APW Wyott DWC13 User manual

Phone: +1
Fax: [phone]
Toll Free: [phone]
Website: www.apwwyott.com
E-mail: [email protected]
[phone]
INSTALLATION AND OPERATING INSTRUCTIONS
INTENDED FOR OTHER THAN HOUSEHOLD USE
Model: DWC13
RETAIN THIS MANUAL FOR FUTURE REFERENCE
UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES
P/N 66974 9/05
1
EXPORT WARMER CABINET
APW WYOTT
729 Third Avenue
Dallas, TX 75226
This equipment has been engineered to provide you with year-round dependable service when used
according to the instructions in this manual and standard commercial kitchen practices.
WARNING: Improper installation, adjustment, alteration, service or maintenance can
cause property damage, injury or death. Read the Installation, Operating and
Maintenance Instructions thoroughly before installing or servicing this equipment.
!!
R

2
INSTALLATION INSTRUCTIONS
OPERATING INSTRUCTIONS
DAILY CLEANING INSTRUCTIONS
SPECIFICATIONS
REPLACEMENT PARTS LIST
1. UNPACK.Thereshould beon cabinet andtwo shelves.
2. Check for loose or damagedparts.
3. Plug the unit into a 230V outlet.
4. Check to see that the light turnson and that the unit heats up.
1. Turn on unit.
2. Set dial between "1 & 2 (see "KNOB SETTING" diagram).
3. Let warm up for 1 hour.
4. Forless heat, turndown (CCW).
To increase heat, turn up(CW).
5. When done, turn off unit.
1. Turn unit off and unplugthe unit from thepower outlet.
2. Doorsmay be removedfor cleaning.
3. Clean the cabinet with soapy water and a soft cloth. Do not use chemicals such as ammonia,
alcohol, or chlorine to clean the cabinet. The door and sides are made of plastic, and these
chemicals will cause cracking. The plastic sides are easily scratched, so be sure to use something
soft to wash them.
4.
5. Theshelves are stainlesssteel, and may be machinewashed.
POWER: 230V, 550W, 50/60HZ
OVERALLDIMENSIONS: 12 W' Wide x 12 Deep x 20 ~" High
INSIDE DIMENSIONS: 12" Wide x 12 W' Deep x 11 5/8" High
CORDSET: 5 FT, 3 GROUNDED WIRECORD
FORAPPLIANCES WITH TYPE YATTACHMENT: IF THE SUPPLY CORD IS DAMAGED,
IT MUST BE REPLACED BY THE MANUFACTURE OR ITS SERVICE AGENT OR A SIMILARLY
QUALIFIED IN ORDERTOAVOIDAHAZARD.
SHIPPINGWEIGHT: 25Ibs.
APPROVALS: ULEPH (NSF4), CE
DO NOT IMMERSE CABINET IN WATER. DO NOT JET SPRAY CABINET. DO NOT PUT
CABINETINADISHWASHER.
3/t"
NOTE:
1
23
4
5
ITEM PART NUMBER DESCRIPTION
1 Stainless Steel Shelf
2 Adjustment Knob (0-5)
4 Door Knob
4a Screw for Door Knob (Need 11/ea)
5 Door
6 Striker Plate (for Door Magnet)
7 Door Hinge
7a Screw for Door Hinge (Need 2/ea)
7b Screw for Frame Hinge (Need 2/ea)
8 Shelf Rod
8a Shelf Rod Screws
9 Door Magnet
9a Screw for Door Magnet (Need 2/ea)
66922
89499
3 70801001 Lamp 230v 40W Philips P45 E14 European
89165
89029
66931
66923
66937
88984
88856
66933
88993
66936
88854

WIRING DIAGRAM - DWC13

4
APW WYOTT EQUIPMENT LIMITED WARRANTY
APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the
following conditions:
This warranty applies to the original owner only and is not assignable.
Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of
APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency. APW Wyott will only be
responsible for charges incurred or service performed by its Authorized Service Agencies. The use of other than APW Wyott
Authorized Service Agencies will void this warranty and APWWyott will not be responsible for such work or any charges associated
with same. The closestAPW WyottAuthorized Service Agent must be used.
This warranty covers products shipped into the 48 contiguous United States, Hawaii, metropolitan areas ofAlaska and Canada. There
will be no labor coverage for equipment located on any island not connected by roadway to the mainland.
One year for parts and one year for labor, effective from the date of purchase by the original owner. The Authorized Service Agency
may, at their option, require proof of purchase. Parts replaced under this warranty are warranted for the un-expired portion of the
original product warranty only.
Models GCB, GCRB, GF, GGM, GGT, CHP-H, EF, EG, EHP. Three (3) Year Warranty on all
component parts, except switches and thermostats. (2 additional years on parts only.No labor on second or third year.)
In all cases, parts covered by extended warranty will be shipped FOB the factory after the first year.
Equipment weighing over 70 pounds or permanently installed will be serviced on-site as per the terms of this warranty. Equipment
weighing 70 pounds or under, and which is not permanently installed, i.e. with cord and plug, is considered portable and is subject to
the following warranty handling limitations. If portable equipment fails to operate in its intended manner on the first day of
connection, or use, atAPWWyott's option or itsAuthorized ServiceAgency,it will be serviced on site or replaced.
From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott
Authorized ServiceAgency for in-warranty repairs. No mileage or travel charges are allowed on portable units after the first day of use.
If the customer wants on-site service, they may receive same by paying the travel and mileage charges. Exceptions to this rule: (1)
countertop warmers and cookers, which are covered under the Enhanced Warranty Program, and (2) toasters or rollergrills which have
in store service.
The following conditions are not covered by warranty:
*Equipment failure relating to improper installation, improper utility connection or supply and problems due to
ventilation.
*Equipment that has not been properly maintained, calibration of controls, adjustments, damage from improper cleaning
and water damage to controls.
*Equipment that has not been used in an appropriate manner, or has been subject to misuse or misapplication, neglect,
abuse, accident, alteration, negligence, damage during transit, delivery or installation, fire, flood, riot or act of god.
*Equipment that has themodel number orserial number removed or altered.
If the equipment has been changed, altered, modified or repaired by other than an Authorized Service Agency during or after the
warranty period, then the manufacturer shall not be liable for any damages to any person or to any property, which may result from the
use of the equipment thereafter.
This warranty does not cover services performed at overtime or premium labor rates. Should service be required at times which
normally involve overtime or premium labor rates, the owner shall be charged for the difference between normal service rates and such
premium rates.APWWyottdoes not assume anyliability for extended delays inreplacing orrepairing any itemsbeyond its control.
In all cases, the use of other thanAPW WyottAuthorized OEM Replacement Parts will void this warranty.
This equipment is intended for commercial use only.Warranty is void if equipment is installed in other than commercial application.
Water supply intended for a unit that has in excess of 3.0 grains of hardness per gallon (GPG) must be treated or softened before
being used. Water containing over 3.0 GPG will decrease the efficiency and reduce the operation life of the unit.
9/05
Warranty coverage on products used outside the 48 contiguous United States, Hawaii, and metropolitan areas ofAlaska and Canada
may vary. Contact the internationalAPWWyott distributor, dealer, orservice agency for details.
Models FD, FDL, FDD, FDDL. Two (2)Year Warranty on element only. No labor second year.
Time Period
Exceptions*Gas/Electric Cookline:
*Glass Windows, Doors, Seals, Rubber Seals, Light Bulbs:
Portable Carry In Products
Exclusions
Water Quality Requirements
Note: Product failure caused by liming or sediment buildup is not covered under warranty.
THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL OTHER WARRANTIES EXPRESSED OR IMPLIED
INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES
AND CONSTITUTES THE ENTIRE LIABILITY OFAPW WYOTT. IN NO EVENT DOES THE LIMITED WARRANTY
EXTEND BEYOND THE TERMS STATED HEREIN.
*BroilerBriquettes,
*Heat Strips: RockGrates,CookingGrates,BurnerShields, Fireboxes:
90DayMaterialOnly. No Labor.
90 Day Material Only. No Labor.