Akai MPC2000 User manual

AKAI Service MANUAL
MIDI PRODUCTION CENTER
move. MPC2000

*
SAFETY
INSTRUCTIONS
PRECAUTIONS DURING SERVICING
1. Parts identified by the A (#) symbol are critical tor
safety. Replace them only with the parts number specified.
2. In addition to safety, other parts and assemblies are
specified for conformance with such regulations as
those applying to spurious radiation. These must also
be replaced only with the specified replacements.
Examples: RF converters, tuner units, antenna selector
switches, RF cables, noise blocking capacitors,
noise blocking filters, etc.
3. Use specified internal wiring. Note especially:
1) Wires covered with PVC tubing
2) Double insulated wires
3) High voltage leads
4. Use specified insulating materials for hazardous live
parts.
Note especially:
1) Insulation Tape
2) PVC tubing
3) Spacers (insulating barriers)
4) Insulation sheets for transistors
5) Plastic screws for fixing micro switches
5. When replacing AC primary side components
(transformers, power cards, noise blocking capacitors,
etc.), wrap the ends of the wires securely around the
terminals before soldering.
Ye à > 1
6. Make sure that wires do not contact heat producing
parts (heat sinks, oxide metal film resistors, fusible
resistors, etc.).
7. Check that replaced wires do not contact sharp edged
or pointed parts.
. Also check areas surrounding repaired locations.
9. Make sure that foreign objects (screws, solder droplets,
etc.) do not remain inside the set.
e
* INFORMATIONS
SAFETY CHECK AFTER SERVICING
After servicing, make measurements of leakage-current
or resistance in order to determine that exposed parts
are acceptably insulated from the supply circuit.
The leakage-current measurement should be done be-
tween accessible metal parts (such as chassis, ground
terminal, microphone jacks, signal input/output connectors,
elc.) and the earth ground through a resistor of 1500
ohms paralleled with a 0.15 pF capacitor, under the unit's
normal working conditions. The leakage-current should
be less than 0.5 mA rms AC.
The resistance measurement should be done between
accessible exposed metal parts and power cord plug
prongs. with the power switch (if included) "ON". The
resistance should be more than 2.2 M ohms.
SYMBOLS FOR PRIMARY DESTINATION
Unit destinations are indicated with letters as shown below.
Symbols
Principal Destinations
U.S.A
U.K
Canada
Europe (except U.K)
Japan
Australia
Germany
Universal Area
Custom version
SERVICE MANUAL

* SPECIFICATIONS
—
Sound generator Stereo output... 1/4 inch Stereo phone jack x 2;
Sampling tate usos 44.1 kHz (20 Hz to-20 kHz) unbalanced
Sampling capacity.......... 2 MB standard (expandable to Output level ..... «11: 0Bu/100 ohms level
32 MB) (21.9 secand/monaural Maximum - Wire
or 10:9 second/stereo) E output level 2... +17 dBu/i60 ohms
Data format... nn. 16 bit linear | Assignable mix out hi
Dynamic filtering ............‘12 dB/oct-dytramic resonant {option} ....... 1/4 inch stereo phone jack x 8,
i low pass filter par voice unbalanced l
Maximum sounds in i Output level... «+17 dBu/100 ohms
memory .... 128 i Maximum
| Number of sound I output level........ +17 dBu/100 ohms
program... 24 Headphone output ......... 14 inch stereo phone jack x 1,
Sound assignments Output level .. .200 mW/32 ohms
per program. 64 MIDI inputs... . 8 pin-DIN x 2 (mergeable) |
| Simultanéous volces......32: ej "MIDI outputs . . 8 pir-DIN x 2 (independent)
SCSI port ...... «o 1 (25-pin D-sub connector)
Sequencer : I
Maximum notes.............. 100,000 General
Resolution ..... . 96 parts per 1/4-note (ppq) Display ....... wns 248 x 64 dots graphic LCD
Sequence sss 99 Disk drive ^ 3,5 inch 2HD/2DD
| Tracks per sequence ..... 64 Expantion
| MIDI output channels .... 32 (16 channels x 2 output memory slots ........ 2 (72 pin SIMM, 70 ns}
ports) Dimensions LL 405 (W) x 126 (H) x 328 (D) mm
Song mode esses 20 songs, 250 steps per song Weight .................. . 6.3 kg
Drum pads .... .. 16 (with velocity & pressure Power requirements... AC 100 V, 50/60 Hz for Japan
sensitive) AC 120 V, 60 Hz for U.S.A and
Drum pad banks............. 4 Canada
Sync moda...................... MIDI clock with S.P.P., MTC, AC 220-240 V, 50 Hz for Europe
MMC, SMPTE (option). Power consumption ....... 23 W
SMPTE frame rates supported 13 W (without optional board)
are 24, 25, 30 and 30 drops
(29.97) Optional boards
| EB16 nennen, Multi effect processor board
| Rear panel IN/OUT FMX008M . 8 MB flash ROM board
Record input ................... 1⁄4 inch stereo phone jack x 2, IB-M208P. . 8 PARA out & digital /O board
balanced IB-M20T SMPTE board
Sensitivity ................... —40 dBu/39 kohms (REC VR
max.) Standard accessories
Maximum input level... 410 dBu Power cable
Digital sampling input .... RCA-pin jack x1, S/PDIF Floppy disk ................. 1 (OS disk)
| (option) 3 (Sound library disk)
Digital master output ..... ACA-pin jack x1, S/PDIF Operator's manual
(option)
0 dBu=0,775 VRMS
* For improvement purposes, specifications and design are subject to change without notice.
This document was cleaned, restored and made available as free download by synfo.nl

I. DISASSEMBLY
In case of trouble, etc., necessitating dismantling, please dismantle in the order shown in the illustrations.
Heassemble in the reverse order.
1, Remove the 4 screws on both the left and right sides | 3. Remove the 3 screws which secure the UPPER PANEL.
and 3 screws on the back. Next, extract the NOTE VARIATION knob and remove
the UPPER PANEL.
KNOB
2. Remove the 3 screws on the bottom. 4. Remove the 4 screws on both the left and right sides
Remove the FRONT PANEL by pulling it in the forward and 2 screws on the sub chassis.
direction.
Disconnect the P2 connector on the CPU PCB then
remove the sub chassis with the OPERATION PCB and
PAD block attached.

IL. PRINCIPAL PARTS LOCATION
JOG PCB PANEL PCB PAD SENSOR BLOCK
Fig. 2-1 Upper view (1)
VAR PCB LCD-JPCB AD/DAPCB IB-M20T POWER PCB
(OPTIONAL)
FLOPPY DISK IB-M208P CPU PCB PULSE POWER
DRIVE (OPTIONAL) PACK
Fig. 2-2 Upper view (2)
SERVICE MANUAL

HI, SUFPLOMENIAMT INrUNMALIUN
TEST MODE
& This test mode is used for the inspection of the unit. To
check the unit, proceed as follows.
Engeging the test mode.
1) Turn the power on and insert the OS disk according to
the LCD indication, After the system is bootup, press
the “MIXER (7)" button while pressing the “SHIFT”
button.
2) Press the "OPEN WINDOW" button.
3) Press the "0" button while pressing the "SHIFT" button.
The “flash file memory test" screen appears when the
test mode is engaged. f i
4) To disengage the test mode, press the "MAIN SCREEN"
button or turn the power of the unit off.
NOTE: Only the [WAVE MEMORY TEST] and (FLASH
FILE MEMORY TEST] modes can be proceed
sequently.
Once you engage the [PAD TEST] [REC OUT (8
PARA)] or [SMPTE TEST] mode in ihe test mode,
it is not possible to go to the other test mode
directly. In this case, press the "MAIN SCREEN"
button and re-engage the test mode again to go
to the other test modes.
% The test mode may be different according to the
version of the software.
3-1. Wave memory test
1) Engage the test mode and press the "F1" button, The
following messages will be displayed .
NOTE: All wave memory (DRAM) will be lost when the
F1" button is pressed.
WAVE MEMORY TEST
1 Mword recognized.
MENE 220 Å FLASH Ü orans fl SUPIE CGO
F1 F2 F3 Fa FS Fe
2) Press the "F6" (GO) button. The following messages
will be displayed after the display stops incrementing.
WAVE MEMORY TEST:
1 Mword recognized.
Testing Memory... okay
MEM I MEEZEJJ fl supre ( CO 7]
Fa F2 FS Fa FS Fe
This means the function of the unit is operating properly.
3-2. Pad test
1) Engage the test mode and press the 'F2' button. The
following messages will be displayed ,
{PAD TESTI
PAD :1 SLIDER : 87
Ë Veiocty After touch [TD]
ci o 8
Fi EZ Fa Fá Fa F&
- SERVICE MANUAL
2) Press any of the 16 pad buttons. The pad number that
you pressed will be shown in the display as well as the
velocity and after touch conditions are displayed
momentarily.
3-3. Flash file memory test
1) Engage the test mode and press the "F3" button. The
following messages will be displayed .
|
O M:0000 D:0000
1 M:0000 D:0000
2 M:0000 D:0000
3 M:0000 D:0000
EREU MG coc. MERE LOSE] 50 7]
F1 F2 F3 FA F5 F6
2) Press the "F6" (GO) button. The following messages
will be displayed if the flash memory is not installed,
FLASH FILE MEMORY TEST
00
F1 F2 F3 Fa FS FB
NOTE: All flash file memory (F-ROM) will be lost when
this memory test is performed.
3-4. REC out (SPARA)
1) Engage the test mode and press the "F4" button. The
following messages will be displayed.
REC OUT (8 PARA)
out ta individual : Esta
EES Pao BENI spana sverte fi onte |
FI F2 Fa Fa F5 F6
2) ifthe IB-M208P (optional BPARA/ DIO PCB) is connected,
" out to individual:” turns on when the "DATA" knob is
turned.
3-5. SMPTE test
1) Engage the test mode and press the "F1" button then
press the "F5" button, The following messages will be
displayed.
2) Press the "F5" (START) button if the IB-M20T (optional
SMPTE PCB) is connected. TX starts incrementing and
count up the time until the F6 (STOP) button is pressed.

IV. PARTS LIST
HOW TO USE THIS PARTS LIST
1. This Parts List lists those parts which are considered necessary tor repairs. Other common parts, such as resistors and
capacitors, are listed in the "Common List for Service Parts" from which these parts should be selected and stocked,
2. The Recommended Spare Pang List shows those parts in the Parts List which are considered particularly important for
service,
3. Parts not shown in the Parts List and "Common List for Service Parts" will not in principle be supplied.
4. How to read the Parts List.
a) Mechanism Block b) PC Board
2.HEAD BASE BLOCK 2.MAIN PC BOARD
Ref. No. Part. No. Description Ref. No. Part, No. Description
1 BH-T2023A320A HEAD BASE BLOCK IG1 El-324536 IC HD14049BP
2 HP-H2206A010A HEAD A/P PR4-8FU C IC2 El-336801 IC MB8841-564M
3 ZS-477876 PAN20x03STL CMT CIA EC-338399 C MMY V 223M 250AC [U,E,B,5]
4 Z5-536488 BID20x08STL CMT c18 EC-350949 C MMY V 223M 2500C [J]
5 -402895 SP CS ANGLE ADJUST cic EC-338397 C MMY V 223M 125AC [C,A
Xi El-318384 OSC X' TAL NC-18C
Symbols for primary destination
[A] : AAL (U.S.A) [S]: SAA (Australia)
[B]: BEAB (England)[U] : U/T (Universal Area)
[C]: CSA (Canada)
[E]: CEE (Europe) [V]: VDE (Germany)
[4] : JPN (Japan) [Y]: Custom
SP (Service Parts) Classification
This number corresponds with the indi-
vidual parts index number in the figure,
SP (Service Parts) Classification
These reference symbols correspond with
component symbols in the Schematic
Diagrams.
The available PC Board Blocks are listed separately.
5. When Part No. is known, Parts Index at end of Parts List can be used to locate where that part is shown in Parts List
by its Reference No. listed at right of Part No.
PARTS LIST

1. RECOMMENDED SPARE PARTS
We suggest you ta stock the following Recommended Spare
Part. items listed below. since they can cover most of the
routine service,
Ref. Ha, Part Ha,
1 BB-8104981
2 ED-3885354
3 ED-B10293J
4 ED-428162N
$ ED-289824J
LA ED-344290
* ED-412105N
2 A, EF-346090
9 A EF-376821
18 4 EF-373142
1 A EF-373143
12 El-810412J
13 Et-429988.J
14 Eil-410414.1
15 El-4328154
16 E1-810980J
7 £i-430936J
18 E1-396536J
19 El-436943J
20 El-387934J
2 El-384882)
22 EF-386289J
23 El-390695J
24 ELB10386J
25 EL3887074
26 El-810982)
27 El-BĦOZGRJ
28 El-401217J
29 fil-B103B3J
30 El-288567J
3 El-810269J
32 Er-393696J
33 EL-810385J
34 El-810153J
35 £i-430810J
36 El-419120J
37 El-810047J
38 El-401218J
58 E1-810328J
40 El-810646.J
4 El-430680J
42 El-430681J
43 El-353227
44 £1-393325N
45 El-348785
46 E1-980043
47 El-377047
48 El-362887J1
49 Et.377191
50 El-810613J
&1 El-810379J
52 Ele ages
93 £1-430873J
$4 El-412279J1
55 El-410389J
56 £EL376741J1
87 El-381299J1
58 El-877101
sa El-430684.
60 EL396531J
6t E1-405572J
62 El-379997J
63 Fl-354123
64 El-414959J
65 El-374176
66 £1-306541J
67 Es-357159
58 EJ-354105
a EJ 8107054
=
Description
FDD FD-236HF-7548
OLED GL-2HD43
D LED GL-3KG8
DSCHOTTKY 1S30-E T26
D SILICON DS1356-FB2 FIZ 1901
D SILICON H GHA.01.FY2 FOR
D ZENER H HZS581 136
FUSE ICP-F18 50V 0.6A.
FUSE ICP-N15 59V 0,6A
FUSE ICP-N25 SOV 1.04
FUSE ICP-N38 SOV 1.5A
ICAK5340-VS
IC AVO173-01-CN8
T
IC CS8402A-CP.
IĊ E28F016SA-100
IG HO74ACOGFP
IC HD74ACOAFP.
16 HD7SAC128P
ICHD74AC74FP
IC HD?74HC04P
IC HD74HC122AP
IC HD74HC138P
IC HD74HQ154P
IC HO74HC174FP
IG HD74HC244P.
IC HD74HC259FP
IG HD74HC273FP
IC HD74HC32FP
IC HOTAHCAOGQFP
IG HD74HCS73P
IC HO74HCSOSFP.
IC HD74HC86P
IG HMS118160ALTT-7
1C HMS14260CLTT.7
iC ICS2008V
IG L7A1045 16028 DSP-A
1C MB89352A.PFQ OF TY
IC MB89371A-PF-G-BND OF
IC MC74AC257M
1G MG74HCU04AN
IC M51957AL
IG M51958AL
IG M5216L
IC MSZ1BAP
IG M5220L
1C MS220P
IG MS223FP
IÇ M5298AL.
IÇ NJMS5320-D
IC PALCE16V480-15PG L40130
IÇ PALCE20V8Q-15PC L4013A
IÇ PALCE20V8Q-15PC L4013B
IC PALCE204BO-15PC L6039A
10 PCMESAP-4
IG PQ30RV:
IC TC7AHC244AF
IC TC74HC2A5AF
IG UPC7BOSHF.
IC UPD70236AGD-16-588
IC UPD72068GF-389
IC UPD78C10AGO-36
IC YM36238
OSC CE CSA120MTZ 12.000000MHZ
OSC X'TALAT-51 11.289600MHZ.
OSC X'TALAT-51 16.2344MHZ
OSG X'TALHC-49/U 32.000000MHZ
PHONE J 2P HLJOS20-110 W/NUT.
PHONE J 2P HLJ0520-110 6.2
PHONE J 2P HLJ0544-010W/N.W6 3
PARTS LIST
Ref. Ho. Part Ne, Description
70 £4-8107064 PHONE J SP HLIOSA4-T1OWIN WGS
rt EJ.810624J PHONE JIP HT.-064110 GI
72 £O-345990N GOIL FIX t ELOBGGERA TOS 470,
78 £O-4140524 TRANS PULSE CiTo7osD-35101
74 EG-348928 RELAY SIG GSA-237P STR 12V
75 ES-4069377J SW ROTARY ENCODER SRGPHJ
76 ES-411687N SW TACT EVO PAE 05%
Ev-2104161 VA ROTARY RK0871220 L25 B103X2
EV-8104174 VR ROTARY RK0971220 L25 C508X2
EV-810833J VA SLIDE RS45112 L15 B103XZ
77 ES-4150154 SWTAGT SKQEAD
78 ET-430926J DETECTOR PC400
79 ET-366753M TROTA114ES TOS
go ET-386838N TA DTCIZIES ToS
kal ET-349693 TA 2541348 FOS
a ET-370013 TA 2548740,
83
BA
85
2. P.C. BOARD BLOCK
Ref. No, Part No. Description
1 BA-Lao13A020 PC CPU BLK
2 BA-L4013A030 PC} MULTI BLK
3 BA-L4013A040 — PC) ADA BLK
PC (4) ADA BLK CONSISTS OF FOLLOWING P.C, BOARDS.
* ADA P.C. BOARD
* VR P.C. BOARD
* LCD-J RC, BOARD
PC (fi) MULTI BLK CONSISTS OF FOLLOWING P.C.
BOARDS.
* PANEL P.C. BOARD
* JOG P.C. BOARD
* POWER P.C. BOARD
3. CPU P.C. BOARD
Ref. No. Part No. Description
DI ED-344280 D SILICON H GMA-M-FY2 FOS
D2 ED-428162N D SCHOTTKY 1S30-E T26
D3 ED-344280 D SILICON H GMA-01-FY2 Fos.
D4 ED-389834J D SILICON DS13SE-FBZ F12 100/1
FLt EH-410420J FILTER EMI DSS906-998101MT05
FL2 £H-410420J FILTER EMI D$5306-93B101MTOS
FL3 EH-410420J FILTER EMI D88306-838 101 M TOS
FLA EH-410420J FILTER EMI DSS306-93B101MTOS
FLS £H-410420J FILTER EMI 0$$306-938101 M TOS
fie EH-410420) FILTER EMI DS5906-998101MT05
FL7 EH-410420J FILTER EMI DSS306-938101MT08
FLB EH-4104204 FILTER EMI DSS306-938101MT05
Fin EH-410420. FILTER EMI 0$$306-93B101M TOS
FL12 EH-413150J FILTER EMI BLOSANZ-AGZTA TOS
FL13 EH-413150J FILTER EMi BLOSANZ-REZTA Tos
FL14 EH-413150J FILTER EMI BLOGAN2-RG2T4 TOS
FLIS EH-410420J FILTER EMI DS5306-938101MT05
FLIG EH-364254 FERRITE BEAD BLó2RN2-R62
FLI7 EH-413150J FILTER EMI BLOSRN2-Re2TA Tos
flig EH-413150J FILTER EMI BLoaRN2-R62T4 TOS
FLIS EH-4131504 FILTER EMI BLOGANZ-RSZTå TOS
FL20 EH-413150J FILTER EMI BLOSANZ-REZTA TAS
FL21 EH-413150J FILTER EMI BLOSARNZ.ASSTATOS
FL22 EH-413150J FILTER EMI BLOSANZ-REZTA TOS
FL23 EH-413150J FILTER EMI BLOSRNZ-R6ZTA TOS
FL24 EH-4131504 FILTER EMI BLOSANZ-REZTA TOS
FL25 EĦ-413150J FILTER EMI BLOSRN2-Re214 Tos
FL25 EH-4131504 FILTER EMI BLOBRN2-Re2T4 195
FL26 EH-A4131504 FILTER EMI BLOGANZ-REZTA Tos
FL27 £H-418150J FILTER EMI BL0O3RN2-R62T4 TOS
FL28 EH-413150J FILTER EMI BLOSRNZ2-R62T4 105

Ref. No.
FL29
FLIO
FS
181
182
183
ia
188
[M
[074
163
ICa
(GS
166
107
ics
ica
icto
Ion
1C12-A
ic12-B
1313
C14
C15
IC16
KAT
IG18
C19
1020
1021
1622
C23
1024
1025
1026
IG27
1028
1029
IG30
ICI
1032
1033
1034
1035
Jt
J2
Ja
J4
J3
J6
47
PHI
PH2
Pe
Pa
PS
P6
P?
Wiġi
x1
X2
4. ADA P.C. BOARD
Ref. No.
Os
DE
Fls
FLS
FL
FAI
FRE
FRA
Part Mo,
EH-413150J
EH-413150J
A EF-373142
EH-357538
EH-384817J
EH-408860J
£H-408860J
EH-810378)
El-430684J
El-430680J
El-38120041
El-810379J
El-810328J
El-810328J
EI-8103804
El-401217J
El-810154J
E1-8101535
El-393695J
EI-B10381.1
El-397343J
Bil-401213J
El-401217J
51.810982.
Et-4309434
Eil-896531J
El-810047J
El.410389J
El-413120J
El-429988J
El-37674141
EIH-810383J
El-430673J
El-810613J
El-810268.J
El-810269.J
El-8102694
£1-430943J
El-810384J
£r-810385J
El-377047
€t-810382J
El-810386J
El-430936J
£J-430956J
EJ-428182)
EJ-430956J
EJ-430687 J
Ej-424423)
£J-424423.]
EJ-810388J
ET-430926J
ET.430926J
EJ-B10389J
£J-430689J
EJ-420027J
£,4-4299274
EJ-429929J
EW-810390J
£1-396541J
El-414959J
Part No,
ED-344280
ED-380834.J
EH-410420J
EH-410420J
EH-4104204
ER-200746
ER-200748
ER-403339%
Description
FILTER EMI BLO3AN2-As2Ta Tos
FILTER EMI BLOSRN2-R62T4 Tos
FUSE ICP-N25 50V 1.0A
COMP R RKCT/8BS 1004
COMP R RKC1/888 102J
COMP R AKC1889 114
COMP R RKCT/8B9 111J
COMP R RGSD10L503G 503G
IC UPD70236AGD-16-58B
IC M51957AL
IC TC74HC245AF
IG PALCE20VBO-15PC L4013A
IC MC74AC257M
IC MC74AC257M
IC HD74ACOOFP
IG HD74HC32FP
IC HM5S14260CLTT-7
IC HM514260CLTT-7
IC HD74HC154P
ICAM27C256-150DC MPC2000V 1,00
[PROGRAM ROM]
iC AM27C256a1 500C
[BLANK ROM]
IC MB89371A-PF-G-BND OF
JC HD74HC32FP
IG HD74HC259FP
IC HD74AC74FP
IG UPD72068GF-389
IC MB89352A-PFO OFTY
IC POSORV1
IC L7A1045 L6028 DSP-A
1C AV9173-01-CN8B
T
IC TC74HC244AF
C HD74HC4060FP
IG PALCE20V8Q-15PC L6039A
IC PALCE16V8Q-15PC L40130
IC HD74HC273FP
C HD74HC595FP
C HD74HC595FP
IG HD74AC74FP.
IC PALCE20V80-15PC L4013B
IC HMS1TI8160ALTT-7
IG MS223FP
C HD74HC259FP
IG HD74HC174FP
IC HD74AC04FP
DIN J YKF51-S058 2X5P
SOCKET DBLC-J25SAF-20L9 25P
DIN J YKF51-5058 2X5P
SOCKET 128A-04452A-S14N 44P
SOCKET 6-176438-7 72P
SOCKET 6-176438-7 72P
SOCKET 2250-10018E2-2314 18P
DETECTOR PC400
DETECTOR PC400
PLUG RA-H201TD-1190 20P
PLUG 128A-060P3C-S14N GOP
PLUG 302-20G58 20P
PLUG 302-20G$B 20P
PLUG 302-34GSB 34P
WIRE ASSY L4013 W1O1 — 34P
OSC X TAL HC-49/U 32 000000MHZ
OSC X'TALAT-51 11.289600MH7Z
Description
B SILICON H GMA-91-FY2 Fos
D SILICON DS135E-FB2 F12 100/1
FILTER EMI DSS306-938101MT05
FILTER EMI DSS306-99B1D1MT05
FILTER EMI DSS306-938101MT05
R FUSE H ERD2FC 1/4W 10006
R FUSE H ERD2FCG 1/4W 10006
R FUSE V Tas EHOZFCV tv/aWioRoG
Ref. No. Part No, Description
FSi Å EF-246880 FUSE ICP-F15 SOV 0.64
FS2 A EF-346880 FUSE ICP-F15 50V 0.64
ici EL377191 IC NJMS532D-D
ic2 Bl-377191 IG NJM55320-D
ica €1-360043 1C MS220P
164 El-360043 IG M5220P
ics Fl-810412J ICAKS340-V5
106 El-377101 IC UPC7E0SHE
IC8 El-412279J1 IC PCM69AP-4
ica El-377101 IC UPC7BOSHF
IC10 El-360043 iG MS220P
Cn Et-360943 iC M5220P
1612 El-893325SN IC MS218AP
1013 Ei-393325N IG M5218AP
1014 E1-359227 IC M52161
1015 El-430681J IC M5195BAL
4201 EJ-B10624J PHONE J 3P HTJ-064110 6,3
3202 EJ-810624.4 PHONE J 3P HTJ-06411D 6,3
4203 EJ-354105 PHONE J 2P HLJ0520-110 6.3
J204 £J-354105 PHONE J 2P HLJ0520.110 6,3
4205 EJ-810624J PHONE J3P HTJ-064110 6.3
LI EO-345990N COIL FIX 1 ELOGOGRA TOS 4704
ALI EQ-348929 RELAY SIG G5A-237P 2TR 12V
R67 ER-430691N ROMF H S12 FS ASSI 1W 1014
Rea ER-4366MN ROME H 512 FS RSSt 1W 1015
TRI ET-366753N TROTA114ES Tos
W203 EW-810415J WIRE ASSY L4013 W203 20P
5. VR P.C. BOARD
Ret. No. Part No, Description
VR201 EV-810416) VR ROTARY RK0971220 1.25 B103X2
vR202 EV-810417J VR ROTARY RK0971220 L25 CS00X2
6. LCD-J P.C. BOARD
Raf, No. Part No. Description
P3 EJ-810418J SOCKET SLD19S-1 19P
W204 EW-B10419J WIRE ASSY L4013 W204 20P
7. PANEL P.C. BOARD
Ret. No. Part No. Description
DI ED-810393J D LED GL-3KG8
p2 E0-388539J D LED GL-3HD43
03 ED-388539J D LED GL-3HD43
G4 ED-810393J D LED GL-3KGB.
DS E0-388539J D LED GL-3HD43
06 E0-810393J O LED GL-3KG8
07 ED-810393J D LED GL-3KG8
08 £0-810393J D LED GL-3KG8
Da £0-810393J D LED GL-3KGB
Dia ED-810393J D LED GL-3KG8
Dit ED-810393J OLED GL-3KGB
mz ED-344280 D SILICON H GMA-01-FY2 Fos
012 ED-344280 D SILICON H GMA-D1-FY2 Fos
Dt4 ED-344280 D SILICON H GMA-01-FV2 Fos
Dis ED-344280 D SILIGON H GMA-01-FY2 Fos
ow ED-344280 D SILICON H GMA-01-FY2 Fos
DI ED-344280 Ü SILICON H GMA-01-FY2 Fos.
DI8 ED-412105N D ZENER H HZSSB1 T26
n ED-344280 D SILICON H GMA-01-FY2 Fos
D2o ED-412105N D ZENER H HZSSB1 T26
021 ED-344280 D SILICON H GMA@01-FYZ Fos
D22 ED-412105N D ZENER H HZS5B1 T26
D23 ED-344280 D SILICON H GMA-01-FY2 Fos
D24 ED-412105N D ZENER H HZS5B1 T26
025 ED-344280 D SILICON H GMA-OT-FY2 F05
026 ED-344280 D SILICON H GMA-01-FY2 Fos
D27 ED-344280 D SILICON H GMA-01-FY2 Fos

Ret, No. Part No.
028 ED-344280
D29 ED-344280
Dag ED-344280
Dar E0-344280
Daz ED-244280
033 ED-344280
D34 ED-344280
pas ED-344280
D36 ED-344280
Dar ED-344280
bas ED-344280
039 ED-344280
Dan ED-344280
Dai ED-344280
tit EH-349374
182 EH-349374
G1 El-405572J
IC2 EL-3862808J
104 £H288567J
IC4A El-8106304
104-8 El-497343J
165 E1-387994J
196 £I-362587J1
IC? El-362587J4
P305 EJ-370603
Swi ES-411687N
SW2 £S-411687N
SW3 ES-411687N
SW4 ES-411687N
SW5 ES-411687N
Swe ES-411687N
Sw? ES-411687N
SVA ES-411687N
sa ES-411687N
Sw ES-411687N
Swi ES-4116B7N
SW12 ES-411687N
SW13 ES-411687N
SW14 ES-411687N
Swi5 ES-A11687N
SWt6 ES-411687N
SWAT ES-411687N
swig ES-411687N
59 ES-411687N
SW20 ES411687N
swes ES-411687N
Sw22 €E8-435015J
Swea ES-411687N
SWz4 ES-411687N
SW25 ES-411687N
SW26 ES.411687N
SW27 ES-411687N
SW28 ES-415015J
sw ES-415015J
SW30 ES.415015J
Swat ES-415018J
SW32 ES-411687N
SW33 ES-411687N
EWI ES-411687N
SW35 ES-411687N
SW36 ES-411687N
5W37 ES-411687N
SW38 ES-411687N
Swag ES-411687H
Swan ES-411687N
Wat ES-415015J
VAT EV-810633J
waga EW-810386)
Xi E1-354123
8. JOG P.C. BOARD
Rat. No. Part No.
Sw302 ES-403377J
in
Description
D SILICON H GMA-01-FY2 Fas
D SILICON H GMA-oT.FY2 Fas
D SILICON H GMA-01-FY2 Fos
D SILICON H GMA-01-FY2 Fos
D SILICON H GMA-01-FYZ Fas,
D SILICON H GMA-01-FYZ Fos
D SILICON H GMA-01-FYZ F05
D SILICON H GMA-01-F¥2 Fos.
D SILICON H GMA-01-FY2 Fos.
D SILICON H GMA-01-FY2 Fos
D SILICON H GMA-01-FY2 Fas
D SILICON H GMA-01-FY2 Fos
D SILICON H GMA-DI-FV2 F05
D SILICON H GMA-01-FY2 F05
COMP R RKC1⁄8B8 472J
COMP R RKCT/BBB 472J
IC UPD78C10AGQ-36
IC HD74HC138P
IC HD74HC873P.
ICAM27C256 MPC2000 V 1.0-OP
[PROGRAM ROM]
1CAM27C256-150DC
{BLANK ROM]
IC HD74HC04P
iC MS238AL
IC MS23BAL
PLUG 20FR-ST
SW TACT EVO PAE 05R
SW TACT EVO PAE 0sR
SW TACT EVO PAE 05A
SW TACT EVO PAE 05R
SW TACT EVO PAE 05A
SW TACT EVO PAE OSR
SW TACT EVO PAE 05A
SW TACT EVQ PAE 05R
5W TACT EVO PAE 05R
SW TACT EVO PAE 05R
SW TACT EVO PAE 05%
SW TACT EVQ PAE 058
SW TACT EVQ PAE 058
SW TACT EVO PAE OSR
SW TACT EVO PAE 05R
SW TACT EVQ PAE 05R
SW TACT EVO PAE 05A
SW TACT EVO PAE 05R
SW TACT EVO PAE 05R
SW TACT EVO PAE osR
SW TACT EVO PAE 05A
SW TACT SKQEAD
SW TACT EVO PAE 05R
SW TACT EVO PAE 05R
SW TACT EVQ PAE 05R
SW TACT EVQ PAE 058
SW TACT EVO PAE 05R
SW TACT SKQEAD
SW TACT SKOEAD
SW TAGT SKQEAD
SW TACT SKOEAD
SW TACT EVO PAE 05R
SW TACT EVO PAE 0sR
SW TACT EVO PAE 05R
SW TACT EVO PAE 058
SW TACT EVO PAE 05A
SW TACT EVO PAE 05A
SW TACT EVO PAE 05R
SW TACT EVO PAE 05R
SW TACT EVO PAE 05A
SW TACT SKOEAD
VA SLIDE AS45112 L15 B103X2
WIRE ASSY 14013 W304 — 20P
OSC CE CSA120MT2 12.000000MHZ
Description
SW ROTARY ENCODER SRGPHJ
PARTS LIST
8. POWER P.C. BOARD
Ret, No. Part No. Description
£301 AEC-427562J
€302 & EC-4256064
C307 A EC-A27562J
fi301 4 EO-3891724
SW3o1 4 ES-A30685J1
C MMY V CUT MEP 3362 103M 275AC
C MMY V CUT MMBC 883M 275AC
C MMY V CUT MKP3362 103M 275A0
COIL LF LF-4N 502
SW PUSH SODFIA 02-1
10. FINAL ASSEMBLY BLOCK
fist. Ho. Part No. Description
1 SA-B10544J FOOT
2 Z5.378405N BID3oX065 TL CMT {8G}
3 ZS-320906 ST BR30X06STL CMT
4 BB-810498J FOD FD-235HF-7549
5 29.322570 ST BIDAOXOBSTL NIZ
6 ZS-376875 BT CTS30X08STL BNI
7 ZW-413267 N FRANGE 40STL CMT
8 A BP-810446J SW REGULATOR SNP-9541
9 A EJ-358632J2 SOCKET INLET SOT-16 3P
10 25-428277J PANSOXOGSTL CMT POLY WAVE
u ZS-345272 ST BR30X06STL BNI
12 ZS-350934 PT BR30X08STL BNI
13 EM-810407J IND LCD GMV24160AF TW
14 ZW-8103474 SPACER LCD
15 ZS-810640J BT PAN17X05STL CMT PS3
16 BA-810408.J INVERSEUR 135BSA-CFL-INV
17 ZW-810346J PLASTIC SPACER
iB 25-4008784 ST BR30X15STL CMT
19 SB-810525J BUTTON POWER
20 BE-376331 PAD
21 BA-379695J1 PC PAD SENSOR
22 SB-429685J BUTTON PUSH(B)
[WHITE]
23 SB-810362J BUTTON PUSH(B)-2
[BLUE]
24 S8-430327J BUTTON PUSH B(2)
[RED]
25 SB-810358J BUTTON PUSH B(3)
[WHITE]
26 S$8-810360J BUTTON PUSH C-3
[WHITE]
27 SB-413601J1 BUTTON CURSOR
28 SE-810673J SPACER BUTTOMPUSHA,
?9 SE-810674J SPACER BUTTONPUSH B
30 SP-810424J PANEL TOR MPC2000
31 25-331182 BT BIDJOXOBSTL BNI
32 SK-810361J KNOB SLIDE (B)
33 SK-B103631 KNOG SHUTTLEKFI
34 SK-810264J KNOB JOGIF)
35 SK-411144J KNOB VOL PART(1)
[WHITE]
36 SK-411147J KNOB VOL PART(2)
[RED)
37 BO-810348J PANEL FRONT
38 ZS-348375 ST BFI30XOBSTL CMT
39 £S-322570 ST BID40X08STL NII
40 SE-810353J LENSLED
41-A A EW-380905J AC CORD 2505 KP300 KS16A H B J
HI
48 4 EW-368420J1 AC GCORD200SKPa0KS16 BAC
[A]
40 A EW-410608J AC CORD 2505 KP4B19D KS31A BE
IEN
41-0 A EW-419170J AG CORD200S KP610 KS31A B
(8)
42 A EJ-4084244 PLUG ADAPTOR KPR-25
Uu
NOTE :
Parts will not be supplied if they are not listed in the parts list,
even if they appear on the assembling illustrations with
reference No.