Vulcan-Hart 2G4BDF User manual

Item # __________________________
C.S.I. Section 11420
VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]
502-778-2791 QUOTE & ORDER FAX: [phone]
A2780
ISO9001
Vulcan-Hart
Co.
F-32938 (5-08)
GBDF KLEENSCREEN PLUS® FILTRATION SYSTEM
STANDARD FEATURES
Filter system accommodates minimum of two, maximum of
four fryer cabinets for each size fry tank.
Solid State knob controls located behind the door. Maintains
+/- 2° F yield quick recovery.
Two melt modes - Liquid and Solid
Boil Out ByPass™ removes water or discard oil .
Drain valve interlock switch.
6" Casters adjustable - 2 locking, 2 non-locking.
Electronic ignition.
Drawn (seamless) 18 gauge, #301 stainless steel filter
pan. 70 lbs. frying compound capacity on G4BDF, 110 lbs.
capacity on G6BDF & G8BDF.
Paperless stainless steel filter screen filters from 2
sides filter area = 270 sq. inches. Mircro Filtartion
Fabric Envelope filter area = 350 square inches.
1/3H.P. motor and pump circulates frying compound at a rate
of 8.0 gallons per minute.
Patented solenoid activated one touch push button switch to
engage pump and motor.
6' High Temperature Discard Hose
Large primary crumb catch basket.
Tank brush, stainless steel crumb scoop and clean-out rod.
120 volt, 60 Hz, 1 phase.
One year limited parts and labor warranty.
12 year fry tank replacement part warranty.
GBDF KLEENSCREEN PLUS®
FILTRATION SYSTEM
SPECIFICATIONS:
Patented Built-in filter system, Vulcan-Hart Model No. 2GBDF (lb.
capacity - 45, 65 or 85) Solid state knob control, F (add suffix-F
to fryer battery model No., i.e. 2G4BDF). Filter sytem accommo-
dates minimum of two, maximum of four cabinets for each size
fry tank. Filter vessel constructed of 18 gauge #301 series
stainless steel. The 2G4BDF filter pan weighs only 12.2 lbs. and
the filter pan for the 2G6 & 8BDF weighs only 20.5 lbs. 1/3H.P.
motor/ pump circulates hot frying compound at the rate of 8
gallons per minute, activated by a patented solenoid push button
switch. Patented System provided standard with paperless
stainless steel mesh filter screen. A complimentary package of
KleenScreen PLUS® Fabric Envelopes is also included. Stan-
dard equipment comes on casters, a primary crumb catch basket,
tank brush, scoop and clean-out rod. Hands free oil return line
connection. Drain valve interlock switch turns fryer's burners off
when drain valve is opened. Requires 120 volt, 60 Hz, 1 phase
power supply.
CSA design certified. NSF Listed.
ACCESSORIES
Stainless steel tank cover.
Micro-Filtration Fabric Envelopes - 6 filters/per package
"Add-On" Frymate - VX15, VX21, VX21S.
Rear oil reclamation discard connection.
Prison Security Package
Flexible gas hose with quick disconnect.
OPTIONS
Second year extended limited parts and labor warranty.
REFERENCEMATERIALS
See 1G4BD Spec Sheet F-32935
See 1G6BD Spec Sheet F-32936
See 1G8BD Spec Sheet F-32937
BUILT-IN FILTER SYSTEM FOR GBDF SERIES FRYERS
SPECIFY TYPE OF GAS: NATURAL OR PROPANE
SPECIFY ALTITUDE: NATURAL GAS ABOVE 2,000 FT.
PROPANE GAS ABOVE 3,500 FT.
2G4BDF Solid State Control Behind the Door Shown

Printed On Recycled Pap
er
VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]
502-778-2791 QUOTE & ORDER FAX: [phone]
NOTE: In line with its policy to continually improve its products, Vulcan-Hart Company reserves the right to change materials and
specifications without notice.
F-32938 (5-08)
BUILT-IN FILTER SYSTEM FOR GBDF SERIES FRYERS
Model No. 2 Fryers 3 Fryers 4 Fryers
Width Width Width
G4BDF 31" 461/2" 62"
G6BDF 42" 63" 84"
G8BDF 42" 63" 84"
BATTERYDIMENSIONS:
IMPORTANT
1. A combination valve with pressure regulator is provided with
this unit.
Natural Gas 4.0" (102 mm) W.C.
Propane Gas 10.0" (254 mm) W.C.
2. An adequate ventilation system is required for Commercial
Cooking Equipment. Information may be obtained by writing
to the National Fire Protection Association, Batterymarch
Park, Quincy, MA 02269. When writing refer to NFPA No. 96.
3. All models require a 6" (152 mm) clearance at both sides and
rear adjacent to combustible construction.
TOP VIEW
2G4BDF/
2G6BDF/
2G8BDF
SERIES
4. All models require a 16" (407 mm) minimum clearance to adjacent
open top burner units.
5. This appliance is manufactured for commercial installation only and
is not intended for home use.
SERVICE CONNECTIONS:
P1 11/4" (32 mm) NPT common rear gas connection.
E1 115 volt cord & 5-15P NEMA plug supplied with fryers(filter pump).
GBDF KLEENSCREEN PLUS®
FILTRATION SYSTEM
E1
P1
FRONT VIEW
2G4BDF/
2G6BDF/
2G8BDF
SERIES
SIDE VIEW
2G4BDF/
2G6BDF/
2G8BDF
SERIES
SEE CHART