Travis Industries 616 GSR User manual


616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 1 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
WARNINGS
MakesurethegascontrolvalveisOFFandtheheateriscoolpriortoconductingservice.
Failuretopositionthepartsinaccordancewiththesediagramsorfailuretouseonlypartsspecificallyapprovedwiththis
appliancemayresultinpropertydamageorpersonalinjury.
Ifusingpropane(LP),converttheappliancebeforeinstallingthelogs(seetheownersmanualfordetails).
Compatibility
616GSR
Packing List
  

10‐PieceTraditionalLogSet  RearAirDeflector,RearLogSupport.BagofRockWool,BagofEmbers
NGandLPcompatible.

Burner Installation
NOTE:Theinsertshouldbeinplace,withthegaslineandventattachedandthefirebacksinstalled(seeowner’smanualfor
furtherdetails).
1. Removetherearburner.
 
Removethe1or2burner
screws(1/4”nutdriver).


616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 2 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
2. Removethe3screwsfromthebackoftherearburnerusinga¼”nutdriver.
 

3. Attachtherearairdeflectortotherearburnerwiththescrewsremovedinthepreviousstep.
 

4. Replacetherearburnerandsecurewiththeattachmentscrew(s).


Thetwotabsonthe rear
burnerrestontopofthe
frontburner.


616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 3 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
5. Installtherearlogshelf.

Rock Wool Placement
6. Placetherockwoolasshownbelow.Useastiffbrushtoapplytherockwoolinaloose,gauze‐likelayer.

TIP:Holdtherockwoolinatightwadwithonehandwhilebrushingwiththeother.
  

Notehowtherockwoolisapproximately1/8”thickoverthe
burnerports.
TIP:Feelfreetoapplyagenerousamountofrockwooltogain
adarkerflameandabrightercoalbed.



616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 4 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
Log and Ember Chunks Placement
Thelogsarefragile,especiallyafterbeingexposedtoheat.
Theburnermustbecorrectlypositionedbeforeinstallingthelogs.Makesuretheburnerisfullyseated.
7. Placetherearlogasshownbelow.

 

  
Pullthelogforwarduntilitrestsagainstthetabsontheburners.



616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 5 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
8. Placetherightmiddlelogasshownbelow.Therightmiddlelogneedstobepushedbacktightagainsttherearburner.

 

9. Placetheleftmiddlelogasshownbelow.Theleftmiddlelogneedstobepushedbacktightagainsttherearburner.
 

 


616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 6 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
10. Placetherightfrontlogasshown.
  
  

11. Placetheleftfrontlogasshown.
 
 




616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 7 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
12. Placeemberchunksinthegapsbetweenleftandrightmiddlelogs
 

13. Placetherightcrosslogasshownbelow.
 
 






616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 8 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
14. Placethemiddlecrosslogasshownbelow.
 
 

15. Placetheleftcrosslogasshownbelow.
 
 





616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 9 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
16. Placefrontemberlogasshownbelow.
 
 

17. Placethetwigchunkasshownbelow.

 






616 GSR Traditional Log Set Version 2
Installation Instructions (SKU94500947)


Page 10 of 10 17601921 — 3/24/16 © Travis Industries, Inc.
18. Placetheemberchunksinthefrontcornersandalongthefrontoftheburner.Usetheemberchunkstocoverscrewheadsbutdo
notplacethemoverporting.



19. Re‐applytherockwoolovertheemberchunksalongthefrontburnerandbetweenthetwofrontlogsforanaturallook.
TIP:Applyingrockwoolinthecracksofthelogshelpstoaddsmallpointsofglow,butmaydampentheoverallglowofthelogs.
TIP:Naturalgas(NG)canusemorerockwoolthanpropane(LP).
NOTE:Initialapplicationofrockwoolmaycause“matting”overburnerports.Turningtheunitonandthenoffagainwillloosen
therockwool,resultinginabetterflame.

20. Theinsertshouldbetest‐burnedwiththeglassframeinplacepriortoleavingtheinstallation.Seetheowner’smanualfordetails
onfinalizingtheinstallation(adjustingtheairshutter,etc.).
21. Checktheexhaustrestrictorsettingbeforefinalizingtheinstallation.
Restrictor Settings
Traditional Logs
Natural Gas Short Vent
(25’ or less)#3 (stock)
Natural Gas Tall Vent
(25’ or more)#3 (stock)
Propane Short Vent
(25’ or less)#1
Propane Tall Vent
(25’ or more)#3 (stock)
