
activities (please call Thuasne
USA for custom options)
Cautions
• Risk of accident when driving a motor vehicle or
machinery when wearing SpryStep is determined on
a case by case basis. Criteria include the type of fitting
and the individual abilities of the SpryStep user
• If the SpryStep is applied too tightly to the body it
can result in restricted blood flow or nerve palsy
• SpryStep can only be worn in appropriate footwear
(closed heel, closed toe, maximum heel height of 1”)
Warranty
• 1 year warranty on carbon
fiber portion of the AFO
• 6 month warranty for pad and strap
Warranty Limitations
• Extreme squatting or kneeling.
• Loading a portion of the toe while
climbing stairs or uneven surfaces
Product Disclaimer
This brace is a prescription product that should be used in
accordance with the directives of a physician as part of a
treatment plan for managing the patient’s total health. While
this type of brace has proven beneficial to many patients,
outcomes will vary based on factors including patient age,
general health, and/or lack of compliance with instructions for
how to put on and use the product. Because of variations in the
health and condition of each patient, Townsend Design also does
not make any specific recommendations regarding appropriate
activities for the user of this brace. You should IMMEDIATELY
DISCONTINUE USE of this brace if there is any abnormal redness
that lasts more than 10 minutes after removing the brace, or
any skin irritation, bruising, blistering or abrasion.
Medical Professional Instruction Guide

SpryStep AFO
4615 Shepard Street Bakersfield, CA 93313
Tele 800.432.3466 - Fax [phone]
www.ThuasneUSA.com
MADE IN USA BY
TOWNSEND DESIGN
4615 SHEPARD STREET
BAKERSFIELD, CA 93313
T E L 6 6 1. 8 3 7.17 9 5
L-0089 REV. A
Footplate Preparation
1. Tracing Footwear Inlay
• Use the inlay from the footwear
to measure the template size
(if the inlay is removable)
• Trace the template onto the
SpryStep footplate
2. Cutting the Footplate
• Use scissors to trim the footplate
to the correct template size
• Note: It is only possible to trim
the blue area with scissors
Fitting instructions
1. Place SpryStep into Shoe
• Take the original inlay out of the shoe, if removable
• The SpryStep should fit into the shoe
with minimal distortion to the shoe
2. Place Inlay Over the Footplate
• Place original inlay over the top
of the SpryStep foot plate
• If the inlay is not removable, disregard this step
3. Fitting the SpryStep
• With the shoe laces loose, slide the foot inside
the shoe. You may use a shoe horn if needed
4. Check the Fit
• Ensure the heel sits flat on the sole and
that the shoe heel is not distorted
5. Secure the Calf Strap
• Feed the straps through the loop
• If the strap is too long, remove the alligator
tab and trim the strap with scissors
• Replace alligator tab
• Fasten strap firmly
6. Secure the Fit
• Ensure laces or other fastening
mechanisms are firmly tightened
• Ensure comfort with no impingements prior to use
1. 3. 5. 6.

SpryStep AFO
4615 Shepard Street Bakersfield, CA 93313
Tele 800.432.3466 - Fax [phone]
www.ThuasneUSA.com
MADE IN USA BY
TOWNSEND DESIGN
4615 SHEPARD STREET
BAKERSFIELD, CA 93313
T E L 6 6 1. 8 3 7.17 9 5
L-0090 REV. A
Patient Instruction Guide
Fitting instructions
1. Place SpryStep into Shoe
• Take the original inlay out of the shoe, if removable
• The SpryStep should fit into the shoe
with minimal distortion to the shoe
2. Place Inlay Over the Footplate
• Place original inlay over the top
of the SpryStep foot plate
• If the inlay is not removable, disregard this step
3. Fitting the SpryStep
• With the shoe laces loose, slide the foot inside
the shoe. You may use a shoe horn if needed
4. Check the Fit
• Ensure the heel sits flat on the sole and
that the shoe heel is not distorted
5. Secure the Calf Strap
• Feed the straps through the loop
• If the strap is too long, remove the alligator
tab and trim the strap with scissors
• Replace alligator tab
• Fasten strap firmly
6. Secure the Fit
• Ensure laces or other fastening
mechanisms are firmly tightened
• Ensure comfort with no impingements prior to use
Cautions
• Risk of accident when driving a motor vehicle or
machinery when wearing SpryStep is determined on
a case by case basis. Criteria include the type of fitting
and the individual abilities of the SpryStep user
• If the SpryStep is applied too tightly to the body it
can result in restricted blood flow or nerve palsy
• SpryStep can only be worn in appropriate footwear
(closed heel, closed toe, maximum heel height of 1”)
Warranty
• 1 year warranty on carbon
fiber portion of the AFO
• 6 month warranty
for pad and strap
Warranty Limitations
• Extreme squatting or kneeling.
• Loading a portion of the toe while climbing
stairs or uneven surfaces.
Product Disclaimer
This brace is a prescription product that should be used in
accordance with the directives of a physician as part of a
treatment plan for managing the patient’s total health. While
this type of brace has proven beneficial to many patients,
outcomes will vary based on factors including patient age,
general health, and/or lack of compliance with instructions for
how to put on and use the product. Because of variations in the
health and condition of each patient, Townsend Design also does
not make any specific recommendations regarding appropriate
activities for the user of this brace. You should IMMEDIATELY
DISCONTINUE USE of this brace if there is any abnormal redness
that lasts more than 10 minutes after removing the brace, or
any skin irritation, bruising, blistering or abrasion.
1. 3. 5. 6.