Wenger Gearboss Center Soft Divider Series User manual

Owner’s Manual
Center Soft Divider
Accessory
©Wenger Corporation 2005 Printed in USA 07/05 Part #240A116-1
Wenger Corporation, 555 Park Drive, P.O. Box 448, Owatonna, Minnesota 55060-0448
Questions? Call.....USA: [phone] • International (call collect): [phone] • www.wengercorp.com
Note: Please read and understand the Center Soft Divider Accessory Owner’s Manual before
attempting installation, assembly, or use.
Note: Remove all items from the shipping containers and sort the components by type, size, etc.
Refer to the illustrations on the following pages. If you need additional information about your
Center Soft Divider Accessory, contact the Wenger Corporation using the information listed
below.
CONTENTS
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Important User Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Intended Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Full Length Center Soft Divider Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Half Length Center Soft Divider Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Replacement Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Full Length Center Soft Divider Accessory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Half Length Center Soft Divider Accessory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Half Length Center Soft Divider
Full Length Center Soft Divider

2
SAFETY
Throughout this manual you will find Cautions and Warnings which are defined as follows.
• Warning means that failure to follow the instruction may result in serious injury or death.
• Caution means that failure to follow the instruction may result in injury or damage to property.
Read and understand the following safety instructions before using or installing any Gearboss
Accessory.
GENERAL
INSTALLATION
The Gearboss Center Soft Divider Accessory is guaranteed free of defects in materials and
workmanship for five full years.
Our guarantee assures you of either a full refund or repair or replacement of the defective materials or
workmanship without charge, at the discretion of our Customer Service Department. Just call a
Customer Service Representative at 1-800-887-7145 and state the reason you are dissatisfied. If a
product return is necessary, your representative will issue a return authorization. This is your sole
remedy for breach of this warranty.
Should you have a question or problem with any Wenger product, don’t hesitate to call, even if the
product is past warranty. It’s important to us that all our customers be satisfied.
This is the sole warranty made by Wenger. Wenger disclaims all other warranties, including the
warranties of merchantability and fitness for a particular purpose, as well as all liability for incidental,
consequential, special, and indirect damage. Wenger liability for direct damages shall be limited to the
amount you paid for the product involved. Wenger reserves the right to make product changes without
obligation to incorporate such changes into products previously sold.
Some states do not allow the exclusion or limitation of damages or warranties, so the above may not
apply to you. This warranty gives you specific legal rights. You may also have other rights which vary
from state to state.
WARRANTY
Installation and use of the
Gearboss Accessories must
always comply with the
information in the
“Important End User
Information, Intended Use”
section on page 3 of this
manual.
!CAUTION
Never stand on a Cart while
working on it.
!CAUTION
When using the Gearboss
Accessories, always observe
and comply with Warnings
and Cautions posted on the
system equipment.
!CAUTION
Make sure that anyone who
helps assemble the
Gearboss Center Soft Divider
Accessory has read and
understands this manual.
!CAUTION

3
IMPORTANT USER INFORMATION
INSTALLATION
•The Gearboss Center Soft Divider Accessory installation must comply with local building regulations
and codes.
•Personnel installing the Gearboss Center Soft Divider Accessory must comply with the Warnings
and Cautions in the Safety Section.
INTENDED USE
•The Gearboss Center Soft Divider Accessory is intended for indoor use in normal ambient
temperature and humidity conditions — it must not be exposed to prolonged outside weather
conditions.
•The Gearboss Center Soft Divider Accessory is intended to be permanently installed only as
described in this manual.

4
FULL LENGTH CENTER SOFT DIVIDER INSTALLATION
To attach the Full Length Center Soft Divider:
1. Secure the Center Soft Divider to each End Frame Wire-grille End Panel using the included
nylon ties.
a. Feed one of the included nylon ties through each eyelet (three holes on each side)
b. Wrap nylon tie around a wire-grille panel horizontal wire and fasten the tie.
NOTE: Once the nylon tie is fastened, it cannot be removed without cutting it off.
Wire-grille
End Panel
Nylon Tie
Eylet

5
HALF LENGTH CENTER SOFT DIVIDER INSTALLATION
NOTE: The Half Length Center Soft Divider Accessory is designed to be used with the Cart Divider
Accessory.
To attach the Half Length Center Soft Divider:
1. Secure the one side of the Center Soft Divider to the End Frame Wire-grille End Panel using the
included nylon ties.
a. Feed one of the included nylon ties through each eyelet (three holes on each side)
b. Wrap nylon tie around a wire-grille panel horizontal wire and fasten the tie.
NOTE: Once the nylon tie is fastened, it cannot be removed without cutting it off.
2. Secure the other side of the Center Soft Divider to the Cart Divider using the steps above.
Wire-grille
End Panel
Cart Divider
Nylon Tie
Eylet

6
REPLACEMENT PARTS LIST
Note: The following parts are contained in
the Full Length Center Soft Divider
Accessory Carton. Contact Wenger
for replacement part information.
FULL LENGTH CENTER SOFT DIVIDER ACCESSORY
Item Qty Description
1 1 Full Length Center Soft Divider
2 6 Nylon Tie
HALF LENGTH CENTER SOFT DIVIDER ACCESSORY
Note: The following parts are contained in
the Half Length Center Soft Divider
Accessory Carton. Contact Wenger
for replacement part information.
Item Qty Description
1 1 Half Length Center Soft Divider
2 6 Nylon Tie
1
2
1
2