Arexx Solar Cosmonaut User manual

Solar Cosmonaut Kit Parts list: see page 2
Assembly of the left arm
Assembly of the right arm
Please check if the holes
(in the red frame) and the
markings front and back
are asshown on the picture.
a. Assemble left leg b. Assemble right leg
b. Assemble the legs and the
gearbox in the back panel,
(put the bosses in the hook).
a.
a.
c. Completely assembled
back panel and legs.a.
d. Push the motor wire
through the hole as shown
in the above image.
a.
a.
a. Assemble right arm,
put the arm lever on
the yellow gear boss
a.
a.
b. Assemble right arm,
put the arm lever on
the yellow gear boss
a.
a.
Install the front panel
WTR-003
AREXX Engineering
AREXX Engineering
Assembled arms
Back Front Back
a
b
Assembly of the gearbox and legs
a
bcd
a. Back panel (check the yellow
colored gear during assembly)a.
ab
WWW.AREXX.COM
March 2012 English and German manual:
AREXX Engineering, Zwolle - The Netherlands
NOTICE
AREXX and Solar Cosmonaut are registered trademarks
of AREXX Engineering Holland.
All rights reserved. Reprinting any of this instruction
manual without our written permission is forbidden.
The specifications, form, and contents of this product are
subject to change without prior notice.
We do not accept any responsibility for disadvantage or
damage caused by improper use or assembly.
AREXX Engineering Holland and DAGU China
European Distributor:
AREXX - Zwolle, The Netherlands www.arexx.com
C
WARNING
- When you open the bag with the parts, you cannot return the product anymore
- Before you start the assembly, read all instructions in this manual first
- Be careful using tools
- Do not assemble this product in the presence of little children, they can hurt themselves
with the toolsor swallow the small parts
！
C

a. – b. Screw the front and back panel together a. Install the back of the helmet b. Install the front of the helmet
Install the solar panel
a. Put the shrinking tube
over the motor wires
b. Connect the motor and
solar panel wire
c. Put the shrinking tube
over the wire connections
and heat it with a lighter
a.
a.
a.
a.
Function test
After you connect the solar panel with the
motor, please check if the motor runs. Put
the solar panel in bright sun or lamplight.
Troubleshooting
Most likely there is a failure in the gearbox
and gear assembly or with the wireconnections. In the worst case
you have to disassemble and reassemble the kit.
READY
PARTS LIST
A. Helmet front side, B. Helmet back side, C. Front panel, D. Back panel,
E. Gearbox, F. Screwdriver, G. Solar panel holder, H. Right arm, I. Left arm,
J. Solar panel, K. Right leg, L. Left leg. M. Right and left lever,
N. 2 pcs. Screw (M2x6), O. Shrinking tube
Parts list Solar Cosmonaut
abab
aba
bc
WWW.AREXX.COM
AB
C
D
E
F
G
H I
JK L
M
N
O