Alinco DJ-500E User manual

A UNCO
VHF/UHF FM HAND HELD TRANSCEIVER
DJ-500T/E
Service Manual
Index
•SPECIFICATIONS . ....................................
• PARTS LIST ....................... ......... ............... . .3—8
•CABINET PARTS LOCATION ..................... 9
•ADJUSTMENT ..................... ................... .10,11
• RF BOARD ADJUSTMENT POINTS ........ 11
• IF BOARD ADJUSTMENT POINTS ............... 1
•CPU BOARD ADJUSTMENT POINTS ...... 1
•BLOCK DIAGRAM ............................... . 13
•SCHEMATIC DIAGRAM OF RF UNIT ...... 14
• RF PC BOARDS ....................... .................... 15
•SW PC BOARDS . ........................................... 16
•VCO PC BOARDS ......... .............................. 16
•SCHEMATIC DIAGRAM OF TONE BURST
UNIT ................................................... . ......... 17
•TONE BURST PC BOARDS . ..................... 17
•SCHEMATIC DIAGRAM OF IF UNIT........ . 18
• IF PC BOARDS ............. ............... ................... 19
• SCHEMATIC DIAGRAM OF CPU UNIT .... 0
•CPU PC BOARDS ........................................ 1
•SCHEMATIC DIAGRAM OF TSQ UNIT .........
•TSQ PC BOARDS ........................................ . 3
C V f A LIN C a ELECTRONICS INC.

■ SPECIFICATIONS
GENERAL
Frequency coverage:
Emission type:
Antenna Impedance:
Operating voltage:
Operating Current:
(typical at 7. vdc)
Battery charging time:
Dimensions:
Weight:
RECEIVER
Type:
Sensitivity:
Spurious response
Rejection ratio:
Selectivity:
Squelch sensitivity:
Audio output:
TRANSMITTER
Output power:
Modulation:
Maximum deviation:
Harmonic suppression:
Microphone:
Operating modes:
DJ-500T
DJ-500E
15 mA Transmit LO 0.4/0.6A
50 mA Transmit HI 0.8/1. A
130 mA
144.0-148 .0 MHz
440-4 5 0 MHz
144.0-146.0 MHz
430-440 MHz
16F3 (FM)
50 ohms, unbalanced
5.5 to 1 vdc
Battery save
Squelched
Max. audio out
14 -1 6 hours
58 mm (L)x176m m (H)x30m m (W)
(2 5 /i6 '') X ( 6 15/ 16 " )X (1 1 /4" )
0.435 kgs. (0.958 lbs.)
Dual conversion;
1st IF 55.05 MHz; nd IF 455 kHz
Less than. 5 uV @ 1 dB SINAD
more than 60 dB
More than ±7.5 kHz at - 6 dB
Less than ± 15 kHz at - 6 0 dB
Less than -1 d B
more than 550 mW (10% THD), 8 ohms
See table
Variable reactance FM
± 5 kHz
- 6 0 dB
Built-in electret condenser
Simplex
Shifted + or -6 0 0 kHz or 5 MHz from receive
frequency (Odd offsets programmable)
RF POWER OUTPUT TABLE
Battery HI LO
EBP-6NAZ V/U: 4.5/4 W600 mW (Approx.)
EBP-7NAZ V/U: .5/ W450 mW( " )
EBP-8NAZ V/U: 6/5.5 W850 mW ( " )
EBP-9NA V/U: .5/ W450 mW ( " )

■ PARTS LIST
Ref.
No. Part Code Part Name and Number Ref.
Ño. Part Code Part Name and Number Ref. No. Part Code Part Name and Number
CPU Unit R57 RK0045 Chip R. MCR1047 J 0 06 XU0003 Transistor, DTC114TK
R59 RK0035 Chip R.MCR1010 J 0 09 XT0035 T ransistor, SC34 9
IC1 XA0067 IC. jiPD7514G RÔO RK0035 Chip R. MCR1010 J 0 10 XT0030 Transistor. SC3356
IC XA0059 IC. BA6993 R61 RK0107 Chp R. MCRIOOft 0 11 XU0016 Transistor. DTC143EK
IC3 XA004 IC.LR4O07 (DJ-500Eonly) 0 1 XT0030 Transistor. SC3356
R$ RK0107 Ch'p R. MCR10 Qn 0 13 XT0059 Transistor. SC308 KSQ
Q1 XT0036 Transistor, SA1037KR (DJ-500T only) 0 14 XT0059 Transistor, SC308 KSQ
0 XU0014 Transistor. DTC144EK R63 RK0107 Chip R, MCR10QQ Q 15 XT0048 Transistor, SC3357
Q3 XU0014 Transistor, DTC144EK (DJ-500E only) 0 16 XT0048 Transistor. SC3357
04 XU0001 Transistor. DTC143TK 0 17 XT0030 Transistor, SC3356
C1 CU800 Ch'p C., C 01 B1H103K 0 18 XT0035 Transistor, SC34 9
D1 XDOoao Diode, RB400D C CU800 Chip C., C 01 B1H103K 0 19 XT0038 Transistor, SA1037KR
0 XDooao Diode, RB400D C3 CUB00 Ch'p C., C 01 B1H103K Q 0 XT0037 Transistor, SC 41 KR
D3 XD0071 Diode. FMPI C4 CU800 Chip C., C 01 B1H10OK 0 1 XT0066 Transistor. SC 413AP
D4 XD0091 Diode, IMN10 C5 CU800 Chip C., C 01 B1H 103K 0 XT0059 Transistor, SC308 KSQ
D5 XD0091 Diode, IMN10 C6 CU8001 Chip C..C 01 B1H10 K Q 3 XT0038 Transistor, SA1037KR
D6 XD0041 Diode, DAP 0 K C1 CU8001 Chip C.. C 01 B1H10 K 0 4 XT0037 Transistor, SC 41 KR
D7 XD0041 Diode. DAP 0 K C13 CU8001 Chip C.. C 01 B1H10 K
D8 XD0040 Diode. DAN 0 K C14 CU00 3 Chip C.. C 01 CH1H330K D 01 XD0070 Oiode, 1SS 65
09 X00090 Diode. 0 CZ3.6X C15 CUB001 Ch'pC..C 01 B1H10 K D 0 XD0070 Diode. 1SS 65
C16 CS0060 Ch'p Tantal C.. TMC1E474TR D 03 XD0070 Diode. 1SS 65
R1 RK01 6 Chip R.. MCR10163J C17 CS0053 Chip Tantal C..TMC0J476TR D 04 XD0070 Diode. 1SS 65
R RK005 Chip R.,MCR10103J C18 CU8001 Chip C..C 01 B1H10 K 0 05 XD0070 Oiode, 1SS 65
R3 RK005 Chip R..MCR10103J C19 CU8001 Chip C.. C 01 B1H10 K D 06 XD0070 Diode, 1SS 65
R4 RK005 Chip R.. MCR10103J C 0 CU8001 Chip C., C 01 B1H10 K D 07 XD0070 Diode, 1SS 65
R5 RK005 Chip R.. MCR10103J C1 CUB001 Chip C.. C 01 B1H10 K D 08 XD0070 Diode. 1SS 65
R6 RK005 Chip R., MCR10103J C CU8001 Chip C., C 01 B1H10 K D 09 XD0070 Diode, 1SS 65
R7 RK0Û5 Chip R., MCR10103J C 3 CU8001 Chip C..C 01 B1H10 K D 10 XD0070 Diode. 1SS 65
R8 RK0073 Ch'p R., MCR10 4J C 4 CS0051 Chip Tantal C.. TMC1C106TR D 11 XD0070 Diode, 1SS 65
R9 RK0069 Chip R..MCR10104J C 5 CU800 Chip C., C 01 B1H103K D 1 XD0070 Diode. 1SS 65
R10 RK006 Chip R.. MCR10473J C30 CU8003 Ch'p C.. C 01 Y1E104 D 13 XD0070 Diode. 1SS 65
R11 RK0073 Chip R-. MCR10 4J C31 CUB001 Chip C., C 01 B1H10 K D 14 XD0070 Diode. 1SS 65
R1 RKÓ045 Chip R., MCR1047 J C3 CU8001 Chip C., C 01 B1H10 K D 15 XD0070 Diode. 1SS 65
R13 RK0073 Chip R.. MCR10 4J C33 CU8001 Chip C., C 01 B1B10 K 0 16 XD0097 Diode. 1SS 68
R14 RK004 Chp R.. MCR1033 J C34 CS0049 Chip Tantal C., TMC1C105TR D 17 XD0066 Diode, RLS135
R15 RK006 Chip R.. MCR10473J 0 18 XD0040 Diode. DAN Q K
R16 RK0035 Chip R., MCR1010 J S1 UU0009 Tact SW.. EVQ-QHJ-04G
R17 RK0035 Chip R., MCR1010 J S UU0009 Tact SW.. EVQ-QHJ-04G X 01 X000 Xtal, UM-1 1 .8 MHz
R1B RK0035 Chip R., MCR1010 J S3 UU0009 Tact SW.. EVQ-QHJ-04G X 0 X000 6 Xlal, UM-1 58.8888 MHz
R19 RK0035 Chip R., MCR1010 J S4 US0014 SlideSW.. ESD-10501
R 0 RK0035 Chip R., MCR1010 J VR 01 RH0036 VR, CVR-4 A-10 AW1D
R 1 RK0035 Chip R.. MCR1010 J LCD EL0004 LCD.CG176X-TNP VR 01 RH0036 VR.CVR-4 A-10 AW1D
R RK0035 Chip R., MCR1010 J VR 03 RH0037 VR.CVR-4 A-471 AW1D
R 3 RK0035 Chip R.. MCR1010 J MIC EY0003 E.C MIC. EM-6B VR 04 RH0037 VR, CVR-4 A-471AW1D
R 4 RK005 Chip R., MCR10103J
R 5 RK003S Chip R., MCR1010 J X1 XB0001 Ceramic Resonator. R 01 RK304 Chp R.. MCR03 . K
R 6 RK0036 Chip R.. MCR1010 J FAR-C4CA03580000-K01 R 0 RK30 9 Chip R..MCR03 180ß
R 7 RKÛ035 Chp R.. MCR1010 J R 03 RK30 6 Chip R.. MCR03 100Q
R 8 RK0035 Chip R., MCR1010 J BATT ED0003 Li-Batt. BR 3 5-IF3 R 04 RK3050 Chip R.. MCR03 10K
R 9 RK0035 Chp R., MCR1010 J R 05 RK30 6 Chip R.. MCR03 100n
R30 RK0035 Chp R.. MCR1010 J LAMP EP0005 Lamp. 3-BR-5V60 LAMP R 06 RK30 6 Ch'p R.. MCR03 100a
R31 RK005 Chp R., MCR10103J R 07 RK3038 Ch'p R., MCR03 1K
R3 RK005 Chip R.. MCR10103J VR1 RH0031 VR.CVR-4 A-103 R 08 RK3058 Chip R.. MCR03 47K
R33 RK0035 Chip R.. MCR1010 J R 10 RK3046 Chip R., MCR034.7K
R34 RK0Û35 Chip R..MCR1010 J R 11 RK30 6 Chip R.. MCR03 100fl
R35 RK0035 Chip R-. MCR1010 J R 1 RK3Û46 Chip R., MCR03 4.7K
R36 RK0035 Chp R., MCR1010 J R 13 RK3050 Chip R.. MCR03 10K
R37 RK01 7 Chip R.. MCR10164J R 14 RK304 Ch'p R., MCR03 . K
R38 RK005 Chp R., MCR10103J R 15 RK3050 Chp R., MCR03 10K
R39 RK006 Chip R., MCR10473J R 16 RK304 Ch'p R.. MCR03 . K
R40 RK0Û39 Chp R..MCR10 J R 17 RK306 Ch'p R.. MCR03 100K
R41 RK006 Chip R.. MCR10473J R 18 RK30 6 Ch'p R., MCR03 lOOfl
R4 RK005 Chip R.. MCR10103J R 19 RK3050 Chip R., MCR03 10K
R43 RKÛÛ6 Chp R.. MCR10473J RF Unit R 0 RK3050 Chip R.. MCR03 10K
R44 RK005 Chp R.. MCR10103J R 1 RK3050 Chip R-. MCR03 10K
R45 RK0001 Chip R., MCR10100J IC 01 XA0064 IC..MB1504 R RK3056 Chip R.. MCR03 33K
R46 RK0035 Chp R.. MCR1010 J IC 0 XA0064 IC..MB1504 R 3 RK303 Chip R.. MCR03 3300
R47 RK0059 Chip R.. MCR10333J IC 03 XA0044 IC.. M57796MA R 5 RK3034 Chp R., MCR03 470il
R48 RK0069 Chp R.. MCRI0104J IC 04 XA0069 IC.. M57797MA R B RK3050 Chip R., MCR03 10K
R49 RK005 Chip R..MCR10103J IC 05 XA0087 IC..TC4S0IFTE85 R 9 RK306 Chip R., MCR03 100K
R50 RK006 Chip R., MCR10473J R 30 RK3030 Chip R., MCR03 0Q
R51 RK0059 Chip R.. MCR10333J Q01 XE0015 FET.. SK3C Y R 31 RK3050 Chip R.. MCR03 10K
R5 RK0039 Chip R., MCR10 J Q 0 XE0015 FET.. SK30 Y R 3 RK3058 Ch'p R.. MCR03 47K
R53 RK005 Chip R.. MCR10103J 0 03 XU0014 Transistor. DTC144EK R 33 RK30 6 Chip R.. MCR03 lOOfl
R54 RK00 8 Chip R.. MCR10471J 0 04 XU0016 Transistor, DTC143EK R 34 RK304 Chip R.. MCR03 . K
355 RK0045 Chp R.. MCR1047 J Q 05 »(TOO 30 Transistor, SC3356 R 35 RK304 Chp R., MCR03 . K
-156 RK0045 Chip R., MCR1047 J 0 06 KT0035 Transistor. SC34 9 R 36 RK303Ö Chip R.. MCR03 0il
- 3 -

Ref.
No. Part Code Pari Name and Number Ref. No. PartCode Part Name and Number Reí.
No. PartCode Part Name and Number
R 37 RK305 Chip R., MCR03 15K R31 RK30 Chip R-, MCR03 47il C 50 CU000 ChipC., C 01 CH1H010C
R 3B RK3044 Chip R., MCR03 3.3K (DJ-500T only) C 51 CU3035 Chip C.. CM 105W5R10 K
R 39 RK3030 Chip R.. MCR03 0Q R313 RK30 8 Chip R.. MCR03 100fl C 5 CU0006 ChipC., C 01 CH1H050C
R 40 RK3038 Chip R.. MCR03 1K R314 RK3001 Chp R., MCR03 Oft C 53 CU0004 ChipC., C 01 CH1H030C
R 4 RK3056 Chip R., MCR03 33K C 54 CU3035 Chip C., CM 105W5R1Q K
R 43 RK3050 Chip R.. MCR03 10K FB3 QB0003 Ferrite Beads. OP- .5 -1. H C 55 CU3035 Chp C., CM 105W5R10 K
R 44 RK30 5 Chip R., MCR03 B ß FB4 QB0003 Ferrite Beads, OP- .5 -1, H C 56 CU3035 Chip C..CM105W5R10 K
R 45 RK01 8 Chip R., MCR10 5.6ft FB5 QB0003 Ferrhe Beads. OP- .5 -1. H C 57 CU0003 Chip C., C 01 CH1H0 0C
R 46 RD00 Lead R., R 0 0a C 59 CU0004 Chp C., C 01 CH1H030C
R 47 RK3034 Chip R., MCR03 470Q TC 01 CT0013 Trimmer C., ECR-GA003A30 C 60 CU0004 ChipC., C 01 CH1H030C
R 48 RK30 7 Chp R., MCR03 1 0Í1 TC 03 CT0003 Trimmer C.. ECR-GA006A30 C 61 CU3035 Chp C., CM 105W5R10 K
R 49 RK3038 Chip R., MCR03 1K TC 04 CT0013 Trimmer C., ECR-GA003A30 C 6 CU3035 Chip C., CM105W5R10 K
R 50 RK3048 Chip R., MCR03 6.8K TC 05 CT0013 Trimmer C., ECR-GA003A30 C 63 CU3035 ChipC., CM105W5R10 K
R 51 RK3046 Chip R., MCR034.7K TC 06 CT0013 Trimmer C.. ECR-GA003A30 C 64 CU0001 Chp C., C 01 CH1H0R5C
R 5 RK30 Chjp R..MCR034 ÎÎ TC 07 CT0013 Trimmer C„ ECR-GA003A30 C 65 CU0004 Chp C.. C 01 CH1H030C
R 53 RK304 Chp R.. MCR03 . K TC 08 CT0013 Trimmer C.. ECR-GA003A30 C 66 CU3035 Chip C., CM105W5R10 K
R 54 RK30 6 Chip R.. MCR03 100TJ TC 09 CT0003 Trimmer C., ECR-GA006A30 C 67 CU3035 Chip C., CM105W5R10 K
R 55 RK01 8 Chip R., MCR10 5.6X1 TC 10 CT0003 Trimmer C„ ECR-GA006A30 C 68 CU3035 Chip C., C M105W5R10 K
R 56 RK3034 Chip R., MCR0347QQ C 69 CU0001 Chip C..C 01 CH1H0R5C
R 57 RK3034 Chip R„ MCR03 470Í1 C 70 CU3035 ChpC., CM105W5R10 K
R 68 RK3038 Chip R., MCR03 1K C 71 CU0051 ChipC., C 01 CH1H471K
R 59 RK3038 Chip R., MCR03 1K C 7 CU0019 Chip C., C 01 CH1H 0J
R 60 RK3050 Chip R..MCR03 10K C 73 CC0104 Ceramic C.. 50 V CH3P
R 61 RK3046 Chip R., MCR034.7K C 01 CU0001 Chp C.. C 01 CH1H0R5C C 74 CU0007 Chp C., C 01 CH1H060D
R 6 RK3038 Chip R..MCR031K C 0 CU0008 Chip C„ C 01 CH1H070D C 75 CU0008 Chip C.. C 01 CH1H0700
R 63 RK30 6 Chip R., MCR03 1000 C 03 CU0017 Chjp C.. C 01 CH1H180J C 76 CU3035 Chip C., CM 105W5R10BK
R 64 RK30 6 Chip R.. MCR03 100Í1 C 04 CU3035 Chip C.. CM105W5R10 K C 78 CU00 3 Chip C..C 01 CH1H330J
R 65 RK3044 Chp R., MCR03 3.3K C 05 CU0007 ChipC., C 01 CH1H060D C 79 CU0015 ChpC., C 01 CH1H150J
R 66 RK306 Chip R.. MCR03 100K C 06 CU00 3 Chip C., C 01 CH1H330J C 80 CU3035 Chip C., CM105W5R10 K
R 67 RK3038 Chip R.. MCR03 1K C 07 CU0003 Chip C-. C 01 CH1H0 0C C 81 CU0015 ChpC., C 01 CH1H150J
R 68 RK3058 Chip R., MCR03 47K C 06 CU0015 Chip C..C 01 CH1H150J C 8 CU3035 Chip C., CM105W5R10 K
R 69 RK3038 Chip R.. MCR001K C 09 CU00 3 ChipC., C 01 CH1H330J C B3 CU3035 Chip C.. CM105W5R10 K
R 70 RK3036 Chip R..MCR031K C 10 CU0019 Chp C., C 01 CH1H 0J C 84 CE0033 Chemical C., MS510^/10 V
R 71 RK30 6 Chip R.. MCR03 100Q C 11 CU0011 ChipC., C 01 CH1H100D C 85 CU3035 ChipC., CM105W5R10 K
R 7 RK3050 Chp R..MCR03 10K C 1 CU30 3 Chjp C„ CM105CH101K C B6 CU3035 Chp C..CM105W5R10 K
R 73 RK304 Chip R., MCR03 Z K C 13 CU00 7 ChjpC.. C 01 CH1H470J C 87 CU0019 Chp C., C 01 CH1H 0J
R 74 RK304 Chp R., MCR03 . K C 14 CU0003 Chip C., C 01 CH1H0 0C C 88 CU0015 Chip C., C 01 CH1H150J
R 75 RK304 Chip R., MCR03 . K C 15 CU3035 ChipC., CM105W5R10 K C 89 CU3035 Chip C.. CM105W5R10 K
R 76 RK3030 Chip R„MCR03 0« C 16 CU3035 ChipC., CM105W5R10 K C 90 CU0011 ChipC., C 01 CH1H100D
R 77 RK306 ChipR., MCR03 100K C 17 CU0007 ChipC., C 01 CH1H060D C 91 CU0015 Chp C., C 01 CH1H150J
R 78 RK3050 Chip R.. MCR03 10K C 18 CU000 Chip C., C 01 CH1 H010C C 9 CE003 Chemical C., MS5 4.7^16 V
R 79 RK30S0 Chip R., MCR03 10K C 19 CU0003 ChipC.. C 01 CH1H0 0C C 93 CU3035 Chip C..CM105W5R1Q K
R 80 RK3050 Chip R..MCR03 10K C 1 CU30 3 Chip C..CM105CH101K C 94 CU3035 Chip C.. CM105W5R10 K
R B1 RK3038 Chip R.. MCR03 1K C CU3035 Chip C.. CM105W5R10 K C 95 CU0019 ChipC., C 01 CH1H 0J
R 8 RK304 Chip R.. MC R03 K C 3 CU3035 Chjp C..CM105W5R10 K C 96 CU0013 ChipC., C 01 CH1H1 0J
R 83 RK3050 Chip R..MCR03 10K C 4 CU3035 Chip C„ CM105W5R10 K (DJ-500T only)
R 84 RK3050 Chip R.. MCR03 10K C 5 CU3035 ChpC., CM105W5R1Q K C 96 CU0015 Chp C..C 01 CH1H150J
R 85 RK304 Chp R.. MCR03 Z2K C 6 CU3035 ChipC., CM 105W5R10 K (DJ-500Eonly)
R 86 RK304 Chip R., MCR03 . K C 7 CU000 Chip C., C 01 CH1H010C C 97 CU3035 Chip C., CM105W5R10 K
R 07 RK304 Chip R., MCR03 . K C B CU0007 ChpC., C 01 CH1H060D C 98 CU0006 Chip C.. C 01 CH1H050C
R 88 RK3038 Chip R., MCR031K (DJ-500T only) C 99 CE0033 Chemical C., M S510^/10 V
R 89 RK30 6 Chip R., MCR03 lOOfl C 8 CU0009 ChipC.. C 01 CH1H0B00 C300 CU3035 Chip C., CM105W5R1Q K
R 90 RK3044 Chip R., MCR03 3.3K (DJ-500E only) C301 CU3035 Chip C..CM105W5R10 K
R 91 RK306 Chip R.. MCR03 100K C 9 CU0003 Chip C.. C 01 CH1H0 0C C30 CU3035 Chip C., CM105W5R10 K
R 9 RK3050 Chip R.. MCR03 10K (DJ-500T only) C304 CU0003 Chip C..C 01 CH1H0 0C
R 93 RK306 Chip R.. MCR03 100K C 9 CU0005 ChipC.. C 01 CH1H040C (DJ-500T only)
R 94 RK3038 Chp R., MCR031K (OJ-500E only) C304 CU0005 ChipC., C 01 CH1H040C
R 95 RK30G6 Chip R., MCR03 0K C 30 CU0013 ChipC., C 01 CH1H1 0J (DJ-500E only)
R 96 RK3050 Chip R.. MCR03 10K C 30 CU0015 ChipC., C 01 CH1H150J C305 CU3035 Chip C..CM105W5R10 K
R 97 RK3050 Chip R.. MCR03 10K C 31 CU0019 ChipC., C 01 CH1H 0J C306 CU0017 Chip C..C 01 CH1H1B0J
R 9B RK3050 Chip R.. MCR03 10K C 3 CU00 7 ChipC., C 01 CH1H470J (DJ-500T only)
R 99 RK3038 Chip R.. MCR03 1K C 33 CU0011 Chip C„ C 01 CH1H100D C306 CU0019 ChipC., C 01 CH1H 0J
R300 RK305 Chp R., MCR03 15K C 34 CU3035 Chip C..CM105W5R10 K (DJ-500E only)
R301 RK3038 Chip R..MCR031K C 35 CU0006 ChipC., C 01 CH1H050D C307 CU0005 Chip C.. C 01 CH1H040C
R30 RK3050 Chp R., MCR03 10K C 36 CU0011 ChipC., C 01 CH1H100D (DJ-500T only)
R303 RK30 6 Chp R., MCR03 1000 C 37 CU00 7 Chip C., C 01 CH1H470J C307 CU0008 ChipC., C 01 CH1H070C
R304 RK30 Chip R.. MCR0347Í1 C 38 CU3035 Chp C..CM105W5R10 K (DJ-500E only)
R305 RK3058 Chp R..MCR03 47K C 39 CU3035 ChipC . CM 105W5R10 K C308 CU3035 Chip C..CM105W5R10 K
R306 RK3001 Chp R., MCR03 Oil C 40 CU3035 ChipC., CM105W5R10 K C309 CU3035 ChipC., CM105W5R10 K
R307 RK3001 Chip R„ MCR03 0ÍÍ C 41 CU3035 ChipC.. CM 105W5R10 K C310 CU3035 ChipC.. CM105W5R10 K
R306 RK3001 Chip R.. MCR03 Oß C 4 CU3035 ChpC.. CM105W5R10 K C311 CU3035 Chp C..CM105W5R10 K
R309 RK3001 Chip R.. MCR03 On C 43 CU0008 ChipC., C 01 CH1H070D C31 CU3035 Chp C., CM 105 W5R10 K
R310 RK304 Chip R., MCR03 . K C 44 CU0005 ChpC., C 01 CH1H040C C313 CU3035 Chip C., CM105W5R10 K
R311 RK3046 Chip R..MCR034.7K C 45 CU000 Chp C.. C 01 CH1H010C C314 CU3035 Chp C., CM 105W5R10 K
R31 RK30 6 ChipR., MCR03 100ft C 46 CU0006 Chp C.. C 01 CH1H050C C315 CU0008 Chip C., C 01 CH1H070D
(DJ-500E only) C 47
C 49 CU0011 CU00 7
ChipC., C 01 CH1H1000
Chip C„ C 01 CH1H470J
(DJ-500T only)
- 4 -

Ref.
No. PartCode Part Name and Number Rel.
No. Part Code Part Name and Number Ref.
No. PartCode Part Name and Number
C315 CU0005 Chip C..C 01 CH1H040D C400 CU3005 Chip C., CM 105CH040C50VAT R401 RK30 6 Chip R^ MCR03 1000
(DJ-500E only) R40 RK3036 Chp R„ MCR03 S80n
C316 CU3035 Chip C.. CM105W5R10 K L 01 QK0047 Air-core Coil, . x3.5T R403 RK3051 Chp R.. MCR03 1 K
C317 CU0011 Chip C., C 01 CH1H100D L 0 QK0048 Air-core Coil, . x4.5T R404 RK3046 Chip R., MCR03 4.7K
C31B CU3035 Chip C., CM105W5R1Q K L 03 QK0048 Air-oore Coil, . x4,5T R405 RK30 6 Chp R., MCR03 100«
C319 CU0019 Chip C., C 01 CH1H 0J L 04 QK0049 Air-core Coil, . x7T R406 RK3050 Chp R., MCR03 10K
C3 CU3035 Chip C.. CM105W5R10 K L 05 QK0046 Air-core Coil, . x . 5T R407 RK30 G Chp R., MCR03 100il
C3 3 CU3035 Chip C., CM105W5R10 K L 06 QK0047 Ak-ooreCoil, . x3.5T R408 RK304 Chp R., MCR03 . K
C3 4 CU3035 Chip C.. CM105W5R10 K L 07 QK0046 Air-core Coil, . x . 5T R409 RK30 Chp R.. MCR0347Q
C3 5 CU3035 Chip C., CM105W5R10 K L 08 QK0046 Air-core Coil, . x . 5T R410 RK3036 Chip R., MCR03 680il
C3 6 CU3035 Chip C.. CM105W5R10 K L 09 QK0046 Air-core Coil, . x . 5T R411 RK3051 Chip R., MCR03 1 K
C3 7 CU3035 Chip C.. CM 105W5R10 K L 10 QK004B Air-core Coil, . x4.5T R41 RK3046 Chip R.. MCR03 4.7K
C3 8 CU3035 Chip C., CM105W5R10 K L 11 QK0049 Air-oore Coil. . x7T R413 RK3050 Chip R., MCR03 10K
C3 9 CU3035 Chip C., CM105W5R10 K L 1 QK0049 Air-core Coil, . x7T R414 RK30 8 Chip R., MCR03 150fl
C330 CU3035 Chip C., CM105W5R10 K L 13 QK0046 Air-core Coil. . x . 5T R415 RK3048 Chip R., MCR03 6.8K
C331 CU3035 Chip C., CM105W5R10 K 1 14 QK0046 Air-core Coil. . x . 5T R416 RK3034 Chip R., MCR03 470Q
C33 CU3035 Chip C., CM105W5R10 K L 15 QK0046 Air-core Coil. . x . 5T R417 RK3058 Chip R.. MCR03 47K
C333 CU0011 Chip C.. C 01 CH1H100D L 16 OK0049 Air-oore Coil. . x7T R41B RK304 Chip R., MCR03 . K
C334 CU3035 Chip C.. CM105W5R10 K L 17 QK0046 Air-core Coil. . * . 5T
C335 CU3035 Chip C.. CM105W5R10 K L 18 QK0046 Air-core Coil, . x . 5T C401 CU3035 Ch‘p C.. CM 105W5 R10 K
C336 CS0050 Chip Tantal C., TMC1A475TR L 1 QA0051 VHF RF Coil 1., QA0051 C40 CU3035 Ch'p C., CM105W5R10 K
C337 CU3035 Chip C.. CM105W5R10 K L QA005 VHF RF Coil ., QA005 C403 CU300 Chip C., CM 105CH010C
C338 CU30 3 Chip C.. CM105CH101K L 3 QA005 VHF RF Coil .. QA005 C404 CU300 Chip C., CM105CH010C
C339 CU8003 Chip C., C 01 Y1E104Z L 4 QA0036 High-frequency Coil, Mixer C405 CU3009 Chp C., CM105CH080C
C340 CU00 7 Chip C., C 01 CH1H470J L 6 QA0034 High-frequency Coil, 340L0 C406 CU3008 Chp C.. CM105CH070C
C341 CS0057 Chip C., TMC0J 5TR L 7 QC0011 Choke Coil. LAL0 R M C407 CU3054 Chip C., CM105W5R 3K
C34 CU30 3 Chip C., CM105CH101K L 0 QC001 Choke Coil, LAL0 NA4 R7M C408 CU3035 Chip C., CM105W5R10 K
C343 CS0050 Chip Tantal C., TMC1A475TR L 9 QC001 Choke Coil, LAL0 NA4R7M C409 CU300 ChipC., CM105CH010C
C344 CU8007 Chip C., C 01 Y1H473Z L 30 OCOC13 Choke Coil, LAL0 1 ROM C410 CU300 Chip C., CM105CH010C
C345 CUB007 Chip C.. C 01 Y1H473Z L 31 QC001 Choke Coil, LAL0 NA4R7M C411 CU3035 ChipC., CM105W5R10 K
C346 CU30 3 Chip C., CM 105CH101K L 3 QC001 Choke Coil, LAL0 NA4R7M C41 CU3035 Chip C., CM105W5R10 K
C347 CU800 Chp C..C 01 B1H103K L 33 QC0011 Choke Coil. LAL0 R M C413 CU301 ChipC., CM105CH1 0K
C348 CU0018 Chip C.. C 01 CH1H 00J L 34 QC0013 Choke Coil. LAL0 1 ROM C414 CU3008 ChipC., CM105CH070D
C349 CU30 3 Chip C., CM105CH101K L 36 QC0014 Choke Coil. LAL0 NA100K C415 CU300 Chp C., CM105CH010D
C350 CU0039 Chip C.. C 0) CH1H151J L 37 OCOOll Choke Coil. LALQ R M C416 CU30 3 ChjpC., CM105CH101K
C351 CU3035 Chip C., CM105W5R10 K L 38 OC001 Choke Coil, LAL0 NA4R7M C417 CU3035 Chp C., CM105W5R10 K
C35 CU00 7 Chip C.. C 01 CH1H470J L 39 QC0011 Choke Coil, LAL0 R M
C353 CU3035 Chp C.. CM105W5R10 K 1 40 QC0011 Choke Coil. LAL0 R M
C354 CU800 Ch'p C., C 01 B1H103K
C356 CU00 7 Chip C., C 01 CH1H470J S 01 U00011 Lock SW ESB64801 TVCO Unit
C357 CU30 3 ChipC.. CM105CH101K S 0 UQ0011 Lock SW F'iRfUflm
C35B CU30 3 Chip C.. CM105CH101K S 03 U00011 Lock SW E SB64801 Q501 XE0016 FET, SK 10Y
C359 CU8007 Chip C., C 01 Y1H473Z 050 XT0059 Transistor, SC308 KSQ
C360 CUB007 Chp C., C 01 Y1H473Z J 01 UJ0003 MIC, SP, Jack, HSJ110 -01-5 0 0503 XT0030 Transistor, SC3356
C361 CS0057 Chip Tantal C., TMC0J 5TR J 0 UE0040 ANT.Conneclof, BNC-RM (FM-363 3) 0504 XT0035 Transistor. SC34 9
C36 CS0058 Chp Tanlal C.. TMCOJ685TR 0505 XT0035 Transistor, SC34 9
C364 CU3035 Chip C.. CM105W5R10 K
C366 CU30 3 Chip C.. CM105CH10IK D501 XD0035 Varicap, 1SV161
C367 CU30 3 Chip C., CM 105CH101K 050 XD0035 Varicap. 1SV161
C368 CU30 3 ChipC., CM105CH10IK 0503 XD0060 Varicap, 1SV153
C370 CU3035 ChipC., CM105W5R10 K D504 XDOOeO Varicap. 1SV153
C371 CU3035 Chip C.. CM105W5R10 K D505 XD0098 Varicap. 1SV153-TPH
C37 CU3035 Chp C.. CM105W5R10 K D506 XD0098 Varicap, 1SV153-TPH
C373 CU3035 Chip C., CM105W5RI0 K
C374 CU3035 Chip C.. CM105W5R10 K L501 OK0074 Air-core Coil, 1.6x9.5T
C375 CU3035 Chip C., CM105W5R10 K L50 OCOÖ11 Choke Coil, LAL0 R M
C376 CU3035 ChipC.. CM105W5R10 K L503 QC0015 Choke Coil. LAL0 R M
C377 CU3035 ChipC-, CM105W5R10 K RVCO Unit L504 QK0071 Air-core Coil, 1.6x4.5T
C378 CU3035 Chip C., CM105W5R10 K L505 QC0013 Choke Coil, LAL0 1 ROM
C379 CU3035 Chip C., CM105W5R10 K O401 XE0016 FET. SK 10Y L506 QK007 Air-core Coil, 1.6x5.5T
C380 CU800 Chip C., C 01 B1H103K 040 XT0059 Transistor, SC308 KSQ L507 QK0070 Air-core Coil, 1.6x .5T
C381 CU3035 ChpC..CMl05W 5Rl0 K 0403 XT0030 Transistor, SC3356
C38 CU3035 ChipC., CM105W5R10 K 0404 XT0035 Transistor, SC34 9
C383 CU3035 ChipC., CM 105W5R10 K
C384 CU3035 Chip C.. CM105W5R10 K D401 XD0060 Varicap. 1SV153 R501 RK30 6 Chip R.. MCR03 100Q
C386 CU30 3 Chip C., CM105CH101K D40 XD0060 Varicap. 1 SV 153 R50 RK303 Chp R.. MCR03 3300
C387 CU3035 Chp C., CM105W5R1Q K D403 XD0098 Varicap. 1SV153-TPH R503 RK3051 Chip R.. MCR03 1 K
C389 CE0033 Chemical C.. MS510ji/10V D404 XD0098 Varicap. 1SV153-TPH R504 RK3046 Chp R.. MCR034.7K
C390 CU3035 ChipC., CM105W5R10 K R505 RK30 6 Chip R.. MCR03 100a
C391 CU3035 Chip C., CM105W5R10 K L401 QK0073 Air-core Coil, 1.6x6.5T R506 RK304 Chip R.. MCR03 . K
C39 cuoon Chip C.. C 01 CH1H100D L40 QC0011 Choke Coil, LALQ R M R507 RK3050 Chp R.. MCROQ 10K
C393 CU0003 Chip C., C 01 CH1H0 0C L403 QC0015 Choke Coil, LAL0 R M R508 RK3030 Chip R., MCR03 0il
C394 CU0051 ChipC.. C 01 CH1H471K L404 QK007 Air-oore Coil, 1.6x5.5T R509 RK3050 Chp R.. MCR03 10K
C395 CU0011 Chp C.. C 01 CH1H100D L405 OC0013 Choke Coil, LAL0 1 ROM R510 RK3046 Chip R., MCR03 4.7K
C397 CU30 3 Chip C.. CM105CH10IK L406 UK007 Air-core Coil. 1.6x5.5T R511 RK3030 Chip H.. MCR03 CK1
3398 CU0001 Ch'pC.,C O1 CH1H0R5C R51 RK30 Ch’p R.. MCR03 47£1
-399 DU3035 Chip C.. CM 105W5R10 K R513 RK3051 Chp R.. MCR03 1 K
- 5 -

Ref.
No. Part Code Part Name and Number Ref.
No. Part Code Part Nam® and Number Ref.
No. Part Codo Part Name and Number
R514 RK3046 Chip R., MCR03 4.7K D609 XD0039 Diode. RLS415 R658 RK3058 Chip R, MCR03 47K
R515 RK3048 Chp R., MCR03 6.8K D610 XD0116 Zener Diode. MTZJ5.1A R659 RK3056 ChpR, MCR03 33K
R516 RK3050 Chip R., MCR03 10K R660 RK3046 Chp R. MCR03 4.7K
R517 RK30 6 Chip R.. MCR03 100ß X601 X000 7 Xtal UM-1 54.595 MHz R661 RK3046 Chip R. MCR03 4.7K
R518 RK3050 Chip R.. MCR03 10K R66 RK3054 Chp R. MCR03 K
R519 RK3034 Chip R. MCR03 470il FL601 XF0003 Xlal Filter. 55M15A 55.05 MHz R663 RK3054 Chp R. MCR03 K
R5 0 RK3046 ChpR., MCR03 4.7K FL60 XC0004 Ceramic Filter. CFUM455E R664 RK3054 Chip R. MCR03 K
R5 1 RK3058 Chp R., MCR03 47K R665 RK3058 Chip R, MCR03 47K
R5 RK304 Chip R.. MCR03 . K L601 QC0017 Chp Choke Coil, ML.F3 16DR47M R666 RK3046 Chp R. MCR03 4.7K
L60 OA0049 Filter-matching Coil, OA0049 (181/41) R667 RK3038 Chp R. MCR03 1K
C501 CU300 Chip C., CM 105CH01OC L603 OA0049 Filter-matching Cofl. OA0049 (181/41) R668 RK3046 Chip R. MCR03 4.7K
C503 CU3005 Chip C., CM105CH040C L604 OC0017 Chp Choke Coil, MLF3 16DR47M R669 RK0105 Chip R, MCR10 . S1
C504 CU300 Chip C., CM 105CH01 OC L605 OC0054 Chp Choke Coil. LAL0 NAR56M R670 RK3050 Chp R. MCR03 10K
C505 CU3054 Chip C., CM105W5R 3K L606 OC0011 Choke Coil, LAL0 R M R671 RK3054 Chip R.MCR03 K
C506 CU3035 Chip C.. CM105W5R10 K L607 QA0044 455 kHz IF Coil. QA0044 R67 RK3070 ChpR . MCR03 470K
C507 CU3003 Chip C., CM105CH0 0C L608 QC0013 Choke Coil. LAL0 1 ROM R673 RK303 ChpR. MCR03 3300
C506 CU300 Chip C., CM 105CH010C L609 QC0013 Choke Coil. LAL0 1 ROM R674 RK3054 Chip R. MCR03 K
C509 CU3035 Chip C.. CM105W5R10 K R675 RK3054 Chip R. MCR03 K
C510 CU3035 Chp C., CM105W5R10 K R601 RK00 Chip R, MCR10 QC1 R676 RK304 Chp R. MCR03 . K
C511 CU3003 C!,pC„ CM105CH0 0C R60 RK00 Chip R,MCR10 0n R677 RK3038 Chip R, MCR031K
C51 CU3035 Chp C., CM105W5R10 K R603 RK3050 Chip R, MCR03 10K R678 RK3047 Chp R. MCR03 5.6K
C513 CU3010 Chip C., CM105CH090C R604 RK3050 ChpR. MCR03 10K R680 RK3046 Chp R. MCR03 4.7K
C514 CU301 Chip C., CM105CH1 0K R605 RK3050 Chp R. MCR03 10K ' R681 RK3050 Chp R, MCR03 10K
C515 CU300 Chip C., CM105CH010C R606 RK3050 Chp R, MCR03 10K R68 RK3070 Chip R, MCR03 470K
C516 CU3004 Chip C., CM105CH030C R607 RK3050 Chip R. MCR03 10K R683 RK30 4 Chip R. MCR03 6Bil
C517 CU30 1 Chip C..CM105CH680K R608 RK304 Chip R. MCR03 . K R684 RK304 Chip R, MCR03 . K
C518 CU3035 Chjp C.. CM 105W5F110ßK R610 RK3050 Chp R. MCR03 10K R685 RK3038 Chip R. MCR03 1K
C519 CU3035 Chip C., CM105W5R10 K R611 RK3050 Chp R, MCR03 10K R686 RK3038 Chip R. MCR03 1K
C5 0 CU3035 Chp C., CM 105W5R10 K R61 RK3050 Chp R. MCR03 10K R687 RK0105 Chip R, MCR10 . Q
C5 1 CU3035 Chip C., CM105W5R10 K R613 RK3054 Chp R. MCR03 K R688 RK3038 Chip R.MCR031K
R614 RK3047 Chp R. MCR03 5.6K R689 RK3054 Chip R, MCR03 K
IF Unit R615 RK3047 Chip R, MCR03 5.6K R690 RK3038 Chp R. MCR03 1K
R616 RK3047 Chp R, MCR03 5.6K R691 RK3046 Chip R.MCR03 4.7K
IC601 XA0019 IC. jiPD4094BG R617 RK3058 Chp R, MCR03 47K R69 RK3038. Chip R, MCR031K
IC60 XA0068 IC. M5 18FP R618 RK3061 Chip R, MCR03 8 K R693 RK3050 Chip R. MCR03 10K
IC603 XA0070 IC, MC33610 R619 RK3054 Chip R. MCR03 K R694 RK3050 Chp R. MCR03 10K
IC604 XA0071 IC. BA546 (DJ-500T only) R695 RK3050 Chip R. MCR03 10K
IC605 XA0080 IC. TC4S81F R619 RK3050 Chip R. MCR03 10K R696 RK30 6 Chip R.MCR03 10QC1
(DJ-500E only) R697 RK306 Chp R. MCR03 100K
0601 XT0037 Transistor. SC 41 KR R6 0 RK3054 Chp R, MCR03 K R69B RK3058 Chp R. MCR03 47K
060 XE0004 FET. SK 09GR R6 1 RK3050 Chip R. MCR03 10K R700 RK3050 Chip R. MCR03 10K
0603 XU0006 Transistor, DTA114TK R6 RK3067 Chip R, MCR03 70K
0604 XT0067 Transistor, FMA4 R6 3 RK3063 Chp R.MCR03 1 0K VR601 RH0038 VR. CVR-4 A-473
0605 XT0067 Transistor. FMA4 R6 4 RK3065 Chip R.MCRO3 10OK VR60 RH0038 VR. CVR-4 A-473
0606 XT0068 Transistor, SA116 GR R6 5 RK3050 Chip R, MCR03 10K VR603 RH0031 VR.CVR-4 A-103
0607 XT0067 Transistor, FMA4 R6 6 RK3050 Chip R, MCR03 10K VR604 RH0031 VR. CVR-4 A-103
0608 XT0067 Transistor, FM A4 R6 7 RK305 Chp R. MCR03 15K VR605 RH0031 VR.CVR-4 A-103
0609 XT0069 Transistor. SD1 5M R6 8 RK30G9 Chp R, MCR03 390K VR606 RH0031 VR.CVR-4 A-103
0610 XT0069 Transistor. SD1 5M R6 9 RK3061 Chip R, MCR03 6 K VR607 RH0057 VR. RK0971110, 10kilB
0611 XU000 Transistor, DTC114YK R630 RK3066 Chip R. MCR03 0K VR608 RH004 VR, RK0971111, 10kilA
061 XU0014 Transistor. DTC144EK R631 RK3031 Chip R. MCR03 7QQ VR609 RH0036 VR, CVR-4 A-103
0613 XE0015 FET. SK30 Y R63 RK30 6 Chp R. MCR03 100CÎ
0614 XT0079 T ransistor, SC 71 G R R633 RK30 6 Chp R. MCR03 1000 S601 U0001 Non-Iock SW, E-SB64803
0615 XT0079 T ransistor, SC 71 G R R634 RK3O60 Chip R. MCR03 330K S60 U0001 Non-lockSW. ESB64803
0616 XU0014 Transistor, DTC144EK R635 RK3066 Chp R. MCR03 0K
0617 XT0070 Transistor, FMS1 R636 RK3050 Chip R. MCR03 10K SP ES0005 SP. 036S13D
0618 XT0040 Transistor. SA1 04Y R637 RK00 Chp R.MCR10 QO
0619 XT0079 Transistor. SC 71 GR R63B RK30 6 Chip R.MCR03 10QC1 C601 CS0057 Chip Tantal C., TMC0J 5TR
06 0 XU0014 Transistor, DTC144EK R639 RK3046 Chip R, MCR03 4.7K C60 CU3035 Chip C., CM 105W5R10 K
06 1 XU0014 Transistor, DTC144EK R640 RK3058 Chip R. MCR03 47K C604 CU3035 Chip C..CM105W5R10 K
06 XU0003 Transistor. DTC114TK R641 RK3066 Chp R. MCR03 0K C605 CUS00 Chip C.. C 01 B1H103K
06 3 XE0004 FET, SK 09GR R64 RK3046 Chip R. MCR03 4.7K C606 CU800 ChpC..C 01 B1H103K
06 4 XU0017 Transistor. DTA144EK R643 RK3034 Chp R. MCR03 47QC1 C607 CU8005 Chip C.. C 01 B1H K
06 5 XU0003 Transistor. DTC114TK R644 RK3044 Chip R.MCR03 3.3K C608 CS0059 Chip Tantal C., TMC0J 6TR
06 6 XT0040 Transistor. SA1 04Y R645 RK307 Chp R. MCR03 68CK C609 CU3035 Chip C..CM105W5R10 K
06 7 XU0014 Transistor. DTC144EK R646 RK3044 Chip R. MCR03 3.3K C610 CS0060 Chip Tantal C.. TMC1E474TR
06 8 XU0014 Transistor, DTC144EK R647 RK307 Chp R. MCR03 680K C611 CS0060 Chip Tantal C.. TMC1E474TR
06 9 XU0014 Transistor, DTC144EK R648 RK3050 Chip R. MCR03 10K C61 CU8018 Chjp C., C 01 B1H15 K
R649 RK304 Chip R, MCR03 . K C613 CU30 3 Chip C.. CM105CH101K
D601 XD0040 Diode, DAN 0 K R650 RK3044 Chip R. MCR03 3.3K C614 CU3035 Chip C., CM105W5R10 K
060 XD0040 Diode. DAN 0 K R651 RK30 Chip R. MCR03 47Í1 C615 CS0060 Chp Tantal C.. TMC1E474TR
D603 XD0040 Diode. DAN 0 K R65 RK3050 Chip R. MCR03 10K C616 CU8005 Chip C., C 01B1H K
D604 XD0040 Diode. DAN 0 K R653 RK3050 Chip R. MCR03 10K C617 CU30 3 ChipC., CM105CH101K
0605 XD0041 Diode. DAP 0 K R654 RK306 Chip R.MCR03 100K C618 CU30 3 Chp C., CM105CH101K
D606 XD0039 Diode, RLS415 R655 RK3038 Chp R. MCR03 1K C619 CS0061 Chip Tantal C., TMC1V 4TR
D607 XD0039 Diode, RLS415 R656 RK3070 Chp R, MCR03 470K C6 0 CU3035 Chip C..CM105W5R10 K
0608 XD0116 Diode. MA716 H657 RK3044 Chp R, MCR03 3.3K C6 1 CS0059 Chip Tantal C.. TMCQJ 6TR
- 6 -

Ref.
No. Parí Code Pari Name and Number Ref.
No. Part Code Part Name and Number Ref.
No. Part Code Part Name and Number
C6 CU800 Ch'pC.,C 01 BlH103K CN5 UE0037 Housing TZL-P10P-A1 R7 RK005 Chp R..MCR10 10K
C6 3 CU0001 Chip C..C 01 CH1H0R5C CNG UE0039 Housing TZL-P0 P-A1 R8 RK0069 Chp R., MCR10 100K
CG 4 CU0006 Chip C.. C 01 CH1H050C CN7 UE0039 Housing TZL-P0 P-A1 R9 RK0076 Chip R., MCR10330K
CG 5 CU0001 Chip C., C 01 CH1H0R5C R11 RK0069 Chip R., MCR10 100K
C6 6 CU800 Chip C.,C 01 B1H103K R1 RK0037 Chip R.. MCR101.5K
CG 8 CU800 Chip C..C 01 B1H103K
C6 9 CU800 Chip C.,C 01 B1H103K C1 CS0059 Chip Tantal C., TMC0J GMTR
C630 CU3035 Ch'p C.. CM105W5R10 K C CS0053 Chip Tantal C., TMC0J476MTR
C631 CU3035 Chip C., CM105W5R10 K C3 CS0051 Chip Tantal C., TMC1C106MTR
1
C63 CU3035 ChipC., CM 105W5R10 K C4 CS0063 Chip Tantal C., TMC1V104MTR
C633 CU800 Chip C.. C 01 B1H103K C5 CS0050 Chip Tantal C.. TMC1A475MTR
C634 CU800 ChipC., C 01 B1H103K 1750 Hz Tone Unit C6 CU3007 ChipC.. C 01 JF1H473Z
C635 CU800 Chip C., C 01 B1H103K C7 CU8007 Chip C.. C 01 JF1H473Z
C63G CU8006 ChipC., C 01 B1E 3K IC1 XA0093 IC, NJU4069UBM-TEI C8 CU8001 Chip C., C 01 B1H10 K
C637 CU3035 Chip C., CM105W5R10 K IC • XA009 IC. NJU40 0BM-TEI C9 CU8001 Chip C.. C 01 B1H10 K
C638 CU00 3 Ch’p C., C 01 CH1H330J IC3 XA0068 IC.M5 18FP-T01-1 C10 CU8001 Ch'p C.. C 01 B1H10 K
C639 CU305 Chip C., CM105W5R103K C11 CU8001 ChipC., C 01 B1H10 K
C640 CU8003 Ch'pC.,C 01 Y1E104Z Q1 XU0005 DG Transistor, DTA143XK C1 CU8001 Ch'p C., C 01 B1H10 K
C641 CU00 3 Chp C., C 01 CH1H330J C13 CC0105 Ceramic C.. 50 V CH 4 PF
C64 CU00 3 Chp C., C 01 CH1H330J X1 XB0001 Ceramic Resonator,
C643 CU3035 Chp C., CM105W5R10 K FAR-C4CA-03580000K01 Ni-Cd Batterv Unit
C644 CU3035 Chip C., CM105W5R10 K
C645 CU8003 ChpC.,C 01 YlE104Z UP0166A 1750 Tone P.C.B., UP0166A J1 UJ0010 DC Power Jack. HEC07B6-01 -040
C64G CU8003 Chip C.,C 01 Y1E104Z J UJ001 DC Power Jack, HEC0779-01-030
C&47 CS0059 Chip Tantal C., TMC0J 6TR UX0091 Harness UX0091
C648 CU0051 Chip C., C 01 CH1H471K Q1 XT0065 Transistor, SB889P
C649 CS0057 Chp Tantal C., TMC0J 5TR VR1 RH0051 VR, CVR-4 A-47 AW1 D
CG50 CU8003 Chip C..C 01 Y1E104Z 01 X00089 Diode. P3300
C651 CU0051 Chip C., C 01 CH1H471K R1 RK0086 Chip R.. MCR10 1M D XD0089 Diode. P3300
C65 CU3035 Ch'p C., CM105W5R10 K R RK0054 Ch'p R., MCR10 15K D3 XD0089 Diode. P3300
C653 CU3035 Chip C., CM105W5R10 K R3 RK0054 Ch'p R.. MCR1015K D4 XD0089 Diode. P330D
C654 CE0037 Chemical C.. MS5 100 mF/6.3 V R4 RK0054 Chip R.. MCR10 15K D5 XD0038 Diode, ISS133
C655 CU3035 Chip C.. CM105W5R10 K R5 RK0054 Chip R.. MCR10 15K D6 XD0038 Diode, ISS 133
C656 CU3035 Chp C., CM105W5R10 K R6 RK0054 Chip R.. MC RIO 15K 07 XD0038 Diode. ISS133
CS57 CU3035 Ch'p C.. CM105W5R10 K R7 RK0069 Chip R.. MCR10 100K D8 XL0018 LED. TLR 4
C658 CU3035 Chp C., CM105W5R10 K R8 RK007 Chip R.. MCR10180K D9 XD009 Diode. GP15B
CG59 CU0051 Chip C., C 01 CH1H471K R9 RK0030 Chip R., MCR10 560il
C$60 CU3035 Ch'p C., CM105W5R10 K R10 RK0045 Chip R..MCR104.7K R1 RD004 Carbon Resistance, RD 5N 3.3 kn
C661 CU3035 ChipC., CM 105W5R10 K R RD0113 Carbon Resistance, RD 5N4.7kfl
C66 CE0100 Chemical C.. MS5 ^/16 V C1 CS0053 Chip Tantal C.. TMC0J476TR R3 RD0035 Carbon Resistance, RD 5N 1 kn
C664 CU8006 Chip C.. C 01 B1E 3K C CU8001 Chip C., C 01 B1H1Q K
C665 CU8005 Chip C., C 01 B1H K C3 CUB00 Chip C..C 01 B1H103K
C666 CU8003 Ch'p C.. C 01 Y1E104Z C4 CU800 ChipC..C 01 BlH103K
C667 CS0063 Chp Tantal C.. TMC1V104TR C5 CU800 Chip C..C 01 B1H103K
C668 CU8007 Ch'p C.. C 01 Y1H473Z C6 CU800 Chip C:. C 01 B1H1Q3K
C669 CS0063 Chp Tantal C., TMC1V104TR C7 CU80 Chp C.. C 01 B1H33 K Mpnhaninal Parts
C670 CU3035 Chip C., CM 105W5R10 K C8 CS0057 Chip Tantal C.. TMC0J 5TR
C671 CU30 3 Ch'p C., CM 105CH101K C9 CS0050 Chp Tantal C., TMC1A475TR KM0036 Front Case
C67 CU8006 Chip C., C 01 B1E 3K KM0051 Front Case
C673 CU0006 Chip C., C 01 CH1H050C Tone Sniifilc.h Unit KB00 4 Rear Case
C674 CU8006 Chip C.. C 01 B1E 3K KU0051 Uppercase
C675 CS0050 Ch'p Tantal C.. TMC1A475TR IC1 XA00 0 1C, MN65 0 KU0055 Uppercase
C676 CE0044 Chemical C., MS5 10(i/16 V XA0019 1C, MPD4094BG DP0030 LCD Panel
C677 CS005 Ch'p Tantal C., TMC1A336TR OP0034 LCD Panel
C678 CU0051 Ch'p C., C 01 CH1H471K Q1 XT0017 Transistor. SA116 Y DP0035 LCD Panel
C679 CE0056 Chemical C.. MS5 100^/16 V Q XT0031 Transistor. SC 71 Y NK0008 Volume Knob
C6B0 CU3035 ChipC.. CM105W5R10 K Q3 XU0006 Transistor, 0TA114TK
C681 CE0056 Chemical C., MS5 100|i/1G V CM XU0006 Transistor, DTA114TK NP0013 Push Knob
C68 CU3035 ChipC.. CM105W5R10 K
C683 CS0061 Chip Tantal C., TMC1V -4TR D1 XD0040 Diode, DAN 0 K NP0014 Call Knob
C684 CE0056 Chemical C.. MS5J00H/1G V ' 0 X00040 Diode, DAN 0 K
C686 CU3035 ChipC., CM105W5R10 K NS0001 Slide Knob L
C6B7 CU3035 Chip C., CM105W5R10 K VR1 RH0031 VR, CV R-4 A-103AW1D
C688 CU800 Chip C., C 01 B1H103K DV000 M. Net
C689 CU8005 Chip C., C 01 B1H K X1 XB000 Ceramic Resonator.
C690 CU800 Chip C..C 01 B1H103K FAR-C4CA-04194000K01 NB0018 PTTKnob
C$91 CUB00 Chip C..C 01 B1H103K
C69 CU0011 Ch'p C.. C 01 CH1H100D UP0149 P.C.B.. UP0149 NB0019 Release Knob
C694 CU3035 Ch'p C., CM105W5R10 K
C695 CU3011 Ch'p C.. CM 105CH100K50VAT UX0091 Harness, UX0091 NB0016 Tone Knob
CG96 CU3035 Ch'p C., CM105W5R10 K
C697 ^CU305 Ch'p C., CM 105W5R103K 5VAT R1 RK005 Ch'p R„ MCR10 10K DS0054 Rating Plate
R RK005 Ch'p R„ MCR10 10K OS0065 Rating Plate
CN1 UE0036 Housing TZL-P14P-A1 R3 RK0053 Chip R„ MCR10 1 K DS0066 Rating Plate
CN lUE0037 Housing TZL-P10P-A1 R4 RK0054 Chip R„ MCR10 15K DS0079 Rating Plate
CN3 UE0038 Housing TZL-P09P-A1 R5 RK0071 Ch'pR., MCR10 150K
CN4 IUE0038 Housing TZL-P09P-A1 06 RK0039 Ch'pR., MCR10 . K DK00B9 Lock Display Panel
- 7 -

Ref.
No. Part Code Pari Name and Number
FG00 5 Silicon Key
FG00 7 EP Rubber
F GOO 6 Interconnect or
FP0013 PTT Cushion
KD0011 Battery Case
KF0011 Battery Case Cover
SD0005 Spring A
SD0006 Spring B
SD0007 Spring C
S00008 Spring D
SD0009 Spring E
SD0010 Spring F
SP0001 Spring. Power,
FF0011 Speaker Sheet
TS0019 Shield
ST0019 Volume Angle
TS0018 Main Shield
ST00 0 Speaker Fastening
SS0035 Bottom Chassis
ST00 1 LCO Clasp,
TZ00 3 Shield Insulator
TZ00 4 Lithium Insulator
TZ00 5 VCO Insulator
TZ00 6 Insulator Sheet
TZ00 7 VCO Spacer
TZ00 8 VOL Spacer
FM00 6 Module Earth
AS0131A Screws
AS0100A Screws
Screws Unit
AF0003 Screw M x3,38FN 0030FN
AF0010 Screw M x4, 3BFN 0040FN
AP0005 Screw M x4,38PN 0040GB
AP0003 Screw M x 16.38PN 0160GB
AB0007 Screw M 6x8.3BAN 6O0OGZ
AF0009 Screw M x4,38FN 0040AB
AA00 1 Screw M x3,38AS 0030GZ
AN0004 Nut MZ 38NH 0NFCM0
AP0007 Screw M x 15, 38PN 0150GB
SA0003 Tone Spacer
Washer
AA00 0 Screw M 6x4, 33AT S040GC
Mechanical Parts (Ni-Cd) Unit
KF001
KD0018
Ni-Cd Battery Case Cover 7NA
Ni-Cd Battery Case
EG0006 Ni-Cd Battery pcs.
FG0003 Cushion
PR001 Caution Label
PR0080 Caution Label
HP0006 Polyvinyl Bag. 43P5x90x170
TT400 Tube
YZ0044 Screw Lock
AS0098
UT001B
AF0008
Screws
M Jack
Screw M x3.5, 38FN 0035FN
Others Unit
HK0151
HK015
HK0153
HU00 9
HM006
Decorative Case
Decorative Case
Decorative Case
Inner Cushion
Outer Case
PR00
EA0008
HP0005
HP00
HP0006
HP0003
HP0031
UZ0010
EJ000
YZ00 5
PS0108
Seal (E).
Antenna. A0RB3008A
Polyvinyl Bag. 43P5x140x 50
Polyvinyl Bag, 43P5x105* 50
Polyvinyl Bag, 43P5x90x170
Polyvinyl Bag, 43P5x75x110
Polyvinyl Bag. 43P5x100x 00
Conversion Plug
E DC-10
EDC-6
Instructions Manual
PH000 Warranty Card
BB0004
BH000
Handle
BehClp
PT0004
PR0081
Serial Seal
Operation Guide Seal
- 8 -

■ CABINET PARTS LOCATION
Ref.
No. Part Code Part Name and Number
Mechanical Parts
1kH c os-/
KM0037-- Front Case
KB00 4 Rear Case
3KU0051 Upper Panel
4KB0018 PTT Knob
5 NB0016 TONE Knob
6NB0019 Release Knob
7 NK0008 Vol Knob
eNP0013 Push Knob
9NP0014 Call Knob
10 FG00 7 EP Rubber
11 TS0018 Shield Plate
1 NS0001 F Lock Knob
Screws
13 AF0003 M x3.0 (Screw)
14 AP0007 M x 15 (Screw)
15 AF0010 M X4.0 (Screw)
16 AF0009 M X4.0 (Screw)
17 AA00 1 M x 3.0 (Screw)

■ ADJUSTMENT
Item Adjustment Point Adjustment Method Spec
5 V line voltage VR605 Turn VR605 so that the voltage of 16 pin of
IC601 should be 5.1 V. 5.1 V±0.1 V
VCO P/D voltage L401 (RX VCO) Adjust L401 so that the voltage of C36 (+) is 1.5 V±0.3V
(VHF) 1.5 V. (145 MHz)
L501 (TX VCO)
(VHF) Adjust L501 so that the voltage of C36 (+) is
.0 V. .0 V±0.3 V
L406 (RX VCO) (DJ-500E) 1.1 V±0. V
(UHF) Adjust L406 so that the voltage of C343 (+) is
1.1 V.
(DJ-500T)
Adjust L406 so that the voltage of C343 (+) is
1.9 V.
(435.0 MHz)
1.9 V±0. V
(445.0 MHz)
L504 (TX VCO)
(UHF) (DJ-500E)
Adjust L504 so that the voltage of C343 (+) is
.1 V.
(DJ-500T)
Adjust L504 so that the voltage of C343 (+) is
3.0 V.
.1 V±0.3 V
3.0 V±0.3 V
Frequency TC 09 Set the unit in the transmission mode at
435 MHz (DJ-500T: 445 MHz) and adjust
TC 09.
435 MHz
±500 Hz
(445 MHz
±500 Hz)
VHF power output VR 01 On “HI” position, turn VR 01 for 6.6 W output
at 145.0 MHz 13.0 V. 6.5 W±0.5 W
VR 04 On “LO" position, turn VR 04 for 0.6 W output
at 145.0 MHz 13.0 V. 0.5 W±0.1 W
UHF power output VR 0 On “HI” position, turn VR 0 for 5.6 W output
at 435 MHz 13.0 V (DJ-500T: 445 MHz
13.0 V)
5.5 W±0.3W
VR 03 On “LO” position, turn VR 03 for 0.6 W output
at 435 MHz 13.0 V (DJ-500T: 445 MHz
13.0 V)
0.5 W±0.1 W
VHF deviation VR604 Input a signal of 1 kHz/50 mV into the Mic jack
and adjust VR604 so that you obtain 4.8 kHz/
Dev in the transmission mode.
4.8 kHz
±0. kHz
UHF deviation VR601 Input a signal of 1 kHz/50 mV into the Mic jack
and adjust VR601 so that you obtain 4.8 kHz/
Dev in the transmission mode.
4.8 kHz
±0. kHz
-1 0 -